2005 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,584 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Escape model years with reports.
Of the 2005 reports, 44 involved a crash and 20 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
Seats, front assembly, head restraintApr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V111000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Representative owner complaints: power train
126 reports, newest first. Show all
Power train, May 23, 2013
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO STUTTER AND STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE TRANSMISSION CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE FAILURE ALSO CAUSED FUEL TO FLOOD THE CATALYTIC CONVERTER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 126,178. *TR
Power train, Electrical system, Engine, Mar 4, 2013
WHILE DRIVING THE CAR COMPLETELY WENT DEAD. EVERYTHING TURNED OFF. HAD TO DRIFT TO SIDE OF THE ROAD. TECHNICIAN TOLD ME IT WAS A PCM PROBLEM AND NEEDS TO REPLACE, COILS, PLUGS AND PCM. *TR
Power train, Feb 25, 2013
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH THE VEHICLE BEGAN TO DECELERATE AND EVENTUALLY STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HER THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.
Power train, Electrical system, Jan 22, 2013
WAS DRIVING MY CAR AT 45 MILES PER HOUR THE CAR BEGAN TO SPUTTER AND CAME TO VERY QUICK HALT IN THE MIDDLE OF TRAFFIC. I HAD THE CAR TOWED TO MY LOCAL GARAGE, IT WAS HOOKED UP TO A COMPUTER DIAGNOSTIC TOOL. THE TROUBLE CODES CAME UP P0351, P0352, P0353, P0354 WHICH I'M BEING TOLD IT WILL COST ME $ 750.00 TO REPLACE ALL 6 COILS, $1100.00 TO REPLACE THE PCM MODULE AND I WILL NEED 6 NEW SPARK PLUGS. THESE PRICES DON'T INCLUDE LABOR OR DIAGNOSTIC COSTS EITHER. IN DOING SOME INVESTIGATION THIS IS A KNOWN ISSUE WITH FORD MOTOR COMPANY AND THE EMISSION WARRANTY ONLY COVERS YOU FOR 8 YEARS/80,000 MILES. NOT SURE WHAT A PCM MODULE IS OR WHAT COILS DO. THANK YOU FORD MOTOR COMPANY FOR INSTALLING FAULTY PARTS IN MY MOTOR WHEN THEY BUILT IT IN 2005. NOW THIS IS MY PROBLEM AND AT MY EXPENSE...... FORD SENT OUT A TBS REGARDING THE WRONG PLUGS WERE INSTALLED WHICH LEADS TO THIS ISSUE. TSB 09-2-6 AND TSB 10-18-10 IS EVIDENCE ENOUGH THEY NEW THERE WAS CLEARLY AN ISSUE WITH THE FACTORY INSTALLED SPARK PLUGS CAUSING RFI DAMAGE TO THE COP'S AND SUBSEQUENTLY THE ECM. IT APPEARS THEY WERE BETTING THAT MOST VEHICLES WOULD HAVE ISSUES OUTSIDE THE 80,000 MILE FEDERAL WARRANTY. *TR
Power train, Dec 4, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, A RUMBLING NOISE WAS HEARD FROM AROUND THE CONSOLE AREA. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND SHIFTED INTO NEUTRAL. THE RUMBLING NOISE THEN CEASED. THE CONTACT ALSO STATED THAT THE VEHICLE WAS SHIFTED BACK INTO DRIVE AND THE RUMBLING NOISE STARTED AGAIN. THE FOLLOWING DAY WHILE DRIVING UPHILL, THE NOISE BECAME LOUDER AND ALL OF THE GEARS FAILED. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME AND WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 71,104.
Power train, Engine, Nov 24, 2012
I WAS DRIVING TO WORK ON US 41 SOUTH WHEN MY 2005 FORD ESCAPE JUST STARTED TO BUCK AND WOULD NOT ACCELERATE, I WAS GOING APPROXIMATELY 45 MPH AND THE CAR JUST SHUT OFF. I COULD NOT STEER OR START IT AGAIN AND WAS ALMOST HIT BY AN 18 WHEEL VEHICLE AND KILLED. I IMMEDIATELY PUT MY FLASHERS ON AND KEPT RETRYING TO START THE CAR TO GET IT OFF THE ROAD. THIS COULD HAVE KILLED ME AND OTHERS THIS MORNING! THIS IS A FORD MOTOR COMPANY MECHANICAL ISSUE AND THEY KNEW ABOUT THIS PROBLEM WITH THIS MODEL VEHICLE AND CHOOSE TO NOT RECALL IT!! HOW MANY PEOPLE HAVE DIED FROM THIS PROBLEM THAT WE ARE NOT AWARE OF??? I TOOK THE CAR AND HAD IT CHECKED OUT AND THEY SAID THAT FORD ISSUED A BULLETIN ON THIS EXACT ISSUE AND HOW TO FIX IT! ONLY NOW, ITS GOING TO COST ME, THE CONSUMER $2000 OR MORE TO FIX!! I AM SO UPSET FROM IT, I AM ALMOST PAID OFF ON THIS VEHICLE AND I FEEL THAT THIS ISSUE SHOULD BE LOOKED INTO BY THE ATTORNEY GENERAL AND BY THE TRANSPORTATION DEPARTMENT OF SAFETY! *TR
Power train, Electrical system, Engine, Nov 18, 2012
PRIOR TO THE INCIDENT IN QUESTION THE CAR HAD A FEW DAYS OF ABNORMAL BEHAVIOR INCLUDING HESITATION AND ROUGH IDLE. THE INCIDENT OCCURRED ON CHRISTMAS EVE WHILE I WAS DRIVING DOWN A TWO LANE HIGHWAY. WHILE TRAVELING 50 MPH THE CAR LOST POWER AND ALTHOUGH I WAS TERRIBLY SCARED, I MANAGED TO GET OFF THE HIGHWAY SAFELY. I WAS TOLD THAT THE COMPUTER FAILED (PCM) WHICH IS VERY EXPENSIVE TO FIX HENCE THE REASON IT HAS BEEN ALMOST A YEAR. I AM A RETIRED WIDOW RAISING MY 12 YEAR OLD GRANDDAUGHTER FEELING STUCK BETWEEN A ROCK AND A HARD PLACE; NOT ABLE TO AFFORD THE REPAIRS AND UNABLE TO DO THINGS WITHOUT A CAR. I SEE THAT MANY MANY OTHERS HAVE HAD THIS SAME ISSUE, PLEASE HELP FORD FACE THEIR NEGLECT WITH REGARD TO THIS ISSUE. THANK YOU *TR
Power train, Electrical system, Engine, Nov 16, 2012
ON WAY HOME, CAR SHUT OFF WHILE GOING 35 MPH. COILS STARTED TO SMOKE. TOWED TO NEAREST DEALER AND WAS TOLD ALL COILS, PLUGS AND POWERTRAIN MODULE NEEDS TO BE REPLACED AT $2500. RESEARCHED LEGITIMATE WEBSITES AND FOUND MANY OWNERS WITH SAME PROBLEM THAT HAD FIXED MORE THAN ONCE AT $2500. WAS TOLD BY DEALER THAT NHTSA ONLY RECALLS FOR SAFETY & EMISSIONS. THIS IS CLEARLY A SAFETY ISSUE, ESPECIALLY IF GOING A HIGH SPEED ON INTERSTATE AND CAR SHUTS OFF WITHOUT WARNING. THANKFULLY MY KIDS WERE NOT IN CAR. *TR
Power train, Electrical system, Electronic stability control (ESC), Nov 9, 2012
WHILE DRIVING 45MPH THE CAR JUST CUT OFF IS A HIGH TRAFFIC AREA. THE CAR BEHIND ME HAD TO SWERVE TO MISS REAR-ENDING ME! I HAD MY 3 YEAR OLD DAUGHTER W/ ME AT THE TIME! OUR MECHANIC HAS INFORMED US THAT APPARENTLY FORD MOTOR COMPANY IS AWARE THAT BAD PLUGS WERE INSTALLED IN THESE CARS AND WOULD CAUSE COMPUTER FAILURE! NOTHING WAS TOLD TO US REGARDING THIS ISSUE WHEN WE PURCHASED THE CAR! WHEN EMAILED FMC THEY INFORMED ME THAT THIS IS NOT A SAFETY ISSUE & A RECALL IS NOT REQUIRED. HOW CAN THIS NOT BE A SAFETY ISSUE WHEN THE CAR COMPLETELY DIES W/OUT WARNING??? *TR
Power train, Oct 31, 2012
THE CAR STOPPED MOVING AT THE POSTED SPEED. THE CATALYTIC CONVERTER DISINTEGRATED, AND BLOCKED THE AIRFLOW. THE WARRANTY EXPIRED 4 MONTHS EARLIER. FORD DID NOT SEEM INTERESTED IN EITHER THE ISSUE OR/ HELPING RESOLVE IT. SHOULD THERE BE A RECALL? *TR
Power train, Oct 17, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND IT RESUMED NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE POWER TRAIN CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE MILEAGE WAS 100,000.
Power train, Oct 5, 2012
[XXX] 2005 FORD ESCAPE XLS, FWD HAD ISSUE WITH THROTTLE BODY. IT GOT TO THE POINT WHERE I WOULD HAVE TO STOP THE GAS PEDAL JUST TO MAKE IT ACCELERATE FROM A STOPPED STATE. THIS FIRST HAPPENED BACK IN NOVEMBER OF 2011, AND NOW I CAN FEEL IT START TO GET TO THAT POINT AGAIN... I WAS ABLE TO CLEAN IT LAST YEAR WITH B-12 CHEMTOOL WHICH TOOK CARE OF IT RIGHT AWAY. IT WAS COMPLETELY GUNKED BUT WORKED LIKE NEW ONCE I HAD IT CLEANED. GUESS IT IS TIME TO DO THIS AGAIN... I FIGURED I WOULD REPORT THIS AFTER SEEING A NEWS ARTICLE ON ABC REGARDING THE EXACT SAME THINGS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
Power train, Sep 24, 2012
WAS DRIVING DOWN THE HIGHWAY, AND THE VEHICLE JUST SHUT OFF. WAS ABLE TO START IT, BUT IT WOULD NOT RUN RIGHT FOR THE FIRST 5 MINUTES. AFTER LEAVING IT OFF FOR A HALF HOUR, WORKED FINE. ALSO HAPPENED ON 9/6/2012 AND 9/23/2012. LOSS OF ALL POWER STEERING, POWER BRAKES, AND VEHICLE HARD TO CONTROL WHEN IT IS SHUT OFF. ASKED FORD DEALERSHIP ABOUT WHAT COULD BE DONE, AND THEY JUST WANT ME TO BRING IT IN. NOW IMPOSSIBLE TO TAKE ANY WHERE BECAUSE IT WONT EVEN START BACK UP. READ ONLINE HOW THIS HAS HAPPENED TO MANY PEOPLE, AND ALL THE DEALERSHIP DOES IS TAKE THEM FOR 6000 DOLLARS AND THE PROBLEM DOES NOT GET RESOLVED. *TR
Power train, Sep 5, 2012
WHILE EXITING HIGHWAY, ALL LIGHTS ON DASH CAME ON, VEHICLE STARTED SPUTTERING. FORD DEALERSHIP HOOKED UP TO DIAGNOSTIC AND INDICATED THAT THE PCM HAD "BLOWN" AND TAKEN ALL SIX COILS WITH IT. THUS, RESULTING IN UPWARDS TO $2500 FOR REPAIRS FOR NOT ONLY A NEW PCM BUT ALSO ALL SIX COILS. OF WHICH, I HAD 2 REPLACED LESS THAN A YEAR AGO. DEALERSHIP ALSO INDICATED THAT FORD WAS AWARE OF THE PROBLEM BUT IT WAS NOT CLASSIFIED AS A RECALL. WHAT THE HECK AS I READ UP ON INTERNET AND THIS IS INDICATIVE TO A PROBLEM THEY ARE AWARE OF AND ALSO THAT OCCURRED IN PREVIOUS YEARS. *TR
Power train, Vehicle speed control, Engine, Jul 23, 2012
WHILE DRIVING HOME FROM WORK, I WENT TO ACCELERATE. UPON REACHING 40. I HEARD A SUBSTANTIAL BACKFIRE NOISE, AND THE ENGINE SHUT OFF IN THE MIDDLE OF A BUSY ROAD CAUSING ME TO BLOCK TRAFFIC AS I COASTED ALMOST INTO A BUSY INTERSECTION. I WAS ABLE TO PUT IT IN NEUTRAL AND RESTART THE ENGINE AFTER COASTING FOR 100+ FEET. AFTER WHICH, THE ENGINE BEGAN RUNNING VERY ROUGH AND RUGGED NEVER BEING ABLE TO ACCELERATE ABOUT 30 MPH AND CAUSING MAJOR TRAFFIC PROBLEMS. I TOOK IT TO A DEALERSHIP (VARSITY FORD IN ANN ARBOR, MI) AND HAVE BEEN TOLD THAT MY 2005 FORD ESCAPE WAS IN TROUBLE. APPARENTLY, MY SPARK PLUG AFTER BEING CLOGGED, CAUSED A BACKFIRE WHICH BLEW MY IGNITION COILS AND SPARKPLUGS AND MY PCM. I AM BEING QUOTED $2,200. AT MY LAST OIL CHANGE (3 MONTHS AGO) VARSITY FORD TOLD ME I WAS GETTING CLOSE TO NEEDING A TUNE UP BUT IT WAS NOT NECESSARY THAT DAY AND THAT I COULD WAIT UNTIL MY NEXT OIL CHANGE. I WAS PLANNING ON GOING THIS WEEKEND BECAUSE I WAS HEADING OUT OF TOWN. HAD I BEEN TOLD THE RISK WAS A $400 TUNE UP VS. A $2,200 BLOWN ENGINE, MAYBE I WOULD HAVE CHANGED THE SPARK PLUGS. I'M VERY DISTRAUGHT AT THE FORD DEALERSHIP, AND NOW AM QUESTIONING WHETHER I WILL EVER BUY A FORD OR WORK WITH A FORD DEALERSHIP. *TR
Power train, Jul 12, 2012
OUR 2005 FORD ESCAPE WAS PURCHASED NEW IN MAY 2005. IT HAS BEEN SERVICED BY FORD TECHNICIANS AT FORD DEALERSHIPS EVERY 5,000 MILES, INCLUDING A RECOMMENDED TRANSMISSION FLUSH LAST YEAR. ON A CROSS COUNTRY TRIP, THE SUV'S TRANSMISSION EXHIBITED A PROBLEM FORD MOTOR COMPANY (FMC) KNOWS AS ENGINE STALLING ON ENGAGEMENT/STOPPING. ACCORDING TO A SERVICE BULLETIN DATED MARCH 19, 2007, SUVS WITH THIS FAULTY TRANSMISSION "EXHIBIT AN ENGINE STALL WHEN COMING TO A STOP OR WHEN ENGAGING THE ENGINE INTO DRIVE OR REVERSE. THE CONDITION MAY BE INTERMITTENT AND OFTEN OCCURS AFTER EXTENDED DRIVES. THERE MAY BE NO DIAGNOSTIC CODES STORED. THIS MAY BE CAUSE BY INTERNAL WEAR IN THE TORQUE CONVERTER WHICH PREVENTS IT FROM LOCKING." THIS EXACT FAILURE CAUSED US TO BE STRANDED IN DANGEROUS HEAT CONDITIONS FOR HOURS AS WE WAITED FOR HELP. HOWEVER, FMC HAS KNOWN ABOUT THIS PROBLEM TRANSMISSION SINCE 2007, YET AS AN OWNER OF A CAR LESS THAN TWO YEARS OLD, I WAS NEVER TOLD ABOUT IT. IF I HAD BEEN INFORMED, I WOULD HAVE TAKEN IT YEARS AGO FOR REPAIR PRIOR TO GOING ON AN EXTENDED TRIP AND PUTTING MY FAMILY IN DANGER. INSTEAD, FMC KNOWINGLY ALLOWED VEHICLE OWNERS TO DRIVE WITH THIS FAULTY TRANSMISSION. FORD-CERTIFIED TECH'S FAILED TO DIAGNOSE THE PROBLEM EVEN THOUGH THEY WERE GIVEN THE EXACT SYMPTOMS AND THE POTENTIAL PROBLEM, THE TORQUE CONVERTER. AFTER TECHS TOLD ME THE TRANSMISSION WAS FINE, THE STALL OCCURRED REPEATEDLY UNTIL TOTAL FAILURE JUST OVER 1,200 MILES LATER, AGAIN, STRANDING MY FAMILY ON THE HIGHWAY. I BECAME AWARE OF THE FAULT ONLY AFTER A SEARCH OF OTHER DRIVERS WHO EXPERIENCED THE SAME PROBLEM. FMC BEHAVED NEGLIGENTLY IN FAILING TO INFORM CUSTOMERS LIKE ME, LIKELY TO SHIELD ITSELF FROM COSTLY REPAIRS. IN 2007, MY CAR ONLY HAD 24,500 MILES??WELL WITHIN WARRANTY LIMITS. A RECALL FOR VEHICLES OF THIS MODEL YEAR SHOULD BE ORDERED AND I SHOULD BE REFUNDED COST OF REPAIR. *TR
Power train, Electrical system, Engine, Fuel/propulsion system, Jul 11, 2012
WE WERE ACCELERATING TO GET ON THE INTERSTATE WHEN THE VEHICLE SUDDENLY DIED WITHOUT WARNING. NO TELLING WHAT WOULD HAVE HAPPENED IF WE WERE DRIVING AT FREEWAY SPEEDS. WE COASTED TO THE BREAKDOWN LANE AND HAD THE VEHICLE TOWED TO THE FORD DEALER WHO STATED THE COMPUTER (PCM), ALL THE COIL OVER PLUGS (COP) AND SPARK PLUGS WERE DAMAGED AND NEEDED REPLACEMENT. THIS IS A KNOWN ISSUE AS IT IS DESCRIBED EXACTLY IN FORD SERVICE BULLETIN TSB 09-2-6. THE SPARK PLUGS IN THE 2005 AND 2006 CAUSE RADIO FREQUENCY INTERFERENCE WITH THE PCM WHICH DAMAGES THE PCM AND THE OTHER COMPONENTS. THE LEAST FORD COULD HAVE DONE WAS NOTIFY US THAT REPLACING THE SPARK PLUGS COULD HAVE PREVENTED THIS VERY EXPENSIVE REPAIR. THE PROBLEMS DON'T END THERE. A FEW DAYS AFTER THE REPAIR WE WERE AGAIN ACCELERATING TO GET ON THE INTERSTATE WHEN THE VEHICLE LOST POWER AND WOULD NOT GO OVER 50MPH. WE BROUGHT THE VEHICLE BACK TO THE FORD DEALER WHO STATED THE CATALYTIC CONVERTERS (THERE ARE 3 OF THEM) WERE CLOGGED DUE TO RAW FUEL COMING IN CONTACT WITH THE CONVERTERS PROBABLY DUE TO THE PREVIOUS ENGINE PROBLEMS. THE COST TO FIX THE CONVERTERS IS EVEN MORE THAN THE COST OF THE INITIAL REPAIR. WE'VE DECIDED TO NOT HAVE THE DEALER REPAIR THE VEHICLE AS THE TOTAL COST OF ALL THE REPAIRS WOULD EXCEED THE VALUE OF THE VEHICLE. WE CALLED FORD CUSTOMER SERVICE AND THEY WERE OF NO HELP IN THIS SITUATION. I THINK FORD SHOULD COVER THE COSTS OF THESE REPAIRS FOR AN ISSUE KNEW EXISTED. I DON'T UNDERSTAND WHY THERE HASN'T BEEN A RECALL FOR THIS PROBLEM AS I SEE THAT IT HAS HAPPENED TO A LOT OF OTHER 2005 ESCAPES LISTED IN YOUR DATABASE. I IMAGINE WE WILL MORE OF THESE FAILURES AS THESE VEHICLES AGE. *TR
Power train, Jul 11, 2012
THE VEHICLE HAS A VIBRATION IN THE POWER TRAIN AROUND THE 45-55 MPH. THE VIBRATION IS PRESENT DAILY AND CAUSES THE ENTIRE VEHICLE TO SHAKE. *TR
Power train, Engine, Jul 3, 2012
WHILE TRAVELING IN THE HIGH SPEED LANE AT APPROXIMATELY 2 AM, THE VEHICLE LOST ENGINE POWER WITHOUT ANY NOTICE AS THE ENGINE SHUT OFF AND THE POWER WAS REDUCED TO MINIMAL POWER GIVEN BY THE ELECTRIC MOTOR. THIS CAUSED AN INABILITY TO MAINTAIN SPEED ON A VERY DANGEROUS OVERPASS CURVE OF THE FREEWAY AND NEARLY CAUSED TWO VEHICLES IN THE IMMEDIATE PROXIMITY TO COLLIDE WITH MY VEHICLE AS SPEED RAPIDLY DROPPED AND THE VEHICLE SAID TO "PULL OVER ANDS SHUT OFF VEHICLE SAFELY". THIS PART OF THE FREEWAY HAD NO PULL OVER SPOT NOR DID IT HAVE AN AREA TO REALLY SAFELY PULL OFF THE FREEWAY. THIS IS THE SECOND TIME THE CAR HAS DONE THIS AT HIGH SPEED WITHIN TWO WEEKS. IT HAS DONE THIS APPROXIMATELY 1-0 TIMES AT LOW SPEEDS ON CITY STREETS. THE CAR IS ABLE TO BE DRIVEN AFTER SHUTTING OFF THE POWER, LETTING IT SIT, AND THEN RESTARTING THE SYSTEM. THERE IS AN ACCOMPANYING OVERHEATING THAT OCCURTS AS A RESULT OF THE ENGINE SHUTTING OFF, CAUSING THE ENGINE TO BE UNABLE TO BE EASILY RESTARTED AT THAT POINT. THIS EVENT GIVES NO WARNING OR INDICATION IT WILL HAPPEN AND IS A VERY DANGEROUS SITUATION FOR ANY DRIVER TO BE THRUST INTO. IF IT HAD BEEN RUSH HOUR TRAFFIC, I AM CERTAIN THERE WOULD HAVE BEEN ACCIDENTS AND VEHICLE COLLISIONS AS A RESULT. *JS
Power train, Engine, Jun 1, 2012
MY CAR STALLED ON A MAJOR HIGHWAY. DIAGNOSED WITH A DEFECTIVE PCM. FORD HAS BEEN AWARE OF THIS COMMON PROBLEM WITH THIS PARTICULAR VEHICLE. *TR
Engine and engine cooling, Power train, Electrical system, Feb 15, 2012
MY WIFE WENT TO ON A TRIP AND THE VEHICLE STARTED TO MISFIRE, WENT TO A FORD DEALER, MECHANIC IDENTIFIED THE PROBLEM; IGNITION COIL #4 FAILED. SHE ASKED WHAT NEEDED DONE TO FIX PROPERLY SO SHE WOULD BE SAFE AND HAVE NO MORE TROUBLE. HE SAID TO REPLACE COIL, PLUGS, AND WIRES. THAT WAS DONE. ON THE WAY HOME IT HAPPENED AGAIN, CAR SHUT OFF W/O WARNING ON I95 @65 MPH. PROBLEM PERSISTED AND FINALLY WOULD NOT START AND HAD TO BE TOWED. MY MECHANIC DISCOVERED FORD SRB 09-2-6. A PROBLEM IDENTIFIED BY FORD BUT NOT MADE PUBLIC. I CONTACTED DEALER; HE WAS AWARE OF SRB BUT DID NOT ACT ON IT OR INFORM US ABOUT IT. WE ARE NOW FACED WITH A BILL 2X LARGER THAN IT WOULD HAVE BEEN IF DEALER WOULD HAVE FOLLOWED SRB. HE PUT MY WIFE AT RISK (NEARLY HAD A FEW ACCIDENTS) AND FORD AND THE NHTSA ARE PUTTING PEOPLE AT UNDUE RISK BY NOT MAKING THIS INFO. PUBLIC AND SPECIFIC TO OWNERS OF THESE VEHICLES. A FAILURE OF THIS MAGNITUDE, IDENTIFIED AS A PROBLEM FROM THE FACTORY SHOULD BE RECALLED AND FORD SHOULD COMPLETE REPAIRS AT NO COST TO THE OWNER. *TR
Power train, Feb 11, 2012
WAS DIVING ON INTERSTATE MOTOR FAILED . WAS IN PASSING LANE HAD TO PULL IN THE GRASSY MEDIA. VERY SCARY. TOOK TO SHOP WAS TOLD PCM WAS BAD. HAD IT REPLACED . 29000K LATER IT IS OUT AGAIN. WAS PURCHASED USED AT A FORD DEALER SHIP IN 2007 4X4 HAS NOT WORKED. TOOK IT BACK WAS TOLD THAT THE COMPUTER SAID IT WAS OK AND THERE WAS NOTHING WRONG. THE REAR WHEELS DO NOT PULL WHEN FRONT SPINS CAR IS DEAD IN DRIVE WAY AT PRESENT STILL OWE 7000 ON IT. FORD SHOULD BE MADE TO REPAIR AT THEIR ON COST. THIS CAR IS JUNK AND WILL NEVER OWE ONE AGAIN. *TR
Suspension, Power train, Jan 31, 2012
RUBBING SOUND COMING FROM LEFT FRONT (DRIVER'S SIDE) WHEEL WELL. DIAGNOSED BY FORD AS A "LOOSE" WHEEL BEARING. SOUNDS MORE LIKE A FAILURE. FORD CHARGED $47 TO "DIAGNOSE" THE PROBLEM. SEEMS LIKE MAYBE THEY ALREADY KNEW WHAT IT MIGHT BE AND LET 3 TECHS SOAK UP SOME CLOCK TIME ON THIS ONE. THE ORIGINAL CHARGE WAS QUOTED AT $95 SO I GUESS WE GOT OFF BETTER THAN SOME. *TT
Engine and engine cooling, Power train, Jan 20, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE STOPPED AT A TRAFFIC STOP, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE TORQUE CONVERTER WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,064. UPDATED 02/15/12*BF UPDATED 03/16/12
Power train, Seat belts, Jan 1, 2012
1. ON OR NEAR NOVEMBER 19, 2011, A SPRING FROM THE CLUTCH PEDAL BROKE. IT SEEMS TO BE ONE THAT RETURNS THE PEDAL TO ITS DEFAULT POSITION AS I HAVE TO LIFT UP ON IT FROM BENEATH WITH MY FOOT TO GET IT BACK TO ITS REGULAR HEIGHT. I'M CONCERNED THAT IT MAY CAUSE PREMATURE WEAR ON THE CLUTCH IF IT DOES NOT RETURN TO ITS STANDARD REST POSITION. THE SPRING BROKE WHILE THE CAR WAS PARKED BEFORE DRIVING. --------------------------------- 2. IN LATE 2011, I BEGAN TO NOTICE THE DRIVER'S SEAT BELT BEGIN TO FRAY ON THE BOTTOM (LAP SIDE). THIS IS MY FIRST EXPERIENCE WITH A SEAT BELT WEARING OUT, AND I GENERALLY KEEP MY VEHICLES AT LEAST TEN YEARS (ALL PREVIOUSLY OWNED). I'VE HAD THIS ONE FOR ONLY 3 1/2 YEARS AND IT'S A TOTAL OF 6 YEARS OLD. *TR