2012 Ford Escape
Problems, recalls and owner-reported issues
Steering is the leading concern among 600 owner complaints filed for this model year. This is the 16th highest complaint count among 26 Escape model years with reports.
Of the 2012 reports, 37 involved a crash and 3 involved a fire. 26 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, delivery, fuel pumpOct 26, 2016
Ford Motor Company (Ford) is recalling certain model year 2010-2012 Ford Escape vehicles manufactured February 26, 2009, to April 29, 2012, and 2010-2011 Mercury Mariner vehicles manufactured February 25, 2009, to December 12, 2010. On vehicles with a 3.0L engine, the Fuel Delivery Module (FDM) may crack, causing a fuel leak.
A fuel leak in the presence of an ignition source increases the risk of a fire.
Ford will notify owners, and dealers will replace the FDM flange with one that has a redesigned fuel supply port, free of charge. Remedy parts are currently unavailable. Interim notices were mailed to owners on December 13, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S41.
Campaign 16V777000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Representative owner complaints: structure
68 reports, newest first. Show all
Structure, Sep 19, 2026
Sun roof is leaking into the passenger compartment. Car was typically parked under cover and not driven in inclement wether. Drain hose was found not to be clogged however water is leaking into the passenger compartment. Staining the headliner seats and collecting on the floors. The date is the most recent occurrence. The water falls into the vehicle and can short or cause fire to occur on the instrument panel, radio, shift mechanism, or HVAC control. This issue is documented on Ford vehicles containing the same component. Across different vehicles and model years. I believe a recall or TSB should be included on this vehicle.
Structure, Other or unspecified, Oct 13, 2024
Sub frame cracked,due to corrosion.Broke Lower control arm. I could not steer my SUV. I was terrified.The noise was so loud. This happened a road away from my home. I called AAA. They came and towed my vehicle to my driveway. I don’t understand why Ford company did not send me a recall. I could have been killed.I was on the highway a day before.I have researched and found this to be a safety concern for Ford Escape 2012. My SUV has 60.000 miles and is in very good condition. I have taken great care of my vehicle.
Structure, Aug 1, 2024
The contact owns a 2012 Ford Escape. The contact stated while driving at an undisclosed speed, the brake pedal was depressed, and the vehicle pulled to the right while stopping. The vehicle was taken to an independent mechanic, who determined that the passenger's side engine cradle subframe was severely corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 75,000.
Steering, Suspension, Structure, Mar 12, 2024
While doing an exhaust inspection on my car, I noticed the front subframe is rusted completely through on the right hand side near the rear lower control are bushing. This is a major structural component of the vehicle and I believe it is a huge safety risk driving it. The car has around 114,000 miles on it. I feel Ford should issue a recall and replace these rusted trough front subframes. I cannot afford to replace it at the cost of $2000 including labor. Please help, thank you.
Structure, Feb 7, 2024
Was informed by my mechanic that the subframe has rusted out and is a safety issue. There is also excessive rust for the car's age and level of maintenance in the rear wheel wells.
Structure, Oct 13, 2023
The contact owns a 2012 Ford Escape. The contact stated that there was a hole in the sub frame cradle due to rust. No warning light was illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 88,000.
Structure, Jul 27, 2023
The contact owns a 2012 Ford Escape. The contact stated that while driving at an undisclosed speed, there was a loud abnormal sound coming from the passenger’s side of the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with rusted and fractured mounts; however, the vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 125,000.
Structure, Feb 27, 2023
Excess Rust on both rear fenders in matching pattern. I've seen this exact issue on other Ford Escapes and there are many reports about it.
Structure, Latches/locks/linkages, Feb 7, 2023
Both rear doors will not open from inside or outside. No way to take panels off to repair. Can’t exit in case of emergency.
Structure, Jul 14, 2022
Frame rotted out under normal use.
Structure, Jun 25, 2022
Unknown. Both rear wheel wells are rusting away. Chunks of this falls off while I’m driving. I do believe that falling rusty chunks of metal may harm another driver that will either run over it and flatten a tire. Or that someone may swerve to miss a piece and cause an accident.
Structure, Jul 9, 2021
The contact owns a 2012 Ford Escape. The contact stated that water entered the vehicle through an unknown opening in the trunk. The vehicle was not diagnosed nor repaired. The manufacturer was informed of the failure and the contact was referred to the NHTSA to file a complaint. The failure mileage was approximately 60,000.
Structure, Mar 1, 2021
TL* THE CONTACT OWNS A 2012 FORD ESCAPE. THE CONTACT STATED THAT THERE WAS SEVERE RUST OVER THE TWO REAR WHEEL WELLS. THE CONTACT HAD TAKEN THE VEHICLE TO THE DEALER FLOOD FORD OF EAST GREENWICH (2545 S COUNTY TRAIL, EAST GREENWICH, RI 02818, (401) 884-4000) WHO INFORMED THE CONTACT THAT THE ISSUE MIGHT HAVE BEEN CAUSED BY THE WINTER WEATHER. THE VEHICLE HAD NOT BEEN DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.
Structure, Mar 1, 2021
OVER THE BACK WHEEL WELL BOTH SIDES OF THE CAR. THEN IS RUST AND CORROSION THAT IS GETTING WORSE AND WORSE. BIG PIECES ARE BREAKING OFF MORE AND MORE EVERY DAY. I FEEL THERE IS SO FAILURE OR DETACHMENT OF EXTERIOR BODY AND FRAME COMPONENTS, AND OTHER STRUCTURAL COMPONENTS THAT MAY PRESENT A SAFETY HAZARD
Structure, Mar 1, 2021
OVER THE BACK WHEEL WELL BOTH SIDES OF THE CAR. THEN IS RUST AND CORROSION THAT IS GETTING WORSE AND WORSE. BIG PIECES ARE BREAKING OFF MORE AND MORE EVERY DAY. I FEEL THERE IS SO FAILURE OR DETACHMENT OF EXTERIOR BODY AND FRAME COMPONENTS, AND OTHER STRUCTURAL COMPONENTS THAT MAY PRESENT A SAFETY HAZARD
Structure, Aug 4, 2020
EVERY TIME IT RAINS WATER SEEMS TO BE COMING THROUGH THE FRONT PASSENGER DOOR, I DON'T KNOW IF IT'S THROUGH A FAULTY WINDOW SEAL OR DOOR SEAL.
Structure, Apr 7, 2020
TL* THE CONTACT OWNS A 2012 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE HOOD UNLATCHED FRACTURING THE FRONT WINDSHIELD. THE CONTACT PULLED OVER TO SIDE OF THE ROAD AND CLOSED THE HOOD OF THE VEHICLE. THE CONTACT STATED THEY HAD TO DRIVE THE VEHICLE AT APPROXIMATELY 20 MPH TO AVOID THE HOOD BECOMING UNLATCHED AGAIN. CLEVELAND FORD (2496 S LEE HWY, CLEVELAND, TN 37311, (423) 218-1622) WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE HOOD AND THE LATCH FOR THE HOOD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE WINDSHIELD WAS REPLACED AT A GLASS REPAIR SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND A CASE WAS OPENED. A POLICE REPORT WAS FILED. THE APPROXIMATE FAILURE MILEAGE WAS 151,000. *LN*JB
Structure, Mar 17, 2020
THE HOOD FLEW OPEN AFTER DRIVING DOWN THE ROAD I CHECKED THE OIL AND MADE SURE THE HOOD WAS CLOSED BY ATTEMPTING TO LIFT IT. I WAS ON THE ROAD FOR ABOUT 3 MINUTES WHEN THE HOOD BLEW OPEN DAMAGING THE HOOD AND LATCHES IT WAS A WINDY DAY OUT MY SPEED WAS AROUND 30 MPH.
Electrical system, Structure, Feb 27, 2020
DRIVER DOOR SEAL (TOP) LEAKS TO THE POINT OF THERE BEING 2 INCHES OF WATER ON DRIVER FLOOR. ALSO WATER IS GETTING INSIDE THE DOOR, WHICH IS CAUSING ELECTRICAL ISSUES. HAD IT REPAIRED 3 TIMES AT DEALER & LEAK STILL EXISTS. THIS IS CAUSING MOLD & RUST IN THE VEHICLE. NOT SURE IF THIS IS THE FAULT OF THE MANUFACTURER OR THE INEXCUSABLE REPAIR WORK OF ATLANTIC AUTOMALL, BUT IT'S BECOMING A REAL SAFETY ISSUE & ATLANTIC AUTOMALL HAS BEEN REFUSING TO RESOLVE THE ISSUE OR EVEN RESPOND TO MY CALLS
Structure, Feb 17, 2020
BACKING OUT OF A DRIVEWAY. BOTH BRACKETS THAT ATTACH FROM THE ROOF TO THE GLASS IN THE REAR (TOP HALF OF HATCH BACK) SNAPPED IN HALF AND THE GLASS DROPPED - HELD ON ONLY BY THE TWO ARMS THAT GUIDE THE WINDOW/GLASS UP AND OUT WHEN OPEN/LIFTED.
Structure, Visibility/wiper, Aug 30, 2019
MY VEHICLE IS IN GOOD CONDITION BUT CONTINUES TO HAVE PROBLEMS. I CLOSED MY LIFT GATE TONIGHT AND HEARD A CRACK. MY REAR GLASS BROKE OFF OF THE LIFTGATE GLASS HINGE ON THE PASSENGER SIDE OF THE VEHICLE. IT ONLY REMAINED ATTACHED BY THE DRIVER SIDE HINGE. IT APPEARS THAT CORROSION/RUST OCCURRED BECAUSE IT WAS NOT SEALED OR WATER GOT IN SOMEHOW. I AM VERY THANKFUL THIS DID NOT HAPPEN WHILE DRIVING BECAUSE IF IT WOULD HAVE BROKEN FROM BOTH, IT WOULD CERTAINLY DETACH AND BREAK ON THE ROADWAY.
Structure, Jul 14, 2019
DRIVER SIDE AND PASSENGER SIDE WHEEL WELDS RUSTING OUT AND UP TOWARD THE WINDOW .
Structure, Jan 21, 2019
THE GLASS LIFT GATE LEAKS AROUND THE SEAL. BROUGHT TO THE ATTENTION OF FORD DEALER WHILE UNDER WARRANTY BUT WAS TOLD THAT THE WARRANTY DID NOT COVER IT. AFTER A RAIN, THE WATER PUDDLES IN THE BACK.
Structure, Visibility/wiper, Nov 27, 2018
VEHICLE WAS TRAVELING AT HIGHWAY SPEED (70MPH) WHEN PRIMARY AND SECONDARY HOOD LATCHES FAILED AND HOOD WAS BLOWN OPEN INTO THE WINDSHIELD. THIS WAS AFTER 5+ HOURS OF HIGHWAY TRAVEL WITHOUT ANY RECENT OPERATION OF THE INTERIOR HOOD LATCH RELEASE. EMERGENCY STOP WAS MADE TO SECURE HOOD. HOOD IS DAMAGED AND UNABLE TO CLOSE. BODY ABOVE THE WINDSHIELD IS ALSO DAMAGED FROM THE HOOD IMPACT.
Structure, Sep 24, 2018
WHILE DRIVING AT A SPEED OF 50-55 MPH ON A HIGHWAY THE HOOD FLEW UP AND HIT THE WINDSHIELD WITHOUT WARNING. THIS WAS AFTER DRIVING FOR APPROXIMATELY 2 HOURS IN VARIOUS HIGHWAY CONDITIONS. THE SAFETY LATCH FAILED TO CATCH IT. SMOOTH ROAD.