2005 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,584 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Escape model years with reports.
Of the 2005 reports, 44 involved a crash and 20 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
Seats, front assembly, head restraintApr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V111000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Representative owner complaints: power train
126 reports, newest first. Show all
Power train, Electrical system, Jul 9, 2015
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING 25 MPH, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WITHOUT WARNING. THE VEHICLE HAD TO BE TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE PCM AND ALL SIX COILS BURNED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 121,000. MA 10/15/2015 UPDATED 11/08/2017*CN
Power train, Feb 20, 2015
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE PCM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.
Engine and engine cooling, Power train, Feb 9, 2015
I WAS COMING BACK TO HOME FROM WORK DRIVING ON HIGHWAY AT 55-60 MPH AND SUDDENLY MY CAR STARTS DECELERATING ITSELF AND I WAS FORCED TO PULL IT OVER ON THE SHOULDER, I WAS LUCKY THAT NOT ONE HIT ME. I COMPLETELY TURNED THE ENGINE OFF AND THEN I TRIED TO START AGAIN, IT STARTED MAKING CRANKING SOUND BUT DID NOT START COMPLETELY, SO I HAD TO CALL THE TOWING TRUCK TO TOW THE CAR TO MY HOME. IT COULD HAVE BEEN WORSE, I AM LUCKY TO BE ALIVE, I AM NOT SURE HOW CAN THE VEHICLE CAN STALL IN THE MIDDLE OF THE DRIVING. IT WAS SCARY. *TR
Power train, Electrical system, Electronic stability control (ESC), Jan 14, 2015
I PURCHASED THE VEHICLE KNOWING THE ECM HAD BEEN REPLACED RECENTLY... ABOUT 3 MONTHS OF PURCHASING THE VEHICLE MY CHECK EMISSIONS LIGHT CAME ON...LOSING GAS MILEAGE, CAR STALLED OUT A FEW TIMES, AND DEALERSHIP SAID IT WAS THE ECM AGAIN... APPROXIMATELY AUGUST 2013. ONE YEAR LATER AUGUST 2014 SAME ISSUE AGAIN... ECM REPLACED AGAIN.. WHEN I TURN THE KEY ON, NOT STARTING IT THE CHECK EMISSION COMES ON AND THE DEALERSHIP TELLS ME THIS IS NORMAL.. MY GAS MILEAGE IS 12 MPG AND IM AFRAID IT IS HAPPENING AGAIN SOON.. I DON'T KNOW WHAT TO DO AND I WAS TOLD IT MAY BE THE WIRING HARNESS CAUSING THIS ISSUE.. I DON'T KNOW WHY NO ONE WILL GET TO THE ROUTE OF THE PROBLEM WHY THE COMPUTER IN MY ESCAPE KEEPS FAILING. THEY WONT LET ME TRADE IT IN SINCE IT IS NOT ANY VALUE TO THEM ANYMORE.. *TR
Power train, Electrical system, Dec 27, 2014
STARTED OFF FROM A LIGHT AND THE CAR HESITATED CONCERNED GAVE IT GAS AND IT STUTTERED,I ROLLED TO A STOP AND HAD IT TOWED TO A REPAIR SHOP.EVIDENTLY THE POWERTRAIN COMPUTER MODULE IS BAD SEVERAL COMPLAINTS THAT FORD PUT THE WRONG SPARK PLUGS IN THIS ESCAPE WHICH AFTER TIME RUINS THE PCM.SERIOUSLY WHY HASN'T A RECALL BEEN ISSUED FOR THIS PROBLEM? HAD I BEEN TRAVELING FASTER WOULD HAVE BEEN AN ACCIDENT AS I WAS IN MORNING TRAFFIC.NOW LOOKING AT A $1000 IN REPAIR BILLS.FORD NEEDS TO FIX THIS PROBLEM. *TR
Power train, Dec 26, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER, WHO DIAGNOSED THAT THE PCM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Power train, Nov 14, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN.
Power train, Nov 9, 2014
TRANSMISSION FAILED AND HAD TO BE REPLACED. *TR
Power train, Fuel/propulsion system, Oct 23, 2014
EARLY SEPT 2014 - BEGAN TO EXPERIENCE INTERMITTENT ISSUES OF "LIMP HOME" MODE. ORIGINALLY, ISSUE BEGAN WITH SMALL "SURGES" IN ACCELERATION THAT I BELIEVED WERE SIMPLY RELATED TO THE HYBRID ENGINE KICKING INTO GEAR. THEN EXPERIENCED MULTIPLE BUT RANDOM "LIMP HOME MODE" EVENTS, PARTICULARLY WHEN STOPPING AT LIGHTS OR ACCELERATING (LIGHT-MOD PRESSURE) FROM A FULL STOP. CAR WOULD FLASH "SERVICE ENGINE SOON" AND NOT GO ABOVE 20MPH AND SOMETIMES NOT THAT. WOULD PULL OFF IF ABLE, OTHERWISE, WOULD HAVE TO STOP WITH FLASHERS IN THE MIDDLE OF THE ROAD, TURN OFF THE ENGINE, WAIT A MINUTE, AND THEN RESTART (REBOOTING CAR). THIS WOULD CLEAR THE CHECK ENGINE LIGHT AND CAR WOULD RESUME NORMAL OPERATION - OF NOTE: CODES WOULD NOT STAY IN THE HISTORY OF THE COMPUTER. AFTER SEVERAL OCCURRENCES, MANAGED TO "LIMP HOME" TO A MECHANIC WHILE THE LIGHT WAS ON AND PULL CODES BETWEEN 2009-2012 AND WAS ADVISED TO HAVE THE COMPUTER REPROGRAMMED BY FORD SERVICE. CAR BEGAN LIMPING HOME DURING FULL TRAFFIC AND FULL ACCELERATION (NOT STOPPED OR SLOWING), CAUSING A MASSIVE SAFETY CONCERN. NOTED MULTIPLE INVESTIGATIVE MENTIONS ON INTERNET REGARDING 2005-2012 ETB ISSUES, BUT ALSO NOTED THIS WAS THEN ONLY "REPLACED" FOR 2009-2012. APPARENTLY, ANYTHING OLDER THAN 09 IS A LOST CAUSE. 10/23/14 - HAVE CAR IN FORD SERVICE AND RECALL (14S19) HAS BEEN NOTED REGARDING MOTOR ELECTRONICS COOLANT PUMP CAUSING "A FAILURE MODE EFFECTS MANAGEMENT STRATEGY THAT CAN RESULT IN A SUDDEN PARTIAL OR FULL LOSS OF MOTIVE POWER" TO PROTECT VEHICLE POWERTRAIN. BEING CHARGED FOR DIAGNOSTIC EVEN THOUGH THERE IS A RECALL ON THE PART THAT IS LIKELY CAUSING THE PROBLEM. *TR
Power train, Wheels, Oct 12, 2014
HAS I WAS DRIVING ON THE HIGHWAY ALL OF A SUDDEN MY TRANSMISSION FAIL. IT SOUND LIKE IT FAIL OUT THE BOTTOM OF THE TRUCK. THE TRUCK WENT INTO A NOISE DIVE AND I FAULT TO GET IT OVER TO THE SHOULDER. NO WARNING SIGNS AT ALL. NEVER HAD SLIPPAGE OR NOTHING. CARS BEHIND ME ALL MOST CRASHED INTO ME AND MY FAMILY. THE TOW TRUCK CAME AND THE TRUCK WOULD NOT MOVE WHEN HE TRIED TO PULL IT UP ON THE TOW TRUCK. WILL FORD FIX THERE TRANS PROBLEM AT THERE COST AND NOT MIND. GOD IS THE GLORY, HE WAS WITH US. *TR
Power train, Service brakes, Engine, Sep 16, 2014
WHEN THE VEHICLE IS WARMED UP AND DECELERATING BELOW 40MPH THEY GASOLINE ENGINE WILL SHUT OFF AS THE REGENERATIVE BRAKING CHARGES THE HYBRID HIGH VOLTAGE BATTERY. ON A RARE OCCASION DURING THIS BRAKING, THE GASOLINE ENGINE WILL TURN BACK ON GIVING A BRIEF SURGE WHICH REQUIRES PRESSING THE BRAKE HARDER. IT HAS DONE THIS SINCE I BOUGHT THE VEHICLE. *TR
Power train, Electrical system, Engine, Sep 12, 2014
VEHICLE WAS SHIPPED TO GERMANY DUE TO MILITARY DUTY. A WEEK LATER AFTER DELIVERED, MY WIFE WAS DRIVING IT GOING DOWN A SHORT HILL WHEN THE VEHICLE TURNED OFF COMPLETELY AND BRAKES WERE NOT FUNCTIONING. MY WIFE HAD TO STOP THE VEHICLE WITH PARKING BRAKE. AFTER THAT THE ENGINE WAS LOSING POWER AND THE ALARM WAS GOING OFF VERY OFTEN. WE DROVE THE VEHICLE FEW OCCASIONS AND IT TURNED OFF COUPLE OF TIMES AGAIN.I ORDERED THE PART AND REPLACED IT IN 2014. THE VEHICLE IS RUNNING FINE, HOWEVER THE ALARM STILL GOING OFF AND ENGINE LIGHT IS ON AGAIN ON DASHBOARD. AT THIS POINT I DO NOT KNOW IF THE VEHICLE IS INDICATING THE SAME PROBLEM OR SOMETHING NEW. *TR
Power train, Engine, Jun 24, 2014
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE VEHICLE STALLED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD AND TURNED OFF. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE ON SEVERAL OCCASIONS BUT IT FAILED TO START. THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND THE STEERING BECAME DIFFICULT TO MANEUVER. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE PCM AND THE ELECTRIC SPARK COILS NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER A REMEDY. THE FAILURE AND CURRENT MILEAGE WAS 113,000. CN10/24/14*CN UPDATED 04/16/2015 *JS
Power train, Vehicle speed control, Jun 17, 2014
PROGRAM 13N03 THROTTLE BODY ISSUES GAS PEDAL LOCKS UP, JOLTS FORWARD. *TR
Power train, Electrical system, Engine, Jun 5, 2014
TRAVELING ON THE HIGHWAY AT 55 MILES PER HOUR AND THE ENTIRE ENGINE STALLED AND CUT OFF. I HAD THE CAR TOWED TO A LOCAL SHOP WHERE THEY TOLD ME THAT 3 OUT OF THE 6 COILS BASICALLY WERE NOT WORKING AND THE PCM/COMPUTER WAS COMPLETELY SHOT, THEY WANTED OVER $1600 AT DEALERSHIP TO FIX THIS. FORD HAD APPARENTLY DISTRIBUTED A BULLETIN ABOUT THIS PROBLEM TO THE DEALERSHIPS BUT NOT THEIR CUSTOMERS - WHO THIS PROBLEM AFFECTS THE MOST. I WAS LUCKY THAT I WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD AND NOT HIT ANYONE OR GET KILLED. I CAN'T IMAGINE HOW MANY PEOPLE THIS HAS AFFECTED BECAUSE IT IS ALL OVER THE INTERNET. THE REPAIR ENDED UP COSTING WELL OVER $1000 BECAUSE OF THE SPARK PLUGS THAT FORD KNEW WERE FAULTY YEARS AGO. A SIMPLE CHANGING OF THE SPARK PLUGS INSTEAD OF SIX COILS. I SEE NO DIFFERENCE IN GM HAVING TO RECALL VEHICLES THAT SHUT OFF ON THE HIGHWAY AND FORD HAVING TO RECALL THESE VEHICLES FOR BASICALLY THE SAME REASON AND REIMBURSE THEIR CUSTOMERS, OUR CARS ARE SHUTTING OFF TOO. *TR
Power train, May 27, 2014
DRIVING NORTH ON HWY 41 WHEN CAR STALLED AND I HAD TO DIRECT IT OFF ROAD WITHOUT POWER STEERING OR BRAKES. WAS ALMOST HIT FROM BEHIND. WAS INFORMED BY MECHANIC THAT IT WAS THE THROTTLE BODY. REFER TO FORD CONSUMER SATISFACTION PROGRAM 13N03. *TR
Power train, Fuel/propulsion system, Feb 12, 2014
THE "WRENCH" LIGHT AND "ENGINE" LIGHT ILLUMINATED ON THE DASH. THE INFORMATION SYSTEM FLASHED "SERVICE NOW" AND "SERVICE EMISSION SYSTEM." THE CAR SUDDENLY SEEMED TO BOG DOWN AND SLOWED TO AROUND 15 MPH. FROM THERE IT WOULD NOT ACCELERATE BEYOND 30 MPH. THE ACCELERATOR WAS UNRESPONSIVE AND SEEMED MUSHY. ONCE AT 30 MPH THE CAR WOULD HESITATE AND JERK. IT ALSO STALLED WHEN SLOWING. THESE ARE THE SAME EXACT SYMPTOMS THAT OTHER ESCAPE OWNERS HAVE EXPERIENCED AND WHICH FORD HAS RECOGNIZED AS A MANUFACTURING DEFECT UNDER CUSTOMER SATISFACTION # 13N03 FOR ESCAPE MODELS 2009-2012. THE FORD DEALER SAYS THE ELECTRONIC THROTTLE BODY NEEDS TO BE REPLACED. HOWEVER, AS OF THIS WRITING FORD IS NOT COVERING THE REPAIR FOR EARLIER MODELS EVEN THOUGH THEY HAVE THE SAME ENGINE, SAME SYMPTOMS, SAME REPAIR NECESSARY. COME ON FORD, DO THE RIGHT THING! *TR
Power train, Feb 1, 2014
I HAVE A 2005 FORD ESCAPE 4WD MANUAL TRANSMISSION. I HAD TO REPLACE THE WHOLE TRANSMISSION ABOUT 5 YEARS DUE TO TRANSMISSION FAILURE. I NOW HAVE A PROBLEM WITH THE MANUAL TRANSMISSION AGAIN. I CAN NOT GET THE TRANSMISSION TO SHIFT INTO REVERSE. THE FORWARD GEARS WORK FINE. I HAVE SEEN ON THE INTERNET A HIGH INCIDENCE OF TRANSMISSION PROBLEMS IN THE 2005 FORD ESCAPE TRANSMISSION. THERE SHOULD BE A RECALL ON THIS. *TR
Power train, Vehicle speed control, Engine, Dec 6, 2013
THE GAS PEDAL WAS STUCK AFTER MASHING ON IT HARD IT BROKE LOOSE WHEN APPROCHING A STOP SIGN I STOPPED AND TRY TO GO AGAIN BUT GAS PEDAL WAS STUCK WHY IS THERE NOT A RECALL. I ALSO HAVE TRANSMISSION AND REAREND PROBLEMS BUT THEY BOTH ARE COSTLY REPAIRS I AM CONCERNED ABOUT THE GAS PEDAL PLEASE FIX IT BEFORE SOMEONE GETS HURT THERE REALLY SHOULD BE A RECALL ON IT
Fuel system, Gasoline, Power train, Vehicle speed control, Engine, Dec 6, 2013
FROM A STOP THIS VEHICLE HAS A PROBLEM WITH THE THROTTLE. IT IS INTERMITTENT, BUT WHEN IT OCCURS YOU UNABLE TO PRESS THE THROTTLE. IT IS JAMMED. IT SEEMS IF I PLACE THE GEAR SHIFT BACK INTO PARK THEN TO DRIVE IT WILL BE FREE AGAIN AND DRIVE NORMALLY. THIS STARTED HAPPENING ONCE IN A WHILE YEARS AGO, BUT SEEMS TO BE OCCURRING A LOT MORE FREQUENTLY NOW. *TR
Power train, Nov 6, 2013
I PURCHASED THIS VEHICLE FROM BYERS KIA 9 MONTHS AGO. I RECENTLY JUST MADE MY 8TH PAYMENT ON IT. 1 MONTH AFTER PURCHASING THIS VEHICLE I NOTICED A SLIGHT VIBRATION FROM 15-25 MPH. WELL ON SUNDAY NOVEMBER 3RD MY DRIVE SHAFT QUIT WORKING. WE INSTALLED A U JOINT HOPING THAT WOULD SOLVE THE PROBLEM. IT ONLY MADE IT WORSE. I HAVE THE DEALERSHIP WORKING TO FIX THIS PROBLEM NOW. I DON'T FEEL IM RESPONSIBLE FOR THIS ISSUE SEEING IT SHOULD HAVE BEEN CAUGHT PRIOR TO ME BUYING THIS TRUCK . *TR
Power train, Sep 5, 2013
MY FORD ESCAPE 2005 WAS WORKING WELL WITHOUT ANY WARNING. SUDDENLY AFTER TURNING THE CAR SHUT DOWN. AFTER RESTARTING THERE WAS NOT ENOUGH POWER. WENT TO FORD AUTHORIZED REPAIR CENTER AND WAS TOLD THIS WAS A KNOWN PROBLEM WITH A TSB 10 -18-10, FAULTY SPARK PLUGS MAKE RADIO FREQUENCY INTERFERENCE WHICH MAKE COILS ON PLUGS AND POWER TRAIN CONTROL MODULE (PCM) TO MALFUNCTION. ALL SIX SPARK PLUGS AND COILS WERE REPLACED AND THE PROBLEM PERSISTS, ONLY SOLUTION IS TO CHANGE PCM. THIS PROBLEM CAN HAPPEN AT ANY TIME, AFTER ANY MILEAGE, WITHOUT ANY NOTICE, THESE VEHICLES SHOULD BE RE-CALLED AND FORD SHOULD PAY FOR THESE AS IT IS A DEFECT FROM FABRIC. *JB
Power train, Engine, Aug 7, 2013
DRIVING 55 MPH ON HIGHWAY, CAR SOUNDED LIKE IT DOWNSHIFTED INTO MUCH LOWER GEAR (VERY LOUD) WITH JERKY MOTION, IMMEDIATELY LOST POWER, WAS CLIMBING LARGE HILL, COASTED TO SIDE OF ROAD IN HEAVY TRAFFIC, LOST POWER STEERING, MADE HORRIFIC GRINDING SOUND, AND THEN STOPPED. IDLED FOR 30-45 SECONDS, ALL DASHLIGHTS CAME ON BEFORE DYING ON HIGHWAY. I HAVE REVIEWED CARCOMPLAINTS.COM ON THIS MODEL ESCAPE, THEY ARE NOTORIOUS FOR PCM COMPUTER GOING WITH NO NOTICE. MY MECHANIC INFORMS ME TODAY THAT IS THE PROBLEM, COST FOR REPAIR IS ABOUT $2,000.00, NOT COVERED BY THE EXTENDED WARRANTY I PURCHASED. THIS IS A WELL DOCUMENTED ISSUE THAT CLEARLY CREATES SAFETY ISSUES WHEN DRIVING AT HIGH RATES OF SPEED, WITH NO WARNING. THE CAR WAS "FINE" BY ALL OTHER ACCOUNTS, THIS HAPPENED OUT OF NO WHERE. *TR
Power train, Electronic stability control (ESC), Engine, Jul 31, 2013
9/10/12, WHILE DRIVING ON THE FREEWAY MY CHECK ENGINE LIGHT CAME ON AND MY CAR STARTED RUNNING VERY HARD AND STARTED SHAKING AND I COULD FEEL THE CAR LOOSING POWER. I TURNED THE STEERING WHEEL TOWARDS THE RIGHT TO PULL OVER AND AS I PRESSED THE GAS PEDAL I COULD FEEL THE CAR HAD SHUT OFF. I WAS ABLE TO PULL OFF TO THE SIDE OF THE HIGHWAY AND MY CAR SMELL LIKE SOMETHING WAS BURNING. AFTER SITTING FOR ABOUT 15MINS THE CAR STARTED AND I WAS ABLE TO START THE CAR AND DROVE IT AT ABOUT 40 MPH UNTIL GETTING OFF THE EXIT TO GO HOME WHICH WAS ABOUT 10 MORE MILES. I HAD TO CONTINUOUSLY PRESS THE GAS MAKING THE CAR ACCELERATE BETWEEN 30 TO 40MPH BECAUSE THE CAR STARTED TO REPEAT THE SAME THING AS I STATED EARLIER. I TOOK THE CAR TO THE SHOP 9/13/12 (MY CAR HAD 153224 MILES) AND WAS TOLD THERE WAS MISFIRE ON #2 COIL, SO I PAID TO HAVE THE COIL CHANGED. 2/15/13 MY CHECK ENGINE LIGHT CAME BACK ON AND THE CAR WAS REPEATEDLY HESITATING, I TOOK IT THE SHOP 2/19/13 (MY CAR HAD 163071 MILES) AND HAD THE SAME MISFIRE CODE, SO I PAID TO HAVE ALL THREE REAR COILS CHANGED, THE OWNER SHOWED ME THE OLD COILS & THE #2 COIL LOOK BURNED AND BURST OPEN FROM THE TOP. AFTER CHANGING THE COILS THE CHECK ENGINE LIGHT CAME BACK ON WITH THE SAME MISFIRE CODE FOR #2 COIL AND I PAID TO HAVE IT CHANGED AGAIN 6/18/13 (MY CAR HAD 171459 MILES). THE ENGINE LIGHT CAME BACK ON WITH THE SAME CODE AND I PAID TO CHANGED IT AGAIN 7/12/13 (MY CAR HAD 173095 MILES) AFTER I DROVE THE CAR ABOUT 50 MILES THE LIGHT CAME BACK ON. I HAD THE CODE READ AGAIN ON 7/30/13 (MY CAR HAD 173920 MILES) AND IT GAVE THE SAME CODE FOR A MISFIRE ON COIL #2. THE OWNER OF THE SHOP ADVISED ME TO TAKE THE CAR TO THE DEALER AND EXPLAIN THE PROBLEM AND CHECK IF THERE HAS BEEN A RECALL ON THE 2005 MODEL. I CALLED THE FORD DEALERSHIP AND WAS TOLD I WOULD HAVE TO PAY FOR THEM TO DO ANOTHER DIAGNOSTIC QUOTED AT $140. *TR
Power train, Jun 2, 2013
I BOUGHT THIS USED CAR FROM A DEALER, I TEST DROVE IT BEFORE BUYING ,AND IT WAS GREAT. SAME DAY WHEN I GOT HOME IT SHOWED AN ISSUE, THE CAR WOULD STALL WHEN PUT INTO GEAR. EITHER REVERSE OR DRIVE, UNLESS U HIT THE GAS PEDAL AT THE SAME TIME YOU PUT GEAR TO KEEP IT ON. AND IT WOULD ALSO STALL AT ANY STOP I MAKE. I HAVE TO KEEP ONE FOOT ON BREAK AND ONE ON THE GAS. AND THE CAR MIGHT BE RUNNING PERFECT FOR 2 OR 3 DAYS, AND IT GOES BACK TO STALLING. I SIGN THE CAR OUT THE DEALER AS IS, SO I CANT TAKE IT TO THEM. I DECIDED TAKING IT TO FORD FOR A $97 DIAGNOSTIC. THEY SAID IT NEEDS THROTTLE BODY OR TRY TO CLEAN IT. THEY ARE EXPENSIVE, SO I WENT TO A MECHANIC TO CLEAN IT.. IT QUIT HAVING THE PROBLEM FOR ALMOST 2 WEEKS, BUT WHEN I GOT ON THE ROAD TO CHICAGO, 60 MILES FROM HOME THE PROBLEM SHOWED BACK WHEN I STOPPED AT A GAS,I REALLY FEEL IS A FACTORY DEFECT AFTER READING ALL THIS POSTS FROM OTHER CUSTOMERS HAVING SIMILAR PROBLEMS. *TR