2020 Ford Escape
Problems, recalls and owner-reported issues
Structure is the leading concern among 1,531 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Escape model years with reports.
Of the 2020 reports, 20 involved a crash and 4 involved a fire. 28 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, softwareMar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Campaign 26V123000 on NHTSA.gov
Visibility, windshield wiper/washer, motorMar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Campaign 26V117000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsDec 1, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2025 Escape vehicles. The liftgate hinge covers may not be properly secured and detach from the vehicle.
A detached liftgate hinge cover can create a distraction or a road hazard, increasing the risk of a crash.
Dealers will inspect and reinstall, or replace any missing liftgate hinge covers as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.
Campaign 25V829000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, padsOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles. The rear brake pads may have been manufactured incorrectly, which can reduce brake function in the event of a brake booster malfunction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Reduced brake function can require the driver to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed on November 5, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025. This recall is an expansion of NHTSA recall number 21V922.
Campaign 25V693000 on NHTSA.gov
Equipment, electrical, engine block heaterOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemJul 11, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Campaign 25V467000 on NHTSA.gov
Back over prevention, softwareJun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Campaign 25V442000 on NHTSA.gov
EngineMay 23, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Campaign 25V345000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemMar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Campaign 25V165000 on NHTSA.gov
Electrical system, propulsion system, traction battery, management system/energy control module (bms/becm)Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.
Campaign 24V954000 on NHTSA.gov
Equipment, other, labelsNov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Campaign 24V852000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)May 10, 2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
A loss of drive power increases the risk of a crash.
Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.
Campaign 24V330000 on NHTSA.gov
EngineMay 26, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Campaign 23V380000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemNov 18, 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Campaign 22V859000 on NHTSA.gov
Engine and engine coolingJul 7, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Campaign 22V484000 on NHTSA.gov
Electrical system, propulsion system, traction batteryMay 13, 2022
Ford Motor Company (Ford) is recalling certain 2020 Escape and 2021 Lincoln Corsair vehicles equipped with 2.5L hybrid powertrains. Insufficient welds inside the high voltage battery may fail, resulting in a loss of drive power.
A loss of drive power increases the risk of a crash.
Dealers will replace the high voltage battery, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed on July 12, 2022. Owner notification letters were mailed August 8, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S33.
Campaign 22V331000 on NHTSA.gov
Engine and engine cooling, engine, oil/lubricationMar 25, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Campaign 22V191000 on NHTSA.gov
Power train, driveline, driveshaftJan 15, 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.
If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.
Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.
Campaign 21V011000 on NHTSA.gov
Electrical system, body control module/bcmOct 15, 2020
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the signal from the rear Tire Pressure Monitoring System (TPMS) sensors or the Remote Key Fob. In the event of a low tire pressure condition, the TPMS system may not provide an adequate warning.
Low tire pressure may lead to poor vehicle handling and a possible loss of vehicle control, increasing the risk of crash.
Ford will notify owners, and dealers will replace the BCM, free of charge. Owners are advised that two key fobs are required for the repair to be completed. The recall began December 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S59.
Campaign 20V635000 on NHTSA.gov
Back over prevention, sensing system, cameraSep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Reduced rearward visibility can increase the risk of a crash.
Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Campaign 20V575000 on NHTSA.gov
Power train, automatic transmissionSep 10, 2020
Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.
Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.
Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.
Campaign 20V550000 on NHTSA.gov
Air bags, side/windowJul 17, 2020
Ford Motor Company (Ford) is recalling certain 2020 Escape and Transit vehicles. The affected vehicles may have an improperly crimped diffuser in the side curtain air bags which may result in the diffuser detaching from the inflator in the event of an air bag deployment.
In the event of a crash, if the diffuser detaches from the inflator during air bag deployment, the curtain air bag may not inflate properly, increasing the risk of injury.
Ford will notify owners, and dealers will replace the side curtain air bag modules, free of charge. An interim letter notifying owners of the safety risk was mailed August 3, 2020. The recall began January 11, 2021. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 20S35.
Campaign 20V415000 on NHTSA.gov
Seats, front assembly, reclinerAug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Campaign 19V633000 on NHTSA.gov
Representative owner complaints: structure
605 reports, newest first. Show all
Electrical system, Structure, Nov 20, 2023
About 3 weeks ago now I opened my driver door and heard a loud cranking followed by a poo, the arm bar weld on the door just broke, had to shut the door from the outside and as a result I don't have control over my driver side window and all the power locks in the vehicle are shot. In addition to this my electrical is going crazy, I have the dash lights set to off but when I remove key or open door all the lights come on and I have to click the button back and forth to get the lights to shut off. This has resulted in a dead battery once for not catching it acting up. I'm extremely concerned about the safety on this vehicle I have had it less then 3 years and it's had several recalled issues fixed already. I can't afford a whole new door so please recall this spot weld!!
Structure, Nov 20, 2023
Drivers Side door Welds broke inside door. And door doesn't lock. Door check broke and window goes down less than half way. Bought it in 2021 with 14, 000 miles now has 30,000 Went to my dealership and they said Ford would give me 1000.00 towards repairs leaving me with a balance of 1500. This should be a recall.
Structure, Nov 19, 2023
Sheet metal piece attached to CHECK ARM ATTACHMENT(PN LJ6Z-7823552-B)detached. 5 spot welds failed. See TSB [XXX]. Door would not close. David McDavid Ford wanted $31000 to replace door. I pop riveted sheet metal piece in 5 places. I will continue driving car but will check rivets every week. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Structure, Nov 18, 2023
hello the driver door makes a loud clicking sound when opening all the way
Steering, Structure, Nov 18, 2023
The spot welds on the interior door assembly for the check arm broke off. Causing damage to my power window motor. And many other components. Car is at 50,000 miles. Not high wear. The welds are poorly done and ford is making me buy a new door as a result of their error.
Structure, Nov 17, 2023
Out of nowhere my front driver side door started making this awful, loud clanking sound whenever I would open or close it. Took it to the mechanic I usually go to and they said that the "door check broke off the door because the spot weld failed" and that I would have to call a Body Shop. Called the dealership and they said that it is a well known and well documented issue with the year, make and model of my vehicle (2020 Ford Escape), but so sorry I would have to pay appr. $2600 to replace the door.
Structure, Nov 16, 2023
Driver's door hinges failed causing the door to swing open unexpectedly while I was trying to exit. Pulled both shoulders while trying to control it. Orthopedic surgeon says I need rotator cuff surgery - he suspects the injury was due to the door failure.
Structure, Nov 16, 2023
Door stop on both the driver side as well as the passenger side have broke off making it hard to actually open and close the door. As of 11/16/2023 the window is also stuck due to the door stop damaging the motor. After searching the Internet this is a very widespread issue when I took it to the dealership they said since it was out of warranty it wouldn't be covered. I don't believe this is anything but bad workmanship because the weld apparently breaks as low as 8000 miles. Well within the warranty period.
Structure, Nov 15, 2023
My driver door started making a loud cranking sound out of the blue when opening and closing the door. After several days, it became clear that the door hinge/catch was no longer secured and was loose. This was not the result of a gist of wind forcefully blowing the door open or something like that; it just broke on its own. Now the door swings wildly when opening and the window won’t roll all the way down. My vehicle was just a few months out of warranty so Ford won’t offer any assistance for fixing the problem. I have not yet repaired it because they say the whole door needs to be replaced and, at this time, I can’t afford the expense.
Structure, Nov 15, 2023
Driver side door weld broke allowing door to possibly open while driving
Structure, Nov 15, 2023
Drivers door check arm broken at spot welds rendering it ineffective and making drivers door window inoperable.
Structure, Nov 14, 2023
When opened front driver’s side door, heard creaking, rattling, and pop. Now door will not close as well as problems with the window not working in that door! The frame on car is also loose due to bad door pulling on the frame. I’m concerned door may open when driving. Ford dealership will not pay due to the fact warranty expired April 2023 with only 33,000 miles on vehicle. An inspection by an independent service center confirms the issue and estimates a $2,400.00 cost of repairs. Inspector indicates poor spot welding and rivets in check arm defective. Insurance will not cover any expenses since it is not a result of a collision!! There was no warning messages indicating any issue. Door noises were heard on a Saturday (11/11/2023) and on Sunday (11/12/2023) door popped and couldn’t be closed’
Structure, Nov 14, 2023
Driver side door will not close tight. Will sometime open while driving on highway
Structure, Nov 14, 2023
The drivers front door began making a popping sound as the door opened and closed. By the next day the door began to have trouble closing fully. I noticed the weld points had broken where the door check/limiter attached to the door. It sounds like the same issue as the NHTSA investigation PE23013. In order to fully close the door the door had to be disabled and the broken part removed.
Other or unspecified, Structure, Nov 13, 2023
The Check Arm Attachment on the driver side door for my 2020 broke off because of poor welding, I have read it is a common issue with the 2020 ford escape
Structure, Nov 13, 2023
Front side driver’s door starting making popping noises on Saturday. By Sunday of the same week only a day later the door made a crunching and breaking noise when opening, now the door has to be forced closed and the window will only go down about 4 inches.
Structure, Nov 13, 2023
The front driver's side door is making a loud popping noise when opening and closing the door. We have not yet taken the car to our local dealership yet, but have spoken with them over the phone and their body shop has confirmed that this sounds like an issue we've identified in online forums, which poses a significant safety risk, as the door may open while the car is moving. We will be taking the car in for a formal diagnostic next week. There are no warning indicators of the issue, just the noise, which has started suddenly over the past week.
Structure, Nov 13, 2023
Per the dealership the driver side door hinge is failing. It also has caused the window track to bind that resulted in window breakage. The door hinge failure is growing worse with time and I'm afraid the door may come loose at some point. The hinge problem first appeared around December 2022.
Structure, Nov 12, 2023
I have only had my car for three years and it is well taken care of, but the door suddenly started popping. The same day, my door became difficult to open and extremely hard to close once I got it open. I contacted Ford Corporate the next day. I was told my car was out of warranty because I have 38981 miles. The only thing that was covered under the 5 year warranty in regards to safety would be the seat belts and the airbags. I said, "Ford doesn't think that the car door being able to open or close in the case of an emergency is a safety issue?!?" The chat operator said she could open a case for Ford to review the issue. I asked her if that meant Ford would help with my door and she said no. They gave me case number CAS-46112899-L1F3M7 for my records. I asked how to track that case number to see Ford's response - but of course there is no way to track or check the status - making that case number useless for me. I took my car to Thoroughbred Ford to see if it could be covered under warranty and if they could also fix my radio which is now magically malfunctioning after the 3 year warranty lapsed, they told me I had to pay $155 EACH to have them to diagnose the door and radio problem before they could even give me a cost. Then I was told Ford had a TSB regarding the issue - so correction - it would be covered by Ford and the door has be replaced. I was happy - but not for long. They came back and apologize and said, no that TSB was just for rust and corrosion - they will cover that but not the popping door even though they admittedly were aware that this was a known issue. Then I was told no doors are available, so they can't quote me until it comes in so they will call me. So I look stupid in my car when I get in or out because I open just barely, turn to the side, slide in and then pray I can get it closed. Found out the window now doesn't want to come down because that door is messed up - so I could not even crawl out the window in an emergency.
Structure, Nov 11, 2023
The driver side door makes a cracking sound when opening and closing and doesn’t shut correctly. Feels unsafe to be driving it around because I’m worried about door popping out at anytime.
Structure, Nov 7, 2023
The drivers side door - the weld on the arm has fractured. Causing a loud clunking noise every time the door is opened or closed. This 'break' has caused the window to only be able to roll down about 6 inches. Also, because of the break, the interior lights don't recognize that the door is closed and will stay on as if there is a door open. When called local Ford Dealership, I was advised it is a common problem and the whole door needed to be replaced. Currently, I am out of warranty but upon investigating online, this is a very common problem in the 2020 Ford Escape Drivers side door.
Structure, Nov 7, 2023
Driver side door hinge/weld breaks. The metal pops, makes a loud sound, door then has to be forced shut. Due to this the window and lock does not work properly. It goes down particularly then stops. Was taken to New Brighton Ford and spoke with Dan who diagnosed the problem. Was told needed new door. The car was purchased brand new from Freeway Ford in October 2020. Was told no warranty and extended warranty does not cover body.
Electrical system, Structure, Nov 7, 2023
Loud popping noise when opening driver side door, feels like the door is starting to slip, at times have trouble closing, now the window when rolled down will not roll back up. Popping, cracking noise started 3+ months ago, have call into dealership at this time. Not able to use the window at all now and not sure the door will stay continue to be usable.
Structure, Nov 6, 2023
A weld in the driver's side door assembly has failed. I am concerned that the door may inadvertently open while driving. The problem has been confirmed by a dealer. I had no warning of the problem until the door mechanism failed and continues to fail with each opening/closing. I do not have the funds to repair/replace the door of the vehicle.
Structure, Nov 5, 2023
The driver door makes a popping noise when opening and closing. Door now has problems closing and sometimes will not shut properly. Also, the window is not going up and down as fast as it should. Both problems happened around the same time and are believed to be related.