2020 Ford Escape
Problems, recalls and owner-reported issues
Structure is the leading concern among 1,531 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Escape model years with reports.
Of the 2020 reports, 20 involved a crash and 4 involved a fire. 28 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, softwareMar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Campaign 26V123000 on NHTSA.gov
Visibility, windshield wiper/washer, motorMar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Campaign 26V117000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsDec 1, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2025 Escape vehicles. The liftgate hinge covers may not be properly secured and detach from the vehicle.
A detached liftgate hinge cover can create a distraction or a road hazard, increasing the risk of a crash.
Dealers will inspect and reinstall, or replace any missing liftgate hinge covers as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.
Campaign 25V829000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, padsOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles. The rear brake pads may have been manufactured incorrectly, which can reduce brake function in the event of a brake booster malfunction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Reduced brake function can require the driver to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed on November 5, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025. This recall is an expansion of NHTSA recall number 21V922.
Campaign 25V693000 on NHTSA.gov
Equipment, electrical, engine block heaterOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemJul 11, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Campaign 25V467000 on NHTSA.gov
Back over prevention, softwareJun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Campaign 25V442000 on NHTSA.gov
EngineMay 23, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Campaign 25V345000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemMar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Campaign 25V165000 on NHTSA.gov
Electrical system, propulsion system, traction battery, management system/energy control module (bms/becm)Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.
Campaign 24V954000 on NHTSA.gov
Equipment, other, labelsNov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Campaign 24V852000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)May 10, 2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
A loss of drive power increases the risk of a crash.
Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.
Campaign 24V330000 on NHTSA.gov
EngineMay 26, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Campaign 23V380000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemNov 18, 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Campaign 22V859000 on NHTSA.gov
Engine and engine coolingJul 7, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
An engine compartment fire increases the risk of injury.
Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Campaign 22V484000 on NHTSA.gov
Electrical system, propulsion system, traction batteryMay 13, 2022
Ford Motor Company (Ford) is recalling certain 2020 Escape and 2021 Lincoln Corsair vehicles equipped with 2.5L hybrid powertrains. Insufficient welds inside the high voltage battery may fail, resulting in a loss of drive power.
A loss of drive power increases the risk of a crash.
Dealers will replace the high voltage battery, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed on July 12, 2022. Owner notification letters were mailed August 8, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S33.
Campaign 22V331000 on NHTSA.gov
Engine and engine cooling, engine, oil/lubricationMar 25, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Campaign 22V191000 on NHTSA.gov
Power train, driveline, driveshaftJan 15, 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.
If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.
Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.
Campaign 21V011000 on NHTSA.gov
Electrical system, body control module/bcmOct 15, 2020
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the signal from the rear Tire Pressure Monitoring System (TPMS) sensors or the Remote Key Fob. In the event of a low tire pressure condition, the TPMS system may not provide an adequate warning.
Low tire pressure may lead to poor vehicle handling and a possible loss of vehicle control, increasing the risk of crash.
Ford will notify owners, and dealers will replace the BCM, free of charge. Owners are advised that two key fobs are required for the repair to be completed. The recall began December 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S59.
Campaign 20V635000 on NHTSA.gov
Back over prevention, sensing system, cameraSep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Reduced rearward visibility can increase the risk of a crash.
Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Campaign 20V575000 on NHTSA.gov
Power train, automatic transmissionSep 10, 2020
Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.
Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.
Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.
Campaign 20V550000 on NHTSA.gov
Air bags, side/windowJul 17, 2020
Ford Motor Company (Ford) is recalling certain 2020 Escape and Transit vehicles. The affected vehicles may have an improperly crimped diffuser in the side curtain air bags which may result in the diffuser detaching from the inflator in the event of an air bag deployment.
In the event of a crash, if the diffuser detaches from the inflator during air bag deployment, the curtain air bag may not inflate properly, increasing the risk of injury.
Ford will notify owners, and dealers will replace the side curtain air bag modules, free of charge. An interim letter notifying owners of the safety risk was mailed August 3, 2020. The recall began January 11, 2021. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 20S35.
Campaign 20V415000 on NHTSA.gov
Seats, front assembly, reclinerAug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Campaign 19V633000 on NHTSA.gov
Representative owner complaints: structure
605 reports, newest first. Show all
Power train, Structure, May 18, 2025
Two issues. 1: transmission shakes, shudders, and loses power intermittently at shift points. 2: check arm spot welds broke loose at the door. Safety issue. Ford has a service bulletin for this SM 51553 And SM 50150
Structure, May 14, 2025
Sunroof/Sunshade - Plastic trim piece approximately 28"x5" in between the Sunroof and Shade across the middle is held in by double face tape. Tape weakens and piece falls down potentially striking a rear passenger. In addition it can get caught in the shade fabric dislodging it and falling potentially obstructing the drivers rear view. Mine has been repaired once by Ford already but has failed again. Estimated cost is approximately $2000 plus labor. This is a known defect by the Ford Motor Company and they claim it out of warranty. Basic internet search revealed it is a common problem for more that one years models.
Structure, Engine, Fuel/propulsion system, Apr 21, 2025
Got the car with many problems . Last recent problems purge cvavle, leak in emission, air make loud sounds . Now it’s my door was making popping noises when closing or opening, now the door doesn’t shut at all. No incident happen, just happen by itself
Structure, Apr 20, 2025
The door weld just broke.
Structure, Apr 13, 2025
My drivers door started 2days ago, April 11, 2025 to make loud cracking noise when opening and closing out of no where. Then on April 12 while out running errands the door became detached. After several attempts to close I was able to close it but I'm having to get in and out from passenger side.
Structure, Mar 26, 2025
Front Drivers door became hard to open and close. Loud popping noise heard while opening and closing. Window also will not roll down. Inspected door check and discovered spot welds holding internal bracing broke loose. Due to difficulty closing the door, I believe the door may not latch properly. Doing research, I discovered that this is a common problem on 2020 Ford Escape models.
Structure, Mar 17, 2025
The contact owns a 2020 Ford Escape. The contact stated that the rear quarter windows' chrome piece had detached. The contact was concerned that the failure could become a road hazard for other drivers. The vehicle was taken to the dealer, who attempted to reseal the chrome but was unable to repair the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 40,000.
Structure, Feb 19, 2025
Faulty welds on door hinges, particularly where the check arm connects. This happened yesterday, loud cracking and grinding noise when the front driver door is opened or closed. Ford has known about this issue and refuses to issue a recall. And getting in touch with my local Ford dealer's service department is difficult.
Structure, Feb 4, 2025
I reported my 2020 Ford Escape last year. It went into the shop for inspection at Cook ford in Texas City after the ford recall for the doors. I also had reported it here. Kyle at Cook ford did a thorough inspection but advised me that their dealership did not have a paint and body shop and referred me to other dealerships with the ability to fix my car. After going to two dealerships, I ended up at Maik Haik in Pasadena Texas. They said they had two doors in stock and three months later my car was still in the shop and not fixed. They had put me in a rental and said in early December that the rental was not being covered by Ford and they were having to "eat" the expense. So, they returned my car in December with hopes of getting parts for it in the future. It now has been two months and no call from them Now your website says I do not have an open recall on my vin, but it does! My car is still not fixed! I am [XXX] and the windows don't work and the locks also have been effected by the problem with the doors! My [XXX] brother and I got locked out of and In the car several times and I had to use my app to unlock the door or climb in the back to get in! During the time the dealership had my car they wiped off all the history in my app and I am not able to reconstruct the history of my car! Including the recalls! I am very upset! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Structure, Lane departure, Forward collision avoidance, Jan 20, 2025
My wife and I bought our 2020 Ford Escape new from a dealer in 2020. We are the first owners of this vehicle. In the time that we have had it, we have experienced the following issues: 1- the forward camera module that provides collision prevention, lane assist, adaptive cruise control, etc has failed. The dealer claims that the unit “overheated”. The module is no longer covered under warranty due to mileage. The result is that our vehicle no longer has the safety features that we paid extra for upon initial purchase. 2- the evaporative canister purge valve failed, causing difficult starts after refueling. This was not covered under warranty, due to mileage. 3- the driver door hinge check arm welds have all broken loose and no longer hold the door when opening, and the loose arm is now preventing the door from closing properly and, when closed, causing the drivers window to not roll down fully. This is not covered under warranty because of mileage AND (while it is a manufacturing defect), it has not been subjected to any recalls, so the dealership will not repair/replace it.
Structure, Jan 18, 2025
Driver door hinges are loose. Door makes loud cracking noise when opening and closing. It’s very hard to close. My window will not go down either.
Electrical system, Structure, Jan 6, 2025
Went to open the drivers side left front door and heard a loud clunk, now door isn't opening or shutting properly and we can't use the drivers window either. I've heard of peoples doors falling off while driving because of this and we just bought the car at the end of October. We have yet to get it looked at, but it's not a cheap fix. There were no warnings or signs. I opened it normal like every other time.
Structure, Dec 16, 2024
Driver side door check arm bracket has completely broken off due to bad spot welds. Makes driver side door function very poorly. The check arm completely broke off while opening the door in my driveway.
Structure, Nov 18, 2024
I have a Ford recall notice 23B56. I have been waiting three months for replacement parts. Ford provides dealership NO status on parts to repair the recall.
Structure, Oct 31, 2024
Front drivers side door makes loud popping sound when opening or closing. Now it doesn't shut completely. One of the spot welds near the door check has torn through the metal frame, and is causing the window to not roll up or down. When driving over any small bump or uneven road, door cracks loudly, and twice has popped open in transit, then would not close until I pulled over, stopped, and manhandled the door to a close.
Electrical system, Structure, Oct 18, 2024
Dashboard message indicates the left front door is open although the door is properly closed and locked. I'm still able to lock and unlock the door using the lock switch on the inside door panel while sitting in the driver's seat. I can also lock and unlock the door using my key fob.
Structure, Sep 20, 2024
The contact owns a 2020 Ford Escape. The contact stated that after a severe rainstorm, the contact noticed that there was a strong odor inside the vehicle. The vehicle was taken to the car wash, and upon removing the floor mats, the contact became aware that the floor mats were significantly wet, and there was mold and mildew on the floor mats and on the carpet. The vehicle was taken to the dealer, where the vehicle was dried out and the seats were taken out. The dealer then performed a water entry test and determined that water was entering through the seam in the rear of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 30,000.
Structure, Sep 17, 2024
The contact owns a 2020 Ford Escape. The contact was informed that the VIN was included in Ford Customer Service Program Number: 23B56 (Warranty - Front Door check arm weld). There was no warning light illuminated. The contact stated that there was no prior failure experienced with any of the doors. The vehicle was taken to a dealer to be diagnosed. The dealer stated that the front driver’s side door needed to be replaced; however, the door was not available due to the programming part being limited and not available. The dealer informed the contact that the vehicle needed to remain with the dealer until the part was available because the vehicle could present a risk to the driver. The vehicle was not repaired. The dealer denied the contact a loaner vehicle. The manufacturer was notified of the failure. The failure mileage was 29,131.
Structure, Sep 16, 2024
Door making a hoping noise window won't go down. Unwelded part of the door
Structure, Sep 13, 2024
The contact owns a 2020 Ford Escape. The contact stated that during inclement weather, moisture would enter the vehicle through the liftgate. Due to the failure, there was water pouring out of the vehicle upon opening the liftgate. The failure persisted and the contact stated that moisture had started to accumulate inside the spare tire wheel compartment leading to mold developing inside the vehicle. Additionally, rust had started to form around the liftgate latch due to the moisture failure. The manufacturer was notified of the failure but offered no assistance. The contact was transferred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 50,000.
Structure, Engine, Sep 11, 2024
The contact owns a 2020 Ford Escape. The contact was informed by a Ford mechanic that the front driver’s side window could possibly shatter while rolled down. The contact was informed that the door needed to be replaced; however, the replacement door remained on backorder. The contact stated that while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. The check engine warning light illuminated, and the vehicle was taken to the dealer. The contact was informed that the engine valve was defective and needed to be replaced. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 80,000.
Structure, Latches/locks/linkages, Sep 3, 2024
The contact owns a 2020 Ford Escape. The contact stated that while the vehicle was parked, the contact became aware that the driver’s side front door had detached, and the hinge on the door was inoperable. The vehicle was taken to the dealer where it was diagnosed and determined that the door had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 92,000.
Structure, Aug 26, 2024
The front door check-arm spot welds failed on the driver's side.
Structure, Aug 26, 2024
Heard load popping sound opening door. Driver side door stop spot welds broke. Door stop broken and door swings freely out; window can't roll down.
Structure, Aug 5, 2024
On the door, the brace to control the stability of the door has broken off on the inside of the door. This is very annoying that this is not considered a recall as this is something that can only be fix by replacing the entire door. That is not a convenient amount of money to just spend.