2005 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,584 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Escape model years with reports.
Of the 2005 reports, 44 involved a crash and 20 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
Seats, front assembly, head restraintApr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V111000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Representative owner complaints: engine
251 reports, newest first. Show all
Engine and engine cooling, May 15, 2011
2005 FORD SHUTS OFF AFTER LONG DISTANCE OR NO DISTANCE SHUTTER LIKE YOU ARE PUSHING IN A CLUTCH BUT THIS IS MANUEL DRIVE THAN SHUTS DOWN DEALER SAYS THEY CAN'T FIND PROBLEM. *TR
Engine and engine cooling, Electrical system, May 12, 2011
EMAIL FROM THE OFFICE OF CONGRESSMAN REID RIBBLE ON BEHALF OF CONSTITUENT, RE PROBLEMS WITH HER 2005 FORD ESCAPE *TGW THE CONSUMER STATED THE VEHICLE STALLED WHILE DRIVING ON THE HIGHWAY. *JB
Engine and engine cooling, May 4, 2011
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING ON THE HIGHWAY THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO LOCAL MECHANIC WHO DIAGNOSED THAT TWO OF THE PLUGS AND COILS WERE DEFECTIVE AS A RESULT THE COMPUTER WAS DAMAGED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE WITH THE REPAIR. THE VEHICLE IDENTIFICATION NUMBER WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 54,000.
Engine and engine cooling, Apr 27, 2011
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 80 MPH, THE VEHICLE SUDDENLY STALLED AFTER AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO CONTINUE DRIVING ON THE BATTERY POWER AND THEN INDEPENDENTLY RESTARTED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED HIM THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. A FEW WEEKS LATER, THE EXACT FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC WHO ADVISED TAKING THE VEHICLE TO AN AUTHORIZED DEALER. THE DEALER INSPECTED THE VEHICLE AND ADVISED HIM THAT THE FAILURE WAS CAUSED BY THE COOLANT PUMP. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 74,000. THE VIN WAS UNAVAILABLE.
Engine and engine cooling, Apr 21, 2011
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. WHENEVER THE FAILURE RECURRED, THE GEAR WAS SHIFTED INTO NEUTRAL OR PARK IN ORDER TO RESTART THE ENGINE. THE FAILURE RECURRED THIRTY TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
Engine and engine cooling, Apr 5, 2011
I STARTED MY CAR AT WORK AND LEFT TO GO PICK UP MY DAUGHTER, I WASN'T DRIVING HARD OR FAST JUST GOING SLOW, AND ALL OF A SUDDEN I HEARD A LARGE EXPLOSION, I HAD TO PULL MY CAR OVER BECAUSE IT HAD BECOME LOUD AND UNABLE TO DRIVE. I OPENED THE HOOD AND FOUND THAT A SPARK PLUG HAD SHOT OUT OF THE HOLE IN THE HEAD OF MY CAR. THE SPARK PLUG HAD ACTUALLY DENTED THE HOOD OF MY CAR WHEN IT SHOT OUT. MY CAR HAS BEEN VERY VERY WELL MAINTAINED. THIS HAS NEVER HAPPENED BEFORE. THIS IS AN UNSAFE AND SCARY EXPERIENCE. THEY SAY THAT IT COULD COST $3500 TO $4000 TO FIX BY REPLACING THE HEAD BECAUSE THE THREADS STRIPPED AND FORD KNOWS THIS IS A PROBLEM. FORD NEEDS TO FIX THIS, BEFORE SOMEONE DOES GET HURT! *TR
Engine and engine cooling, Electrical system, Apr 3, 2011
WHILE DRIVING OUR 2005 FORD ESCAPE, WE WERE ON THE HIGHWAY, IN THE ACCELERATION LANE, TRAVELING APPROXIMATELY 45 MILES AN HOUR ACCELERATING UP TO 55, THE VEHICLE SUDDENLY SHUTTERED, AND THEN DIED, THE CHECK ENGINE, OVERDRIVE, ABS, AND AIRBAG LIGHTS ILLUMINATED ON THE CONSOLE. I HAD TO HIT THE HAZARD LIGHTS AND PUT THE VEHICLE INTO NEUTRAL NARROWLY AVOIDING BEING HIT BY A TRACTOR TRAILER TRUCK. I WAS ABLE TO MANEUVER THE VEHICLE TO THE SHOULDER. I ATTEMPTED TO RESTART THE VEHICLE AND WHILE IT RESTARTED IT WAS MISFIRING AND CHECK ENGINE LIGHT WAS ON. THE VEHICLE WAS UNABLE TO MOVE UNDER ITS OWN POWER. WE WERE ON THE SIDE OF A HIGHWAY WITH OUR 4 YEAR OLD DAUGHTER IN THE CAR DURING MORNING RUSH HOUR. THANKFULLY WE WERE NOT HIT AND KILLED BY THIS FORD ENGINE FAILURE. *TR
Engine and engine cooling, Electrical system, Other or unspecified, Mar 2, 2011
THE PROBLEM IS WHEN DRIVING 2005 FORD ESCAPE THE ENGINE CUTS OUT. WHEN DRIVING ON INTERSTATE 5 AT 60 MPH THE ENGINE WILL SHUT OFF AND THEN START BACK UP. THE THEFT LIGHT LIGHTS UP WHEN THIS HAPPENS. ALSO, AT ANY SPEEDS THE ENGINE WILL CUT OUT. EXAMPLE IS WHEN AT STOP SIGN AT INTERSECTION OR CROSS STREET, WHILE IN DRIVE AND PROCEEDING ACROSS INTERSECTION THE CARS ENGINE AND ALL ELECTRICAL WILL TURN OFF. I WILL THEN HAVE TO SHIFT CAR INTO NEUTRAL AND RESTART CAR AND THEN SHIFT INTO DRIVE AND PROCEED ACROSS INTERSECTION HOPEFULLY WITHOUT GETTING HIT FROM OTHER CARS. THIS HAS HAPPENED WITH A CAR FULL OF GRANDCHILDREN ON SEVERAL OCCASIONS. THE CARS ENGINE CUT OUT HAPPENS AT GREATER OCCURRENCES WHEN DRIVING UP INCLINES.
Engine and engine cooling, Feb 28, 2011
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 30 MPH UP A HILL THE CHECK ENGINE LIGHT BEGAN ILLUMINATING BEFORE THE VEHICLE STALLED. WITHIN A FEW MINUTES THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT THE VEHICLE WOULD ACCELERATE WITH MINIMAL SPEED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THREE IGNITION COILS WERE REPLACED. THE VEHICLE CONTINUED TO DRIVE WITH MINIMAL SPEED AND THE CONTACT WAS THEN TOLD THAT THE ENGINE COMPUTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 117,000. THE VIN WAS UNAVAILABLE.
Engine and engine cooling, Electrical system, Feb 8, 2011
IN DECEMBER 2010, MY 2005 FORD ESCAPE LIMITED STARTING MISFIRING AT 79,000 MILES AND THE SERVICE EMISSIONS SYSTEM MESSAGE CAME ON. I TOOK IT TO A FORD DEALERSHIP AND THEY COULDN'T GET THE LIGHT TO COME BACK ON OR ANY ERROR CODES TO APPEAR. THE NEXT DAY, THE MISFIRING HAPPENED AGAIN AND THE FORD DEALERSHIP DIAGNOSED IT AS A BAD PRC COMPUTER. FORD REPLACED THE MAIN COMPUTER, UNDER WARRANTY, AT ABOUT 79,900 MILES. THE MISFIRE WENT AWAY FOR ABOUT 3 WEEKS AND THEN RECURRED AT 82,000 MILES. THIS TIME, THE CAR DRAMATICALLY LOST POWER, WILL NOT PROPERLY SHIFT INTO GEAR, SHAKES WHEN IDLING AND MAXES OUT AT ABOUT 30 MPH ON ANY HILL. THE SERVICE EMISSIONS MESSAGE AND CHECK ENGINE LIGHT ARE CONSTANTLY ON. I TOOK IT TO THE SAME FORD DEALERSHIP AND THEY STATED THE COIL PACKS ARE ALL MISFIRING AND CAUSING THE MAIN COMPUTER TO FRY. THEY STATED THAT ALL 6 COILS NEED REPLACED AT A COST OF $900, AND THE MAIN COMPUTER ALSO NEEDS REPLACED AGAIN. THE COMPUTER REPLACEMENT WILL BE FREE, BECAUSE IT WAS JUST REPLACED 3 WEEKS AGO WHEN THE PART WAS STILL COVERED UNDER AN 80,000 MILE WARRANTY. THE REGULAR COST TO REPLACE THE COMPUTER WOULD HAVE BEEN AROUND $950. *TR
Engine and engine cooling, Jan 25, 2011
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS DIAGNOSED. THE TECHNICIAN ADVISED THAT THE SPARK PLUG, COILS AND MANIFOLD WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED BUT WAS LATER TOWED TO A SECOND AUTO REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE CATALYTIC CONVERTER AND COMPUTER WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 84,000. THE VIN WAS NOT AVAILABLE.
Engine and engine cooling, Jan 10, 2011
WHILE VACATIONING IN MYRTLE BEACH, MY 2005 FORD ESCAPE RAN SLUGGISH AND WAS MISSING AFTER A HEAVY RAIN. HAD IT TOWED TO THE LOCAL DEALER WHERE THEY TOLD ME THAT THE CASING FOR THE PCM HAD LEAKED AND WATER HAD GOTTEN INTO THE PCM AND CAUSED THE MALFUNCTION. THIS PROBLEM ALSO CAUSED THE PLUGS AND COILS TO NEED REPLACING. PARTS WERE NOT AVAILABLE AND HAD TO WAIT TWO WEEKS FOR REPAIRS. RECEIVED A CALL FROM DEALER SAYING THAT IT WAS ALSO NECESSARY TO REPLACE THE EXHAUST MANIFOLD AND THE CATALYTIC CONVERTER. ANOTHER 3 DAYS AND THE TOTAL BILL FROM THE DEALER WAS $5,262.38. ALONG WITH A RENTAL CAR FOR 1.5 WEEKS AND TWO ADDITIONAL DAYS IN HOTEL MADE FOR AN EXPENSIVE HOLIDAY. CALLED FORD CUSTOMER SERVICE WHEN I RETURNED HOME AND THEY WERE NOT EVEN INTERESTED IN MY SITUATION. NEEDLESS TO SAY, I WILL NEVER OWN ANOTHER FORD, AND AM NOW DRIVING JAPANESE. *TR
Engine and engine cooling, Dec 30, 2010
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE AT A TRAFFIC LIGHT, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MADE SEVERAL ATTEMPTS TO RESTART THE VEHICLE, THEN IT FINALLY STARTED. THE FAILURE BEGAN TWO MONTHS AGO. THE DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT THERE WERE NO RELATED RECALLS. THE DEALER ALSO PERFORMED A DIAGNOSTIC TEST WHICH CONCLUDED THAT THE COIL FAILED AND THAT THE POWER CONTROL MODULE NEEDED TO BE REPAIRED. THE CONTACT DID NOT INFORM THE MANUFACTURER NOR WAS THE VEHICLE REPAIRED DUE TO THE COST. THE CURRENT MILEAGE WAS APPROXIMATELY 77,958. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000. THE VIN WAS UNAVAILABLE.
Engine and engine cooling, Dec 27, 2010
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 55 MPH, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BUT THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE OCCURRED AGAIN AND THE VEHICLE JERKED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. A FEW MONTHS LATER, THE FAILURE OCCURRED AGAIN AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT AN ENGINE COIL FAILED AND THE PCM NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 105,000. THE VIN WAS UNAVAILABLE.
Engine and engine cooling, Fuel system, Gasoline, Electrical system, Dec 22, 2010
ON 3/17/2009, AFTER WASHING THE VEHICLE AT A CAR WASH, THE SERVICE ENGINE SOON LIGHT CAME ON. THE VEHICLE LATER STOPPED RUNNING AND WAS TOWED TO THE DEALERSHIP. THEY HAD IT FOR 3 DAYS AND SAID THEY COULDN'T FIND ANYTHING WRONG WITH IT. WE WERE CHARGED WITHOUT PRIOR NOTIFICATION. ON 9/01/2010, THE FUEL FILTER WAS REPLACED AT THE SAME DEALERSHIP. ON THE WAY HOME, THE VEHICLE BEGAN TO OVERHEAT. IT STOPPED RUNNING IN TRAFFIC AND WE WERE ALMOST HIT. IT WAS TAKEN TO THE LOCAL FORD DEALER ON 9/07/2010 TO BE LOOKED AT AT THE ADVICE OF FORD. THEY FOUND A FAULTY WATER PUMP, REPLACED IT AND A FILTER, AND WE WERE TOLD THE PROBLEM WAS FIXED. ON 9/09/2010, THE VEHICLE ONCE AGAIN OVERHEATED, STRANDING US AGAIN. IT WAS RETURNED TO THE DEALER, WHERE THEY RESET THE COMPUTER AND AGAIN TOLD US IT WAS FIXED. ON 11/23/2010, IT WAS RAINING AND AGAIN THE VEHICLE STALLED, BUT WE WERE ABLE TO RETURN HOME. ON 12/17/2010, THE REPAIR ENGINE SOON LIGHT CAME ON, AND WE HAVEN'T DRIVEN IT SINCE.
Engine and engine cooling, Nov 24, 2010
TRAVELING AT HIGHWAY SPEEDS, 2005 ESCAPE WITH UNDER 90,000 MILES BEGAN MISSING AND CUTTING OUT. WAS ABLE TO LIMP IN TO FORD DEALER (SAM SCISM FORD) WHERE DIAGNOSIS INDICATED # 2 # 6 MISFIRES WITH FURTHER DIAGNOSIS INDICATING NO SIGNAL TO COIL. DEALER DETERMINED NEED TO REPLACE PCM AND DID SO AT OVER $1100. LESS THAN 30 DAYS LATER, SIMILAR SYMPTOMS AND DIFFERENT DEALER DIAGNOSED #6 COIL PROBLEMS. REPLACED COILA AT $240. *TR
Engine and engine cooling, Oct 28, 2010
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT DRIVING APPROXIMATELY 50 MPH, THE VEHICLE SUDDENLY SHUT DOWN; THERE WERE NO POWER BRAKES OR STEERING. SHE WAS ABLE TO RESTART THE VEHICLE BUT IT CONTINUED TO STALL ON HER WAY HOME. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE POWER CONTROL MODULE WAS THE CAUSE OF THE FAILURE AND NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 105,000.
Engine and engine cooling, Oct 27, 2010
IGNITION SPARK PLUG COILS (6) SHORTED OUT; SHORTING OUT THE COMPUTER AS TOLD BY THE FORD TECH TO THE OWNER OF THE VECHICLE. THE FORD TECHNICIAN TOLD THE VECHICLE OWNER TO KEEP THE RECEIPTS BECAUSE THIS SHOULD HAVE BEEN A RECALL.
Engine and engine cooling, Oct 20, 2010
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 55 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE ENGINE COMPLETELY STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE ONE OF THE SIX COIL PACKS WAS REPLACED IN THE ENGINE. THE FAILURE CONTINUED AFTER THE REPAIR. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES. A TOTAL OF EIGHT ENGINE COIL PACKS HAD BEEN REPLACED ON THE VEHICLE. ALSO, THE MAIN COMPUTER AND ONE SPARK PLUG WAS REPLACED BY THE DEALER. THE CONTACT HAD CONCERN OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 85,000.
Engine and engine cooling, Sep 22, 2010
WHILE DRIVING MY 2005 FORD ESCAPE HYBRID THE FOLLOWING OCCURRED. I WAS STOPPED AT AN INTERSECTION AND WHEN I BEGAN MAKING A LEFT TURN, AN ALARM SOUNDED, A RED WRENCH SYMBOL, AND RED EXCLAMATION MARK LIT UP ON THE DASH. I IMMEDIATELY PULLED TO THE CURB AND THE CAR LOST ALL POWER AND STEERING LOCKED UP. THE CAR RESTARTED AND I TOOK IT TO FORD. THE SERVICE REP SAID THE CAR WENT INTO A "FAIL SAFE MODE" WHICH IT DOES TO PROTECT THE HYBRID BATTERY FROM OVERHEATING. I WAS TOLD THAT THE ALARM AND SYMBOLS OCCUR TO GIVE YOU ABOUT 5 MINUTES TO SAFELY GET OFF THE ROAD. THIS DID NOT HAPPEN. THE CAR JUST LOST POWER IMMEDIATELY. THE FORD DEALERSHIP DETERMINED THAT A COOLANT PUMP FOR THE HYBRID BATTERY NEEDED TO BE REPLACED WHICH WAS DONE. FIVE WEEKS LATER THE SAME THING HAPPENED AGAIN. I WAS STOPPED AT A LIGHT AND WHEN I BEGAN TURNING RIGHT, THE ALARM SOUNDED, THE RED WRENCH AND EXCLAMATION LIGHT LIT UP AND THE CAR LOST ALL POWER IMMEDIATELY. AGAIN, I WAS ABLE TO RESTART THE ENGINE SO I TOOK IT BACK TO FORD TO BE LOOKED AT. THEY REPLACED A "SUSPECT" COOLING PUMP RELAY AND ROAD TESTED THE CAR. THE PROBLEM COULD NOT BE DUPLICATED. MY CONCERN IS THAT THIS VEHICLE'S "FAIL SAFE MODE" MAKES THE CAR COMPLETELY SHUT DOWN IMMEDIATELY. BOTH TIMES I WAS ABLE TO MOVE INTO AN EMERGENCY LANE, BUT WHAT WOULD HAVE HAPPENED IF I WAS ON A FREEWAY AND THE CAR JUST STOPPED? I AM CONCERNED THAT OTHER FORD ESCAPE HYBRIDS MAY HAVE THE SAME PROBLEM AND IT IS A REAL SAFETY HAZARD. THE SECOND TIME IT HAPPENED MY GRANDCHILDREN WERE IN THE BACKSEAT AND I COULD HAVE BEEN REAR ENDED. AFTER HAVING THE FORD DEALERSHIP LOOK AT IT AND REPLACE THE COOLING PUMP RELAY I TRADED IN THE VEHICLE THE NEXT DAY. I WOULD LIKE TO HAVE THIS DOCUMENTED IN CASE THERE IS A PATTERN WITH THESE CARS OR OTHER HYBRIDS. I WILL NEVER PURCHASE ONE AGAIN. *TR
Engine and engine cooling, Jun 28, 2010
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED WHEN DRIVING AT 65 MPH AND WITHOUT ANY WARNINGS THE VEHICLE WOULD STALL AND THE STOP SAFELY NOW WARNING LIGHT WOULD ILLUMINATE. THE VEHICLE WAS ABLE TO BE RESTARTED WITHIN SECONDS. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND THE VEHICLE WOULD NOT GENERATE ANY DIAGNOSTIC CODES. THE MANUFACTURE ADVISED THEY WERE UNABLE TO PROVIDE ANY ASSISTANCE WITHOUT KNOWING THE EXACT FAILURE BASED UPON THE DEALER'S DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 88,837.
Engine and engine cooling, Jun 18, 2010
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT SPEEDS OF 65 MPH, THE EMISSION CONTROL WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT WAS ABLE TO MOVE THE VEHICLE FROM THE ROADWAY WITHOUT INCIDENT. THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER ADVISED THE IGNITION COILS, SPARK PLUGS AND POWER TRAIN CONTROL MODULE WOULD NEED TO BE REPLACED. THE MANUFACTURER WOULD NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES ARE 102,585.
Engine and engine cooling, May 26, 2010
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO VIBRATE. THE CONTACT DROVE ONTO THE EMERGENCY LANE AND INSPECTED THE VEHICLE; YET, THERE WERE NO VISIBLE FAILURES. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT A COIL IN THE ENGINE FAILED. THE VEHICLE WAS BEING REPAIRED BY THE DEALER WHEN THE COMPLAINT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 79,000.
Engine and engine cooling, Electrical system, May 12, 2010
WHILE DRIVING 50 MPH WITHOUT WARNING THE VEHICLE SHUT OFF BY ITSELF. IF IT WERE NOT 5:30 IN THE MORNING I MAY HAVE CAUSED AN ACCIDENT OR BEEN KILLED. I WAS ABLE TO RESTART IT, BUT THE ENGINE LIGHT CAME ON AND IT RAN VERY HARD. IT THEN GAVE ME A SERVICE EMISSIONS WARNING. THE MECHANIC STATES THAT ALL 6 SPARK PLUGS AND 6 COILS NEED REPLACED AND THAT THE COMPUTER SYSTEM WAS FRIED (SMV).FURTHERMORE, HE STATED THAT IT WAS AN ERROR IN MANUFACTURING IN REGARDS TO THE SPARK PLUG INSTALLATION. I NOW FIND THAT THIS IS A COMMON PROBLEM WITH THE 2005 FORD ESCAPES BUT NO RECALLS OR NOTICES HAVE BEEN MADE. *TR
Engine and engine cooling, Apr 25, 2010
2005 FORD ESCAPE V-6 4WD STUTTERS AND STALLS WHEN IT SLOWS TO A STOP. AT THIS TIME, ABLE TO RESTART AGAIN. VEHICLE HAS 105,000 MILES ON IT. RECENT PROBLEM, APPEARS TO BE WORSE IN COLD WEATHER. *TR