2005 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,584 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Escape model years with reports.
Of the 2005 reports, 44 involved a crash and 20 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
Seats, front assembly, head restraintApr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V111000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Representative owner complaints
1,584 reports, newest first.
Vehicle speed control, Nov 14, 2012
I OWN AT 2005 FORD ESCAPE. IN 2007 AND 2009 I HAD TWO INCIDENTS OF BEING AT A RED LIGHT AND WHEN I PUSHED ON THE ACCELERATOR IT FELT HARD TO PRESS AND WOULD NOT BUDGE. I HAD TO PULL OVER AND CONTINUALLY PUSH ON THE ACCELERATOR AND THE CAR WOULD FINALLY GO. THIS MORNING I HAD THE SAME THING HAPPEN. THE FIRST TWO INCIDENTS RESULTED IN MY TAKING THE CAR TO THE DEALERSHIP AND THEY REPLACED THE THROTTLE BODY STATING THAT IT WAS A DEFECTIVE PART. AFTER THIS MOST RECENT INCIDENT I AM PLANNING ON TAKING THE CAR TO THE DEALERSHIP AGAIN. *TR
Vehicle speed control, Nov 13, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE PARKED SHE ATTEMPTED TO START THE VEHICLE WHEN SHE NOTICED THE GAS PEDAL WAS STICKING CAUSING THE VEHICLE TO ACCELERATE. THE CONTACT STARTED TO TAP THE GAS PEDAL AND MANAGED TO UNLODGED THE PEDAL. ALSO THE CONTACT MENTIONED THAT THE FAILURE OCCURS CONSTANTLY DURING THE WINTER. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE THROTTLE NEEDED TO BE SPRAYED WITH WD-40. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 100,000.
Suspension, Structure, Wheels, Nov 12, 2012
THE PASSENGER-SIDE REAR WHEEL WELL HAS COMPLETELY RUSTED THROUGH TO THE POINT WHERE YOU CAN SEE INTO THE CABIN, AND THE SHOCK/STRUT IS MOUNTED TO NOTHING AND IS POKING INTO MY TRUNK. THE METAL ALL AROUND THE MOUNT (OR WHERE IT SHOULD BE MOUNTED) IS COMPLETELY CORRODED AND RUSTED TO THE POINT OF BEING COMPLETELY DETACHED, AND THE SURROUNDING METAL IS STAMPED SO THIN TO BEGIN WITH THAT IT IS PLIABLE. THE SHOCK IS COMPLETELY INEFFECTIVE, AND MY CAR IS A TICKING TIME BOMB OF SAFETY ISSUES. I HAVE CONTACTEDFORD SEVERAL TIMES, AND FORD CANADA IS DENYING THAT THIS IS A SAFETY OR QUALITY ISSUE AND HAVE TAKEN NO RESPONSIBILITY; THEY REFUSE TO FIX MY CAR. I CANNOT FIND A RECALL AT PRESENT, HOWEVER THERE ARE NUMEROUS PEOPLE REPORTING THE SAME PROBLEM WITH THEIR ESCAPES, 6 ALONE ON [XXX] AND 5 ON [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Air bags, Nov 10, 2012, crash
ON 10/18/12 I WAS INVOLVED IN A MOTOR VEHICLE ACCIDENT WITH MY 2005 FORD ESCAPE. MY VEHICLE SLAMMED INTO AN EMBANKMENT, CRUSHING THE DRIVERS SIDE OF THE VEHICLE, AND THERE WAS A LARGE CRACK NEAR THE LUGGAGE RACK EXTENDING THE LENGTH OF THE VEHICLE ON THE DRIVERS SIDE AT SOME POINTS I COULD VISUALLY SEE INTO THE CRACK AND INTO THE VEHICLE INTERIOR. DRIVERS SIDE OF VEHICLE HIT HEAD ON INTO TREE AT 55MPH, BUT AIRBAGS DID NOT DEPLOY. BOTH HEADLIGHTS POPPED OUT, HOOD CRINKLED, AND THERE WAS EXTENSIVE FRONT END DAMAGE. REAR WINDOW ON DRIVERS SIDE BROKEN. VEHICLE WAS TOTALED. *TR
Engine, Nov 9, 2012
I WAS TRYING DOWN THE HIGHWAY DOING ABOUT 55 MPH ALL THE LIGHTS CAME ON THE CAR, I WAS ABLE TO GET TO THE SIDE OF THE ROAD. I STOPPED THE CAR FOR ABOUT 5 MINUTES WAS ABLE TO RESTART AND DRIVE ANOTHER 1/2 MILE AND IT HAPPENED AGAIN. GOT THE CAR TOWED TO A MECHANIC, WHO PLACED ENGINE ON CODE MACHINE AND STATES MY ENGINE COILS WERE BAD. REPLACED ALL OF MY ENGINE COILS AND THE CAR IS STILL RIDING LIKE A DUMP TRUNK. TOOK DO A FORD DEALERSHIP WHO CHARGED ME 160.00 TO PUT ON MACHINE AND TOLD ME IT WAS MY ENGINE COILS, I HAVE REPLACED ALL THE COILS. I AM JUST AT MY WITTS END. I WILL NOT EVER BUY A FORD AGAIN. AS A SIDE NOTE, I PUT A TRANSMISSION IN THIS TRUCK ABOUT 2 YEARS AGO AND THE DEALER WHO FIXED MY CAR, DIDN'T EVEN GIVE ME A RENTAL TO DRIVE. ITS A NEW AND USED CAR DEALERSHIP AND THEY COULDN'T EVEN GIVE ME ONE OF THEIR CARS TO DRIVE. ARE YOU SERIOUS? *TR
Power train, Electrical system, Electronic stability control (ESC), Nov 9, 2012
WHILE DRIVING 45MPH THE CAR JUST CUT OFF IS A HIGH TRAFFIC AREA. THE CAR BEHIND ME HAD TO SWERVE TO MISS REAR-ENDING ME! I HAD MY 3 YEAR OLD DAUGHTER W/ ME AT THE TIME! OUR MECHANIC HAS INFORMED US THAT APPARENTLY FORD MOTOR COMPANY IS AWARE THAT BAD PLUGS WERE INSTALLED IN THESE CARS AND WOULD CAUSE COMPUTER FAILURE! NOTHING WAS TOLD TO US REGARDING THIS ISSUE WHEN WE PURCHASED THE CAR! WHEN EMAILED FMC THEY INFORMED ME THAT THIS IS NOT A SAFETY ISSUE & A RECALL IS NOT REQUIRED. HOW CAN THIS NOT BE A SAFETY ISSUE WHEN THE CAR COMPLETELY DIES W/OUT WARNING??? *TR
Vehicle speed control, Nov 8, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE STOPPED IN A PARKING SPACE, THE CONTACT DEPRESSED THE ACCELERATOR PEDAL BUT NOTICED THAT THE PEDAL HAD BECOME HARD AND WOULD NOT RESPOND. THE CONTACT PLACED THE VEHICLE IN NEUTRAL AND THEN BACK INTO DRIVE WHILE CONTINUALLY APPLYING PRESSURE TO THE ACCELERATOR PEDAL. THE VEHICLE JERKED FORWARD AND PROCEEDED TO ACCELERATE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Electrical system, Nov 7, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 55 MPH THE CONTACT STATED THE THEFT WARNING LIGHT ILLUMINATED AND THE VEHICLE BEGAN TO DECELERATE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 65,000.
Electrical system, Vehicle speed control, Nov 7, 2012
DRIVING DOWN HIGHWAY AT APROX. 55 MPH. THEFT LIGHT CAME ON IN VEHICLE AND VEHICLE QUICKLY DECELERATED. FROM THE RESEARCH THAT I GATHERED, THIS IS A KNOWN PROBLEM TO FORD. FAULTY SPARK PLUGS WERE INSTALLED IN SOME 2005 ESCAPES. THE SPARK PLUGS EMIT A RADIO FREQUENCY THAT CAUSE THE COILS TO BASICALLY FRY YOUR COMPUTER. FORD HAS RELEASED A BULLETIN ABOUT THIS (TSB 09-2-6) BUT REFUSES TO ISSUE A RECALL. THIS IS A HUGE SAFETY ISSUE, AS DECELERATING ON A MAJOR HIGHWAY WITHOUT BRAKE LIGHTS HAS THE POTENTIAL TO CAUSE A TERRIBLE ACCIDENT. CONTACTED FORD'S CORPORATE OFFICE AND WAS OFFERED NO ASSISTANCE. I WOULD LIKE TO HAVE MY SPARK PLUGS AT LEAST CHECKED AT NO CHARGE. THE COST, FOR ONLY CHECKING THE SPARK PLUGS TO SEE IF THEY ARE THE ONES AFFECTED IS $90. I BELIEVE THAT THIS SHOULD BE A RECALL. FORD IS WELL AWARE OF THE PROBLEM BUT REFUSES TO TAKE ANY STEPS TO FIX THIS. *TR
Vehicle speed control, Nov 7, 2012
WHILE TRAVELING ON THE INTERSTATE IN THE LEFT LANE DURING RUSH HOUR TRAFFIC, THE GAS PEDAL STUCK AND WOULD NOT ACCELERATE ANY LONGER. CAUSED OTHER CARS TO SUDDENLY SLOW WHILE TRYING TO GET OFF TO THE RAMP. THE PEDAL WOULD NOT RELEASE FOR APPROXIMATELY 10 MINUTES. THEN AFTER TRAVELING MAYBE 20 YARDS, THE PEDAL STUCK AGAIN FOR ANOTHER 5 MINUTES. *TR
Vehicle speed control, Nov 7, 2012
DURING COLD WEATHER, THE GAS PEDAL WILL STICK AND NOT ACCELERATE OR RELEASE. IT WILL NOT RELEASE FOR SOMETIMES UP TO TEN MINUTES. THIS HAPPENS SEVERAL TIMES OVER SEVERAL DAYS IN A WEEK DURING COLDER MONTHS. THIS HAS BEEN CONSISTENTLY HAPPENING SINCE 2009. THE MOST RECENT ON 11/5/2012. *TR
Vehicle speed control, Nov 5, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE ATTEMPTING TO ACCELERATE FROMA TRAFFIC STOP THE VEHICLE STALLED. THE DEALER WAS NOTIFIED WHO ADVISED THE CONTACT TO TRY TO REACH OUT TO THE MANUFACTURER AND DID NOT OFFER ANY ADDITIONAL ASSISTANCE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED ON ANY RECALLS. THE FAILURE MILEAGE WAS 67,000.
Power train, Oct 31, 2012
THE CAR STOPPED MOVING AT THE POSTED SPEED. THE CATALYTIC CONVERTER DISINTEGRATED, AND BLOCKED THE AIRFLOW. THE WARRANTY EXPIRED 4 MONTHS EARLIER. FORD DID NOT SEEM INTERESTED IN EITHER THE ISSUE OR/ HELPING RESOLVE IT. SHOULD THERE BE A RECALL? *TR
Vehicle speed control, Fuel/propulsion system, Oct 30, 2012
SON WAS DRIVING VEHICLE WHEN GAS PEDAL STUCK AND WOULD NOT GO DOWN--HE PUSHED PEDAL DOWN WITH ALL HIS STRENGTH BUT IT WOULD NOT MOVE. *TR
Suspension, Oct 27, 2012
RIGHT REAR SHOCK ABSORBER MOUNT IS RUSTING PREMATURELY MAKING THE VEHICLE UNSAFE TO DRIVE. *TR
Electrical system, Engine, Oct 25, 2012
MY DAUGHTER WAS DRIVING OUR 2005 FORD ESCAPE ON THE HIGHWAY AT 55 MPH WHEN IT COMPLETELY CUT OFF ON HER. LUCKILY SHE WAS ABLE TO GET TO THE SIDE OF THE HIGHWAY WITHOUT INCIDENT. SHE GOT THE CAR BACK ON AND MADE IT HOME, HOWEVER, IT WAS JERKING AND MISFIRING ALL THE WAY HOME. WE TOOK IT TO A MECHANIC WHO SAID IT NEEDED SPARK PLUGS AND 2 COILS TO THE TUNE OF $700.00. WHEN WE WENT TO PICK IT UP WE WERE TOLD THAT THE COMPUTER WAS SHOT AND THAT WE HAD TO TAKE IT TO THE FORD DEALERSHIP. THE FORD PLACE IS REPLACING ALL 6 COILS AND THE COMPUTER FOR $2300.00. APPARENTLY THERE IS A KNOWN PROBLEM WITH FORD INSTALLING THE WRONG SPARK PLUGS IN THESE MODELS AT THE FACTORY CAUSING THE COILS AND THE COMPUTER TO GO OUT. I DON'T UNDERSTAND WHY FORD HAS NOT RECALLED THIS PROBLEM. GOING DOWN A HIGHWAY AT 55 MPH AND YOU CAR CUTS OFF IS A SAFETY ISSUE IN MY EYES!! *TR
Suspension, Wheels, Oct 25, 2012
STARTED HEARING LOUD RATTLING SOUNDS FROM REAR OF CAR , LOOKED AND SAW PASSENGER REAR WHEEL WELL/SHOCK MOUNT RUSTED OUT AND SEPARATED FROM REST OF VEHICLE. *TR
Electrical system, Engine, Oct 18, 2012
I WAS DRIVING HOME FROM WORK AND THE CAR STALLS OUT OF NOWHERE. THEN THE CHECK ENGINE, OIL, AND ABS WARNING LIGHTS ALL LIT UP. AFTER ABOUT 20 MIN I TRIED STARTING UP THE CAR AGAIN AND IT STARTED UP AND SLOWLY MADE IT HOME. THE FOLLOWING DAY IT HAPPEN AGAIN! LUCKILY NO ONE WAS BEHIND ME, OTHERWISE I WOULD HAVE BEEN REAR ENDED. IMMEDIATELY LOOKED ONLINE DESCRIBING THE ISSUE TO SEE IF I COULD FIND OUT WHAT COULD BE CAUSING THIS, AND COME TO FIND OUT AN OVERWHELMING AMOUNT OF PEOPLE HAVE EXPERIENCED THE SAME THING! THIS IS A SAFETY HAZARD AND HAD I BEEN ON A MAJOR HIGHWAY THE RESULT COULD HAVE DRASTICALLY DIFFERENT. IT IS APPALLING THAT THIS HAS BEEN A KNOW ISSUE AND FORD HAS DONE NOTHING TO REMEDY THE SAFETY OF IT'S CUSTOMERS. *TR
Power train, Oct 17, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND IT RESUMED NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE POWER TRAIN CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE MILEAGE WAS 100,000.
Suspension, Oct 17, 2012
THE RIGHT REAR SHOCK MOUNT BROKE FREE FROM THE BODY OF THE SUV DUE TO ERROSION/RUST. FROM WHAT I CAN SEE FROM RESEARCH THIS IS A PREVELANT ISSUE WITH 2004, 2005, 2006 FORD ESCAPES. HOWEVER FORD HAS NOT ISSUED A RECALL TO DEAL WITH AN ONGOING ISSUE. IT IS MY UNDERSTANDING THAT BECAUSE OF THE FREQUENCY WITH THE ISSUE, THEY CORRECTED THE SUSPENSION DESIGN IN 2007 ESCAPES. *TR
Suspension, Structure, Oct 14, 2012
HI- I HAVE A 2005 FORD ESCAPE. I BOUGHT IT USED. JUST RECENTLY I STARTED TO HEAR A BANGING IN THE BACK REAR OF THE CAB PART OF THE CAR. I FOUND OUT THE SHOCK MOUNTS ARE RUSTED OUT, AND I FEEL LIKE THIS IS A SAFETY ISSUE DUE TO THE FACT THAT THE CAR COULD FALL APART WHILE DRIVING OR CATCH FIRE. I RESEARCHED THIS AND FOUND IT A COMMON PROBLEM. *TR
Service brakes, Oct 12, 2012
ON SEVERAL OCCASIONS, I WAS GETTING READY TO STOP AND NOTICED THAT THE BRAKE PAD "STUCK." THE PAD WOULDN'T DEPRESS AND I WAS UNABLE TO STOP. AFTER ADDITIONAL EFFORT, I WAS ABLE TO GET THE VEHICLE TO SLOW DOWN AND STOP, BUT I WAS ALREADY AT A REDUCED SPEED SINCE I WAS COMING TO A STOP. I THOUGHT MY CAR MAT HAD JAMMED MY BRAKES, SO I THOUGHT NOTHING OF IT UNTIL IT HAPPENED AGAIN. I TOOK MY VEHICLE TO THE FORD DEALER WHERE I MADE THE PURCHASE. THEY KEPT MY VEHICLE FOR A WEEK TO "REPRODUCE" THE PROBLEM, WHICH THEY DID. I WAS THEN TOLD THAT THE PARTS ALONE WOULD COST $3,000, BUT THAT THE ENGINEERS AT FORD CORPORATE SUGGESTED THAT THE MECHANICS PERFORM AN ELECTRO-MECHANICAL BRAKE BLEED, WHICH SEEMED TO FIX THE PROBLEM, BUT IT DID NOT. THREE WEEKS LATER, THE BRAKES FAILED AGAIN. THIS TIME THE DEALERSHIP KEPT MY VEHICLE FOR TWO WEEKS, BUT WERE UNABLE TO REPRODUCE THE FAILURE. I WAS TOLD THAT THE ONLY WAY TO FIX THE PROBLEM WAS TO COMPLETELY REPLACE THE BRAKING SYSTEM. I ACTUALLY CALLED FORD HQ ABOUT THIS ISSUE. THE PERSON WITH WHOM I SPOKE OFFERED NO REAL RESOLUTION, AND SHE SEEMED UNAWARE OF THINGS. FORD IS VERY AWARE OF THE PROBLEMS WITH THE HYBRID BRAKING SYSTEM. THIS IS A DANGEROUS SITUATION THAT IS A DESIGN FLAW--NOT A MECHANICAL FAILURE COVERED BY A WARRANTY. THERE IS A DIFFERENCE, AND FORD NEEDS TO BE HELD RESPONSIBLE. HYBRIDS ARE VERY EXPENSIVE, AND THEREFORE THE MANUFACTURERS OF THESE VEHICLES SHOULD BE FORCED TO TAKE RESPONSIBILITY FOR DESIGN FLAWS THAT ARE AS DANGEROUS AS BRAKE FAILURE. IT'S JUST A MATTER OF TIME BEFORE MY BRAKES FAIL AND I END UP IN A TERRIBLE CRASH, EITHER KILLING MYSELF OR SOMEONE ELSE. EVEN IF I SPENT $7,000 ON A NEW SYSTEM, IT'S GOING TO FAIL AGAIN BECAUSE IT HAS THE SAME DESIGN FLAW OF THE CURRENT BRAKING SYSTEM. THIS IS WHY FORD NEEDS TO REDESIGN THIS BRAKING SYSTEM AND RECALL AFFECTED VEHICLES BEFORE SOMEONE GETS KILLED. *TR
Electrical system, Electronic stability control (ESC), Engine, Oct 11, 2012
DRIVING AT 55 MPH AND CAR BEGAN TO LURCH AND BUCK. CAR SHUT OFF 3 TIMES IN BUSY INTERSECTION WITH NO WARNING AND ALMOST CAUSED AN ACCIDENT. TOOK TO MECHANIC, AND LEARNED THAT THE COMPUTER SYSTEM HAD SHORTED OUT DUE TO MANUFACTURERS USING INCORRECT SPARK PLUGS. APPARENTLY, THIS IS A COMMON ISSUE WITH THIS YEAR AND MAKE. THIS IS A DANGEROUS PROBLEM, AND CAN OCCUR ANYWHERE, DOING ANY SPEED! THE COMPUTER SYSTEM MUST BE REPLACED AND IT IS VERY EXPENSIVE. *TR
Vehicle speed control, Oct 10, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH THE ACCELERATOR PEDAL BECAME STUCK. THE CONTACT MENTIONED THAT THE FAILURE WOULD OCCUR DURING COLD WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED ON ANY RECALLS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 0 AND THE CURRENT MILEAGE WAS 100,000. ..UPDATED 12/06/12 *BF THE CONSUMER STATED THE ACCELERATOR PEDAL WOULD STICK WHEN THE ENGINE WAS COLD AND IN COLD WEATHER. UPDATED 12/06/12
Steering, Oct 9, 2012
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THERE WAS AN OIL LEAK FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE HIGH POWER STEERING HOSE NEEDED TO BE REPLACED. THE CONTACT WAS UNABLE TO HAVE THE VEHICLE REPAIRED BECAUSE THE PARTS NEEDED TO COMPLETE THE REPAIR WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 90,000.