2020 Ford Escape
Problems, recalls and owner-reported issues
Structure is the leading concern among 1,531 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Escape model years with reports.
Of the 2020 reports, 20 involved a crash and 4 involved a fire. 28 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, softwareMar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Campaign 26V123000 on NHTSA.gov
Visibility, windshield wiper/washer, motorMar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Campaign 26V117000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsDec 1, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2025 Escape vehicles. The liftgate hinge covers may not be properly secured and detach from the vehicle.
A detached liftgate hinge cover can create a distraction or a road hazard, increasing the risk of a crash.
Dealers will inspect and reinstall, or replace any missing liftgate hinge covers as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.
Campaign 25V829000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, padsOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles. The rear brake pads may have been manufactured incorrectly, which can reduce brake function in the event of a brake booster malfunction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Reduced brake function can require the driver to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed on November 5, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025. This recall is an expansion of NHTSA recall number 21V922.
Campaign 25V693000 on NHTSA.gov
Equipment, electrical, engine block heaterOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemJul 11, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Campaign 25V467000 on NHTSA.gov
Back over prevention, softwareJun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Campaign 25V442000 on NHTSA.gov
EngineMay 23, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Campaign 25V345000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemMar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Campaign 25V165000 on NHTSA.gov
Electrical system, propulsion system, traction battery, management system/energy control module (bms/becm)Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.
Campaign 24V954000 on NHTSA.gov
Equipment, other, labelsNov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Campaign 24V852000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)May 10, 2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
A loss of drive power increases the risk of a crash.
Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.
Campaign 24V330000 on NHTSA.gov
EngineMay 26, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Campaign 23V380000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemNov 18, 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Campaign 22V859000 on NHTSA.gov
Engine and engine coolingJul 7, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Campaign 22V484000 on NHTSA.gov
Electrical system, propulsion system, traction batteryMay 13, 2022
Ford Motor Company (Ford) is recalling certain 2020 Escape and 2021 Lincoln Corsair vehicles equipped with 2.5L hybrid powertrains. Insufficient welds inside the high voltage battery may fail, resulting in a loss of drive power.
A loss of drive power increases the risk of a crash.
Dealers will replace the high voltage battery, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed on July 12, 2022. Owner notification letters were mailed August 8, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S33.
Campaign 22V331000 on NHTSA.gov
Engine and engine cooling, engine, oil/lubricationMar 25, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Campaign 22V191000 on NHTSA.gov
Power train, driveline, driveshaftJan 15, 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.
If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.
Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.
Campaign 21V011000 on NHTSA.gov
Electrical system, body control module/bcmOct 15, 2020
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the signal from the rear Tire Pressure Monitoring System (TPMS) sensors or the Remote Key Fob. In the event of a low tire pressure condition, the TPMS system may not provide an adequate warning.
Low tire pressure may lead to poor vehicle handling and a possible loss of vehicle control, increasing the risk of crash.
Ford will notify owners, and dealers will replace the BCM, free of charge. Owners are advised that two key fobs are required for the repair to be completed. The recall began December 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S59.
Campaign 20V635000 on NHTSA.gov
Back over prevention, sensing system, cameraSep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Reduced rearward visibility can increase the risk of a crash.
Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Campaign 20V575000 on NHTSA.gov
Power train, automatic transmissionSep 10, 2020
Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.
Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.
Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.
Campaign 20V550000 on NHTSA.gov
Air bags, side/windowJul 17, 2020
Ford Motor Company (Ford) is recalling certain 2020 Escape and Transit vehicles. The affected vehicles may have an improperly crimped diffuser in the side curtain air bags which may result in the diffuser detaching from the inflator in the event of an air bag deployment.
In the event of a crash, if the diffuser detaches from the inflator during air bag deployment, the curtain air bag may not inflate properly, increasing the risk of injury.
Ford will notify owners, and dealers will replace the side curtain air bag modules, free of charge. An interim letter notifying owners of the safety risk was mailed August 3, 2020. The recall began January 11, 2021. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 20S35.
Campaign 20V415000 on NHTSA.gov
Seats, front assembly, reclinerAug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Campaign 19V633000 on NHTSA.gov
Representative owner complaints: structure
605 reports, newest first. Show all
Structure, Dec 8, 2023
Drivers door started popping when opening. I understand this is common with this model. A Ford service tech said it only happens to Escapes. Ford won’t repair past 36000 miles
Structure, Dec 8, 2023
The door spot welds on the driver door were not welded properly causing the door to fall apart from the inside. The door and window are now both broken.
Structure, Dec 8, 2023
ISSUE: Left front door (driver's door) door check spot welds broke free from the door frame making it impossible to close the door without damage. Issue presented itself as a loud popping sound approximately 36 hours prior to weld failure. Until weld failure, I was unsure what the issue was, and was unable to visit a dealership due to time constraints. Door was operated with caution after the issue was discovered, and I figured that something had just popped out of place and would look at it over the weekend and/or schedule a service visit with the local dealer. I was not expecting factory welds to break. The component has not yet been inspected by the dealership or other parties. SAFETY CONCERN: Lack of a functional door check may allow the door to forcefully swing closed while the driver is entering/exiting the vehicle, causing injury. The door may also swing outward uncontrolled in which multiple injury or damage outcomes are possible. The breaking of the welds also caused the check arm to be stuck in the extended position, preventing the door from being able to close. To allow closure of the door without additional damage, bolts and nuts securing the check arm to the door frame and bracket were removed, allowing insertion of the door check assembly into the door body.
Structure, Dec 5, 2023
Right front passenger door weld has failed as confirmed by Ford dealership. Car has 84,000 miles on it and is not eligible for warranty. Ford does not do body work and suggested it be taken to a body shop. Took to a body shop and they confirmed the weld has failed. Door can hardly be opened and when it does it sounds like broken metal from within. Cost to fix it was $1200. Found this out in October 2023. To date Ford has issued no recall even though there has been well over 300,000 complaints. Is there anyway we can do?
Structure, Dec 5, 2023
Left front door has popping noise when opening and closing the door. I took it to our dealership and was given an estimate to replace the door because the spot welds were broken and not repairable. They stated that the mileage was 45,300 and not under warranty. They couldn’t confirm that it was safe to drive or if they had seen this problem before. The estimate is $1357.98.
Electrical system, Structure, Dec 5, 2023
For at least a year or better, I noticed a creaking noise in the driver side door. Then on November 14th while doing my first time doing meals on wheels delivery, the door sounded as if it was going to fall off. We drove to Horn Ford Dealership in Brillion where the car was purchased and had them look at it. There was mention that they had repaired a couple of other Ford Escapes with the same issue. We scheduled an appt. for repair. We used the SUV very limited after that visit and only opened the door far enough to enter inside. The loud creak stopped before the appt. on 12/4, but the power window also would not fully open. During this time, I also contacted Ford Motor Company to file a claim, since the SUV was just out of warranty. They worked with our dealership Horn Ford and agreed to pay 40% of the cost. Today, 12/5/2023 we received our vehicle back and all is working well including the window. I also discovered that a resident in our village had the same problem. I felt this was worth reporting. I have owned many Fords and it would appear this was a defect from the Factory due to a bad weld on the door. Unfortunately, the vehicle was just out of warranty and I regret not saying something sooner, although, I don't think the dealership would have done anything about a creak in the door, especially since it was occurring when the door was fully open, until the day of November 14th.
Structure, Dec 5, 2023
Driver door (left front to be clear, yes, I know it should be obvious) started making strange sound. Popping/dragging noises when opened and shut. Window sometimes gets stuck going down past about 1/4 of the way down. Now door will not fully open - goes abut 40% open and stops.
Structure, Dec 4, 2023
Driver side door is making a click click sound when opening the door. Doing some research it seems the problem is that the hinge is broken and will continue to get worse. I have to go from the passenger side to get in and out or slightly open the driver door to get in and out.I also noticed that my power window doesn't go all the way down starting today 12/04/2023. I believe this is due to the door hinge problem. I hope this get a recall soon as I'm taking it to the dealership as I use the car everyday. I don't have thousands of dollars for a door replacement and not sure if this will go through my insurance if it's extremely expensive for nothing that I did wrong besides opening my door.
Structure, Dec 4, 2023
My driver side door began to make a popping sound and was hard to open and shut. Now it feels like the door will fall off or open while driving and has caused the window to no longer roll down. The Ford dealership (Bob Tomes) has acknowledged the problem and the same problem with other same year models but will not take care of the issue unless I pay full price out of pocket.
Structure, Dec 4, 2023
The driver's door hinge welds broke. Vehicle is available for inspection and do to the nature of the problem I am afraid that the door may fall off. The door and hinge piece need to be replaced to fix this issue. I called the Dealer, and they are aware of the issue but seem to not be willing to get this fixed without charging me due to me being 2 months outside of the bumper-to-bumper warranty. This is a Manufacture defect not an issue caused by me or an accident.
Structure, Dec 3, 2023
Driver side door began making a popping sound when opening and closing. Eventually window would not go all the way down. Took to dealer and they said there is a known problem with some spot welds associated with the door bracket and that Ford recommends replacement of the entire door. They also said this is not a recall and would cost around $1,800.00 since its out of warranty.
Structure, Dec 1, 2023
Driver side door malfunctioning. Popping when opening and closing
Structure, Dec 1, 2023
DRIVER DOOR RETAINER WELDS HAVE CRACKED AND SEPARATED. MAKING THE DOOR DIFFICULT TO OPEN OR CLOSE AND REMAIN CLOSED. THERE ARE NO WARNING LAMPS THIS PROBLEM IS ALREADY CURRENTLY UNDER INVESTIGATION BY NHTSA SSM 50150. ITS TIME FOR A RECALL OF THIS DANGEROUS LIFE SAFETY ISSUE AS THE DOOR IS ABLE TO OPEN SUDDENLY WHILE DRIVING
Structure, Nov 30, 2023
The driver door hinge broke at the 3 weld spots and now the door sometimes closes and other times hard to close. It has also popped open while driving.
Structure, Nov 30, 2023
Investigation: PE 23-013
Structure, Nov 30, 2023
3 door welds (cracked) on drivers door. making popping noise when opening door. i have confirmed with auto body shop and car dealership, where car was purchased. 2020 ford escape, passed warranty . concerned that door may not close, or open. have heard the popping noise for months, just thought is was dirt in the hinges, but had it checked out at the auto body shop. body shop estimate is $2300
Structure, Nov 30, 2023
Drivers door Check Arm has broken from door because of faulty spot welds from factory. You no longer have control of door when opening and door can swing open to full opening and out of control. This problem was confirmed by Fred Beans Ford in Boyertown PA. Apparently according to dealership this is an ongoing issue and Ford Refuses to recall or fix if out of warranty. I was quoted $2800 for the repair. My car has 31500 miles on it.
Structure, Nov 30, 2023
The door hinge on the driver's side failed. The 3 weld joints broke off. At times the door will not shut and latch properly, and the driver's window cannot be lowered. The dealer I took the vehicle to informed me that this is a recurring problem with the 2020 Ford Escape. They have had many people with the same problem. Ford refuses to acknowledge that there is a problem.
Structure, Nov 28, 2023
Every time the driver side opens, I hear a popping sound. I took it to my local Ford dealership and apparently it was passed warranty just two days prior so no work has been done. They advised me that the welds failed on the door and now the car needs a new door and latch that will take at least a week to complete repairs. My car has only 32,000 miles so it's fairly new. I fear that the door will eventually give out on me and not close properly.
Structure, Nov 27, 2023
broken spot welds in the left front door at the check arm attachment point in the door
Structure, Nov 27, 2023
Front drivers door makes popping noise and it appears to be loose. No physical damage. Looks like an internal part failure
Structure, Nov 25, 2023
Left front driver side door, making loud popping noise when opening and closing. Almost could not close with most recent use. Afraid to open again in fear that I will not be able to drive my car or lock it shut.
Structure, Nov 23, 2023
Left driver's side door is popping and gets stuck open sometimes. Vehicle mileage is only 33,505.
Structure, Nov 23, 2023
Factory Spot welds in driver side door have failed. The swing arm is not attached properly. Door will not open or close properly and it also affecting the window.
Structure, Nov 21, 2023
Driver's side door hinge has failed. Per staff at two separate dealerships, a "cup" or where the end of hinge attaches within the door has broken loose due to failed spot welds. Staff at both dealerships claim this is a common occurrence. Ford refuses to participate in the repair even though staff indicates it should be a recall event. Concerned door hinge will either jam thereby not allowing ingress / egress or will shatter window as parts appear to be moving inside body of door.