2006 Ford Escape
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 720 owner complaints filed for this model year. This is the 15th highest complaint count among 26 Escape model years with reports.
Of the 2006 reports, 23 involved a crash and 10 involved a fire. 30 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
EquipmentSep 3, 2010
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Campaign 10E043000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints: electrical system
79 reports, newest first. Show all
Electrical system, May 18, 2015
***DOOR AJAR/CAR ALARM/DOME LIGHT/ ISSUES*** 5/18/15 2006 FORD ESCAPE XLT 4WD 3.0L 6 CYLINDER HAS INTERMITTENT FALSE DOOR AJAR/CAR ALARM/DOME LIGHT ISSUES ALL THREE SYMPTOMS CAUSED BY FAULTY DOOR LATCH SENSORS. THE SUSPECT PART HAS A TEMPERATURE COEFFICIENT. THAT IS TO SAY WHEN YOU PARK YOUR CAR, AND GO INSIDE YOUR HOUSE, THE CAR ALARM WILL START GOING OFF IN NEIGHBORHOOD WAKING UP NEIGHBORS AND IS A HUGE ANNOYANCE TO QUIET NEIGHBORHOODS BECAUSE ALARM WILL FALSELY ACTIVATE WHEN THE TEMPERATURE VARIES. SOMETIMES WHEN OUTSIDE TEMPERATURES WARMS UP TO ABOUT 75-80 DEGREES OUTSIDE THE CAR ALARM SOUNDS TO INDICATE A FALSELY TRIPPED ALARM. IT SOMETIMES WILL OCCUR IN WINTER WEATHER CLIMATES ALSO. TEMPERATURE CHANGES PROVOKE THE FAULTY SYMPTOMS. FORD REFUSES TO ACKNOWLEDGE THE FORD ESCAPE AND MANY OF THEIR MODEL VEHICLES HAVE THIS PROBLEM. THE PROBLEM APPEARS TO BE CHEAP FLIMSY METAL ELECTRICAL CONTACTS WITHIN THE DOOR LATCH MECHANISM THAT OXIDIZE AND LOSE SPRING TENSION OVER TIME CAUSING THESE FALSE ALARMS. WITH EACH FALSE ACTIVATION, CAR ALARM WILL SOUND, DOOR AJAR LIGHT ACTIVATES (CAN'T TELL WHICH DOOR IS FAULTY) DOME LIGHT TURNS ON AND WILL STAY ON UNTIL IT RUNS DOWN YOUR BATTERY IN YOUR CAR AND THEN YOUR STRANDED BECAUSE YOUR CAR WON'T START BECAUSE FAULTY DOOR ELECTRICAL SWITCH BUILT INTO DOOR LATCH MECHANISM ACTIVATED YOUR DOME LIGHT WHICH DISCHARGES YOUR BATTERY CHARGE. IF YOUR IN A COLD WEATHER ENVIRONMENT AND THE BATTERY DIES BECAUSE OF THIS DEFECT IN ELECTRICAL SENSOR SWITCH, YOU CAN BECOME STRANDED BECAUSE YOU CAN NOT START YOUR CAR BECAUSE FORD REFUSES TO ADMIT THEIR IS A PROBLEM AND ISSUE A RECALL. [XXX] - SPRINGFIELD, IL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Electrical system, Equipment adaptive/mobility, Service brakes, May 8, 2015
WAS DRIVING TO WORK IN THE MORNING. HAD BEEN IN THE CAR APPROXIMATELY 10 MINUTES WHEN THE ABS, BRAKE, AND SERVICE BRAKES, INDICATORS CAME ON ALL AT ONCE. DEPRESSED BRAKE PEDAL ONLY TO DISCOVER THAT I DID IN FACT NOT HAVE ANY BRAKES. TURNED ON EMERGENCY FLASHERS AND BEGAN TO MERGE OVER INTO RIGHT HAND SHOULDER, REPEATEDLY STOMPING ON BRAKE PEDAL. WAS ABLE TO COME TO A STOP. THIS INCIDENT HAPPENED WHILE I WAS APPROACHING A VERY BUSY 3-WAY INTERSECTION, OFF OF A MAJOR HIGHWAY. TURNED CAR OFF AND BACK ON TO SEE IF THIS WAS A MALFUNCTION, BUT ALL THREE INDICATORS CAME ON AGAIN. HAD VEHICLE TOWED TO FORD DEALERSHIP. PAID $5280.03 IN PARTS AND LABOR TO HAVE FAULTY HYDRAULIC UNIT REPAIRED, AND HCU AND HYBRID SYSTEM BLEED. HAD NOT HAD ANY PROBLEMS WITH THIS VEHICLE IN THE PAST. VERY THANKFUL THAT THIS INCIDENT DID NOT CAUSE AN ACCIDENT OR INJURIES TO MYSELF OR OTHERS. ...UPDATED 04/11/17 *BF UPDATED 10/16/2017*CN
Electrical system, Apr 27, 2015
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE INTERIOR LIGHTS ILLUMINATED AND THE HORN ACTIVATED INDEPENDENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000. THE VIN WAS NOT AVAILABLE.
Electrical system, Mar 9, 2015
TL*THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM) AND STATED THAT THE PARTS WERE NOT AVAILABLE. THE DEALER DID NOT PROVIDE A SPECIFIC DATE FOR WHEN THE PARTS WOULD BECOME AVAILABLE TO SCHEDULE THE RECALL REPAIR. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE CONTACT CONTINUED TO EXPERIENCE THE FAILURE IN WHICH THE VEHICLE WAS EXTREMELY SLOW TO PICK UP SPEED UPON PRESSING THE ACCELERATION PEDAL. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.
Electrical system, Engine, Mar 8, 2015
I WAS DRIVING ON THE 495 BELTWAY (APPROX 55MPH) IN THE RIGHT LANE WHEN SUDDENLY MY CAR LOST POWER AND THE FAIL SAFE MESSAGE APPEARED SAYING STOP THE CAR IMMEDIATELY. FORTUNATELY, I WAS ABLE TO TAKE A NEARBY EXIT OFF THE BELTWAY WITHOUT INJURING MYSELF OR SOMEONE BEHIND ME AND CAUSING A MULTIPLE CAR COLLISION. A RED TRIANGLE ICON APPEARED ON THE DASHBOARD INCLUDING OTHER LIGHTS AND MESSAGES SINCE THE CAR HAD NO POWER. I DID HAVE THE CAR HEATER ON DUE TO WINTER TEMPERATURES. I IMMEDIATELY TURNED THE CAR OFF AND RESTED IT AND DID NOT PUT MY HEAT BACK ON SUSPECTING THE ELECTRONIC MOTOR COOLANT PUMP AS THE PROBLEM AFTER RECENTLY READING A NYT ARTICLE. THE CAR STARTED ABOUT 10 MINUTES LATER. I MADE AN APPT W MY FORD DEALER TO INSPECT THE CAR FOR THIS PROBLEM.I HAD A SIMILAR PROBLEM LAST SUMMER AND WAS TOLD BY FORD THAT MY VIN DIDN'T HAVE ANY RECALLS. I HAD THE A/C ON THAT DAY. UNFORTUNATELY, THE RECALL FOR THROTTLES ONLY APPLIES TO FORD NON-HYBRID CARS. THERE HAS ONLY BEEN A SERVICE BULLETIN TO FORD MECHANICS AND NO RECALL FOR THE ELECTRONICS MOTOR COOLANT PUMP. THIS INCIDENT SCARED ME AND I FEEL MY CAR IS UNSAFE TO DRIVE ESP ON INTERSTATE HIGHWAYS AT HIGH RATES OF SPEED UNTIL THIS PROBLEM IS RESOLVED. *TR
Electrical system, Jan 23, 2015
OUR FORD ESCAPE ENGINE STOPPED SUDDENLY ON THE HIGHWAY. WE BROUGHT IT TO CYPRESS COAST FORD LINCOLN IN SEASIDE CALIFORNIA. I HAD NOT RECEIVED A RECALL NOTICE FROM FORD ABOUT THE RECALL, BUT UPON RESEARCHING THE SYMPTOMS ONLINE, I FOUND OUT ABOUT THE RECALL AND INFORMED THE SERVICE ADVISOR AT CYPRESS FORD. THEY ADVISED ME THAT THE RECALL WAS NOT RELEVANT AND THAT THE CAR NEEDED $1700 IN VERY SIMILAR REPAIRS. I PAID WITH A CREDIT CARD AND THE WORK WAS COMPLETED. I PICKED UP THE CAR AND TRIED TO DRIVE IT HOME; THE SAME EXACT PROBLEM HAPPENED AGAIN, LATE AT NIGHT, ON THE HIGHWAY. I HAD THE CAR TOWED (AT MY EXPENSE) TO MY HOME AND THEN WAS ABLE TO GET IT TO MY LOCAL FORD DEALER. THEY RAN THE VIN AND SAID THE RECALL WAS PRESENT AND SHOULD BE FIXED. WHAT RECOURSE DO I HAVE TO GET A FULL REFUND AND PAYMENT FOR NEGLIGENCE FROM THE FORD AUTHORIZED DEALER/SERVICE CENTER THAT 1) DID NOT PROPERLY REPAIR MY CAR 2) IGNORED THE RECALL ON THE SPECIFIC PART OF THE CAR THAT I WAS COMPLAINING ABOUT AND THE RECALL I ALERTED THEM TO 3) PLACED ME IN DANGER THROUGH THEIR NEGLIGENCE BY SEND ME BACK TO THE HIGHWAY WITHOUT FIXING THE PROBLEM PLEASE ADVISE. *TR
Steering, Electrical system, Electronic stability control (ESC), Dec 24, 2014
THIS HAS HAPPENED 3 TIMES NOW, 2 IN SOUTHERN CALIFORNIA ON THE FREEWAY AT NIGHT. HYBRID VEHICLE HAS RECALL PROBLEMS WHICH MAKES VEHICLE STOP RUNNING. HAD IT FIXED, PAID OUT OF MY OWN POCKET IN SOUTHERN CALIFORNIA AND THOUGHT PROBLEM WAS FIXED. SOMETHING TO DO WITH BATTERY. THEN ON FRIDAY, DEC. 12, IT HAPPENED AGAIN AS I WAS DRIVING HOME FROM COLLEGE, THE VEHICLE STOPPED SUDDENLY. I COULDN'T PULL OVER, IT WON'T RESTART EVEN AFTER MANY ATTEMPTS. I WAITED 5 TO 25 MINUTES, VEHICLE WOULD NOT START. FINALLY HAD TO CALL A TOW TRUCK TO CLOSEST FORD DEALER. I THOUGHT DEALER COULD FIX PROBLEM AFTER HAVING IT ALL DAY BUT WHEN I LEFT AND HEADED ON HIGHWAY, MY HYBRID VEHICLE STALLED AGAIN ON THE HIGHWAY. I HAVE PTSD FROM THIS CAR, I NEVER WANT TO GET IN IT. I DON'T TRUST IT AND AFTER 3 DIFFERENT FORD DEALERS, ALL OF MY OWN MONEY TO PAY, CAR STILL DOESN'T WORK PROPERLY. I PAID A PREMIUM TO PURCHASE THIS VEHICLE AND IT IS WORTHLESS. NOW I AM RECEIVING MORE RECALL NOTICES ABOUT THE AIRBAGS. I AM AFRAID TO DRIVE MY VEHICLE BECAUSE IF IT STALLS AGAIN I MIGHT BE IN A HORRIFIC ACCIDENT AS IT STOPS SUDDENLY WITH NO WARNING WHATSOEVER. *TR
Electrical system, Engine, Dec 15, 2014
ON COLD MORNING, CAR STARTED DROVE DOWN THE ROAD ABOUT 5 MILES AND THE CAR JUST DIED, SAYING "BRAKE SAFELY NOW." SEEMS TO HAPPEN ONLY ON COLD DAYS WHEN HEATER IS ON. IT WILL NOT START AGAIN FOR 30 MINUTES. IT WILL START, BUT WILL CONTINUOUSLY DIE. WE HAD CALLED FORD IN MIDDLESBORO, KY AND SPOKEN WITH FRANK WHO SAID OUR VEHICLE DID NOT HAVE ANY RECALLS. I THEN FOUND OUT IT HAD A RECALL. I TOOK IT IN OVER THE WEEKEND AND HE THEN CLAIMED ON MONDAY THAT THE RECALL ITEM HAD BEEN FIXED. HOWEVER, WHEN I CHECKED THE WEBSITE, IT CONFIRMED THE PROBLEM HAD NOT BEEN FIXED. THIS HAS BEEN GOING ON FOR ABOUT A MONTH NOW. WE HAVE HAD THE OIL CHANGED, BATTERY REPLACED AND IT CHECKED BY FORD OF MORRISTOWN, TN. THEY CLAIM THEY CAN'T FIND OUT WHATS WRONG WITH IT. WE HAVE READ OTHER PEOPLE'S SIMILAR COMPLAINTS WHO SAID IT WAS EITHER THE "ELECTRIC MOTOR WATER PUMP" OR COOLANT PUMP. *TR
Power train, Electrical system, Engine, Jul 10, 2014
WE PURCHASED THIS FORD ESCAPE HYBRID IN AUGUST, 2012, AFTER PROCURING A PRE-SALE EVALUATION AT FORD DEALER 1, INCLUDING A FULL VIN SEARCH FOR ANY INCOMPLETE RECALLS.THE EVALUATION FOUND NOTHING INCOMPLETE.RETURNING HOME 6.11.14, ON OUR RESIDENTIAL STREET, THE ESCAPE WITHOUT PRIOR WARNING FLASHED 'STOP VEHICLE SAFELY' AND SIMULTANEOUSLY TURNED OFF ALL POWER. RESEARCH INDICATED A FAILED OEM MECS COOLANT PUMP (TSB 08-24-5), AND WE HAD ISSUES GETTING THE CORRECT PART FROM FORD DEALER 1 AND SOURCED A DORMAN PART FROM THE LOCAL X AUTO PARTS STORE, SUPPLYING IT TO AN ASE-CERTIFIED SHOP FOR INSTALLATION (VEHICLE INOPERABLE/ON A LIFT). ANOTHER 'STOP VEHICLE SAFELY' EVENT OCCURRED 6.24.14 WITH MY FAMILY IN THE VEHICLE ON AN EXPRESSWAY ENTRANCE RAMP, WITH THE ESCAPE TAKEN TO FORD DEALER 2 FOR EVALUATION. FORD DEALER 2'S VIN CHECK FOUND CSP 07B48 AND TSB 09-18-6, NOT AVAILABLE PREVIOUSLY. FORD DEALER 2 MADE REPAIRS CONSISTENT WITH THE CSP/TSB ON 7.12.14 AT OUR EXPENSE. THESE SERIOUS SAFETY IMPLICATIONS WELL-KNOWN TO FORD (BOTH CSP 07B48/TSB 09-18-6 AND TSB 08-24-5) WERE NOT IDENTIFIED BY FORD DEALER 1 IN OUR PRE-PURCHASE INSPECTION, OR BY FORD IN A PRIOR INVESTIGATION AND REPAIR OF THE CORROSION ISSUES IN THIS ESCAPE. WE ARE CONCERNED THAT KNOWN/IDENTIFIED SAFETY ISSUES GENERATING AN ERRANT BCM SIGNAL DISABLING THE CAR MADE THIS PARTICULAR ESCAPE A TICKING TIME BOMB. WE COULD NOT HAVE BEEN AWARE OF THE ISSUES DESPITE OUR DILIGENCE, BUT FORD HAD DIRECT ACCESS TO THAT INFORMATION.WE WERE FORTUNATE WHEN/WHERE OUR FAILURES OCCURRED. FOR ANYONE ELSE IN A SIMILAR ESCAPE WITH THE CSP 07B48/TSB 09-18-6 AND TSB 08-24-5 REPAIRS NOT ALREADY ACCOMPLISHED, THE NHTSA SHOULD COMPEL A LONG-OVERDUE RECALL FOR THE AFFECTED VEHICLES. *TR
Electrical system, Engine, Jun 28, 2014
WHILE GOING ABOUT 73MPH IN PASSING LANE-HEARD "BEEP" DASHBOARD HAD RED TRIANGLE LITE UP AND A MESSAGE TO STOP SAFELY NOW--THEN CAR JUST STOPPED!! I WAS IN THE FAR LEFT LANE--PULLED OFF INTO MEDIAN--READ MANUAL--STARTED CAR UP AND WENT--ON RETURN TRIP SAME THING--ALTHOUGH NOW I WAS ALWAYS LOOKING FOR MY "EXIT"--ALTHOUGH WAS PANICKING GOING THRU TUNNEL IN BOSTON. FORD HAD RECALL ON THIS SYSTEM THAT ENDED IN 2009--I BOUGHT THIS IN 2012. BROUGHT TO FORD DEALER--THEY SAID THERE WAS NO RECALL AND FOR A STARTING FEE OF $120/HR THEY COULD TAKE A LOOK. I CALLED FORD IN MI-TOLD TOO LATE--TOO BAD..SO NOW I HAVE PRINTED OUT RECALL AND WILL BRING TO A DIFFERENT DEALER ON MONDAY. SAW THAT THIS IS AN ONGOING SAFETY ISSUE THAT FORD WILL NOT TAKE OWNERSHIP OF. *TR
Electrical system, Vehicle speed control, Engine, Jun 27, 2014
WE WERE DRIVING EAST ON I-26 IN SOUTH CAROLINA AT 65 MPH IN 3 LANES OF TRAFFIC WHEN THE TRIANGLE HAZARD WARNING LIGHT ON THE DASH SOUNDED AND LIT UP SAYING "PULL OVER SAFELY NOW". AT THE SAME TIME , WITH THE GAS PEDDLE FLOORED, THE SPEED OF THE CAR WAS SLOWING BY THE SECOND! THE GAS PEDDLE DID NOT WORK. WE WERE ABLE TO PULL OVER AND TURN THE CAR OFF WITHOUT GETTING HIT BY ONCOMING TRAFFIC. PER THE MANUAL, WE WAITED AWHILE AND RESTARTED THE CAR, AND WERE ABLE TO GET IT HOME. I CALLED THE FORD CUSTOMER CARE LINE TO ASK IF IT WAS SAFE TO DRIVE THE CAR AND WOULD THIS HAPPEN AGAIN. THEY WERE NOT HELPFUL AT ALL. THEY BASICALLY TOLD ME TO TAKE IT TO A DEALERSHIP. OUR LOCAL DEALERSHIP SAID THEY KNEW NOTHING ABOUT THE ISSUE I DESCRIBED, BUT DIAGNOSED THE PROBLEM AS BEING AN MECS PUMP FAILURE FOR $135. THE REPLACEMENT COST WOULD BE $800. DUE TO THE HIGH COST QUOTE AND KNOWING THAT IT ONLY TAKES 45 MINUTES OR LESS TO CHANGE THIS PUMP, WE TOOK IT ELSEWHERE. THE PART IS $277. OUR CONCERN IS THAT HOW COULD FORD DEALERS NOT KNOW ABOUT THIS DANGEROUS DEFECT, WHEN IN 3 SECONDS YOU CAN PULL UP HUNDREDS OF WEBSITES COVERING THIS FAILURE, AND THE DANGEROUS AND POTENTIALLY FATAL ACCIDENT IT COULD CAUSE. NOW I HAVE FOUND THIS US DOT WEBSITE WHICH HAS HUNDREDS OF COMPLAINTS ON THIS ISSUE ALSO,I AM HOPING MORE PEOPLE WILL COME FORWARD TO GET THESE CARS OFF THE ROAD. *TR
Electrical system, Jun 5, 2014
PULLING INTO A PARKING LOT WITH MY 2 YEAR OLD GRANDDAUGHTER AND DAUGHTER WHEN MY CAR STALLED. THINKING QUICK, I PUT THE CAR INTO NEUTRAL SO I COULD STEER AND RESTART.MY CAR HAS BEEN IN THE GARAGE 4 TIMES AND A $1000.00 OF WORK PUT INTO IT TO TRY AND FIX THE PROBLEM, TO THIS DAY IT STILL STALLS!!!!!! NO ONE KNOWS WHAT'S WRONG WITH IT!!!!! *TR
Electrical system, Engine, May 15, 2014
ERROR CODE IS "STOP SAFELY NOW". I WAS DRIVING, AND ALL IN THE SUDDEN - AN ERROR MESSAGE CAME UP ON DASH DISPLAY "STOP SAFELY NOW". IMMEDIATELY, THE CAR WAS TOTALLY SHUT DOWN RIGHT AFTER, LOST THE ABILITY TO STOP, AND I HAVE NO CONTROLS OF ANY THING. I WAS LUCKY THAT I'M IN A MIDDLE OF A PARKING LOT. I ALMOST GOT HIT WITH THE CAR DROVE RIGHT BEHIND ME. WHAT IF THIS INCIDENT OCCURS ON A FREEWAY AT A HIGH SPEED. MY CAR IS FULLY WELL MAINTENANCE WITH SUCH LOW MILES FOR 2006. *TR
Electrical system, May 14, 2014
WHILE DRIVING ON THE FREEWAY MY CAR LOST ALL POWER AND SAID STOP SAFELY NOW. I PULLED TO THE SIDE OF THE ROAD AND 10 MINUTES LATER THE CAR STARTED UP AND I WAS ABLE TO DRIVE HOME. THE CAR DID NOT DO THIS AGAIN FOR OVER A YEAR. AT THAT TIME I WAS DRIVING IN TUCSON AZ AND IT LOST ALL POWER IN THE MIDDLE OF AN INTERSECTION.FORTUNATLY IT STARTED RIGHT AWAY AND I WAS ABLE TO GET TO A PARKING LOT.AFTER A LOT OF RESEARCH WE REPLACED THE ELECTRIC COOLING MOTOR ONLY TO HAVE IT CONTINUE TO SHUT DOWN WITH THE STOP SAFELY NOW DISPLAYED. AFTER MORE RESEARCH WE REPLACED THE BLEND DOOR ACTUATOR WITH NO RESULTS. FORD REALLY NEEDS TO DO A RECALL AND FIX THIS PROBLEM BEFORE PEOPLE DIE. THE CAR SHUTS DOWN WITH NO WARNING AND IT HAPPENS SO FAST. IF THERE IS NO WHERE TO PULL OVER YOU ARE STUCK IN THE ROAD AND A TARGET FOR OTHER VEHICLES TO RUN INTO. *TR
Electrical system, Engine, May 8, 2014
TIME OF DAY: 1800, TEMPERATURE ABOUT 80F. "STOP SAFELY NOW" MESSAGE APPEARED ON CONSOLE. VEHICLE SLOWED DOWN WHILE TRAVELING AT 65MPH ON AN INTERSTATE HIGHWAY DURING A HEAVY RUSH HOUR TRAFFIC. FORTUNATELY, I WAS TRAVELING ON THE LEFT LANE AND SAFELY MOVED TO THE LEFT CURB AND WITHIN SECONDS THE ENGINE DIED. I KEPT TRYING TO START BUT NO SUCCESS. WHILE ON THE PHONE WITH THE INSURANCE COMPANY FOR A TOW TRUCK, I TRIED AGAIN, AND THE ENGINE RESTARTED. I WAS ABLE TO CONTINUE DRIVING HOME FOR ABOUT 25 MINUTES, APPROXIMATELY 15 MILES. WHILE APPROACHING A TRAFFIC LIGHT, THE "STOP SAFELY NOW" MESSAGE APPEARED AND THIS TIME THE CAR DIED IN THE MIDDLE OF THE STREET. THIS TIME, IT DIED WITHIN 3 SECONDS AFTER THE MESSAGE APPEARED. IT WAS A MAJOR SAFETY HAZARD WHEN OTHER CARS WERE APPROACHING AND WITH VERY LITTLE ROOM TO STOP AND REACT. THIS WAS IN A 35 MPH RESIDENTIAL ZONE. I HAD TO CALL A LOCAL POLICE DEPARTMENT TO ASSIST MANAGING THE TRAFFIC. AFTER ABOUT 15 MINUTES, I WAS ABLE TO START THE CAR AGAIN AND CONTINUED THE LAST 2 BLOCKS TO MY RESIDENT. THIS IS A SERIOUS SAFETY ISSUE THAT COULD HAVE RESULTED IN MULTI CARS ACCIDENT HAD I NOT HAD THE OPPORTUNITY TO DRIVE TO THE CURB BEFORE IT STOPPED. *TR
Electrical system, Vehicle speed control, Feb 14, 2014
AFTER STARTING THE VEHICLE IT HAS TO BE WARMER UP FOR ABOUT 30 MINUTES OR MORE, IN ORDER FOR THE GAS PEDAL TO PRESS DOWN SO THE VEHICLE WILL MOVE. THE GAS PEDAL WILL NOT MOVE AT ALL. IT HAS TO BE WARMED UP IN THE SUMMER MONTHS AND WELL AS THE WINTER MONTHS IN ORDER FOR THE VEHICLE TO MOVE. THE GAS PEDAL IS SO HARD TO PRESS THAT IT LIKE TRYING TO PRESS YOUR FOOT THROUGH A BRICK WALL. IT DOES THIS EVEN WHEN AT A STAND STILL WHEN TRYING TO ACCELERATOR FOR ANY SPEED. IT JUST WILL NOT MOVE. THIS IS DANGEROUS FOR ME AND MY FAMILY. PLEASE HELP !!! *TR
Fuel system, Gasoline, Power train, Electrical system, Engine, Nov 1, 2013
THE FIRST INCIDENT OCCURRED WHILE I WAS DRIVING 65 MPH ON THE EXPRESSWAY. I WENT TO CHANGE LANES AND HIT THE ACCELERATOR AND THE CAR WOULD NOT ACCELERATE AND WAS SHUDDERING. I HAD PULL OFF THE EXPRESSWAY AND TURN THE CAR OFF. I TRIED RESTARTING AND IT JUST SHUDDERED AGAIN. I WAITED FIVE MINUTES AND TRIED AGAIN AND FINALLY IT STARTED AND WAS ABLE TO SHIFT. TWO DAYS AGO I WAS GETTING OFF THE EXPRESSWAY AND MAKING A LEFT TURN WHEN THE CAR DIED AND I LOST STEERING POWER. I WAS ABLE TO FORTUNATELY GET TO THE SIDE OF THE ROAD AND PUT IT INTO PARK. I TRIED RESTARTING THE CAR AND IT WOULD NOT START. I WAITED 3 MINS AND WAS ABLE TO FINALLY GET IT GOING. BOTH TIMES THERE WAS NO CHECK ENGINE LIGHT. I HAD THE ESCAPE READ BY A CODE READER DEVICE MULTIPLE TIMES AND THERE ARE NO ERROR CODES DISPLAYED FROM THE COMPUTER. THIS IS A VERY SERIOUS AND POTENTIALLY LIFE THREATENING ISSUE, AND WOULD LIKE FORD TO ACT UPON IT FOR ITS CUSTOMERS IMMEDIATELY. I AM FILING THIS BECAUSE I HAVE READ THAT THE ISSUE IS WITH A DEFECTIVE THROTTLE BODY, AND THERE IS ALREADY AN INVESTIGATION INTO FORD ON THIS ISSUE (PE13-003). I WOULD LIKE MY VEHICLE TO BE ADDED TO THIS INVESTIGATION FOR MY FAMILIES SAFETY AND ALL OTHERS EXPERIENCING THE PROBLEM. *TR
Steering, Electrical system, Oct 3, 2013
ELECTRIC ASSISTED POWER STEERING NOT FUNCTIONAL. DEALER TROUBLESHOOTING CONSISTED OF READING CODES, THEN INDICATING THAT THE ENTIRE RACK AND PINION ASSEMBLY NEEDED REPLACED ($2200). REPLACED THE ASSEMBLY, STILL DOESN'T WORK. THE ELECTRONIC STEERING CONTROL MODULE WAS REPLACED, STILL DOESN'T WORK. THE REPAIR SHOPS AND THE DEALERS HAVE INADEQUATE INFORMATION AND TRAINING TO REPAIR THESE ELECTRIC STEERING SYSTEMS. THERE SHOULD BE ADEQUATE INFORMATION AND TRAINING TO IDENTIFY THE FAILED COMPONENT, AS OPPOSED TO SWAPPING OUT LARGE ASSEMBLIES, AND STILL NOT FIXING THE PROBLEM. THESE SYSTEMS APPEAR TO HAVE A HIGH FAILURE RATE, AND PRESENT A HUGE SAFETY ISSUE WHEN THEY FAIL WHILE DRIVING! PLEASE ISSUE A RECALL ASAP! *TR
Electrical system, Vehicle speed control, Engine, Oct 3, 2013
PROBLEMS WITH GAS PEDAL STICKING/ LOCKING UP. WHILE DRIVING AND SOMETIMES WHEN IDLE DASH LIGHTS, A/C AND RADIO TURN ON AND OFF, THEN THERE WAS A CLICKING SOUND BEFORE THE ACTUAL ENGINE SHUTS OFF. *TR
Electrical system, Engine, Aug 10, 2013
WHILE DRIVING ON I-195 EAST GOING TOWARDS BWI THE ENGINE JUST CUT OFF FOR NO REASON OR WARNING THEN A RED TRAINGLE APPEARED STOP SAFELY I WAS ABLE TO PULL OVER SAFELY WAS ALMOST REAR ENDED BY A TRACTOR TRAILER THE CAR WOULD NOT TURN BACK ON FOR ABOUT 5 MIN AFTER IT STARTED I HAD NO POWER WHAT SO EVER WHEN ABOUT 2 MILES AT 30 MILES PER HOUR AND IT DID IT AGAIN MANAGED TO GET IT HOME BASED ON WHAT I HAVE BEEN READING WHY HAS FORD NOT RECALLED THIS ISSUES OR ARE THEY WAITING FOR SOME ONE TO GET KILLED THERE NEEDS TO BE A RECALL BEFORE SOMEONE GETS HURT. I AM LOOKING INTO GETTING A LAWYER IF FORD DOES NOT WANT TO FIX IT. *TR
Electrical system, Jun 25, 2013
TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE SERVICE SOON LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE JUMPER HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 36,000. UPDATED 8/13/13 *CN
Steering, Electrical system, Visibility, Mar 26, 2013
1) WE HAVE BEEN RECEIVING A YELLOW WRENCH LIGHT INDICATING MAINTENANCE NEEDED OFF AND ON FOR A COUPLE OF WEEKS EVEN THOUGH WE WERE WELL WITHIN THE MAINTENANCE PERIOD. THIS TURNS OUT TO BE AN ISSUE WITH THE BLEND DOOR FOR ALLOWING AIR COOLING OF THE HYBRID BATTERIES. 2) THE POWER STEERING WENT OUT COMPLETELY FOR THE CAR. WE HAVE HAD NO PRIOR PROBLEMS WITH THE STEERING, AND THE SYSTEM CHECK SHOWED NO PROBLEM (I BELIEVE IT CHECKS FLUID LEVELS) SO THE PROBLEM APPEARED TO BE ELECTRICAL. *TR
Electrical system, Vehicle speed control, Mar 8, 2013
ON FEB 14TH, 2013, ON MY WAY TO WORK, MY CAR RADIO WENT COMPLETE DEAD...THEN AS I WAS APPROACHING AN INTERSECTION, MY CAR 'SURGED' LIKE IT WAS GOING "ON & OFF". I PRAYED TO GET TO GET OUT OF HARMS WAY ENOUGH TO PULL MY CAR OVER, AS SOON AS I DID, ALL THE LIGHTS STARTED FLASHING AND THERE WAS A CONSTANT 'CLICKING SOUND'. I CALLED A TOWN TRUCK AND HAD MY CAR TOWED TO MY CAR REPAIR PLACE. TURNS OUT I NEEDED AN NEW ALTERNATOR. AFTER SPENDING $550 + TO HAVE IT FIXED, THE FOLLOWING WEEK, ON TUESDAY, FEB 19TH, MY CAR DIED. AGAIN, HAVING IT TOWED TO MY CAR REPAIR AGAIN, IT TURNS OUT THAT THE ELECTRICAL SYSTEM NEEDED REPLACING. I ONLY HAVE 67K ON MY CAR AND AFTER SPENDING ANOTHER $600 TO FIX, I AM NOT A HAPPY CONSUMER! FORD SHOULD REIMBURSE ME FOR THESE COSTS. NOW, MY CAR IS FIXED AND AS MUCH AS I LOVED IT, I AM NOT CONFIDENT DRIVING IT ANYMORE. UNLESS FORD REIMBURSES ME, I WILL NEVER BUY ANOTHER ESCAPE AGAIN, NOR WILL I TELL EVERYONE ABOUT HOW WONDERFUL OF A VEHICLE THEY ARE BECAUSE THEY AREN'T AND WHEN YOU SPEND THAT MUCH MONEY ON A CAR...WELL, WHEN SOMETHING COSTLY HAPPENS LIKE THAT, THE VEHICLE SHOULD BE REPLACED BY FORD WITH NO COST TO THE CONSUMER. AN EXTRA $1200 OUT OF MY POCKET MEANS MY FAMILY HAS TO GO WITHOUT FOOD. *TR
Electrical system, Engine, Nov 15, 2012
WIFE WAS DRIVING HER 2003 FORD ESCAPE 2.3L XLS (FWD, 5-SPD MANUAL) AT 65MPH, PRACTICALLY COASTING DOWN A HILL. 26 MINUTES AFTER ENGINE START SHE HEARD A LOUD BANG AND SUBSEQUENT POPPING SOUNDS. THIS WAS FOLLOWED IMMEDIATELY BY SEVERE POWER LOSS FROM THE ENGINE. SHE DROVE IT TO THE NEXT BEST OFF-RAMP, AN ADDITIONAL 2 MILES. WHEN SHE GOT OFF THE FREEWAY SHE SAYS SHE HAD TO REV IT UP QUITE A BIT TO MAKE AN INTERSECTION TO GET TO THE GAS STATION WHERE THE CAR ROLLED TO A STOP. THAT LOUD BANG TURNED UP TO BE THE NBR 3 CYLINDER BLOWING ITS SPARK PLUG CLEAN OFF THE SPARK PLUG BORE. THE SPARK PLUG BORE WAS COMPLETELY THREADLESS. THE SUBSEQUENT POPPING SOUNDS WERE DUE TO THE SPARK PLUG NOT BEING ON THE NBR 3 CYLINDER AS THE FUEL THAT CONTINUED TO SPRAY INTO THE CYLINDER WAS BURNING OFF. THE IMMEDIATE POWER LOSS IS A DIRECT RESULT OF THE ENGINE LOOSING 25% OF ITS CHUGGA-CHUGGA AND THE LOSS OF THE CHT SENSOR SIGNAL WHICH BOTH THEN CAUSED THE PCM (POWERTRAIN CONTROL MODULE) TO GO INTO LIMP MODE AND FURTHER REDUCE ENGINE POWER. FIRST THING I DID WAS PLUG IN MY OBDII SCANNER AND CHECK FOR CODES. I FOUND THE FOLLOWING THREE: P0303 - CYLINDER 3 THREE MISFIRE. P0353 - IGNITION COIL 'C' PRIMARY/SECONDARY CIRCUIT. P1289 - CYLINDER HEAD TEMP SENSOR HIGH INPUT. I THEN PERFORMED A KOEO (KEY-ON/ENGINE-OFF) CHECK WITH MY OBDII SCANNER AND FOUND THE FOLLOWING TWO CODES: P0119 - ENGINE COOLANT TEMPERATURE CIRCUIT INTERMITTENT/ERRATIC. P1289 - CYLINDER HEAD TEMP SENSOR HIGH INPUT. THE CHT PROBE (CYLINDER HEAD TEMPERATURE) COVER/BOOT WAS POPPED OFF THE ENGINE CAMSHAFT COVER AND THE WIRES WERE BROKEN OFF THE CHT PROBE ELECTRICAL CONNECTOR. THE SPARK PLUG TERMINAL BROKE OFF. THE IGNITION COIL PACK WAS SEVERELY DAMAGED (LOOKED LIKE AN EXPLODED CIGAR, CARTOON STYLE). *TR
Electrical system, Vehicle speed control, Engine, Sep 11, 2012
DRIVING ON THE INTERSTATE AND THE CAR SHUTS DOWN DISPLAYING A STOP SAFELY NOW ERROR.... APPARENTLY A FAULTY PUMP. THE SAME PUMP THAT WE'VE ALREADY REPLACED 3 TIMES..... NOT ONLY IS THIS ANNOYING BUT IT'S A HUGE SAFETY PROBLEM. THE VEHICLE LOSES ALL POWER! *TR