2005 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,584 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Escape model years with reports.
Of the 2005 reports, 44 involved a crash and 20 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
Seats, front assembly, head restraintApr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V111000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Representative owner complaints: engine
251 reports, newest first. Show all
Engine and engine cooling, Power train, Feb 9, 2015
I WAS COMING BACK TO HOME FROM WORK DRIVING ON HIGHWAY AT 55-60 MPH AND SUDDENLY MY CAR STARTS DECELERATING ITSELF AND I WAS FORCED TO PULL IT OVER ON THE SHOULDER, I WAS LUCKY THAT NOT ONE HIT ME. I COMPLETELY TURNED THE ENGINE OFF AND THEN I TRIED TO START AGAIN, IT STARTED MAKING CRANKING SOUND BUT DID NOT START COMPLETELY, SO I HAD TO CALL THE TOWING TRUCK TO TOW THE CAR TO MY HOME. IT COULD HAVE BEEN WORSE, I AM LUCKY TO BE ALIVE, I AM NOT SURE HOW CAN THE VEHICLE CAN STALL IN THE MIDDLE OF THE DRIVING. IT WAS SCARY. *TR
Electrical system, Engine, Fuel/propulsion system, Feb 8, 2015
FIRST OCCURRENCE OF PROBLEM: 48800 MILES, 5/2012. ENGINE LIGHT ON AND ENGINE MISFIRING. FORD DEALERSHIP DETERMINED FAULTY IGNITION COIL IN # 6 CYLINDER. REPLACED IGNITION COIL AND SPARK PLUG. $295 SECOND OCCURRENCE OF PROBLEM: 74,400 MILES, 11/2013. ENGINE LIGHT ON AND ENGINE MISFIRING. MECHANIC REPLACED SPARKPLUGS IN CYLINDERS # 1-3 ALL AT ONCE SINCE IT IS DIFFICULT TO ACCESS THOSE. $276 ADDITIONAL OCCURRENCES OF SAME PROBLEM: UPON MISFIRING IN 2014 I BOUGHT A CODE READER WHICH INDICATED CYLINDER #5 MISFIRE - REPLACED IGNITION COIL AND SPARK PLUG. MORE MISFIRING INDICATED CYLINDER #4 MISFIRE - REPLACED IGNITION FOIL AND SPARK PLUG. MAJOR PROBLEM UPDATE. 2/2/2015 - TRAVELLING 55 MPH CAR SHUTS OFF, ALL WARNING LIGHTS COME ON, COAST TO SHOULDER. RESTART CAR, SEEMS FINE, NO WARNING LIGHTS. AGAIN CYLINDER # 4 MISFIRING - REPLACED SPARK PLUG. MY RESEARCH INDICATES THE ECM/PCM MAY BE DAMAGED AND THAT THIS IS A VERY FREQUENT PROBLEM WITH THIS CAR, OFTEN MANIFESTING AFTER THE WARRANTY EXPIRES/RECALL MILEAGE, AND COSTS $2000-$3000 OR MORE. I DON'T WAN'T TO PAY TO HAVE IT FIXED BECAUSE MANY PEOPLE HAVE HAD THE PCM FRIED MULTIPLE TIMES BUT I'M SCARED IT WILL SHUT DOWN WHILE DRIVING AGAIN AND THINK THIS SHOULD BE COVERED BY A RECALL. MANY PEOPLE ARE HAVING THIS PROBLEM AND IT APPEARS TO BE CAUSED BY FORD ENGINEERING. PLEASE HELP FORCE A RECALL OR PROVIDE ME WITH INFORMATION FOR A CLASS ACTION LAWSUIT. *JS
Electrical system, Engine, Jan 29, 2015
WHILE DRIVING ABOUT 30 MPH, THE CAR STARTED SPUTTERING AS IF IT WERE RUNNING OUT OF GAS. I WAS NEAR A GAS STATION AND AS I WAS PULLING IN, THE ENGINE JUST STOPPED AND THE POWER STEERING WENT DEAD. THE CAR THEN WOULDN'T RESTART. I CALLED AAA AND THEY COULDN'T START IT, SO I HAD THE CAR TOWED TO THE FORD DEALERSHIP. THEY EXAMINED THE CAR AND LATER THAT DAY TOLD ME THE COILS OVERHEATED AND FRIED THE PCM. NOW IT NEEDS NEW COILS ON 2 CYLINDERS, POSSIBLY MORE, AND A NEW PCM WITH REPROGRAMMING. COST QUOTED WAS $3520. THE SERVICE TECH THAT LOOKED AT THE CAR SAID HE HASN'T SEEN THIS BEFORE, NOR HEARD OF THIS. AFTER RESEARCHING THIS PROBLEM ONLINE, I DON'T BELIEVE HIM. I WONDER HOW MANY PEOPLE HAVEN'T REPORTED THIS BECAUSE THEY WERE MADE TO THINK THEIR PROBLEM WAS A VERY RARE OCCURRENCE. *TR
Electrical system, Engine, Jan 22, 2015
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE INSTRUMENT PANEL LIGHTS ILLUMINATED AND THE VEHICLE WOULD HESITATE TO ACCELERATE. IN ADDITION, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE COMPUTER AND THE IGNITION COILS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE THE APPROXIMATE FAILURE MILEAGE WAS 114,000.
Engine and engine cooling, Dec 28, 2014
WAS PULLING AWAY FROM A STOP LIGHT AND VEHICLE WOULDN'T GO OVER 20 MPH BUT NO CHECK ENGINE LIGHT IS ON, IT'S NOT HIGH IDLING OR OVER HEATING. A WEEK PRIOR THE CHECK ENGINE LIGHT WAS ON AND WAS TOLD I HAD A MIS FIRE ON A CYLINDER AND I REPLACED THE SPARK PLUG AND IGNITION COIL AND THE ENGINE LIGHT WENT OFF. *TR
Vehicle speed control, Engine, Fuel/propulsion system, Dec 23, 2014
AFTER TOTALING A 2004 ESCAPE, I PURCHASED ANOTHER 2005 ESCAPE BECAUSE I LOVED IT. WELL NOT SO MUCH ANYMORE. I BOUGHT THE VEHICLE FROM A DEALERSHIP IN SEPTEMBER 2012. ONLY THREE SHORT MONTHS LATER I STARTED HAVING THE EXACT SAME PROBLEM I AM READING IN ALL COMPLAINTS. I TRIED TO PUSH ON THE GAS AND NOTHING. IT WAS MISFIRING BAD. I THEN TOOK IT TOO A SHOP AND THEY TOLD ME COILS 1, 3, AND 5 WERE OUT AND NEEDED TO BE REPLACED. THE DEALERSHIP WANTED CLOSE TOO $2,000 TO REPAIR IT. I WAS FURIOUS BECAUSE I HAD BOUGHT MY 2004 FROM THE SAME DEALERSHIP AND MY FAMILY ALONE HAD PURCHASED A TOTAL OF 6 VEHICLES FROM THE DEALERSHIP. I WAS A LOYAL CUSTOMER AND WAS NOT GOING TO PAY TO HAVE IT FIXED. SO THEY SPLIT THE COST OF $1000 WITH ME. NOW IT IS ACTING UP AGAIN AND I'VE REPLACED THE FUEL FILTER AND THE THERMOSTAT BC THAT'S WHAT THE COMPUTER SAID ONLY FOR IT TO STILL NOT BE RUNNING. I AM A SINGLE MOTHER, COLLEGE STUDENT, AND SERVER AND IT'S 2 DAYS BEFORE CHRISTMAS SO I AM VERY DISAPPOINTED! FIX THE PROBLEM FORD!! *TR
Suspension, Engine and engine cooling, Structure, Nov 29, 2014
COMPLAINT ONE: EXCESSIVE RUSTED PASSENGER SIDE REAR WHEEL WELL AND STRUT MOUNT, STRUT MOUNT BROKE AWAY. COMPLAINT TWO: RUSTED ENGINE CRADLE CAUSED PASSENGER SIDE FRONT HALF SHAFT TO SEPARATE FROM CENTER OF THE CAR CAUSING THE TO STOP MOVING FOREWORD AND LOSS OF STEERING. *TR
Engine, Nov 24, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
Electrical system, Engine, Nov 21, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 65 MPH, THE CHECK ENGINE AND POWER LOSS INDICATOR ILLUMINATED CONTINUOUSLY, WHICH CAUSED THE VEHICLE TO STALL. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE HYBRID SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 110,000.
Engine and engine cooling, Nov 15, 2014
HAVE TAKEN AUTO TO TWO DIFFERENT MECHANICS HAVE GOTTEN A LOT OF DIFFERENT RESULTS. HAVE PAID QUITE A BIT STILL HAVE PROBLEMS WITH AUTO COASTING THEN STALLING & CONKING OUT ALL TOGETHER. WOULD LIKE TO KNOW IF THERE HAS BEEN RECALL ON ISSUE.. THANK YOU *TR
Suspension, Structure, Engine, Sep 17, 2014
RIGHT REAR WELL CORRODED EXTENSIVELY. 4 INCH HOLE EXPOSING HIGH VOLTAGE BATTERY IN TRUNK TO WATER, SALT, SNOW. DEALER STATES THAT VEHICLE IS UNSAFE TO DRIVE DUE TO RISK OF COLLAPSE OF STRUTS AND RISK OF EXPLOSION/FIRE FROM HIGH VOLTAGE BATTERY EXPOSURE. QUOTES MORE THAN $4000 TO REPAIR THIS VEHICLE WITH ONLY 59,510 MILES. REAR BUMPER AND REAR SUSPENSION BOTH COMPROMISED. REAR BUMPER HAS NO SUPPORT ON RIGHT SIDE RISKING PASSENGER INJURY IN ACCIDENT. REAR SHOCK STRUT COLLAPSING. REQUEST INVESTIGATION AND RECALL ACTION. *TR
Power train, Service brakes, Engine, Sep 16, 2014
WHEN THE VEHICLE IS WARMED UP AND DECELERATING BELOW 40MPH THEY GASOLINE ENGINE WILL SHUT OFF AS THE REGENERATIVE BRAKING CHARGES THE HYBRID HIGH VOLTAGE BATTERY. ON A RARE OCCASION DURING THIS BRAKING, THE GASOLINE ENGINE WILL TURN BACK ON GIVING A BRIEF SURGE WHICH REQUIRES PRESSING THE BRAKE HARDER. IT HAS DONE THIS SINCE I BOUGHT THE VEHICLE. *TR
Engine, Sep 12, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING DOWNHILL ON A STEEP ROAD AT 40 MPH, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART BUT THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. UPDATED 12/24/14*LJ UPDATED 9/28/2015*JS
Power train, Electrical system, Engine, Sep 12, 2014
VEHICLE WAS SHIPPED TO GERMANY DUE TO MILITARY DUTY. A WEEK LATER AFTER DELIVERED, MY WIFE WAS DRIVING IT GOING DOWN A SHORT HILL WHEN THE VEHICLE TURNED OFF COMPLETELY AND BRAKES WERE NOT FUNCTIONING. MY WIFE HAD TO STOP THE VEHICLE WITH PARKING BRAKE. AFTER THAT THE ENGINE WAS LOSING POWER AND THE ALARM WAS GOING OFF VERY OFTEN. WE DROVE THE VEHICLE FEW OCCASIONS AND IT TURNED OFF COUPLE OF TIMES AGAIN.I ORDERED THE PART AND REPLACED IT IN 2014. THE VEHICLE IS RUNNING FINE, HOWEVER THE ALARM STILL GOING OFF AND ENGINE LIGHT IS ON AGAIN ON DASHBOARD. AT THIS POINT I DO NOT KNOW IF THE VEHICLE IS INDICATING THE SAME PROBLEM OR SOMETHING NEW. *TR
Engine, Sep 4, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AN UNKNOWN SPEED, THE VEHICLE STARTED TO SPUTTER AND THE ENGINE WOULD STALL. THE CONTACT MENTIONED THAT THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000.
Engine and engine cooling, Electrical system, Aug 27, 2014
I'VE ALWAYS BEEN A STAUNCH DEFENDER OF THE FORD BRAND...UNTIL NOW. THE MORE RESEARCH I DID ON THE LINK BETWEEN FAULTY FACTORY-INSTALLED SPARK PLUGS AND PCM FAILURE, AND FORDS KNOWLEDGE OF THIS LINK FROM THE GET-GO, THE ANGRIER I BECOME. THERE IS A TSB OUT ON THIS "KNOWN" ISSUE HOWEVER THE WARRANTY PERIOD ONLY EXTENDS UP TO 80,000 MILES. PRETTY CONVENIENT SINCE THE AVERAGE FAILURE MARKER IS 98K MILES. ALSO CONVENIENT THAT FORD WAITED UNTIL 99.99% OF ALL AFFECTED DRIVERS WOULD BE OUTSIDE OF THEIR "WARRANTY" PERIOD BEFORE GRACIOUSLY EXTENDING SAID "WARRANTY". HOGWASH. I CONSIDER MYSELF FORTUNATE THAT MY FAILURE DID NOT CAUSE AN ACCIDENT (BECAUSE YOU KNOW, LOSS OF ALL ELECTRICAL CONTROL AT 70 MPH IS NOT HIGH ON MY BUCKET LIST). I BROUGHT IT INTO MY MECHANIC . DIAGNOSTICS WAS THE # 3 COILS WAS BAD. IT WAS REPLACED AND RETESTED. IT SHOWED THAT IT WAS GOOD BUT THE NEXT COIL WAS BAD AND THE ENGINE LIGHT WAS STILL ON. WE TOOK THE CAR TO FORD AND WAS TOLD THAT THE PCM WAS BAD AND NEEDS TO BE REPLACED 2,100 LATER STILL HAVING ISSUES. ON THE WAY HOME FROM THE SHOP I NOTICED IT WAS STILL HESITATING SLIGHTLY, BUT NOTHING LIKE IT WAS .NO, IT WILL NOT LAST FOREVER BUT KNOWN ISSUES SUCH AS THESE REALLY CHAP MY HIDE!!! THIS HAS SOURED ME OFF FORD FOREVER AT THIS POINT. DISAPPOINTING, DANGEROUS AND DOWNRIGHT DECEPTIVE. WHY WON'T FORD DO A RECALL ON THIS? SAFETY IS AN ISSUE.... *TR
Engine, Aug 7, 2014
I JUST BOUGHT THIS CAR AND MY CHECK ENGINE LIGHT CAME ON. I TOOK IT TO THE MECHANICS AND THEY FIXED ONE OF THE COILS. IT STILL DID THE SAME THING AFTER I GOT IT BACK[ SPUTTERING]. I WENT TO WAL-MART AND COMING BACK IT CUT OFF ON ME. LUCKILY I WAS AT A STOP, BUT IFI HAD OF BEEN GOING AT FULL SPEED IT WOULD HAVE HURT ME AND MY SEVEN YEAR OLD BECAUSE SINCE IT HAS POWER STEERING, WHEN IT CUT OFF THE STEERING WHEEL GOES STIFF. FROM WHAT I HAVE SEEON THE INTERNET THIS IS A COMMON PROBLEM AND THE FORD PLACE WILL NOT DO ANYTHING ABOUT IT. PLEASE INVESTIGATE IT. I THINK THAT THIS WOULD HELP OTHER PEOPLE. *TR
Electrical system, Engine, Jul 18, 2014
I BOUGHT A USED 2005 FORD ESCAPE LIMITED 6 DAYS AGO IT WAS RUNNING FINE NO PROBLEMS LIGHTS OR WARNINGS. THEN I WAS DRIVING DOWN THE HIGHWAY ACCELERATING TO 50MPH AND MY DASHBOARD LIT UP LIKE A CHRISTMAS TREE AND STOPPED RUNNING. I TOWED IT BACK TO WHERE I GOT IT AND THEY STATED THAT THE COMPUTER WAA FRIED. NOW I AM WAITING FOR THEM TO REPLACE IT. I HAVE SEEN SIMILIAR COMPLAINTS ABOUT THE SAME MODEL AND YEAR. FRIED COMPUTER DUE TO IGNITION COILS. I BELIEVE WITH AS MANY COMPLAINTS ABOUT THIS RECURRING PROBLEM THERE SHOULD BE A RECALL, BUT I GUESS WE HAVE TO WAIT TILL SOMEONE DIES BECAUSE OF IT. A SHAME THAT'S THE ONLY WAY THINGS GET DONE. *TR
Engine, Jul 8, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, ALL WARNING LIGHTS STARTED BLINKING AND ILLUMINATING ON THE CONTROL PANEL. THE CONTACT MENTIONED THAT IMMEDIATELY AFTER THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT NO REPAIRS HAD BEEN MADE. THE DEALER WAS CONTACTED AND STATED THAT THE TRANSMISSION NEEDED TO BE PULL APART TO DETERMINE IF THE TORQUE CONVERTER CAUSED THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 76,382.
Power train, Engine, Jun 24, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE VEHICLE STALLED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD AND TURNED OFF. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE ON SEVERAL OCCASIONS BUT IT FAILED TO START. THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND THE STEERING BECAME DIFFICULT TO MANEUVER. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE PCM AND THE ELECTRIC SPARK COILS NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER A REMEDY. THE FAILURE AND CURRENT MILEAGE WAS 113,000. CN10/24/14*CN UPDATED 04/16/2015 *JS
Power train, Electrical system, Engine, Jun 5, 2014
TRAVELING ON THE HIGHWAY AT 55 MILES PER HOUR AND THE ENTIRE ENGINE STALLED AND CUT OFF. I HAD THE CAR TOWED TO A LOCAL SHOP WHERE THEY TOLD ME THAT 3 OUT OF THE 6 COILS BASICALLY WERE NOT WORKING AND THE PCM/COMPUTER WAS COMPLETELY SHOT, THEY WANTED OVER $1600 AT DEALERSHIP TO FIX THIS. FORD HAD APPARENTLY DISTRIBUTED A BULLETIN ABOUT THIS PROBLEM TO THE DEALERSHIPS BUT NOT THEIR CUSTOMERS - WHO THIS PROBLEM AFFECTS THE MOST. I WAS LUCKY THAT I WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD AND NOT HIT ANYONE OR GET KILLED. I CAN'T IMAGINE HOW MANY PEOPLE THIS HAS AFFECTED BECAUSE IT IS ALL OVER THE INTERNET. THE REPAIR ENDED UP COSTING WELL OVER $1000 BECAUSE OF THE SPARK PLUGS THAT FORD KNEW WERE FAULTY YEARS AGO. A SIMPLE CHANGING OF THE SPARK PLUGS INSTEAD OF SIX COILS. I SEE NO DIFFERENCE IN GM HAVING TO RECALL VEHICLES THAT SHUT OFF ON THE HIGHWAY AND FORD HAVING TO RECALL THESE VEHICLES FOR BASICALLY THE SAME REASON AND REIMBURSE THEIR CUSTOMERS, OUR CARS ARE SHUTTING OFF TOO. *TR
Electrical system, Engine, May 29, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE WATER PUMP FOR THE HYBRID BATTERY FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 75,000. THE VIN WAS NOT AVAILABLE.
Electrical system, Engine, May 27, 2014
MY 2005 FORD ESCAPE 3.0 V6 HAD A COIL ISSUE THAT FORD KNEW ABOUT AND SENT SERVICE BULLETINS TO DEALERS, BUT NOT THE AFFECTED PARTIES. THE COILS WERE DEFECTIVE FROM A VENDOR AND WHEN THEY FAILED, BURNT OUT THE PSM, MAKING THE AUTOMOBILE UNUSABLE AND EXPENSIVE TO FIX. FORD HAS KNOWN ABOUT THIS SINCE 2011 AND HAS DONE NOTHING TO RECTIFY IT, OR HELP, ALL OF THOSE WHOSE ESCAPES HAVE STOPPED RUNNING COMPLETELY. MINE HAD THIS GO OUT AND NOW THE PARTS ARE ON BACK ORDER FOR MONTHS, AS WELL AS INCREDIBLY EXPENSIVE. PLEASE HELP TO GET FORD TO ORDER A RECALL ON THIS FOR ALL OF US. *TR
Fuel system, Gasoline, Electrical system, Engine, May 23, 2014
I TURNED A CORNER AND WAS ONLY GOING 20 MPH WHEN THE VEHICLE WENT DEAD. I HAD NO CONTROL SO LUCKILY I WASN'T GOING FAST. I STOPPED THE VEHICLE. I HAD TO GET IT TOWED. ONE MECHANIC SAID MY COILS AND SPARK PLUGS WERE BAD BECAUSE OF THE FUEL RAIL PRESSURE SENSOR MALFUNCTION. SECOND OPINION - THE PCM NEEDED TO BE REPROGRAMMED OR REPLACED. THIRD OPINION - ALL OF THE ABOVE. IT COSTS $1900 AND TWO TOW BILLS ($275). THE ENGINE LIGHT HAD BEEN ON FOR SEVERAL MONTHS. THE ONLY CODE WAS THE FUEL RAIL PRESSURE SENSOR HIGH INPUT (P0193 GENERIC). *TR
Electrical system, Engine, May 3, 2014
0 *TR