2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: suspension
386 reports, newest first. Show all
Suspension, Jan 3, 2003
CONSUMER STATED THAT DURING INSPECTION, MECHANIC DETERMINED THAT WHEEL BEARINGS WERE DEFECTIVE. CONSUMER CONTACTED MANUFACTURER ABOUT RELATED RECALL 00V303000. MFR ADVISED CONSUMER'S V.I.N. DOES NOT FALL WITHIN MANUFACTURING DATE RANGE OF 3/5/99-5/5/00. CONSUMER ADVISED THAT CERTIFICATION LABEL STATES VEHICLE WAS MANUFACTURED IN 09/99. TS
Steering, Suspension, Fuel system, Gasoline, Electrical system, Structure, Tires, Equipment, Jan 2, 2003
THE CONSUMER HAS EXPERIENCED THE FOLLOWING: THE REPLACEMENT OF THE LEFT DASH BOARD CLUSTER (TEMPERATURE GAUGE INOP FROM THE TIME OF PURCHASE), REATTACHMENT OF RUBBER SEAL AROUND DRIVER DOOR WINDOW, REATTACHMENT OF FUEL PUMP, REATTACHMENT OF HEADLINER IN REAR OF VEHICLE, UNCRIMPING OF FUEL LINE, LUBRICATION DRIVER DOOR HANDLE(STICKING), LUBRICATION OF CATCH ON REAR PASSENGER SIDE DOOR(HAD COME OPEN WHILE VEHICLE WAS IN MOTION), REPLACEMENT THE TURN SIGNAL SWITCH IN STEERING COLUMN-HAD TO BE TURNED OFF MANUALLY, PERSISTENT NOISES/VIBRATIONS IN THE FRONT END OF VEHICLE STARTING AT 36K MILES AND WAS TOLD THAT THE TIRES HAD TREAD THAT WAS TOO NARROW/WERE HIGH PERFORMANCE WHICH WASN'T NEEDED/WAS ALSO TOLD THAT THE VIBRATION WAS CAUSED BY IMPROPER TIRE CARE AND TIRE CUPPING, THE LEFT REAR SHOCK NEEDED REPLACEMENT, AND THE RADIO GOES OUT-SOMETIMES GOES OUT WHEN THE HEAT IS TURNED UP HIGH. SCC
Suspension, Dec 26, 2002
WHILE TRAVELING ON THE HIGHWAY THE REAR WHEEL WAS MAKING A LOUD NOISE. DUE TO THE WHEEL BEARERS. PLEASE FILL IN ADDITIONAL INFORMATION. DEALER IS AWARE OF THE PROBLEM. TS
Suspension, Service brakes, Air, Fuel system, Other, Electrical system, Structure, Dec 16, 2002
CONTINUED PROBLEMS WITH FORD 200 FOCUS ZTS. BEARINGS, ELECTIRCAL SYSTEM, BRAKE AND PAINT ISSUES AMONG OTHERS.
Suspension, Dec 9, 2002
WHILE DRIVING AT 35/40 MPH , VEHICLE PULLED SHARPLY TO THE RIGHT. CONSUMER LOST CONTROL OF VEHICLE, WHICH RESULTED IN AN ACCIDENT. THE DEALERSHIP INDICATED THAT THIS WAS CAUSED BY THE ENTIRE RIGHT FRONT SUSPENSION SEPARATING FROM THE VEHICLE WHICH INCLUDED THE AXLE, TIE ROD, AND WHEELS. PLEASE PROVIDE MORE DETAILS. TS
Suspension, Nov 17, 2002
REAR SUSPENSION: EVERY 3 MONTHS, DEALER MUST ADJUST SUSPENSION COMPONENTS TO STOP LOUD CRACKING NOISES FROM OCCURING (3+ TIMES) AND MUST BE REPAIRED AGAIN NEXT WEEK. FRONT SUSPENSION HAS BEEN REPAIRED TWICE DUE TO CRACKING/CLUNKING NOISES AND MUST BE REPAIRED AGAIN THIS WEEK. DT
Suspension, Engine and engine cooling, Other or unspecified, Nov 11, 2002
FIRST PURCHASE FOCUS IT HAD A LOUD ENGINE WE TOOK IT BACK AND THEY HAD TO REPLACE TOP OF THE ENGINE. THEN OTHER PARTS OF THE VEHICLE STARTED TO FALL APART. IN A 2 YEAR SPAN, MOSTLY THE OCCURANCES HAPPENED IN THE FIRST YR, MOLDING AROUND THE HEADLIGHTS CAME OFF ALONG WITH THE MOLDING AROUND THE WINDSHIELD BACK AND FRONT, TRUNK WILL NOT SHUT THE MOLDING AROUND THE KEY HOLE FELL OUT AND THE LOCK INSIDE WAS LOOSE(TAKEN IN TWICE ONLY THE LOCK WAS FIXED ONCE THE MOLDING WAS JUST REPLACE THE LAST TIME, STILL WON'T SHUT) IGNITION GOT STUCK KEY WOULD GO IN BUT WOULD NOT TURN, ENGINE IS STALLING ALL DASHBOARD LIGHTS COME ON AND THEN CAR STALLS IN PARK AND JUST STARTING TO MOVE. DT
Suspension, Nov 7, 2002
WHILE DRIVING UNDER NORMAL CONDITIONS, CONSUMER STATES' THERE WAS A SQUEAKING NOISE, ABS LIGHT ILLUMINATED, TIRE WOBBLING. TOOK TO FORD AND THEY STATED THE REAR WHEEL BEARING NEEDED REPLACING. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
Suspension, Nov 6, 2002
WHILE DRIVING THE VEHICLE AT 20MPH THE RIGHT FRONT SUSPENSION COLLAPSE. CAUSING TO PULL OUT OF THE ROAD. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS
Suspension, Nov 4, 2002, crash
CV JOINT CRACKED, LOUD THUD NOISE, CAR FISH-TAILED, CAR HIT GUARD RAIL, SPUN HIT RAIL AGAIN. DT
Suspension, Oct 31, 2002
DURING WHEEL ALIGNMENT MECHANIC NOTICED THE FRONT DRIVER SIDE COIL SPRING WAS BROKEN. BOTH FRONT COIL SPRINGS WERE REPLACED. TS
Suspension, Oct 16, 2002
WHILE TRAVELING ON A SIDE STREET WITHOUT PRIOR WARNING THE VEHICLE FRONT SUSPENSION COLLAPED AND THE RIGHT WHEEL BROKE . THE DEALERSHIP IS AWARE OF THE PROBLEM. MR
Suspension, Oct 15, 2002
VEHICLE HIT A BUMP OR POTHOLE IN THE ROAD AND THE FRONT END WOULD MAKE A LOUD CLUNKING NOISE AS IF SOMETHING HAD COME LOOSE OR HAD FALLEN OFF. MR *TT *JB
Suspension, Oct 9, 2002
CONSUMER STATES ABS LIGHT HAS ILLUMINATED, VEHICLE SHIMMY'S, CONSUMER NOTICED THAT THE RIGHT REAR WHEEL IS WOBBLING. CONSUMER STATES THAT THE WHEEL BEARING GOT SO HOT IT MELTING THE HUB CAP OFF. PLEASE PROVIDE ANY FURTHER INFORMATION. MR
Suspension, Oct 4, 2002
PASSENGER REAR TIRE MAKING NOISE AND WOBBLING. VEHICLE HARD TO CONTROL. PROBLEM WITH WHEEL BEARING. *MR
Suspension, Sep 30, 2002
CONSUMER STATES WHEN TURNING IN EITHER DIRECTION THERE IS NOISE COMING FROM THE FRONT END. VEHICLE HAS NOT BEEN EXAMINED BY DEALER. NLM FORD CHECKED AND SAID THAT THE PROBLEM WAS FROM AN ACCIDENT ON 3-9-2002. MR
Suspension, Sep 18, 2002
WHILE DRIVING AND WITH NO WARNING LEFT REAR WHEEL BEARING SNAPPED, CAUSING TIRE TO WOBBLE. IT WILL BE HARD FOR CONSUMER TO CONTROL VEHICLE. DEALER NOTIFIED. *AK CONSUMER STATES THERE WAS EXTENSIVE DAMAGE CAUSED TO THE LEFT REAR WHEEL ASSEMBLY, BEARINGS, HUB, BRAKE SHOES AND WHEEL SPEED SENSOR. *YH
Suspension, Sep 10, 2002
FRONT COIL SPRING BROKE, ALSO CUTTING THE ABS SENSOR WIRE. *JG
Suspension, Sep 5, 2002
BOTH REAR WHEEL BEARINGS HAD TO BE REPLACED.*AK *JB
Suspension, Engine and engine cooling, Aug 26, 2002
CONTROL ARM FAILURE RESULTED IN TIRES NEEDING TO BE REPLACED, THOUGH THEY HAD LESS THAN 20,000 MILES. FORD WOULD NOT WARRANTY THEM AND FIRESTONE WOULD NOT HONOR WARRANTY DUE TO DAMAGE BEING CAUSED BY DEFECT IN THE CAR. THE PROBLEM WITH THE ENGINE STARTING AND/OR DYING HAS JUST BEGUN IN RECENT MONTHS AND SEEMS TO BE GETTING WORSE.*AK
Suspension, Other or unspecified, Aug 22, 2002
LAST MONTH, I REPLACED THE RIGHT REAR WHEEL BEARING ON MY FORD FOCUS WHEN IT FAILED. I HAVE HEARD REPORTS THAT OTHER PEOPLE HAVE HAD THE SAME PROBLEMS, AND I BELIEVE THIS PROBLEM IS RELATED TO A FLAW IN DESIGN. MORE DANGEROUS THAN THAT, THOUGH, IS THE PROBLEM I HAD WITH THE FUEL SYSTEM. THE CAR LOST POWER ON SEVERAL OCCASIONS AFTER RIGHT-HAND TURNS OR GOING UPHILL. IT DID NOT STALL, SIMPLY SPUTTERED AND LOST POWER FOR BETWEEN 2-5 SECONDS. ONE OF THE MOST FRIGHTENING INCIDENTS HAPPENED WHEN MY HUSBAND AND I WERE MERGING ONTO THE CAPITAL BELTWAY ON OUR WAY TO VISIT FRIENDS, AND THE CAR LOST POWER, NEARLY CAUSING AN ACCIDENT. I TOOK THE CAR TO THE DEALER AND THEY WERE QUITE FAMILIAR WITH THE PROBLEM, AS FORD HAS ISSUED A SERVICE BULLETIN ABOUT IT. THE REPAIRS COST OVER $425, AND INVOLVED REPLACEMENT OF THE FUEL PUMP AND COMPLETE FLUSH OF THE FUEL TANK. I WAS TOLD THAT FORD CLAIMS THE PROBLEM IS CREATED BY CONTAMINATED GASOLINE, WHICH MEANS THAT AT ANY TIME, THIS PROBLEM COULD RESURFACE. I AM FRIGHTENED TO DRIVE THE VEHICLE IN TRAFFIC OR ON THE HIGHWAY, BECAUSE MY CONFIDENCE IN ITS SAFETY HAS BEEN SHATTERED BY THIS PROBLEM. I BELIEVE THAT FORD IS AWARE OF THIS SAFETY ISSUE AND SHOULD ISSUE A RECALL ON THE FAULTY SYSTEM.*AK
Suspension, Aug 21, 2002
REAR WHEEL BEARING WAS MAKING NOISE. TOOK VEHICLE TO DEALER, AND THEY STATED THAT REAR BEARING NEEDED REPLACEMENT. *AK CONSUMER STATED THAT WHEEL BEARING WENT OUT AND WAS REPLACED. *YH
Suspension, Aug 19, 2002
DEALERSHIP SAD PARTS TO RECALL 01I017000 CONCERNING REAR WHEEL BEARING FAILURE ARE ON BACK ORDER.*AK
Suspension, Aug 16, 2002, crash
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Suspension, Aug 15, 2002
WHILE DRIVING 45MPH, WHEEL SHAKES AND MAKES LOUD NOISES. *AK THE WHEEL BEARING SPONTANEOUSLY LOOSENED. THE DEALER REPAIRED THE PROBLEM PROMPTLY. *JG