2005 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,584 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Escape model years with reports.
Of the 2005 reports, 44 involved a crash and 20 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
Seats, front assembly, head restraintApr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V111000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Representative owner complaints: engine
251 reports, newest first. Show all
Engine and engine cooling, Electrical system, Feb 14, 2012
AT HIGHWAY SPEED, THE ENGINE SUDDENLY SHUT ITSELF OFF. AT THE SAME TIME, A DASHBOARD READOUT DISPLAYED THE MESSAGE "STOP SAFELY NOW." IN ORDER TO GET TO THE SHOULDER OF THE ROAD I WAS FORCED TO CUT ACROSS A LANE OF TRAFFIC WITHOUT WARNING AND WITHOUT POWER. NO OTHER WARNING LIGHTS OR SIGNALS DISPLAYED. HAD THERE BEEN NO SHOULDER, I COULD EASILY HAVE BEEN A HIGH-SPEED CRASH. THE ENGINE STARTED AGAIN AS SOON I TURNED THE KEY AFTER STOPPING THE VEHICLE, BUT STILL NO WARNING LIGHTS OR EXPLANATIONS DISPLAYED. THIS HAPPENED THREE TIMES DURING A 3-HOUR TRIP ACROSS MARYLAND, AND IT HAPPENED AGAIN ONCE ON THE RETURN TRIP TWO DAYS LATER. AN INTERNET SEARCH REVEALS THAT THIS IS NOT AN UNCOMMON PROBLEM WITH FORD HYBRIDS, YET NO RECALL HAS BEEN ISSUED TO REMEDY THIS EXTREMELY DANGEROUS DEFECT. *TR
Engine and engine cooling, Feb 9, 2012, fire
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 65 MPH. THE VEHICLE VIBRATED AND THE CHECK ENGINE LIGHT ILLUMINATED WHILE THE FAILURE OCCURRED. THE CONTACT ALSO NOTICED SMOKE RISING FROM UNDER THE HOOD. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER. THE DEALER STATED THAT METAL PARTICLES PENETRATED THE ENGINE AND THE ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGES WERE. 80,000.
Engine and engine cooling, Feb 6, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WOULD MISFIRE AT ANY TIME. THE DEALER DIAGNOSED THAT THE SPARK PLUGS, COIL AND COMPUTER FAILED AND WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 123,000. THE VIN WAS UNAVAILABLE.
Engine and engine cooling, Feb 6, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WOULD VIBRATE VIOLENTLY WHILE DRIVING AT VARIOUS SPEEDS. THE DEALER DIAGNOSED THAT THE MOTOR MOUNTS WOULD NEED REPLACING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS REPAIRED. THE FAILURE AND HE CURRENT MILEAGE WAS 53,423.
Engine and engine cooling, Feb 2, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT WAS DRIVING 50 MPH WHEN THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC FOR A DIAGNOSTIC TEST. THE MECHANIC STATED THAT THE SPARK PLUGS WERE INSTALLED INCORRECTLY AND AFFECTED THE ELECTRONIC CONTROL MODULE. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 127,000.
Engine and engine cooling, Fuel system, Gasoline, Jan 30, 2012, fire
#5 SPARK PLUG BLEW OUT OF CYL HEAD CAUSING MINOR FIRE FROM FUEL IN CYLINDER WHEN INJECTOR FIRED. COULD HAVE BEEN MAJOR, HAVE HEARD MANY OTHER FORD OWNERS WITH SAME PROBLEM. *TT
Engine and engine cooling, Jan 25, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. AFTER COASTING TO THE SIDE OF THE ROAD THE VEHICLE WAS ABLE TO BE RESTARTED WITHIN A FEW MOMENTS. THE VEHICLE STALLED APPROXIMATELY THREE ADDITIONAL TIMES AS THE CONTACT PROCEEDED DRIVING AND AFTER THE THIRD STALL, THE VEHICLE COULD NOT BE RESTARTED. THE VEHICLE WAS TOWED TO THE DEALER WHO ADVISED THAT THE COILS IN THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED FOR THE COILS. APPROXIMATELY 20,000 MILES LATER, THE FAILURE RECURRED AND THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT THE COILS HAD FAILED ONCE AGAIN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
Engine and engine cooling, Power train, Jan 20, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE STOPPED AT A TRAFFIC STOP, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE TORQUE CONVERTER WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,064. UPDATED 02/15/12*BF UPDATED 03/16/12
Engine and engine cooling, Electrical system, Vehicle speed control, Jan 14, 2012
THE FIRST ISSUE I HAD WITH MY CAR WAS IN DECEMBER OF 2010. I IMMEDIATELY TOOK MY CAR TO A REPAIR PLACE AND THEY TOLD ME THAT THE COILS AND THE PLUGS WERE OUT AND THAT THEY NEEDED TO BE REPLACED. I ASSUMED THAT THIS WAS JUST TIME TO GET THIS REPAIRED BECAUSE MY CAR WAS RIGHT OVER THE 100,000 MILE MARK. EVERYTHING SEEMED FINE UNTIL MAY OF 2011 WHEN THE PROBLEM RETURNED. THIS TIME I TOOK MY CAR TO A FORD SERVICE CENTER. THIS TIME I NOTICED THAT MY CAR WOULD RUN OK UP TO ABOUT 35 MPH AND THEN AFTER THAT SPEED IT WOULD START JERKING. IF I TAKE MY FOOT OFF THE GAS IT STOPS, BUT IF I LEAVE MY FOOT ON THE GAS AND CONTINUE TO ACCELERATE, THE CAR SHUTS OFF COMPLETELY. I HAVEN'T TAKEN MY CAR ANYWHERE THAT I HAVE TO DRIVE OVER 45MPH BUT RECENTLY I NOTICED THAT IF I TRY TO ACCELERATE PAST 35, THAT INSTEAD OF JERKING TO TURN MY CAR OFF, THE HARDER I PUSH THE GAS, IT FEELS LIKE I AM PUSHING THE BRAKE WITH THAT SAME INTENSITY WHEN I HAVEN'T EVEN TOUCHED THE BRAKE. IM AFRAID THAT WHILE PUSHING THE GAS, THE CAR IS GOING TO BRAKE AND THAT SOMEONE ELSE IS GOING TO SLAM INTO THE BACK OF MY CAR AND HURT MY 2 YR OLD SON IN HIS CARSEAT IN THE BACK. I AVOID DRIVING THIS CAR UNLESS I ABSOLUTELY HAVE TO BECAUSE IT IS DANGEROUS. IT SEEMS THAT MANY OTHER OWNERS OF THE SAME CAR I HAVE ARE HAVING THE SAME OR A SIMILAR ISSUE. THIS REALLY NEEDS TO BE CHECKED INTO BECAUSE FORD IS AWARE THAT THIS IS A COMMON ISSUE BUT WILL DO NOTHING ABOUT IT. IT SEEMS LIKE THEY ARE WAITING FOR SOMEONE TO GET HURT BEFORE THE ASSUME RESPONSIBILITY. *TR
Engine and engine cooling, Electrical system, Jan 9, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT IN AN ATTEMPT TO START THE VEHICLE, THE VEHICLE WOULD BEGIN TO SMOKE AND STALL WITHOUT WARNING. THE DEALER DIAGNOSED THAT THERE WAS A SHORT IN THE SPARK PLUGS, CAUSING THE VEHICLE TO STALL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 58,000 AND THE CURRENT MILEAGE WAS 68,200. UPDATED 02/09/12*LJ THE VEHICLE WAS REAIRED. UPDATED 02/13/12
Engine and engine cooling, Jan 9, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SHAKE VIGOROUSLY AND STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT COIL PACK NUMBER ONE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 71,000.
Engine and engine cooling, Electrical system, Dec 7, 2011
IN MY 2005 FORD ESCAPE XLT V6 3.0L ON 11/16/11, I WAS DRIVING EAST BOUND ON I55 TOWARDS CHICAGO AT APPROXIMATELY 55 MPH WHEN THE ENGINE STARTED BAD MISFIRING AND THE COMPLETELY DIED (NO POWER OR ENGINE). WITH NO POWER STEERING AND NO BRAKES, I ATTEMPTED TO STEERED TOWARD THE SHOULDER. I WAITED ABOUT 10 MINUTES AND TRIED TO RESTART AND WAS UNABLE. I HAD THE VEHICLE TOWED TO ROESCH FORD 333 W GRAND AVE BENSENVILLE, IL 60106. I WAS ADVISED BY THE SERVICE MANAGER THAT THE ENGINE WAS MISFIRING ON 4 OF THE 6 CYLINDERS AND THAT THEY WOULD NEED TO REPLACE THE PCM, 6 COILS, 6 PLUGS AND CALIBRATE, TOTAL $2,114.21. I DECIDED TO DO SOME RESEARCH ONLINE AND FOUND NUMEROUS PEOPLE EXPERIENCING THE SAME PROBLEM. THERE ARE MULTIPLE TSB: TSB 05-11-1,TSB 09-02-06 TSB 09-02-06 AND TSB 10-18-10. THE PROBLEM IS: THE WRONG SPARK PLUGS WERE INSTALLED AT THE FACTORY. THIS COMBO OF WRONG PLUGS CAUSES THE COILS TO SEND EMI/RFI BACK TO THE PCM (POWERTRAIN CONTROL MODULE) BURNING OUT THE PCM.EMI/RFI IS EMITTED FROM SPARKING DEVICE,IN THIS CASE A SET OF BAD SPARK PLUGS. THIS CAUSES THE VEHICLE TO MISS-FIRE, LOSE POWER, OR IN MANY CASES, HAVE TOTAL ENGINE FAILURE. WRONG SPARK PLUGS/BAD COP'S/UN-SHIELDED PCM BOX/POORLY ENGINEERED & UN-TESTED, MULTI-CHANGED, RARE PCM AND IT'S THE $12.50 RADIO FREQUENCY INTERFERENCE DEVICE. MULTIPLE ONLINE COMPLAINTS/PROBLEMS: HTTP://WWW.CARCOMPLAINTS.COM/FORD/ESCAPE/2005/ELECTRICAL/POWERTRAIN_CONTROL_MODULE_PCM_FAILURE.SHTML HTTP://WWW.FORDFORUMSONLINE.COM/FORUM/FORD-ESCAPE/643-2005-FORD-ESCAPE-PCM-ECM-COMPUTER-FAILURE.HTML HTTP://WWW.YELLOWBULLET.COM/FORUM/SHOWTHREAD.PHP?T=199403 REPAIRED. THEN CHECK ENGINE LIGHT. NOW IT NEEDS 2 CATALYTIC CONVERTERS $2,500 BECAUSE OF PCM/COIL. TOTAL $4,500 NUMEROUS COMPLAINTS EXTREME SAFETY ISSUE! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine and engine cooling, Dec 5, 2011
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 60 MPH. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED A TOTAL OF AT LEAST FOUR TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE COMPUTER SYSTEM WAS REPLACED. THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 55,000.
Engine and engine cooling, Power train, Nov 12, 2011
THIS 2005 ESCAPE FAILED WHEN DRIVING THROUGH THE MOUNTAINS IN NORTHERN CALIFORNIA. FORD HAS DOCUMENTED THAT SPARK PLUGS INSTALLED BY FORD AT THE FACTORY CAN CAUSE ALL COILS AND THE PCM TO FAIL AS THEY DID IN THIS CASE. THREE TSB'S HAVE BEEN GENERATED RELATED TO THIS PROBLEM. MY CAR WAS REPAIRED UNDER WARRANTY AT APPROXIMATELY 60000 MILES AND THE PLUGS WERE NOT CHECKED AND REPLACED AS REQUIRED IN THE FORD TSB'S. THIS WAS AN EXPENSIVE $2300 + REPAIR THAT FORD SHOULD TAKE RESPONSIBILITY FOR. GOOD FAITH WAS NOT DEMONSTRATED IN SOLVING THIS PROBLEM AND FORD REFUSES TO ACKNOWLEDGE THEIR RESPONSIBILITY. *TR
Engine and engine cooling, Nov 1, 2011
2005 FORD ESCAPE. CONSUMER STATES PROBLEMS WITH VEHICLE STALLING WHILE DRIVING. *TGW
Engine and engine cooling, Power train, Oct 30, 2011
DRIVING ALONG INTERSTATE ENGINE SUDDENLY LOST POWER, WOULD NOT GO ABOVE 20MPH, NO CHECK ENGINE LIGHT. TOOK TO REPAIR SHOP AND FIRST CATALYTIC CONVERTER COMPLETELY CLOGGED, NUMBER 2 CONVERTER PARTIALLY CLOGGED. VEHICLE ONLY HAS 84,000 MILES. WARRANTY EXPIRED AT 80,000 MILES FOR EXHAUST. REPAIR SHOP THIS HAPPENS A LOT FOR THESE VEHICLES. *TR
Engine and engine cooling, Sep 6, 2011
CATALYTIC CONVERTERS AND FLEX PIPE THE CATALYTIC CONVERTERS HAVE BEEN DIAGNOSED AS HAVING SIGNIFICANT RESTRICTION TO CAUSE DRAMATIC POWER LOSS TO THE VEHICLE WHILE DRIVING. THIS CONDITION CAUSES ABNORMAL BACK PRESSURES IN THE EXHAUST SYSTEM WHICH ALSO CAUSES MULTIPLE MISFIRES AND SETS THE CHECK ENGINE LIGHT. THE FLEX PIPE IS ALSO DEFECTIVE AND LEAKS. I HAVE OWNED MANY FORD VEHICLES THROUGH THE YEARS. ONE WAS A 1994 LINCOLN TOWN CAR WITH OVER 400,000 MILES. ANOTHER WAS A 1998 TOWN CAR WITH OVER 200,000 MILES. NEVER ONCE DID I HAVE TO REPLACE ANYTHING ON THE EXHAUST SYSTEM,ESPECIALLY CATALYTIC CONVERTERS (THE MOST EXPENSIVE PART IN THE SYSTEM). THIS IS UNACCEPTABLE AND A RECALL NEEDS TO BE INITIATED TO RESOLVE THIS. NOT ONLY IS THIS A SAFETY AND MORAL ISSUE BUT AN ENVIRONMENTAL ON AS WELL. *TR
Engine and engine cooling, Aug 11, 2011
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS, WHERE THE MECHANIC STATED THAT THE HARD DRIVE IN THE ENGINE CONTROL MODULE FAILED AND THE ENGINE CONTROL MODULE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Engine and engine cooling, Jul 14, 2011, fire
WHILE OUT OF TOWN SUNDAY JULY 10TH 2011, 300 MILES FROM HOME MY 2005 FORD ESCAPE CAUGHT ON FIRE, OD 90046. WE GOT IN THE CAR STARTED IT UP AND THEN WHEN LOOKING AT THE MAP I LOOKED UP AND SMOKE WAS POURING OUT FROM UNDER THE HOOD. AS I JUMPED OUT THE DOOR CAME BACK AND GOUGED MY NOSE OPEN. WHILE BLEEDING ALL OVER THE PLACE I OPENED THE HOOD AND POURED WATER OVER THE FIRE. THE CAR HAD CAUGHT ON FIRE JUST UNDER THE REAR SIDE OF THE INTAKE MANIFOLD. AFTER EXTINGUISHING THE FIRE, I CALLED THE LOCAL SANTA MARIA FORD DEALER, WHO ONLY OFFERED OUR SERVICE DEPARTMENT WILL BE OPEN TOMORROW. I HAD THE VEHICLE TOWED TO THE DEALER THAT DAY AND WHILE THERE DECIDED TO HAVE MY WIFE LOOK AT A NEW CAR. REGARDLESS OF THE FACT THAT I PUT THE FLAMES OUT EARLY AND I AS A MAINTENANCE OFFICER WITH 24 YEARS EXPERIENCE I COULD HAVE FIXED THE CAR, I WANTED MY WIFE TO HAVE A NEW CAR SO WHEN I LEAVE HER BEHIND FOR MY NEXT DUTY STATION IN THE MARINE CORPS AND DEPLOY, I WOULD NOT HAVE ANY WORRIES. THE SALES EXPERIENCE WAS WHAT I EXPECTED BUT MY BIGGEST ISSUES WERE THAT, ALTHOUGH THE SERVICE DEPARTMENT WAS CLOSED, OUT OF LUCK, YEA RIGHT, THE SERVICE MANAGER STOPPED BY TO WORK ON HIS RV AND ASSISTED IN THE APPRAISAL OF MY 2005 ESCAPE THEN LEFT BEFORE I KNEW HE WAS THERE. DUE TO THE FORD DEFECT, FIRE DAMAGE, THEY OFFERED MY $2,000 FOR A TRADE IN. I TALKED THEM INTO AROUND $4,200. I HAD A CAR THAT COST ME $28,000 SIX YEARS AGO AND DUE TO A DEFECT I GOT AROUND $4,200 FOR IT IN GREAT SHAPE, EXCEPT THE VERY SMALL FIRE DAMAGE> LUCKILY WE HAD THE FIRE IN A PARKING LOT NOT WHILE ON A BACK ROAD, OFF ROAD, TRAFFIC JAM. FROM RESEARCH EARLIER ESCAPE MODELS HAVE A HISTORY OF ENGINE FIRES, AND SOME OF THE LATER, BUT NOTHING TO DATE ON THE 2005. FORD CORPORATE HAS YET TO CONTACT ME ABOUT MY COMPLAINT, I AM ASKING THEM TO ACKNOWLEDGE THE PROBLEM AND HOPE THEY WOULD COMPENSATE ME FOR THE LOST VALUE IN MY TRADE IN DUE TO SOME TYPE OF OBVIOUS DEFECT IN THEIR PRODUCT. CASE # [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine and engine cooling, Jun 6, 2011
NOTHING LET UP TO THE FAILURE. CAR DIED WHILE PULLING OUT IN TRAFFIC. WAS TOLD IT WAS THE COIL PACKS GONE BAD. REPLACED THEM. THEN TOLD THE CATALYTIC CONVERTER BURN OUT WHEN THE COILS WENT. COME TO FIND OUT THIS IS A ISSUE FOR IS AWARE OF ON THE 2005 ESCAPE. I WAS ALMOST REAR ENDED WHEN THIS HAPPENED AND HAS A HARD TIME GETTING OFF THE ROAD. NO INDICATION IT WAS GOING TO STALL. THIS IS A SAFETY ISSUE ON THESE CARS. I HAVE ALREADY PUT OUT CLOSE TO $200.00 AND ITS STILL NOT FIXED. IT ALSO HAS BLOWN UP MY COMPUTER IN THE CAR. I WAS SCARED TO DEATH AND VERY LUCKY THAT I WAS NOT HIT. FORD IS AWARE OF THIS PROBLEM AND WILL DO NOTHING ABOUT IT. WHAT WILL IT TAKE FOR SOME ACTION TO BE TAKEN? SOMEBODY GETTING KILLED BEFORE FORD IS MADE TO DO SOMETHING WITH THIS ISSUE. *TR
Engine and engine cooling, Jun 4, 2011
HIGHWAY DRIVEING 55 MPH JUST SHUT DOWN IN CENTER LANE PULLED OVER TO SHOULDER WARNING LIGHTS ON NO POWER RE STARTED IT WAS OK THIS WAS THE 2 TIME THIS HAS HAPENED IN 3 MO..
Steering, Engine and engine cooling, Electrical system, May 23, 2011
I AM A WEDDING PHOTOGRAPHER AND WHILE TRAVELING ABOUT 4.5 HOURS AWAY FROM HOME TO SHOOT A WEDDING I HAD PROBLEMS ABOUT 2 HOURS INTO MY TRIP. I WAS ON INTERSTATE 20 JUST OUTSIDE OF COLUMBIA, SC. I WAS IN THE LEFT HAND LANE BEHIND A SEMI TRUCK, THERE WAS ANOTHER SEMI TRUCK IN THE RIGHT LANE BESIDE ME AND BEHIND ME I HAD A LARGE VAN. I WAS GOING ABOUT 65-70 WHEN SUDDENLY, THE CAR LOST ALL POWER INCLUDING THE STEERING AND ALL THE WARNING LIGHTS BLINKED ON. I SOMEHOW REGAINED CONTROL OF THE CAR BY SHIFTING IN NEUTRAL AND RESTARTING. I HATE TO THINK WHAT WOULD HAVE HAPPENED HAD I NOT BEEN ABLE TO REACT AS FAST AS I DID AS THE VAN BEHIND ME HAD TO SLAM ON HIS BREAKS TO KEEP FROM HITTING ME. ONCE THE SEMI TRUCK WAS CLEARED OF THE RIGHT LANE I GOT OVER AND TURNED ON MY FLASHERS. SINCE I HAD IT RUNNING I WAS TOO SCARED TO PULL OVER ON THE SIDE. I GOT TO MY NEAREST EXIT AND PULLED OVER. I TURNED OFF THE VEHICLE AND ALL THE WARNING LIGHTS WENT OFF EXCEPT THE ABS AND THE CHECK ENGINE LIGHT. I RESTARTED AND DROVE ABOUT A MILE TO A MECHANIC. THEY COULD NOT SEE ANYTHING WRONG BUT HEARD THE MISFIRE. THE CAR WAS TOWED TO CLASSIC FORD IN COLUMBIA, SC. I HAD TO RENT A CAR TO FINISH MY TRIP AS I COULDN'T LET DOWN A COUPLE ABOUT TO BE MARRIED. I JUST GOT THE ESTIMATE TO THE TUNE OF OVER $2700.00. IT'S THE PCM MODULE ALONG WITH COIL, SPARK PLUGS AND A FEW OTHER THINGS. I AM NOW DEBATING ABOUT WEATHER TO FIX IT OR NOT AS ALL THE REVIEWS I HAVE READ IT SEEMS LIKE PEOPLE CONTINUE TO HAVE PROBLEMS AFTER IT'S FIXED. IT SOUNDS LIKE FORD REALLY NEEDS TO FIGURE OUT A WAY TO FIX THIS CHRONIC PROBLEM BEFORE SOMEONE DIES IN AN ACCIDENT.
Engine and engine cooling, Power train, May 20, 2011
EMAIL FROM SENATOR ON BEHALF OF CONSTITUENT RE CONCERNS WITH HER 2005 FORD ESCAPE AUTOMOBILE (DESIGN OF THE POWERTRAIN CONTROL MODULE COMPUTER). *KB THE CONSUMER STATED WHILE DRIVING, ALL THE LIGHTS ON THE DASHBOARD ILLUMINATED. WHEN SHE ARRIVED AT THE REPAIR SHOP, THE MECHANIC PERFORMED A DIAGNOSTICS TEST WHERE IT WAS DETERMINED THAT A CYLINDER WAS NOT FIRING. AFTER FURTHER EXAMINATION, IT WAS DISCOVERED THE POWER CONTROL MODULE WAS DAMAGED. *JB
Engine and engine cooling, Structure, May 16, 2011, crash
THE COMPUTER SHORT, BECAUSE A WATER LEAK IN THE COMPUTER, THE VEHICLE STALLED ON THE BRIDGE. *TR
Engine and engine cooling, May 16, 2011
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WOULD LOSE POWER WHILE ATTEMPTING TO ACCELERATE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE ELECTRONIC CONTROL MODULE. IN ADDITION, THE SPARK PLUGS WERE DEFECTIVE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 100,000.