2005 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,584 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Escape model years with reports.
Of the 2005 reports, 44 involved a crash and 20 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
Seats, front assembly, head restraintApr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V111000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Representative owner complaints: wheels
107 reports, newest first. Show all
Suspension, Electrical system, Wheels, Aug 12, 2012
DRIVING MY FORD ESCAPE 2005, 35MPH, HEARD A THUMP/BANG THEN VERY LOUD RATTLING FROM THE BACK OF THE VEHICLE. ARRIVED HOME, FOUND THAT THE RIGHT REAR SHOCK, SHOCK MOUNT, AND A DINNER-PLATE-SIZED CHUNK OF WHEEL WELL HAD PUNCHED UP INTO THE BACK OF THE VEHICLE. OPENED THE LIFTGATE, SAW THE SHOCK MOUNT FLOPPING AROUND INSIDE THE CAR AND A DANGLING CLUSTER OF WIRES THAT HAD BEEN SHREDDED BY THE JAGGED METAL. ENTIRE RIGHT SIDE OF THE REAR COMPARTMENT HAD BEEN SHOVED UP 10CM. HUSBAND WAS SHOCKED, SURE I MUST HAVE HIT SOMETHING, BUT I HAD NOT. RIGHT REAR WHEEL WELL HAD COMPLETELY RUSTED OUT UNDERNEATH THE UNDERCOATING. COULD NOT SEE THE RUST FROM THE OUTSIDE, SO DID NOT KNOW IT WAS HAPPENING. CHECKED LEFT REAR WHEEL WELL, SAW NO RUST, BUT UNDERCOATING LIFTS RIGHT OFF TO REVEAL TERRIBLE RUST UNDERNEATH AS WELL. VEHICLE IS NOT SAFE TO DRIVE, NO SHOCK, WATER AND ROAD DEBRIS WOULD FLY RIGHT UP INTO THE CAR THROUGH THE HUGE HOLE. THIS KIND OF DAMAGE IS INCREDIBLE. ESTIMATE FOR REPAIR FROM DEALERSHIP (BRONDES FORD, TOLEDO) WAS $5752.34. CERTAINLY CAN NOT AFFORD THAT. RESEARCHED ONLINE FOR REPAIR ALTERNATIVES AND FOUND DOZENS OF OTHER PEOPLE WITH THE SAME TYPE OF DAMAGE TO THE SAME VEHICLE MAKE AND MODEL. REPORTED THE DAMAGE TO FORD CUSTOMER RELATIONSHIP HOTLINE, WAS INFORMED THAT NO RECALL HAS BEEN ISSUED FOR THIS VEHICLE, AND THAT THEY WERE UNAWARE THAT THIS WAS A COMMON, FREQUENT, OR WIDESPREAD PROBLEM. THEY DID NOT CONSIDER IT A DEFECT. THIS IS EXTREMELY DANGEROUS. MY CHILDREN WERE AFRAID WE WERE GOING CRASH. EASILY COULD HAVE LOST CONTROL IF THIS HAD HAPPENED WHILE TURNING A CORNER, MERGING INTO TRAFFIC, DRIVING 65MPH ON THE HIGHWAY, ETC. I AM CERTAIN, HOWEVER, THAT ONCE FORD MOTOR COMPANY REALIZES THE POTENTIAL HARM THIS DEFECT CAN CAUSE TO LIFE AND PROPERTY, THEY WILL BE DETERMINED TO DO RIGHT BY THEIR LOYAL CUSTOMERS. *TR
Suspension, Structure, Wheels, Apr 28, 2012
2005 FORD ESCAPE WITH A RUSTED OUT RIGHT REAR WHEEL WELL AROUND THE UPPER SHOCK MOUNT. I CHECKED WITH A FORD DEALER ABOUT ANY RECALLS, NONE. FORD MANAGER SAID THEY HAVE NEVER SEEN SUCH AN ISSUE AT LASCO FORD FENTON MI. (FORD EST. TO REPAIR WAS 3400.00) I STOPPED AT A COUPLE BODYSHOPS IN THE AREA AND THEY (KNEW) OF THIS PROBLEM AND COULD QUOTE ME THE PARTS NEEDED, ALONG WITH THE 25 HOURS TO REPLACE/REPAIR IT. MY ESCAPE IS 7 YEARS OLD AND HAS 115,000 MILES, HOWEVER I DON'T THINK THAT THE BODY STRUCTURE (IN WHEEL WELL) SHOULD HAVE RUSTED COMPLETELY AWAY (RIGHT SIDE ONLY?), LEAVING THE TOP SHOCK MOUNT FLAPPING BACK AND FORTH, MAKING THE VEHICLE UNSAFE AND (NOT) DRIVABLE. THIS PROBLEM ENDED UP COSTING 2005.00 TO REPAIR. THIS IS A SAFETY ISSUE THAT SHOULD BE ADDRESSED. I CALLED FORD CUSTOMER SERVICE AND THIS WAS THERE RESPONSE: I UNDERSTAND THAT YOU ARE EXPERIENCING RUST ISSUES ON THE RIGHT REAR FENDER AND SHOCK MOUNTS OF YOUR VEHICLE. I APOLOGIZE FOR THE INCONVENIENCE THIS MAY HAVE CAUSED. I CAN ALSO SEE WHY YOU FEEL THIS IS A MIGHT BE A COMMON ISSUE WITH THE RESEARCH YOU MADE. PLEASE UNDERSTAND, WE SHARE ALL OF OUR VEHICLE CONCERN DOCUMENTATION WITH NATIONAL HIGHWAY TRAFFIC AND SAFETY ADMINISTRATION (NHTSA) AND FORD ENGINEERING. TOGETHER, WE WORK TO FURTHER DETERMINE IF A RECALL OR CUSTOMER SATISFACTION PROGRAMS (CSP) IS NEEDED FOR COMPONENT FAILURES. IF A RECALL OR CSP BECOMES AVAILABLE FOR YOUR VEHICLE, YOU WILL BE NOTIFIED BY U.S. MAIL TO THE CURRENT ADDRESS WE HAVE ON FILE. PLEASE KEEP IN MIND THAT NHTSA, WHICH IS THE FEDERAL AGENCY RESPONSIBLE FOR MOTOR VEHICLE SAFETY IS THE ONLY ORGANIZATION WITH THE AUTHORITY TO ORDER A RECALL OR CSP. IN ADDITION, I FOUND THERE ARE NO WARRANTIES, FIELD SERVICE ACTIONS (RECALLS) / CSPS ON YOUR VEHICLE THAT WOULD PROVIDE ASSISTANCE FOR YOUR CURRENT CONCERN. FORD MOTOR COMPANY. *TR
Wheels, Mar 8, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT NOTICED A THUMPING NOISE COMING FROM THE REAR PASSENGER SIDE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIANS ADVISED THE CONTACT THAT THERE WAS CORROSION ON THE PASSENGER SIDE REAR WHEEL WELL AND THE UNDER COATING WAS CHIPPING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Wheels, Aug 1, 2011
2005 FORD ESCAPE. FORD DEALER SERVICE FOR OIL CHANGE, ROTATE TIRES AND BRAKE INSPECTION NOTED FRONT BRAKE PADS NEEDED REPLACED. DECLINED SERVICE, (PRICE) ABLE TO CHANGE FRONT PADS OURSELVES. WE COULD NOT REMOVE WHEEL LUG NUTS. (THE SAME DAY) CHECKED TORQUE AND FOUND DEALER HAD OVER TIGHTENED THE LUG NUTS TO OVER 150 LBS. WITH MUCH EFFORT REMOVED LUG NUTS AND CHANGED FRONT BRAKE PADS. RETURNED TO DEALER TO COMPLAIN AND REQUEST ALL NEW WHEEL STUDS. ALTHOUGH THEY COULD NOT REMOVE THE REAR LUG NUTS WITH THE WRENCH SUPPLIED WITH THE ESCAPE THEY DENIED REPLACING THE WHEEL STUDS. I BELIEVE THE FAILURE WITH WHEEL STUDS ON FORD PRODUCTS IS A DEALER SERVICE PROBLEM. QUESTION: HAVE THE FAILURES ALL HAPPENED AFTER DEALER SERVICE? *KB
Wheels, Apr 25, 2008
THE FINISH ON MY ALUMINUM WHEELS IS PEELING OFF AND THERE IS CORROSION THAT HAS FORMED AROUND THE RIM AND CENTER OF ALL FOUR OF MY WHEELS. I CHECKED THE SPARE WHEEL AND THE FINISH IN THE CENTER OF THE WHEEL IS STARTING TO BUBBLE ALSO. THE VEHICLE IS A 2005 FORD ESCAPE. THESE ARE FACTORY WHEELS AND I HAVE ONLY 40,000 MILES ON THE VEHICLE. I HAVE AN EXTENDED WARRANTY AND FORD WILL NOT COVER THIS ITEM EVEN THOUGH IT IS OBVIOUSLY A MANUFACTURING DEFECT. THE EXFOLIATING ON THE WHEELS IS SO BAD THAT I AM ABLE TO REMOVE SMALL CHUNKS. *TR
Wheels, Mar 1, 2005
COMPLAINT RECEIVED VIA E-MAIL. THE FRONT WHEEL ASSEMBLY CAME APART WHILE DRIVING, THUS CAUSING ANOTHER VEHICLE DAMAGE AS WELL. NO CONTACT WAS WITH THIS CAR UNTIL AFTER PARTS CAME OFF THE ESCAPE, CAUSING US TO LOSE CONTROL AND CROSS THE CENTER LINE. THERE HAS BEEN NO REMEDY FROM FORD MOTOR COMPANY AT ALL TO FIX MY CAR. FORD WILL NOT EVEN ACKNOWLEDGE THAT IT WAS A DEFECT IN WORKMANSHIP OR IN MANUFACTURING. *AK
Wheels, Oct 15, 2004, crash
BACK WHEELS WERE MISALIGNED MAKING TH EVEHICLE UNSTABLE. THE WHEELS ROCKED BACK AND FORTH. CONSUMER WAS TOLD BY THE DEALER THAT THEY COULD NOT REPAIR THE DEFECT UNTIL THEY RECEIVED NEW SPECIFICATIONS. ALSO, ACCELERATION WAS VERY HIGH. RPMS WENT UP 8,000 RPMS. HOWEVER, ON THIS VEHICLE THE RPM'S WENT TO 15,000 RPMS, WHICH WAS TO0 HIGH. *AK *NM