2006 Ford Escape
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 720 owner complaints filed for this model year. This is the 15th highest complaint count among 26 Escape model years with reports.
Of the 2006 reports, 23 involved a crash and 10 involved a fire. 30 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
EquipmentSep 3, 2010
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Campaign 10E043000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints: engine
127 reports, newest first. Show all
Electrical system, Engine, Fuel/propulsion system, Dec 26, 2015
ON SEVERAL OCCASIONS AFTER GETTING OFF THE HIGHWAY ONTO AN EXIT RAMP MY VEHICLE HAS DIED WITH NO CHECK ENGINE LIGHTS, IT ALSO SHUTS DOWN WHEN MAKING A HARD TURN AT SLOWER SPEEDS. I HAVE HAD ISSUES WITH THE ACCELERATOR STICKING WHEN IT IS COLD OUTSIDE (SEVERAL TIMES HAVING TO MANUALLY SHUT OFF ENGINE AND COAST TO A STOP IN SNOW). I HAVE CURRENTLY STARTED EXPERIENCING A #3 MISFIRE AND AM CURRENTLY WAITING FOR PARTS TO COME. I HAVE ALREADY REPLACED ALL SPARK PLUGS AND NUMBER 3 IGNITION COIL. I AM WAITING FOR OTHER 3 COILS TO COME IN. IF STILL SHOOTING WILL TRY REPLACING SEALS. IT ALSO WAS "BURNING" OIL THEN STARTED TO HAVE AN ACTUAL OIL LEAK FROM MAIN SEAL. I DO THE REPAIRS MYSELF AND APPARENTLY THESE ARE KNOWN ISSUES. I COMPLAINED TO FORD ABOUT THE STICKY ACCELERATOR AND GOT NO REPLY. IT ALSO MAKES A TAPPING SOUND FROM THE CAM SHAFT WHICH I FOUND OUT IS TYPICAL OF FORD ESCAPES.
Power train, Other or unspecified, Engine, Dec 8, 2015
DRIVING DOWN THE FREEWAY AND MY VEHICLE SHUTS OFF WITHOUT WARNING. THERE IS A LOUD KNOCKING AND SHUTTERING NOISE LIKE MY WHOLE ENGINE IS GOING TO DROP ONTO THE FREEWAY. I GET TO THE SHOULDER AND PUT IT IN PARK. AS I TRY TO START THE VEHICLE AGAIN THE ENGINE/MOTOR STARTS SHAKING YET AGAIN WITH A LOUD KNOCKING NOISE AND WONT TURN OVER. I HAD TO GET MY CAR TOWED. MY CHILDREN WERE EXTREMELY SCARED AND BEING ON THE FREEWAY THIS ISSUE IS VERY DANGEROUS AND HAS BEEN COMPLAINED ABOUT MULTIPLE TIMES.
Power train, Air bags, Engine, Oct 21, 2015
I BOUGHT THE VEHICLE ON SEPTEMBER 4,2015 ALL THESE PROBLEM STARTED 1 MONTH AFTER. MANUEL TRANSMISSION GETS TO ROUGH AT TIMES WHEN BEING SHIFTED INTO 1ST GEAR AND REVERSE GETS STUCK AND HARD TO SHIFT, MIGHT BE PART OF THE RECALL NO# 15S28 THE ENGINE OIL SEEMS TO USE 1QT A WEEK, RECENTLY HAD A CHANGED OIL BUT CONTINUES TO USE THE SAME EVERY WEEK, MILEAGE IS AT 132467. THE AIR BAG FOR PASSENGER LIGHT CONTINUES TO LIGHT UP AND GOES OFF WHEN DRIVEN. A BANGING NOISE WHEN DRIVEN ON THE ROAD AT REAR SHOCK ABSORBERS ARE LOCATED, THE SHOCKS ARE STILL NEW.
Engine, Oct 11, 2015
I PURCHASED MY 06 FORD ESCAPE IN JANUARY OF THIS YEAR. IT HAS 92,000 MILES ON IT. I TEST DROVE THE CAR AND HAD IT INSPECTED BY A MECHANIC AFTER PURCHASE TO MAKE SURE THAT THERE WASNT AN ISSUE THE DEALER " FORGOT " TO MENTION, ABOUT 3 WEEKS AFTER PURCHASE MY OIL LIGHT CAME ON. I ADDED OIL BUT DID NOT GET AN OIL CHANGE BECAUSE I WASN'T DUE ONE FOR 1400 MILES. AFTER THAT THE CAR WAS FINE.... FOR ABOUT A WEEK WHEN THE OIL LIGHT CAME ON AGAIN, IN THE MEAN TIME I WAS DILIGENT ABOUT CHECKING THE OIL AND ALSO INSPECTING BENEATH THE VEHICLE TO MAKE SURE THERE WAS NO OIL ON THE GROUND. THERE WASN'T. THE OIL LIGHT STOPPED COMING ON BUT I CONFINED TO CHECK THE OIL DAILY. AND I'M GLAD I DID BECAUSE , THE OIL IN MY CAR CONTINUED TO DISAPPEAR. I HAVE NOW HAD THE CAR 9 MONTHS AND THE PROBLEM HAS PROGRESSIVELY GOTTEN WORSE. THE CAR BARELY DRIVES NOW AND THE CHECK ENGINE LIGHT IS INDICATING A CYLINDER IS MISFIRING. I'M GOING THEY A QT OF OIL A DAY AND DRIVING ONLY 30 MILES ROUND TRIP TO WORK AND BACK .I'VE RESEARCHED THIS ISSUE AND I KNOW THAT THIS IS A CONSISTENT AND ONGOING PROBLEM WITH THIS VEHICLE. FORD HAS LEFT ME WITH 4,000 DOLLARS LEFT OF A LOAN, NO WAY FOR MY HUSBAND AND I TO GET TO WORK OR BRING OUR CHILDREN TO SCHOOL AND WITH XMAS COMING, NOT ONE EXTRA DIME TO PUT TOWARDS A NEW VEHICLE. I KNOW FORD HAS BEEN INFORMED OF THESE PROBLEMS. WHAT WILL IT TAKE FOR THEM TO ISSUE A RECALL? WHEN THE 06 ESCAPES ENGINE FAILS ON A BUSY HIGH WAY AND GOD FORBID PEOPLE ARE HURT ? OR WORSE? AND FORD CAN'T SAY THEY WEREN'T WELL AWARE OF THE PROBLEM BECAUSE THEY HAD IT WITH THE 05 ESCAPE TOO AND STILL USED THE SAME ENGINE IN THE 06. NOW I'M PAST THE LEMON LAW TIME FRAME AND I HAVE NO OPTIONS BUT TO PAY FOR A 6500 DOLLAR LAWN ORNAMENT.
Engine, Jul 16, 2015
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 50 MPH, A WARNING INDICATOR TO SHUT THE VEHICLE DOWN ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Steering, Service brakes, Engine, Jun 9, 2015
AFTER TRAVELING FOR APPROXIMATELY 1 MILE AT 35 MPH, THE ENGINE SUDDENLY SHUT OFF. UPON SAFELY STOPPING THE VEHICLE IN A PARKING LOT. THE ENGINE RE-STARTED WITH NO ISSUES. DROVE THE VEHICLE FOR APPROXIMATELY ANOTHER MILE AT 35 MPH WHEN IT SHUT OFF AGAIN. RE-STARTED WITH NO ISSUES. HAVE NOT DRIVEN THE VEHICLE SINCE THEN. NO FAULT CODES WERE GENERATED & NO APPARENT PROBLEMS HAVE BEEN DETECTED.
Air bags, Engine, May 6, 2015
I OWN A 2006 FORD ESCAPE XLT WITH 100,000 MILES. 90% HIGHWAY MILES, WELL MAINTAINED WITH DEALER OR INDEPENDENT MECHANIC. HAVE ALL PAPER WORK. "MY BIGGEST WORRY IS THE STALLING FOR NO REASON AND AN ACCIDENT HAPPENING AND THIS SHOULD BE A RECALL ISSUE". JAN. 2015 I HAD A INTAKE AND VALVE OIL LEAK THAT WAS FIXED 3 TIMES, JAN, FEB AND MARCH. WHEN I TOOK IT TO THE DEALER IN MARCH, I MENTIONED THAT MY VEHICLE HAD STALLED IN MY DRIVEWAY AFTER A 30 MINUTE HIGHWAY DRIVE FROM WORK. THEY PUT IT ON THE COMPUTER AND SAID THERE WAS NO CODE FOR A STALL. DEALER SAID FORD SENT THEM NOTICE DESCRIBING MY SAME ISSUE BUT COULDN'T CONFIRM IT WAS THE TORQUE CONVERTER. APRIL 10TH 2015 I WAS OUT OF EXTENDED WARRANTY. THE STALLING HAPPENED AGAIN LATE APRIL, TOOK TO DEALER AGAIN. DEALER SAID NO CODES AGAIN. TOOK STRAIGHT TO UNCLE AFTER LEAVING DEALER FOR HIM TO LOOK AT AND COULDN'T GET THE VEHICLE TO STALL AFTER A WEEK OF HAVING IT. I'VE READ ONLINE FORUMS OF PEOPLE REPLACING TRANSMISSION MULTIPLE TIMES FOR TORQUE CONVERTER AND OTHER ISSUES WITHIN THE TRANSMISSION. ALSO, AFTER 3 DEER RAN OUT IN FRONT OF ME 2 YEARS AGO, REPAIRS DONE TO PHYSICAL DAMAGE AND PASSENGER SEATBELT REPLACED TWICE DURING REPAIRS, PASSENGER SEATBELT AND AIRBAG LIGHTS COME ON AND SEATBELT ALERT BEEPS WHILE DRIVING EVEN KNOW THE PASSENGER HAS THE SEATBELT ON. I HAVE TO PARK, SHUT DOWN, BUCKLE SEATBELT AND THEN START AGAIN AND THIS WORKED EXCEPT FOR ONE TIME I HAD TO REPEAT THIS A SECOND TIME. DEALER SAID THERE WAS NO CODES FOR AIRBAGS OR SEAT BELTS. FORD HAS NOT BEEN NOTIFIED YET. ALSO, WHEN I BOUGHT THE VEHICLE BRAND NEW I HAD THE UNDERBODY SPRAYED BUT THE REAR WHEEL WELLS ARE RUSTING FROM UNDERNEATH TO OUTER BODY AND RUSTING UNDER FRONT DOORS TOO. *TR
Engine, Mar 22, 2015
AS I WAS TRAVELING ACROSS INTERSTATE 86 IN NEW YORK STATE, AT 65 MILES PER HOUR, MY FORD ESCAPE COMPLETELY LOST POWER. FORTUNATELY FOR ME I WAS RIGHT NEXT TO AN OFF RAMP AND A CONVENIENT MARKET. WHEN I CHECKED THE ENGINE FOR SIGNS OF WHAT COULD HAVE GONE WRONG I FOUND THAT MY ENGINE WAS COMPLETELY OUT OF OIL. I MAINTAIN MY OWN VEHICLES DUE TO THE COSTS OF THE REPAIR SHOPS AND CHECK MY VEHICLES FLUIDS REGULARLY. THERE WERE NO SIGNS OF OIL LOSS WHERE I HAD BEEN PARKING MY VEHICLE AS WELL. WHEN I HAD THE VEHICLE CHECKED AT MY LOCAL REPAIR SHOP THEY TOLD ME IT WAS OUT OF TIME. HOW DOES A CHAIN DRIVEN VEHICLE BECOME OUT OF TIME? AS I RESEARCHED THE PROBLEM ON CAR FORUMS ON THE INTERNET I REALIZED THAT I AM NOT THE ONLY ONE FACING THIS ISSUE. MANY INDIVIDUALS HAVE REPLACED ENGINES IN THIS MODEL YEAR AT VERY UNREASONABLE PRICES SOME ONLY TO HAVE THE SAME ISSUE REOCCUR. I WAS FORTUNATE THAT I WAS NOT IN HEAVY TRAFFIC WHERE THIS SUDDEN LOSS OF POWER COULD HAVE CREATED AN ACCIDENT. I HOPE MORE INDIVIDUALS TAKE THE TIME TO COMPLAIN SO SOMETHING MAY BE DONE ABOUT THIS ISSUE. THIS IS NOT AN ISOLATED ISSUE AND THE VEHICLE HAS A REPUTATION FOR FAILURE WHICH UNFORTUNATELY I DID NOT KNOW ABOUT BEFORE I PURCHASED THIS VEHICLE. I WORK PART TIME AND CAN NOT AFFORD TO REPAIR THE ONLY VEHICLE I OWN. I AM WITHOUT A VEHICLE DUE TO A MAJOR COMPANY UNWILLING TO TAKE ACCOUNTABILITY OF THEIR INFERIOR PRODUCT. I PURCHASED THIS VEHICLE DUE TO THE FACT IT WAS AMERICAN MADE AND ASSEMBLED IN THE U.S. NEXT TIME I GUESS I BUY A FOREIGN PRODUCT THAT AT LEAST I WILL RECEIVE A PRODUCT THAT IS WORTH MY INVESTMENT. *TR
Engine, Mar 15, 2015
I OWN A 2006 FORD ESCAPE HYBRID- I RECEIVED NOTICE LAST YEAR OF RECALL FOR STALLING. I ASKED DEALER IN DEC TO REPLACE. WAS TOLD PART WAS LIMITED AND AS LONG AS NO PROBLEM THEY WERE UNABLE TO GET PART.( ALSO ASKED IN JAN- NO CHANGE.. IN FEB THE VEHICLE STARTED STALLING NUMEROUS TIMES. AFTER THEN HAVING THE CAR 3 DAYS. WAS TOLD THEY NO LONGER AM ABLE TO GET THE PART. TOOK IT BACK TWICE MORE AND AM NOW BEING TOLD THEY ARE NO LONGER MAKING THE PART . AND MY VEHICLE CONTINUES TO STALL.- IS THERE A NUMBER TO CALL AT FORD TO SEE WHY NO PART.. *TR
Engine, Mar 9, 2015
TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
Electrical system, Engine, Mar 8, 2015
I WAS DRIVING ON THE 495 BELTWAY (APPROX 55MPH) IN THE RIGHT LANE WHEN SUDDENLY MY CAR LOST POWER AND THE FAIL SAFE MESSAGE APPEARED SAYING STOP THE CAR IMMEDIATELY. FORTUNATELY, I WAS ABLE TO TAKE A NEARBY EXIT OFF THE BELTWAY WITHOUT INJURING MYSELF OR SOMEONE BEHIND ME AND CAUSING A MULTIPLE CAR COLLISION. A RED TRIANGLE ICON APPEARED ON THE DASHBOARD INCLUDING OTHER LIGHTS AND MESSAGES SINCE THE CAR HAD NO POWER. I DID HAVE THE CAR HEATER ON DUE TO WINTER TEMPERATURES. I IMMEDIATELY TURNED THE CAR OFF AND RESTED IT AND DID NOT PUT MY HEAT BACK ON SUSPECTING THE ELECTRONIC MOTOR COOLANT PUMP AS THE PROBLEM AFTER RECENTLY READING A NYT ARTICLE. THE CAR STARTED ABOUT 10 MINUTES LATER. I MADE AN APPT W MY FORD DEALER TO INSPECT THE CAR FOR THIS PROBLEM.I HAD A SIMILAR PROBLEM LAST SUMMER AND WAS TOLD BY FORD THAT MY VIN DIDN'T HAVE ANY RECALLS. I HAD THE A/C ON THAT DAY. UNFORTUNATELY, THE RECALL FOR THROTTLES ONLY APPLIES TO FORD NON-HYBRID CARS. THERE HAS ONLY BEEN A SERVICE BULLETIN TO FORD MECHANICS AND NO RECALL FOR THE ELECTRONICS MOTOR COOLANT PUMP. THIS INCIDENT SCARED ME AND I FEEL MY CAR IS UNSAFE TO DRIVE ESP ON INTERSTATE HIGHWAYS AT HIGH RATES OF SPEED UNTIL THIS PROBLEM IS RESOLVED. *TR
Engine and engine cooling, Feb 27, 2015
I BOUGHT A USED 2006 FORD ESCAPE FROM PASADENA AUTO PLANET IN SOUTH HOUSTON TX. ON 1/31/15. ABOUT A WEEK LATER I THOUGHT I SAW SMOKE COMING FROM UNDER MY HOOD BUT I DISMISSED IT BECAUSE THERE WAS A CAR IN FRONT OF ME WITH SMOKE COMING FROM THE MUFFLER. ON ANOTHER DAY THE SAME THING. I WASN'T BEHIND ANY CAR AND I SAW SMOKE COMING FROM UNDER MY HOOD SO I PULLED OVER. I COULD SMELL COOLANT. MY CAR DID NOT INDICATE OVERHEATING BECAUSE IT IS COLD OUTSIDE. WHEN I LIFTED MY HOOD SMOKE GALORE CAME OUT FROM THE RADIATOR. IT WAS DARK SO I COULDN'T SEE ANYTHING. THE NEXT MORNING I TOOK IT TO A MECHANIC AND WE DISCOVERED THE RADIATOR WAS CRUSHED FROM AN APPARENT PRIOR ACCIDENT AND THE FANS WEREN'T WORKING EITHER. I CALLED THE CAR LOT THE NEXT MORNING AND SPOKE WITH A MAN NAMED [XXX]. I TOLD HIM THE SITUATION. HE TOLD ME WHEN HE GOT TO THE CAR LOT HE WOULD PULL MY FILE AND CALL ME BACK. 3 HOURS WENT BY AND NOTHING. SO I WENT TO THE CAR LOT AND THERE HE WAS. HE DID NOT LOOK HAPPY TO SEE ME. I WENT INSIDE AND TOLD HIM AGAIN ABOUT THE DAMAGED RADIATOR. WE WALKED OUTSIDE AND HE LIFTED THE TOP OFF THE COOLANT SYSTEM AND SAID TO ME, "WELL, YOU DON'T HAVE ANY FLUID IN HERE." LIKE HE WAS TRYING TO DANCE ALL AROUND IT. I FINALLY MADE HIM GET ON HIS KNEES AND LOOK AT THE DAMAGE AND HE SAID, "OH, THAT'S JUST THE CONDENSER." SO I ASKED HIM WHAT WAS HE GOING TO DO ABOUT IT. HE SAID HE WOULD "TRY" TO GET APPROVAL TO FIX IT AT NO COST TO ME. I DECIDED I DON'T WANT THEM FIXING IT BECAUSE AT THIS POINT I DO NOT TRUST THEM. I WANT MY MONEY BACK. AFTER RESEARCHING, I FOUND OUT THAT FIRE CAN RESULT FROM A CAR OVERHEATING SO HE SOLD ME A SAFETY HAZARD. MY 1ST CAR PAYMENT IS DUE THIS SATURDAY, 2/28/15. I'M NOT PAYING IT FOR I JUST WANT MY MONEY BACK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine, Jan 24, 2015
MY ENGINE SEIZED, THERE WERE NO WARNING LIGHTS(OIL, CHECK ENGINE, TEMP) NOTHING. MY MECHANIC SAID THAT THERE WAS NO OIL IN THE CAR. BUT THERE WAS NO ODOR OF BURNING OIL. MY CAR HAD LESS THAN90 THOUSAND MILES ON IT AND IT WAS WELL MAINTAINED . WHAT CAN I DO? *TR
Engine and engine cooling, Power train, Jan 23, 2015
THE SERVICE ENGINE LIGHT CAME ON PLUS THE WRENCH LIGHT. THE VEHICLE TOLD ME TO PULL OVER SAFELY. IT WOULD NOT GO OVER 20 MILES PER HOUR. I HAD IT TOWED TO THE FORD DEALERSHIP AND WAS TOLD IT WAS THE THROTTLE BODY. I DID RESEARCH ONLINE WHERE OTHER ESCAPES WERE HAVING THE SAME ISSUE. THE NORTH CAROLINA CONSUMERS COUNCIL STATED THIS ONLINE- "WE HAVE BEEN INFORMED THAT FORD HAS ISSUED AN EXTENDED WARRANTY FOR DEFECTIVE THROTTLE BODY ASSEMBLIES AND SENSORS FOR 10 YEARS OR 150,000 MILES FROM THE DATA OF ORIGINAL PURCHASE. FOR VEHICLES PAST THIS TIME LIMIT, THE WARRANTY IS REPORTED TO BE VALID UNTIL JANUARY 31, 2015." SINCE I AM OVER THE MILEAGE I AM HAVING TO PAY FOR THE PART. *TR
Steering, Service brakes, Engine, Jan 1, 2015
ON 12/23/14, VEHICLE CUT OUT AFTER BACKING OUT OF PARKING TO ENTER MOVING TRAFFIC ON HIGHWAY. THE SECOND TIME IT CUT OUT,12/24/14, THE VEHICLE WAS BEING DRIVEN DOWN THE ROADWAY. THAT TIME, THE VEHICLE SPUTTERED, SOUNDED LIKE A WINDED HORSE, RUNNING ON THREE LEGS. MY CAR WAS ALWAYS WELL MAINTAINED, INCLUDING OIL CHANGES EVERY 3,000 MILES, TRANSMISSION FLUSHES EVERY YEAR, FUEL INJECTION CLEANING EVERY OTHER YEAR. WITH THE DOUBLE TIMING CHAIN, I WAS ASSURED AT PURCHASE, THAT THEY RARELY BREAK. I COULD NOT UNDERSTAND WHAT HAD CAUSED THIS. THEN, I AM TOLD IT IS A PCM FAILURE CAUSED BY SPARK PLUGS , COILS, THAT WERE NOT COMPATIBLE WITH THE PCM, OR WHERE THE RESISTOR WAS INEFFECTIVE TO COMBAT THE FEEDBACK FROM THE COILS/ SPARK PLUGS, AND THEREFORE CAUSED THE COMPUTER TO SHUT DOWN THREE CYLINDERS OF MY ENGINE. APPARENTLY THERE WERE TSB BULLETINS TO DEALERSHIPS ON THIS ISSUE, BUT NO RECALLS, BECAUSE FORD DETERMINED THAT THE PCM FAILURE WOULD PROBABLY OCCUR POST-WARRANTY. HOWEVER, CAR OWNERS SHOULD HAVE BEEN NOTIFIED, THERE SHOULD HAVE BEEN A RECALL. I WAS IN THE LAST FEW MONTHS OF PAYING FOR THIS VEHICLE, AND AM FACED WITH A $2500 BILL, THAT I DO NOT DESERVE, BECAUSE IT IS IN NO WAY LINKED TO MY OWN NEGLIGENCE OF VEHICLE MAINTENANCE! TO ME, IT IS A FORM OF BUILT-IN OBSOLESCENCE, THAT MIGHT BE OK WITH SMALL-COST ITEMS LIKE WATCHES, BUT SHOULD NEVER BE ALLOWED WITH HIGH-COST ITEMS, SUCH AS CARS! *JS
Engine, Dec 19, 2014, fire
ON MY HOME FROM THE GROCERY STORE DRIVING APPROXIMATELY 55 TO 60 MPH IN OUR 2006 FORD ESCAPE 4 CYL SUV. THE VEHICLE MADE A LOUD POP AND THEN CAUGHT ON FIRE. FREAKED OUT I PULLED OFF IN A DRIVEWAY. WE POURED SODA POP FROM 2 LITRES ON THE FIRE TO EXTINGUISH THE FLAME. THE MESH PIPE BEFORE THE LAST CATALYTIC CONVERTER WAS GLOWING RED. I HAVE READ MANY STORIES OF PEOPLE WITH THE SAME PROBLEM ON ALL YEARS OF FORD ESCAPE. IT IS IN MY OPINION THE REAR CONVERTER STOPPED UP CAUSING THIS DAMAGE TO OUR ONCE LOVELY RIDE.NOW I AM NOT EVEN SURE IF IT WILL RUN. THE HEAT FROM THINGS LIKE THIS CAUSES MAJOR STRESS ON INTERNAL ENGINE PARTS AS THE EXHAUST HAS NO WHERE TO GO. THEN WHEN THE ENGINE EXPLODES AS IT SHOULD FIRE STARTS. WE ARE NOW OUT OF A RIDE UNTIL WE CAN PAY AN EXTREME AMOUNT FOR THIS DEFECTIVE SUV. *TR
Electrical system, Engine, Dec 15, 2014
ON COLD MORNING, CAR STARTED DROVE DOWN THE ROAD ABOUT 5 MILES AND THE CAR JUST DIED, SAYING "BRAKE SAFELY NOW." SEEMS TO HAPPEN ONLY ON COLD DAYS WHEN HEATER IS ON. IT WILL NOT START AGAIN FOR 30 MINUTES. IT WILL START, BUT WILL CONTINUOUSLY DIE. WE HAD CALLED FORD IN MIDDLESBORO, KY AND SPOKEN WITH FRANK WHO SAID OUR VEHICLE DID NOT HAVE ANY RECALLS. I THEN FOUND OUT IT HAD A RECALL. I TOOK IT IN OVER THE WEEKEND AND HE THEN CLAIMED ON MONDAY THAT THE RECALL ITEM HAD BEEN FIXED. HOWEVER, WHEN I CHECKED THE WEBSITE, IT CONFIRMED THE PROBLEM HAD NOT BEEN FIXED. THIS HAS BEEN GOING ON FOR ABOUT A MONTH NOW. WE HAVE HAD THE OIL CHANGED, BATTERY REPLACED AND IT CHECKED BY FORD OF MORRISTOWN, TN. THEY CLAIM THEY CAN'T FIND OUT WHATS WRONG WITH IT. WE HAVE READ OTHER PEOPLE'S SIMILAR COMPLAINTS WHO SAID IT WAS EITHER THE "ELECTRIC MOTOR WATER PUMP" OR COOLANT PUMP. *TR
Engine and engine cooling, Nov 5, 2014
TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED AND THE MESSAGE STATING TO "STOP SAFELY NOW" ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE RESTARTED AND RESUMED NORMAL FUNCTION. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE MOTOR ELECTRONIC COOLANT PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE CONTACT WAS MADE AWARE OF RECALL NHTSA CAMPAIGN ID NUMBER: 14V526000 (ELECTRICAL SYSTEM). HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE MILEAGE WAS 120,000.
Engine, Hybrid propulsion system, Nov 5, 2014
TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE ENGINE STALLED. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE HYBRID BATTERY WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V526000 (ENGINE) AND BELIEVED THAT THE RECALL WAS DIRECTLY RELATED TO THE FAILRUE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
Engine, Oct 29, 2014
I WAS SITTING AT A DRIVE THROUGH AND VEHICLE STARTED SPUTTERING. HAD TO KEEP FOOT ON GAS TO KEEP THE VEHICLE RUNNING. WHEN I WENT TO PULL OUT ON THE STREET, THE VEHICLE STALLED OUT. AFTER 4 OR 5 ATTEMPTS AT RESTARTING, IT STARTED ABOUT 20 MIN LATER. *TR
Engine, Oct 12, 2014
I WAS DRIVING ON AN INTERSTATE HIGHWAY AND THE ENGINE SHUT DOWN. THE DASH SHOWED A WARNING STATING SOMETHING TO THE EFFECT OF 'STOP SAFELY NOW'. I STEERED THE CAR TO THE SHOULDER OF THE ROAD AND TRIED TO RESTART IT AND NOTHING HAPPENED. I WAITED A FEW MINUTES AND THE CAR STARTED. IT HAS RUN FINE SINCE THEN. THIS PROBLEM OCCURRED A NUMBER OF YEARS AGO WITH THIS SAME VEHICLE. I WOULD BE DRIVING DOWN THE HIGHWAY AND THE CAR WOULD JUST STOP. AFTER A FEW MINUTES IT WOULD START AGAIN. SOMETIMES IT WOULD HAPPEN TWICE WITHIN AN HOUR AND THEN THERE WOULD BE NO INCIDENCES FOR WEEKS TO MONTHS AND THEN IT WOULD HAPPEN AGAIN. A MECHANIC REPLACED AN ELECTRICAL COMPONENT AND IT APPEARED THAT THE PROBLEM WAS FIXED UNTIL THE INCIDENT ABOVE. I AM THE SOLE DRIVER OF THE CAR AND THE ORIGINAL OWNER. *TR
Engine, Sep 27, 2014
I HAVE OWNED THIS CAR SINCE 2006 WHEN I BOUGHT IT NEW. AFTER ABOUT FOUR YEARS THE BATTERY PACK BLEW AND HAD TO BE REPLACED. IT WOULD HAVE COST $4000 BUT THANKFULLY I HAD PURCHASED THE EXTENDED WARRANTY AND IT WAS COVERED. ON SEPT. 20, 2014 THE CAR THREW A ROD AND THE ENGINE WAS COMPLETELY DESTROYED. THE MECHANIC SAID IT WOULD COST $5000 TO FIX IT WITH A REBUILT ENGINE BUT THAT IT WASN'T WORTH IT BECAUSE THE ENGINES FOR THESE CARS ARE NOTORIOUSLY UNRELIABLE AND IT WOULD PROBABLY JUST FAIL AGAIN. IT WAS RECOMMENDED THAT WE SCRAP THE CAR. THE ENTIRE LIFECYCLE OF THIS VEHICLE WAS ONLY 8 YEARS WHICH IS ABSOLUTELY PREPOSTEROUS. CARS SHOULD LAST LONGER. *TR
Vehicle speed control, Engine, Sep 11, 2014
I WAS ACCELERATING ON THE FREEWAY, AND THE ENGINE STALLED. I COULD STILL STEER TO THE SIDE, BUT THE ENGINE HAD ABSOLUTELY NO POWER. CAME VERY CLOSE TO GETTING REAR-ENDED. BROUGHT CAR IN FOR SERVICE. THEY SAID NOTHING WAS WRONG WITH IT. CONTINUED TO HAVE MULTIPLE SIMILAR OCCURRENCES. BROUGHT IT IN AGAIN. THIS TIME THEY SAID THE BATTERY FAN WASN'T WORKING, SO I PAID A LOT TO HAVE IT FIXED (ABOUT A YEAR AGO), HOWEVER, I STILL HAVE CONTINUED TO HAVE THE SAME PROBLEM, MORE OFTEN AND ON MANY OCCASIONS NOW. IT SEEMS TO BE GETTING MUCH WORSE. I DREAD DRIVING ON FREEWAYS NOW, ESPECIALLY UP HILLS. I AM BRINGING MY CAR IN FOR SERVICE AGAIN LATER THIS WEEK. WONDER WHAT LINE THEY ARE GOING TO GIVE ME THIS TIME. *TR
Engine, Aug 23, 2014
I HAVE ONE QUESTION. WHY ARE 06 FORD ESCAPES STILL ON THE ROAD? WHAT BUGS ME MORE IS THE FACT FORD AND EVERYONE IS TURNING THEIR HEADS TO THE ISSUE. NOT ONLY HAVE I READ HUNDREDS OF COMPLAINTS OF ENGINE FAILURE, I HAVE NOT SEEN ONE PERSON SAY FORD MADE ANY EFFORT TO FIX THE PROBLEM INSTEAD I ONLY SEE CONTINUOUS PROBLEM DATING UP TO NOW INVOLVING THIS SAME ISSUE. MY GRANDFATHER WHO PURCHASED THIS VEHICLE NEW IN 06 IS NOW ON DISABILITY AND NOW WITHOUT A CAR AFTER ONLY 52,000 MILES. THE CAUSE. ENGINE FAILURE LIKE THE REST. NO WARNING, NO NOTHING. INSTEAD A $6,000 QUOTE FOR A NEW ENGINE. A MONTH BEFORE THAT WE REALIZED THE VEHICLE WAS BURNING OIL FASTER THEN NORMAL BUT WHEN CHECKED THERE WAS NO LEAK. FOLLOWING THAT THE ENGINE BLEW ONE MORNING AFTER BEING STARTED AND HEARING A LOUD BANGING. THE VEHICLE WAS TURNED OFF AND WOULD NOT TURN BACK ON. AFTER HAVING IT CHECKED THEY SAID THE ENGINE WAS FIRED AND OIL STARTED LEAKING INTO THE ENGINE. LUCKY WE WERE PARKED BUT UNLIKE MOST COMPLAINTS IV READ PEOPLE WERE DRIVING OR ON THE HIGHWAY WHEN THE SAME THING OCCURRED. I DON'T THINK I HAVE TO TELL YOU HAVE EXTREMELY DANGEROUS THAT IS AND COULD BE. ITS A PROBLEM TO MANY FORD OWNERS ARE EXPERIENCING AND NO ONE HAS TAKING ACTION. THAT VEHICLE IS A DEATH WAITING TO HAPPEN. HOW MANY MORE PEOPLE NEED TO LOSS MONEY OR POSSIBLE THEIR LIFE FOR SOMEONE TO STOP THIS? *TR
Fuel system, Gasoline, Vehicle speed control, Engine, Jul 31, 2014
I WAS DRIVING APPROXIMATELY 45-50 MPH & COULD NO LONGER ACCELERATE. GAS PEDAL WAS STUCK. I REALIZED I WAS ABLE TO RELEASE IT BY STEPPING ON BRAKES OR HITTING THE GAS PEDAL REALLY HARD. THIS WAS UNDER WARRANTY IN OCT 2009 & THE THROTTLE BODY WAS REPLACED (SUPPOSEDLY) THEN AGAIN IN NOV 2011 I HAD TO HAVE IT REPLACED BUT IT WAS NOT UNDER WARRANTY & HAD TO PAY FOR IT. IT WAS ICY OUT & IT'S PRETTY DANGEROUS TO SLAM ON YOUR BRAKES TO RELEASE THE GAS PEDAL. LUCKILY THERE WERE NO CARS BEHIND ME. I WROTE A LETTER TO FORD BUT THEY WOULD NOT REFUND ME NOR WAS THERE A RECALL. I JUST HAD THE SAME PROBLEM JULY 2014 & THE DEALER (SUPPOSEDLY) CLEANED THE THROTTLE BODY BUT CHARGED ME & I CALLED FORD BUT AGAIN THEY SAID THERE'S NO RECALL. I ALSO SPENT 7K IN FEB 2013 FOR A NEW ENGINE.....BEGINNING TO WONDER IF THAT WAS A WISE DECISION. *TR