2005 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,584 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Escape model years with reports.
Of the 2005 reports, 44 involved a crash and 20 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
Seats, front assembly, head restraintApr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V111000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Representative owner complaints
1,584 reports, newest first.
Engine, Sep 10, 2013
DRIVING AT ANY SPEED, VEHICLE WILL SUDDENLY LOOSE ENGINE POWER AND ENGINE WILL STUTTER OR SHAKE AS SOMEONE PULLED OUT ONE SPARK PLUG AND VEHICLE IS TRYING TO COMPENSATE. ENGINE LIGHT WILL FLASH DURING THIS TIME APROX 40 SECONDS AND THEN ENGINE WILL CATCH AND RESUME NORMAL DRIVING. DOES NOT MATTER IF ENGINE IS HOT OR COLD, SHORT OR LONG DISTANCE THIS WILL HAPPEN RANDOMLY WITH OUT WARNING. AC OFF HEAT OFF AC ON HEAT ON DOES NOT MATTER. WE ARE NOW TRYING TO GOOGLE THE PROBLEM AND SEE WHAT OTHERS HAVE DONE WITH THE SAME PROBLEM. FORD HAS BEEN NO HELP AFTER READING THE CODES THEY TRY TO FIX WHAT MY PERSONAL MECHANIC HAS ALREADY REPLACED. CODES ALWAYS READ THE SAME THING COILS, FUEL INJECTION ALL HAVE ALREADY BEEN REPLACED AND PROBLEM PERSISTS. HAS BEEN IN TO REPAIR NUMEROUS TIMES AND SPENT 1,000'S OF DOLLARS ON VEHICLE. *TR
Power train, Sep 5, 2013
MY FORD ESCAPE 2005 WAS WORKING WELL WITHOUT ANY WARNING. SUDDENLY AFTER TURNING THE CAR SHUT DOWN. AFTER RESTARTING THERE WAS NOT ENOUGH POWER. WENT TO FORD AUTHORIZED REPAIR CENTER AND WAS TOLD THIS WAS A KNOWN PROBLEM WITH A TSB 10 -18-10, FAULTY SPARK PLUGS MAKE RADIO FREQUENCY INTERFERENCE WHICH MAKE COILS ON PLUGS AND POWER TRAIN CONTROL MODULE (PCM) TO MALFUNCTION. ALL SIX SPARK PLUGS AND COILS WERE REPLACED AND THE PROBLEM PERSISTS, ONLY SOLUTION IS TO CHANGE PCM. THIS PROBLEM CAN HAPPEN AT ANY TIME, AFTER ANY MILEAGE, WITHOUT ANY NOTICE, THESE VEHICLES SHOULD BE RE-CALLED AND FORD SHOULD PAY FOR THESE AS IT IS A DEFECT FROM FABRIC. *JB
Structure, Sep 5, 2013
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION IT WAS FOUND THAT THE DRIVER'S SIDE REAR SUSPENSION TOWER WAS COMPLETELY RUSTED AND RENDERED THE VEHICLE INOPERABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS CONFIRMED AND THE CONTACT WAS INFORMED THAT THE PART WAS NO LONGER MANUFACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS UNAVAILABLE.
Engine, Sep 2, 2013
AFTER DRIVING AT HIGH SPEEDS AND THEN SLOWING DOWN, (FOR EXAMPLE: GETTING OFF THE INTERSTATE ON THE OFFRAMP) THE ESCAPE WILL STALL OUT AND THE ENGINE WILL STOP. IT WILL START AGAIN, BUT WILL STALL OUT WHEN THE CAR IS PUT INTO GEAR. THIS HAS HAPPENED MULTIPLE TIMES TO ME. MECHANICS HAVE NOT BEEN ABLE TO REPEAT THE ISSUE. THERE IS A RECALL ON THE 2004 ESCAPE DUE TO THIS EXACT MISTAKE, BUT THE FORD DEALERSHIP WILL NOT FIX MINE BECAUSE THEY CANNOT REPEAT THE ISSUE. *JS
Suspension, Structure, Wheels, Aug 29, 2013
AS WE ARE DRIVING ALONG WE HEAR A VERY LOUD BANGING COMING FROM THE REAR OF THE VEHICLE.WHEN WE GET OUT TO INSPECT THE AREA WE FIND THE REAR PASENGER SIDE WHEEL WELL IS EXTREMELY RUSTED THRU AND CHUNKS OF THE WELL ARE ACTUALLY FALLING OUT. WE TOOK THE CAR TO THE FORD DEALER AND THEY SAID IT CANNOT BE REPAIRED!!!! BY THE FORD DEALER....THEN WE TOOK IT TO SEVERAL AUTO BODY SHOPS THAT SAID THEY CANNOT FIX THIS! SEVERAL PLACES SAID FORD USED FAULTY METAL OR UNDERCOATING AND THAT IS WHY IT RUSTED SO BADLY.THE CAR HAS ONLY 50000 MILES ON IT AND HAS BEEN HIGHLY MAINTAINED...I FINALLY FOUND AN AUTOBODY SHOP THAT WILL REPLACE THE ENTIRE WHEEL WELL AND THEER WILL BE NO GUARANTEE IT WONT HAPPEN AGAIN OR TO ANY OF THE OTHER WHEELS!!! I FEEL TOTALLY RIPPED OFF! I READ ONLINE THAT SEVERAL OTHER PEOPLE HAVE HAD THIS SAME PROBLEM.
Suspension, Structure, Aug 23, 2013
I WAS EN ROUTE TO A REPAIR SHOP TO CHECK A POSSIBLE U-JOINT NOISE, AND HIT A REPAIR BUMP IN THE ROAD WHEN MY CAR MADE A VERY SCARY CLUNK AT THE RIGHT/REAR WHEEL. IT CONTINUED TO MAKE A BANGING /CLUNKING NOISE. I CONTINUED ON TO THE REPAIR SHOP TRAVELING AT 25MPH WITH MY FLASHERS ON. THEY TOOK THE VEHICLE FOR A SHORT TEST DRIVE AND CONFIRMED THE BANGING/CLUNKING NOISE. THEY THEN PUT THE VEHICLE ON A HOIST FOR A VISUAL INSPECTION AND FOUND THE UNDER-BODY FRAME AROUND THE RIGHT/REAR SHOCK MOUNT HAD RUSTED AWAY, AND THE REMAINING PORTION THAT WAS STILL ATTACHED TO THE SHOCK WAS SNAPPING AND BANGING WITH ANY MOVEMENT OF THE RIGHT/REAR WHEEL. SINCE THEN I HAVE NOT DRIVEN MY VEHICLE. THE REPAIR SHOP HAS INFORMED ME THAT THEY HAVE SEEN 5 MORE ESCAPES SINCE THEN ,AND ONLY ONE HAD THE SAME PROBLEM. IT WAS ALSO AN ESCAPE HYBRID. THEY ALSO ADVISED ME TO CONTACT YOUR WEBSITE AND MAKE A COMPLAINT. *TR
Suspension, Structure, Aug 22, 2013
THE LEFT PASSENGER REAR FENDER WELL HAS RUSTED OUT AROUND THE SHOCK MOUNT, READY TO BREAK FREE. *TR
Suspension, Aug 22, 2013
RIGHT REAR WHEEL WELL COMPLETELY RUSTED OUT AROUND SHOCK TOWER AND SHOCK PUNCHED THROUGH INTO INTERIOR OF VEHICLE NOTHING ELSE RUSTED ON VEHICLE FORD SAID THERE IS NO RECALL AND EVERYONE SEEMS TO HAVE THE SAME PROBLEM WITH THE ESCAPES AND SAID BODY SHOP WOULD BE $1300 TO FIX. *TR
Steering, Suspension, Structure, Aug 22, 2013
THE RIGHT REAR UPPER SHOCK MOUNT COMPLETELY RUSTED THRU THE TRUNK AREA&WAS PROTRUDING UP ABOUT A FOOT INTO TRUNK AREA-VERY GLAD I WASN'T GOING FAST WHEN THIS HAPPENED!!MOST LIKELY WOULD HAVE LOST CONTROL OF VEHICLE!!!!!!!!!THIS IS ONE OF FORDS BEST IDEAS EVER!!!!!!!!!!!!!!!!!!!!!!!!!!!VERY THIN SHEET METAL WITH A THICKER PIECE WELDED TO IT TO SUPPORT 1 SIDE OF A VEHICLE.YEAH,THAT IS COMMON SENSE AT THE FINEST!!!!! THANKYOU FORD ENGINEERS!!!!!!!!!!!!!!!!!!!!&DESIGNERS!!!!!!!!!!!!!!!!!! THESE SAME COMMON SENSE PEOPLE HOPEFULLY PUT OUT A RECALL SO PEOPLE CAN GET IT FIXED&GET SOME MONEY BACK!! I DID HAVE MINE FIXED RIGHT AWAY_IT'S THE ONLY VEHICLE I HAVE. *TR
Vehicle speed control, Aug 21, 2013
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE ACCELERATOR PEDAL BECAME STUCK TO THE FLOOR BOARD WHEN PARKING OR IN REVERSE. THE CONTACT HAD TO DEPRESS THE ACCELERATOR PEDAL SEVERAL TIMES FOR IT TO RELEASE. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000 AND THE CURRENT MILEAGE WAS 123,000.
Suspension, Aug 13, 2013
I'VE BEEN HEARING SOME LOUD NOISES/BANGS FROM THE BACK END OF MY CAR BUT COULDN'T FIGURE OUT WHAT IT WAS. I FOUND OUT THE ENTIRE REAR PASSENGER WHEEL WELL HAD RUSTED OUT IN A 1/2 CIRCLE AROUND THE SHOCK. THE SHOCK WAS NO LONGER ATTACHED TO THE CAR. EVERYTIME IT WENT OVER A BUMP - IT SOUNDS LIKE MY TRUNK IS PICKING UP AND SLAMMING DOWN. I HAVE VERY MINIMAL RUST ON MY CAR AND THE OTHER WHEEL WELLS ARE IN VERY GOOD CONDITION. IF YOU OPEN THE COMPARTMENT WHERE THE JACK IS STORED IN MY TRUNK YOU CAN SEE MY TIRE THROUGH A HOLE. I HAVE SEEN DOZENS AND DOZENS OF ONLINE COMPLAINTS FOR THE SAME PASSENGER SIDE WHEEL WELL RUSTED OUT CAUSING THE SHOCK TO DISCONNECT BUT FORD HAS NOT PUT OUT A RECALL AND IT COSTING $1200-$1800 TO REPAIR. *TR
Vehicle speed control, Aug 9, 2013
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY LOST ACCELERATION POWER. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE THROTTLE BODY NEEDED TO BE CLEANED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 152,000.
Service brakes, Aug 9, 2013
I PRESSED ON THE BRAKE PEDDLE. IT WAS VERY LOOSE AND DEPRESSED EASILY ABOUT 1 INCH, THEN STOPPED ABRUPTLY AND HELD FIRM WITHOUT SLOWING THE CAR AT ALL. AFTER PRESSING DOWN HARDER WITHOUT BEING ABLE TO BUDGE THE BRAKES, I LIFTED AND REAPPLIED THE BRAKES. THIS TIME THEY WORKED. THE SAME THING HAPPENED AGAIN A COUPE DAYS LATER. I TOOK IT IN TO THE FORD DEALER AND THEY TOLD ME THE ABS MODULE AND MASTER CYLINDER NEEDED TO BE REPLACED. FROM MY RESEARCH, FAULTY MASTER CYLINDER AND ABS MODULE ARE COMMON FOR THIS VEHICLE. *TR
Suspension, Aug 9, 2013
I PRESENTED MY VEHICLE FOR PA SAFETY INSPECTION. INSPECTION REVEALED THAT THE RIGHT REAR SHOCK TOWER HAD RUSTED OUT AND NEEDS TO BE FIXED. THIS IS A COMPELLING SAFETY CONCERN. *TR
Suspension, Aug 7, 2013
I NOTICED AN UNUSUAL SOUND FROM THE RIGHT REAR END OF MY 2005 ESCAPE HYBRID A COUPLE OF WEEKS AGO AND WAS ONLY ABLE TO LOOK AT IT TODAY. I WAS AMAZED TO FIND THE WHEEL WELL HAD RUSTED OUT AT THE ATTACHMENT POINT OF THE SHOCK AND THE UPPER PART OF THE SHOCK IS HANGING FREE. THEN I LOOKED AT THE OTHER SIDE AND IT IS STARTING TO GO. CLEARLY THE VEHICLE IS UNSAFE TO DRIVE IN THIS CONDITION. I WAS HOPING TO KEEP THE VEHICLE A FEW MORE YEARS BUT IT LOOKS AS THOUGH WITHOUT MAJOR RECONSTRUCTION IT IS JUNK AT THIS POINT IN TIME. CLEARLY THE VEHICLE IS OUT OF WARRANTY BUT IT DOES NOT SEEM TO ME THAT THE DEGREE OF FAILURE SEEN HERE IS UNEXPECTED UNDER NORMAL CONDITIONS ESPECIALLY IN THAT I HAVE OWNED THE CAR SINCE NEW AND IT HAS BEEN WELL MAINTAINED. IN A BRIEF SEARCH OF THE WEB I HAVE FOUND THAT OTHER ESCAPE OWNERS HAVE EXPERIENCED THIS PROBLEM AND THAT FORD IS AWARE OF THIS. I AM CONCERNED THAT WITH A POTENTIAL FOR CATASTROPHIC FAILURE FORD DID NOT NOTIFY THE OWNERS TO CHECK FOR THIS PROBLEM. *TR
Power train, Engine, Aug 7, 2013
DRIVING 55 MPH ON HIGHWAY, CAR SOUNDED LIKE IT DOWNSHIFTED INTO MUCH LOWER GEAR (VERY LOUD) WITH JERKY MOTION, IMMEDIATELY LOST POWER, WAS CLIMBING LARGE HILL, COASTED TO SIDE OF ROAD IN HEAVY TRAFFIC, LOST POWER STEERING, MADE HORRIFIC GRINDING SOUND, AND THEN STOPPED. IDLED FOR 30-45 SECONDS, ALL DASHLIGHTS CAME ON BEFORE DYING ON HIGHWAY. I HAVE REVIEWED CARCOMPLAINTS.COM ON THIS MODEL ESCAPE, THEY ARE NOTORIOUS FOR PCM COMPUTER GOING WITH NO NOTICE. MY MECHANIC INFORMS ME TODAY THAT IS THE PROBLEM, COST FOR REPAIR IS ABOUT $2,000.00, NOT COVERED BY THE EXTENDED WARRANTY I PURCHASED. THIS IS A WELL DOCUMENTED ISSUE THAT CLEARLY CREATES SAFETY ISSUES WHEN DRIVING AT HIGH RATES OF SPEED, WITH NO WARNING. THE CAR WAS "FINE" BY ALL OTHER ACCOUNTS, THIS HAPPENED OUT OF NO WHERE. *TR
Wheels, Aug 1, 2013
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THERE WAS A LOUD BANG FROM THE REAR END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER'S SIDE INNER WHEEL HOUSE WAS CORRODED AND NEEDED TO BE REPLACED. THE TECHNICIAN STATED THAT THE PART NEEDED FOR THE REPAIR WAS ON BACK ORDER AND COULD NOT YET BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 87,000.
Structure, Wheels, Jul 31, 2013
I HAD BEEN HEARING SOME LOUD NOISES FROM THE BACK END OF MY CAR FOR A WEEK OR SO, WE HAD THOUGHT THE SPARE TIRE AND EQUIPMENT HADN'T BEEN PUT BACK PROPERLY SO WE RE-ADJUSTED IT AND THOUGHT WE HAD FIXED THE PROBLEM. A FEW DAYS LATER THE SOUND STARTED BACK UP. THEN IT GOT REALLY LOUD AND THERE WAS A LOUD POP. UPON FURTHER INVESTIGATION, WE FOUND OUT THE ENTIRE WHEEL WELL HAD RUSTED OUT IN A PERFECT CIRCLE AROUND THE SHOCK. THE SHOCK WAS NO LONGER ATTACHED TO THE CAR. I TOOK IT TO FORD AND THEY TOLD ME THIS HAD BEEN RECALLED ON THEIR MINI-VANS FOR THE SAME YEAR. FORD BODY SHOP STAFF INFORMED ME THAT THIS WAS THE ONLY RUST ON MY VEHICLE AND THIS RUST WOULD NOT BE CAUSED BY MIS-TREATMENT OF THE VEHICLE NOR NORMAL WEAR AND TEAR OF ANY CAR. FORD IS CURRENTLY UNABLE TO GET THE WHEEL HOUSE TO FIX THE CAR AND IT WILL NOT BE AVAILABLE FOR "MONTHS". ONCE I RESEARCHED THIS A LITTLE MORE, IT APPEARS TO BE A HIGHLY COMMON PROBLEM IN THE 2005 FORD ESCAPES. THE CAR IS NOT CURRENTLY FIXABLE OR DRIVE ABLE. *TR
Power train, Electronic stability control (ESC), Engine, Jul 31, 2013
9/10/12, WHILE DRIVING ON THE FREEWAY MY CHECK ENGINE LIGHT CAME ON AND MY CAR STARTED RUNNING VERY HARD AND STARTED SHAKING AND I COULD FEEL THE CAR LOOSING POWER. I TURNED THE STEERING WHEEL TOWARDS THE RIGHT TO PULL OVER AND AS I PRESSED THE GAS PEDAL I COULD FEEL THE CAR HAD SHUT OFF. I WAS ABLE TO PULL OFF TO THE SIDE OF THE HIGHWAY AND MY CAR SMELL LIKE SOMETHING WAS BURNING. AFTER SITTING FOR ABOUT 15MINS THE CAR STARTED AND I WAS ABLE TO START THE CAR AND DROVE IT AT ABOUT 40 MPH UNTIL GETTING OFF THE EXIT TO GO HOME WHICH WAS ABOUT 10 MORE MILES. I HAD TO CONTINUOUSLY PRESS THE GAS MAKING THE CAR ACCELERATE BETWEEN 30 TO 40MPH BECAUSE THE CAR STARTED TO REPEAT THE SAME THING AS I STATED EARLIER. I TOOK THE CAR TO THE SHOP 9/13/12 (MY CAR HAD 153224 MILES) AND WAS TOLD THERE WAS MISFIRE ON #2 COIL, SO I PAID TO HAVE THE COIL CHANGED. 2/15/13 MY CHECK ENGINE LIGHT CAME BACK ON AND THE CAR WAS REPEATEDLY HESITATING, I TOOK IT THE SHOP 2/19/13 (MY CAR HAD 163071 MILES) AND HAD THE SAME MISFIRE CODE, SO I PAID TO HAVE ALL THREE REAR COILS CHANGED, THE OWNER SHOWED ME THE OLD COILS & THE #2 COIL LOOK BURNED AND BURST OPEN FROM THE TOP. AFTER CHANGING THE COILS THE CHECK ENGINE LIGHT CAME BACK ON WITH THE SAME MISFIRE CODE FOR #2 COIL AND I PAID TO HAVE IT CHANGED AGAIN 6/18/13 (MY CAR HAD 171459 MILES). THE ENGINE LIGHT CAME BACK ON WITH THE SAME CODE AND I PAID TO CHANGED IT AGAIN 7/12/13 (MY CAR HAD 173095 MILES) AFTER I DROVE THE CAR ABOUT 50 MILES THE LIGHT CAME BACK ON. I HAD THE CODE READ AGAIN ON 7/30/13 (MY CAR HAD 173920 MILES) AND IT GAVE THE SAME CODE FOR A MISFIRE ON COIL #2. THE OWNER OF THE SHOP ADVISED ME TO TAKE THE CAR TO THE DEALER AND EXPLAIN THE PROBLEM AND CHECK IF THERE HAS BEEN A RECALL ON THE 2005 MODEL. I CALLED THE FORD DEALERSHIP AND WAS TOLD I WOULD HAVE TO PAY FOR THEM TO DO ANOTHER DIAGNOSTIC QUOTED AT $140. *TR
Suspension, Structure, Jul 30, 2013
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE PASSENGER'S SIDE REAR SHOCK HAD PENETRATED THE BODY OF THE VEHICLE DUE TO RUST. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 48,000. THE CURRENT MILEAGE WAS 90,000.
Suspension, Structure, Jul 30, 2013
THE RIGHT REAR SHOCK MOUNT HAS RUSTED OUT, AND NOW BANGS AGAINST THE WHEEL HOUSING. *TR
Suspension, Structure, Wheels, Jul 25, 2013
THE WHEEL WELL RUSTED OUT AND THE SHOCK BROKE LOOSE AND WAS BANGING AROUND. BASICALLY THE WHOLE WHEEL WELL IS RUSTED OUT AND WILL NOT HOLD THE SHOCK ANY MORE. I CALLED THE LOCAL FORD DEALER TO SEE IF THERE WAS A RECALL. I WAS TOLD THERE WAS NO RECALL. WHEN I SEARCHED ONLINE I FOUND MANY WITH THE SAME EXPERIENCE, AND EVEN A FACEBOOK PAGE. I'M DISAPPOINTED THAT FORD ISN'T TAKING CARE OF THIS. *TR
Suspension, Structure, Jul 25, 2013
RIGHT REAR WHEEL HOUSING THAT ALSO IS THE TOP RIGHT REAR SHOCK MOUNT IS COMPLETELY RUSTED LOOSE. *TR
Fuel system, Gasoline, Electrical system, Engine, Jul 19, 2013
WITHIN 1/4 MILE OF STARTING AND DRIVING FROM HOME, THE ENGINE BEGAN TO RUN VERY ROUGH, MISFIRING, IDLING ROUGH, ETC. PULLED OVER, OPENED HOOD, ENGINE WAS IDLING VERY ROUGH. NO CHECK ENGINE LIGHT. BROUGHT IT BACK HOME. TOTAL TRIP WAS LESS THAN 1 MILE. NEXT DAY, STARTED IT UP AGAIN, RAN SMOOTHER, BUT HAD NO POWER; VERY DIFFICULT TO GET ABOVE 20-30MPH. BROUGHT IT TO REPAIR SHOP. THEY DETERMINED THAT ALL THREE CATALYTIC CONVERTERS WERE CLOGGED UP FROM BROKEN/MELTED CATALYTIC CONVERTER INTERNAL PARTS. REPLACED ALL THREE CATALYTIC CONVERTERS, BUT REPAIR SHOP COULD NOT DETERMINE THE CAUSE OF THE INITIAL MISFIRING AND CATALYTIC CONVERTER DAMAGE. CHECK ENGINE LIGHT NEVER CAME ON AT ANY TIME. TOTAL REPAIR COST $2350.00. CAR HAD BEEN IN THE SAME SHOP EARLIER THAT WEEK FOR STATE INSPECTION AND LUBE-OIL-FILTER. NO ISSUES FOUND AT THAT TIME. BATTERY HAD FAILED TWO DAYS BEFORE THE PROBLEM, AND WAS REPLACED THE MORNING OF THE PROBLEM. THE ISSUE APPEARED UPON FIRST DRIVING THE CAR AFTER THE BATTERY WAS CHANGED. *TR
Suspension, Structure, Wheels, Jul 18, 2013
I WAS DRIVING HOME AND SLOWED DOWN TO GO OVER SOME RAILWAY TRACKS. AS I WENT OVER THE TRACKS I HEARD A "THUD" COMING FROM THE REAR OF THE VEHICLE. THE SOUND CONTINUED AS I WENT OVER BUMPS, AND I DISCOVERED ONCE I ARRIVED HOME THAT THE PASSENGER SIDE REAR WHEEL WELL WAS COMPLETELY RUSTED OUT AND THE SHOCK WAS UNATTACHED AT THE TOP. SINCE THEN THE TOP OF THE SHOCK HAS PIERCED THROUGH THE INTERIOR CABIN WALL. *TR