2020 Ford Escape
Problems, recalls and owner-reported issues
Structure is the leading concern among 1,531 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Escape model years with reports.
Of the 2020 reports, 20 involved a crash and 4 involved a fire. 28 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, softwareMar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Campaign 26V123000 on NHTSA.gov
Visibility, windshield wiper/washer, motorMar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Campaign 26V117000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsDec 1, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2025 Escape vehicles. The liftgate hinge covers may not be properly secured and detach from the vehicle.
A detached liftgate hinge cover can create a distraction or a road hazard, increasing the risk of a crash.
Dealers will inspect and reinstall, or replace any missing liftgate hinge covers as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.
Campaign 25V829000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, padsOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles. The rear brake pads may have been manufactured incorrectly, which can reduce brake function in the event of a brake booster malfunction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Reduced brake function can require the driver to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed on November 5, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025. This recall is an expansion of NHTSA recall number 21V922.
Campaign 25V693000 on NHTSA.gov
Equipment, electrical, engine block heaterOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemJul 11, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Campaign 25V467000 on NHTSA.gov
Back over prevention, softwareJun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Campaign 25V442000 on NHTSA.gov
EngineMay 23, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Campaign 25V345000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemMar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Campaign 25V165000 on NHTSA.gov
Electrical system, propulsion system, traction battery, management system/energy control module (bms/becm)Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.
Campaign 24V954000 on NHTSA.gov
Equipment, other, labelsNov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Campaign 24V852000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)May 10, 2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
A loss of drive power increases the risk of a crash.
Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.
Campaign 24V330000 on NHTSA.gov
EngineMay 26, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Campaign 23V380000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemNov 18, 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Campaign 22V859000 on NHTSA.gov
Engine and engine coolingJul 7, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Campaign 22V484000 on NHTSA.gov
Electrical system, propulsion system, traction batteryMay 13, 2022
Ford Motor Company (Ford) is recalling certain 2020 Escape and 2021 Lincoln Corsair vehicles equipped with 2.5L hybrid powertrains. Insufficient welds inside the high voltage battery may fail, resulting in a loss of drive power.
A loss of drive power increases the risk of a crash.
Dealers will replace the high voltage battery, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed on July 12, 2022. Owner notification letters were mailed August 8, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S33.
Campaign 22V331000 on NHTSA.gov
Engine and engine cooling, engine, oil/lubricationMar 25, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Campaign 22V191000 on NHTSA.gov
Power train, driveline, driveshaftJan 15, 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.
If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.
Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.
Campaign 21V011000 on NHTSA.gov
Electrical system, body control module/bcmOct 15, 2020
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the signal from the rear Tire Pressure Monitoring System (TPMS) sensors or the Remote Key Fob. In the event of a low tire pressure condition, the TPMS system may not provide an adequate warning.
Low tire pressure may lead to poor vehicle handling and a possible loss of vehicle control, increasing the risk of crash.
Ford will notify owners, and dealers will replace the BCM, free of charge. Owners are advised that two key fobs are required for the repair to be completed. The recall began December 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S59.
Campaign 20V635000 on NHTSA.gov
Back over prevention, sensing system, cameraSep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Reduced rearward visibility can increase the risk of a crash.
Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Campaign 20V575000 on NHTSA.gov
Power train, automatic transmissionSep 10, 2020
Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.
Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.
Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.
Campaign 20V550000 on NHTSA.gov
Air bags, side/windowJul 17, 2020
Ford Motor Company (Ford) is recalling certain 2020 Escape and Transit vehicles. The affected vehicles may have an improperly crimped diffuser in the side curtain air bags which may result in the diffuser detaching from the inflator in the event of an air bag deployment.
In the event of a crash, if the diffuser detaches from the inflator during air bag deployment, the curtain air bag may not inflate properly, increasing the risk of injury.
Ford will notify owners, and dealers will replace the side curtain air bag modules, free of charge. An interim letter notifying owners of the safety risk was mailed August 3, 2020. The recall began January 11, 2021. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 20S35.
Campaign 20V415000 on NHTSA.gov
Seats, front assembly, reclinerAug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Campaign 19V633000 on NHTSA.gov
Representative owner complaints: structure
605 reports, newest first. Show all
Structure, Dec 27, 2023
Driver door hinge welds broke and the door pops and creaks. The broken hinge rubbed on the window wiring harness and now the window won’t open. This has happened to hundreds of 2020 & 2021 ford escapes and my extended warranty won’t cover it because it’s coded as a “trim” piece, which is infuriating as it’s WELDED INSIDE of the door.
Structure, Dec 24, 2023
Drivers door began to make clicking banging sounds while opening and closing. It now is almost impossible to close and I has a lot of outward pressure once secured. I am scared the door will fly open while driving. This appears to be an ongoing issue with these models with a faulty spot weld but no recall as of yet.
Structure, Dec 22, 2023
The contact owns a 2020 Ford Escape. The contact stated while opening the front driver's side door, the door made an abnormal popping sound. Additionally, the front driver's side window failed to roll down as designed. The dealer was notified of the failure and informed the contact that it was a known failure, and that the front driver's side door needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: PE23013 (Structure). The manufacturer was not notified of the failure. The failure mileage was approximately 49,100.
Structure, Dec 22, 2023
DRIVER'S DOOR CHECK SPOT WELDS MALFUNCTIONED CAUSING THE DRIVERS WINDOW TO BECOME INOPERATIVE
Structure, Dec 22, 2023
The hinge for the passenger door that holds the door from opening widely broke. This is preventing for the door to close properly and I’m unable to lower the window.
Structure, Dec 21, 2023
The contact's boyfriend owns a 2020 Ford Escape. The contact stated that the front driver's side door made an abnormal popping sound while opening. Additionally, the door failed to close properly. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Action Number: PE23013 (Structure). The manufacturer was not notified of the failure. The failure mileage was approximately 80,000. The VIN was unavailable.
Structure, Dec 20, 2023
Broken spot welds in the front doors at the check arm attachment point. Have already replaced both door on a 2020 escape and now needing to replace the driver door for a second time. Very poor quality by FORD.
Structure, Dec 20, 2023
There is a spot weld failure inside my driver side door resulting in the doors hinge being broken inside the door. The door does not open all the way and it makes loud cracking noises. Also, the door will not always latch close properly and can open suddenly without touching it. I cannot roll down my window all the way. I need to crawl through the passenger side door and up over the console to get in my vehicle each time I use it. I am concerned for myself and my family that if heaven fobid we were in a car crash, that this unhinged door would not provide us with the means to keep us safe. The car is unsafe and unusable as the door could fly open at any time. The only fix that I have been offered from Ford Motor Company is to replace the entire door, since the broken hinge is inside the door and cannot be fixed. This will cost my famiy roughly $4000. Paying for a problem that Ford is very aware of, and that was by no means a fault of our daily usage or accident of any sort is infuriatling!
Structure, Dec 19, 2023
Driver side door quit working, the awelding on the arm is bad. Effects door opening and shutting and window going down.
Structure, Other or unspecified, Dec 18, 2023
Bought my daughter a 2020 Ford Escape. Last week, while at college, she called to say her door was making loud sounds when opening and shutting it and her window wouldn't roll down. Concerned that the door wouldn't stay shut I had her go to the Ford dealership in her college town. They told her they have seen two other Ford Escapes this week with the same issue and that she would probably need a new door. I called my local dealership and was basically told the same thing. They knew exactly what I was talking about before I started in 4-5 sentences. When she got home I went to look at the door. It swings open with no resistance and the window doesn't roll down. Upon further investigating from my local repair shop he helped me look up the problem. It is SSM 50150 -Cracked or broken spot welds in the left front door at the check arm attachment point in the door assembly. I have a major concern with safety on this issue. How do I get Ford to correct this issue?
Structure, Dec 18, 2023
The contact owns a 2020 Ford Escape. The contact stated that the driver's side door was making an abnormal clicking sound while being opened. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the door check strap on the weld had separated. The mechanic informed the contact that the door could drop and not close properly. The vehicle was not repaired. The manufacturer was contacted and opened a case but declined any further assistance. The contact was referred to the NHTSA Hotline. The failure mileage was approximately 20,740.
Structure, Dec 18, 2023
The contact owns a 2020 Ford Escape. The contact stated that the front driver's side door was making an abnormal popping sound while opening and the door was misaligned. Additionally, the contact stated that the driver's side window failed to roll down. The vehicle was taken to the dealer, where it was diagnosed that the spot welds in the driver's side door check arm brackets were fractured. The vehicle was not repaired. The contact related the failure to the NHTSA Action Number: PE23013 (Structure). The manufacturer was not notified of the failure. The failure mileage was approximately 35,000.
Structure, Other or unspecified, Dec 18, 2023
Driver side door suddenly began making loud creaking and popping noise when opening and closing. The driver side window also will not let all the way down since the noises started. Took it to the Ford dealership advised it was the door check assembly that was broke and they order the part. Took it to a 3rd party to have it put on and they advised that there was a failure with the spot welds in the check arm bracket on the the front door. Bracket has pulled out of the front driver's side door. Also advised this is why the window will only let down a little bit. Call the dealership and they advised that the door panel was not taken off so they would of not been able to see the spot welds provided Ford Company# called and stated that they was not a warranty on the vehicle and that there was nothing they could do at this time and provided case# CXH01214372. The cheapest estimate I have received so far to fix this issue is approximately 2,200.00 which I do not have please issue a recall on this issue
Structure, Dec 18, 2023
3 weld spots failed on driver door arm latch
Structure, Dec 15, 2023
the paseenger side door hinge welding has come apart making my door unsafe
Structure, Dec 14, 2023
DRIVERS SIDE DOOR IS CLANKING/ POPPING NOISE WHEN OPENING THE DOOR. THE DOOR DOOT STAY ROD WELD IS BROKEN AND THE WINDOW WILL NOT GO DOWN. IT IS A SAFETY PROBLEM WHEN THE WINDOW WILL NOT GO DOWN TO OPEN IT AND THE DOOR HINGE WELD IS BROKEN. THIS HAS HAPPENING TO OTHERS AND THE DEALER HAS SAID IT IS A PROBLEM THEY HAVE HAD WITH THIS CAR.
Structure, Dec 13, 2023
The contact owns a 2020 Ford Escape. The contact stated that the front driver's side door made abnormal grinding and cracking sounds while opening. The vehicle was taken to the dealer, where it was diagnosed that the front driver's side door hinges were corroded and that the door needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 23,000.
Structure, Dec 13, 2023
The contact owns a 2020 Ford Escape. The contact stated that the front driver's side door hinge fractured and there was an abnormal clicking sound coming from the front door. The contact stated that three spot wells needed to secure the door had fractured. The vehicle was not taken to a dealer to be inspected. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,000.
Structure, Dec 13, 2023
The door hold back has detached from its spot welds
Structure, Dec 13, 2023
The welds on the door bracket broke from just opening the door with no force
Structure, Dec 12, 2023
Front left drivers door hinge check arm attachment welds have broken causing a terrible noise and making it hard to close the door. It hasn't been reproduced or confirmed yet by a dealer or independent service center as I just now figured out what the noise was and it's getting worse every time the door is used. Hasn't been inspected by the manufacturer, police, insurance representatives or others, I came here first just now. No warnings or messages, just a terrible sound that was hard to pinpoint what was causing it until I saw the spot welds move away from the door when it opened. But now it is hard to close the door.
Structure, Dec 12, 2023
SSM 51553. My vehicle has a known problem with the left front door that has been reported by many other car owners. It presents with a cracked or broken spot weld in the left front door at the check arm attachment point in the vehicle assembly. The wider is also impacted as it will only open approximately 5 inches. A door assembly replacement at the cost of $2100 has been recommended. I contacted Ford and was initially told that they would assist with replacement costs. After two weeks, we were told that we could save paperwork in case a recall was made on this part but there was nothing else they could do to help.
Structure, Forward collision avoidance, Dec 12, 2023
Drivers door making noises. I was given the option WHOLE new door- total cost $2900 - I have to pay $1635 for NEW door which by the way will not match my car color as car 3 - 4 years old! SSM 50150 from national highway traffic safety administration. They also offer another solution to solve the problem. Ford should offer a better solution as shabby workmanship
Structure, Dec 11, 2023
Front Left Driver Door Has a Horrible Grinding and Popping Sound When Door Is Open Or Closed. The hinge is visibly damaged at welding joint. This issues a causes serious problems when trying to close the door and open.
Structure, Other or unspecified, Dec 10, 2023
Cracks or broken spot welds in the passenger front door at the check arm attachment point in the door. Door check broke off from door causing the door to be hard to close or not able to close at all.