2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: suspension
386 reports, newest first. Show all
Suspension, Feb 15, 2002
RECEIVED A RECALL LETTER OCTOBER 2000, RELATED TO THE INSUFFICIENT WHEEL BEARING CLAMP LOAD. THIS WOULD ALLOW THE LEFT REAR WHEEL AND DRUM ASSEMBLY TO SEPERATE FROM THE VEHICLE. PRIOR TO SEPERATION A LOUD GRINDING NOICE OR CLUCKING NOISE FROM THE REAR OF THE VEHICLE AND THE REAR WHEEL WOBBLING. SOME KIND OF DEFECT ON THE WHEEL BEARING BUT ON THE RIGHT REAR WHEEL.
Suspension, Feb 12, 2002
THIS CAR IN SNOWY/ICY CONDITIONS BECOMES IN SOME CASES NEARLY UNCONTROLABLE. IT CONSTANTLY SWAYS FROM SIDE TO SIDE AND THE BACK END TRIES TO COME AROUND. I LOVE THIS CAR ON THE DRY BUT IN THE SLICK CONDITIONS IS BECOMES THE WORST CAR I'VE EVER OWNED. THERE MUST BE SOMETHING FUNDAMENTALLY WRONG WITH IT. IT HAS BEEN THIS WAY SINCE NEW. I'VE HAD EVERYTHING CHECKED ON IT, INSTALLED NEW TIRES ETC. AND NOTHING SEEMS TO HELP. THIS IS SUPPOSE TO BE A LOW COST CAR FOR THE 1ST TIME CAR BYER BUT I'D NOT RECOMMEND IT TO ANYONE MUCH LESS AN ENEXPERENCED DRIVER. I WILL NOT LET MY 16 YEAR OLD DRIVE IT IF THE CONDITIONS ARE EVEN A LITTLE SLICK. IT CAN BE A TERRIFYING CAR TO DRIVE. *AK
Suspension, Jan 31, 2002
THERE IS A CLINKING NOISE COMING FROM REAR. CONSUMER TOOK OFF HUB CAP, AND NOTICED WHEEL BEARING NUTS WERE MISSING FROM RIGHT REAR TIRE. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
Suspension, Structure, Jan 28, 2002
FRONT END WAS FALLING OFF. CONTACTED DEALER, AND DEALER DID NOT THINK THAT THERE WAS ANYTHING WRONG WITH VEHICLE. BUT, WHEN SHAKING THE BUMPER SCREWS COME LOOSE.*AK
Suspension, Jan 14, 2002
WHILE DRIVING 65MPH OVER A BUMP IN THE ROAD BACK END OF VEHICLE WILL SHIFT TO ONE SIDE. DEALERSHIP WAS CONTACTED.*AK
Suspension, Jan 9, 2002
MY 2000 FORD FOCUS WAS NOT INCLUDED IN THE RECALL OF THE LEFT REAR WHEEL BEARING. BUT IT SHOULD HAVE BEEN. MY CAR BROKE DOWN ON FRIDAY JAN4 TH WHEN I GOT IT TO THE FORD MECHANIC HE SSAID THE PROBLEM WAS THE LEFT REAR WHEEL BEARING, WHICH IS THE EXACT SAME PART OTHER FOCUS ARE BEING RECALLED FOR. THE MECHAINC ALSO TOLD ME WHAT COULD HAVE HAPPENED WITH THE TIRE COMING OFF WHILE I WAS DRIVING. I FELT THIS WAS A SAFETY ISSUE AND CALLED FORD THEY SAID SINCE MY CAR WASN'T ON THE RECALL LISTS THERE WAS NOTHING THEY COULD DO EVEN THOUGH THE PART THAT BROKE IS THE SAME PART THAT WAS RECALLED ON OTHER FOCUS AND MY CAR ONLY HAS 42212 MILES ON IT AND BEARINGS SHOULD NOT BREAK DOWN THAT SOON. SO I FEEL THAT THIS IS A SAFETY ISSUE THAT NEEDS TO BE DELT WITH *AK
Suspension, Dec 28, 2001
TIRE CAME OFF IN DRIVEWAY WITH LITTLE WARNING - THIS CAR HAS SHOULD NOT HAVE NEEDED BEARING REPLACEMENT THIS SOON. A NEW DESIGN NEEDS DEVELOPMENT INSTEAD OF REPLACEMENT OF BEARINGS FOR 2 YEARS AS FORD HAS ANNOUNCED. A RECALL WAS SENT TO OWNERS IN A COLORFUL FLIER LIKE ADVERTISEMENT. THIS IS INAPPROPRIATE DUE TO THE FACT IT LOOKED LIKE AN AD NOT LIKE A RECALL PREVIOUSLY ISSUED BY FORD INSIDE A BROWN ENVELOPE CORRECTLY LABELED, ADDRESSED AND SENT TO OWNERS. THIS CAR IS A LEMON.*AK
Suspension, Dec 20, 2001
WHILE TRAVELING AT 40-50 MPH, THERE WAS SOME EXTREME VIBRATION WHICH OCCURRED IN FRONT END, CAUSING LOSS OF VEHICLE CONTROL. PLEASE PROVIDE MORE INFORMATION.*AK
Suspension, Dec 18, 2001
RECALL 00 V 303 000/REAR WHEEL BEARINGS. DEALER METRO FORD, SCHENECTADY, NY; PHONE# 382-1010 UNABLE TO HONOR RECALL BECAUSE NO PARTS WERE AVAILABLE. SEEKING NHTSA HELP IN THIS MATTER. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION CONCERNING THIS MATTER.*AK
Suspension, Dec 18, 2001
ONGOING PROBLEM WITH VEHICLE COMMENCING TO WOBBLE WHEN IT REACHES 50 MPH OR MORE. VEHICLE BEEN TO DEALER SHOP ON THREE OCCASIONS, AND THE PROBELM STILL REOCCURRING. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
Suspension, Wheels, Nov 28, 2001
REAR WHEELS WOBBLE WHEN CONSUMER IS DRIVING, THIS PROBLEM CAN HAPPEN AT ANY SPEED. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO ANYTHING. *AK DEALER PERFORMED RECALL 00S55B REPAIRS. CONSUMER ADDS THAT VEHICLE PULLS TO LEFT AND STEERING WHEEL IS OFF CENTER. *TT
Suspension, Nov 27, 2001
CONSUMER HAD TAKEN VEHICLE TO DEALER FOR SOME STEERING PROBLEMS THAT HAD EXPERIENCED AT THE TIME OF DRIVING AND KEEPING CONTROL OF VEHICLE. DEALER HAD DETERMINED THAT PROBLEM WAS WITH FRONT BEARINGS, THEN FIXED THEM. PLEASE PROVIDE MORE INFORMATION. *AK
Suspension, Electrical system, Vehicle speed control, Other or unspecified, Nov 20, 2001
TIRES WEARING OUT FAST, ACCELERATED SPEED, AND ENGINE KILL, UNEVEN SUSPENSION, INDICATOR GAUGES AND LIGHTS HAYWIRE. I WAS TOLD BY FORD THAT I HAD WRECKED THE CAR AND HAD TO PAY $883.00 FOR REPAIRS + $350.00 FOR NEW TIRES.*AK
Suspension, Oct 30, 2001
FIRST FAILURE(18,925 MILES)- LOUD MOAN COMING FROM REAR OF VEHICLE WHILE DRIVING. TOOK VEHICLE TO DEALER WHERE RIGHT REAR WHEEL BEARING WAS REPLACED. SECOND FAILURE(28,218MILES)- LOUD GRINDING AND CLUNKING SOUND FROM REAR OF VEHICLE. RIGHT REAR WHEEL LOCKED UP. DEALER REPLACED RIGHT REAR WHEEL BEARING AGAIN.*AK
Suspension, Tires, Sep 26, 2001
CONSUMER HEARD A RATTLING NOISE COMING FROM FRONT TIRE. DEALERSHIP REPLACED WHEEL BEARING. DEALERSHIP WAS AWARE OF PROBLEM.*AK
Suspension, Sep 25, 2001
VEHICLE IS MAKING A THUMPING NOISE WHEN DRIVING. VEHICLE SOUNDS AS IF RUNNING OVER BUMPS IN ROAD. CONTACTED DEALER AND, DEALER STATED THEY CAN'T FIX THE PROBLEM UNTIL THEY FIND OUT WHAT THE PROBLEM IS. PLEASE ADD.*AK
Suspension, Tires, Sep 19, 2001
TIRES ON VEHICLE IS WEARING DOWN. REAR WHEEL BEARING WENT BAD AND HAD TO REPLACE THEM. TIRES HAD BEEN REPLACED TWICE. CONTACTED DEALER, AND DEALER STATED NEVER HEARD OF PROBLEM BEFORE.*AK
Suspension, Aug 16, 2001
WHEN DRIVING 50 MPH OR ABOVE FRONT END VIBRATES, AND VEHICLE PULLS TO THE RIGHT. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK
Suspension, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Exterior lighting, Structure, Tires, Aug 14, 2001
WHILE CONSUMER WAS DRIVING GAS TANK COVER BLEW OFF THE TANK AND GAS WAS SPILLING EVERY WHERE.*AK CONSUMER STATES VEHICLE HAS EXPERIENCED PROBLEMS WITH THE SENDING UNIT AND GAS GAUGE. WHEEL BEARINGS ON THE LEFT REAR FAILED. TRANSMISSION FLUID LEAKS, CONSUMER STATES THIS IS CAUSING SLIPPAGE AND SHIFTING PROBLEMS. VEHICLE EXPERIENCES A BURNING OIL SMELL. WIRING HARNESS FAILURE. LIGHT FAILURE (CONSUMER DID NOT SPECIFY). GAS LEAKS. FAILED SUSPENSION PARTS (CONSUMER DID NOT SPECIFY). TIRES WEAR PREMATURELY (CONSUMER DID NOT GIVE TIRE INFORMATION). SPLASH SHIELDS BROKE. BROCKING WIRES IN CENTRAL LOCKING SYSTEM. *SLC
Suspension, Service brakes, Hydraulic, Exterior lighting, Visibility, Seat belts, Structure, Seats, Jul 12, 2001
WAS TRAVELING APPROXIMATELY 65MPH WHEN VEHICLE WENT OUT OF CONTROL. WHEELS HAD FELT WOBBLELY AND LOOSE. HAD TO SWERVE TO MISS SEVERAL VEHICLES. MANAGED TO GET OFF FREEWAY AND STOPPED VEHICLE. HAD VEHICLE TOWED TO DEALERSHIP. WAS INFORMED BY MECHANIC WHEEL BEARINGS WENT OUT. DEALERSHIP HAS TO ORDER PARTS. VEHICLE WAS REPAIRED PREVIOUSLY UNDER RECALL.*AK SCREWS KEEP FALLING OUT OF SEAT BELT AND HAS HAPPENED TWO TIMES. DRIVERS SIDE SEAT LEVER KEEPS BREAKING AND HAS HAPPENED THREE TIMES. WINDSHIELD WIPERS FAILED WHILE DRIVING DURING A HEAVY RAIN STORM, RECEIVED RECALL TWO WEEKS LATER, 01V258, DEALER REPLACED WIPER MOTOR. TURN SIGNAL FAILED, DEALER REPLACED BULB. PROBLEMS WITH BRAKES, REAR DRUM ASSEMBLY BEARING WORE INTO WHEEL SPINDLE, FRONT BRAKE PADS REPLACED, FRONT ROTORS RESURFACED. CONSUMER FEELS EVERY BUMP IN THE ROAD. BEARINGS HAVE FAILED TWICE. SIDE MIRROR BROKE. A-PILLAR TRIM COMING LOOSE AFTER RECALL REPAIR 00S20. *SLC
Suspension, Fuel system, Gasoline, Electrical system, May 22, 2001
RIGHT REAR WHEEL BEARING CAUSED CAR TO SWERVE VIOLENTLY AT 55MPH, DRIVER SLOWED TO 20MPH TO AVOID BEING PULLED OFF ROAD. DRIVER TRIED TO SLOWLY DRIVE TO REPAIR STATION BUT CAR KEPT WOBBLING ON ROAD SO STOPPED AND HAD CAR TOWED INTO GARAGE..IGNITION /LOCK SYSTEM FAILED IN JANUARY AND LEFT DRIVER STRANDED. CAR COULD NOT BE STARTED. IN ANOTHER PROBLEM THAT OCCURED IN OCTOBER 2000 THE FUEL ASSEMBLY RECALL WAS NOT PROPERLY REPAIRED AND CAUSED CAR ACCELERATOR TO NOT FUNCTION. THE CAR WOULD ONLY GO 1-3MPH AT FULL ACELLERATION. THIS WAS VERY DANGEROUS IN TRAFFIC. I DO NOT HAVE PAPERWORK ON THIS INCIDENT BUT PROBLEM WAS CORRECTED AT BERGSTROM FORD, NEENAH, WI 54956*AK
Suspension, May 16, 2001
AT 15,000 MILES CONSUMER NOTICED STEERING WAS SHAKING. A FEW MILES LATER, CONSUMER WAS MAKING A LEFT HAND TURN WHEN STEERING WHEEL CONTINUED TO TURN LEFT, WHEEL COULD BE TURNED ALL WAY AROUND. CONSUMER WAS TOLD ALIGNMENT WAS TOTALLY GONE. *AK
Suspension, Service brakes, Hydraulic, May 16, 2001
BRAKES WERE SQUEAKING AT 10,000 MILES. TOOK VEHICLE TO DEALER, BUT WAS TOLD IT WAS A NORMAL CHARACTERISTIC. AT 22,000 MILES, CONSUMER TOOK VEHICLE TO DEALER FOR ANOTHER PROBLEM WITH ALIGNMENT. CONSUMER WAS TOLD BY DEALER THAT BRAKES WERE DOWN TO METAL. PLEASE PROVIDE FURTHER INFORMATION.*AK
Suspension, May 14, 2001
AT HIGHWAY SPEEDS STEERING WHEEL WILL JUMP, CAUSING VEHICLE TO SWAY FROM SIDE TO SIDE. DEALER HAS REPLACED SEVERAL PARTS OF FRONT END, AND THE PROBLEM STILL EXISTS.*AK
Suspension, May 7, 2001
DRIVER'S SIDE REAR WHEEL BEARINGS WENT OUT WHILE DIVING 60 MPH. CONSUMER HEARD A NOISE FROM WHEEL, AND VEHICLE WAS HARD TO CONTROL. ON 6 MAY 2001, THIS HAPPENED AGAIN WITH PASSENGER SIDE REAR WHEEL BEARINGS. THERE WAS A RECALL ON WHEEL BEARINGS, BUT THIS VEHICLE WAS NOT AFFECTED DUE TO VIN. *AK *JB