2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: suspension
386 reports, newest first. Show all
Suspension, Apr 28, 2005
THE LEFT FRONT TIRE FELL OFF UNEXPECTEDLY WHILE THE VEHICLE WAS BEING PARKED. RESULTS SHOWED THAT THE FRONT COIL SPRING BROKE OFF THE VEHICLE. *AK *SC *JB
Suspension, Apr 13, 2005
FROM WHAT I CAN UNDERSTAND ABOUT RECALLS ON FORD FOCUS MODELS, THERE HAS BEEN A RECALL ON THE ISSUES OF WHEEL BEARINGS. THE LAST TIME I VISITED A FORD DEALERSHIP FOR SERVICE THIS RECALL WAS NOT MENTIONED AS NEEDING TO BE DONE OR AS TAKEN CARE OF ON THE SERVICE TICKET, SO I ASSUMED THAT THE PROBLEM WAS TAKEN CARE OF. HOWEVER, ON A VISIT TO MY LOCAL MECHANIC, HE TOLD ME THAT I WOULD NEED NEW WHEEL BEARINGS IN THE NEAR FUTURE. SO FROM THIS I CAN ONLY ASSUME THAT THE PROBLEM WAS TAKEN CARE OF ONCE AND NOW HAS TO BE TAKEN CARE OF AGAIN. AND THIS IS ON A VEHICLE WITH ONLY 73,000 MILES. THE VEHICLE IS 2000 FOCUS ZX3 5 SPEED. ALSO THE VEHICLE WAS BOUGHT USED IN DEC. 2003 WITH 49,000 MILES ON THE ODOM. THANK YOU FOR YOUR TIME. *AK
Suspension, Apr 6, 2005
THE REAR SHOCKS ARE MAKING NOISES AND ARE CUPPING THE REAR TIRES. I HAVE REPLACED THE REAR TIRES ONCE AND THEY ARE GETTING DESTROYED AGAIN. I PLAN TO REPLACE THE REAR SHOCKS WHEN I CAN AFFORD IT.*AK
Suspension, Apr 6, 2005
THE FRONT SUSPENSION HAS BEEN MAKING POPPING AND GRONING SOUNDS LEADING UP TO THE PROBLEM. THEY WERE VERY LOUD WHEN GOING OVER BUMPY ROAD. THE FAILURE HAPPENED WHEN WE WENT TO PULL AWAY FROM A STOP SIGN. THE LEFT FRONT SPRING BROKE WITH A LOUD BANGING SOUND. THE CAR PULLED SLIGHTLY TO THE RIGHT BUT WAS STILL CONTROLABLE. TO FIX THE PROBLEM WE HAD TO REPLACE THE FRONT SPRINGS AND STRUTS. I REPLACED BOTH SIDES OF THE CAR FOR FEAR THAT THE OTHER SIDE WOULD BREAK WHILE I WAS ON THE HIGHWAY. *AK
Steering, Suspension, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Visibility, Air bags, Seat belts, Latches/locks/linkages, Equipment, Apr 6, 2005, crash, fire
FATALITY VEHICLE FIRE, DEC. 8 2004. MY HUSBAND IS THE ORIGINAL OWNER OF A 2000 FORD FOCUS, SUBJECT TO NUMEROUS SERVICE VISITS TO BILL BROWN FORD, LIVONIA MI FOR: IGNITION, STEERING COLUMN, WHEEL BEARING, BRAKE, REAR WINDOW CONTROL, SEAT BELT &TRUNK LATCHES, OVERHEAD LIGHT AND ENGINE LIGHT. THE VACUUM LINE & FUEL PUMP & VALVE ASSEMBLY WERE REPLACED 2/03, FOLLOWED BY STALLING. IN 6/03, A/C COMPRESSOR & MANIFOLD LINE REPLACED. FUEL LINE & PUMP FAILURE IN 8/03, RESULTED IN GASOLINE SPILL ON RESIDENTIAL STREET MINUTES AFTER PARKING. BOGGING FOLLOWED REPAIRS, PCM REPROGRAMMED & LEAKING PVC TUBE REPLACED 1/04. FUEL PUMP AGAIN REPLACED. IN 8/04, OUR 24 YEAR OLD SON TOOK OWNERSHIP OF THIS PROBLEMATIC CAR. WE ARE UNCERTAIN AS TO WHETHER VEHICLE MALFUNCTION CAUSED A 35 MPH COLLISION WITH A FIRE HYDRANT. AN IMMEDIATE ENGINE EXPLOSION AND FUEL FED FIRE TRAPPED MY SON AND HIS PASSENGER. DESCRIBED BY POLICE AS A RELATIVELY MINOR CRASH WHICH WOULD NOT BE EXPECTED TO CLAIM LIVES, THE SUBSEQUENT UNEXPLAINED ENGINE FIRE CLAIMED TWO YOUNG LIVES. A MALFUNCTIONING DRIVER'S AIRBAG WAS ALSO DETECTED. THIS INCIDENT WAS ORIGINALLY REPORTED TO NHTSA BY MY HUSBAND (#10104088). I AM SUPPLYING THESE ADDITIONAL FACTS FOR YOUR CLARIFICATION. PLEASE CORRECT YOUR POSTING OF "0" INJURIES AS THERE WERE 2 FATALITIES. PLEASE TAKE EFFECTIVE ACTION TO SAVE LIVES, AS THESE TROUBLE PLAGUED VEHICLES SEEM TO BECOME MORE LETHAL AS THEY AGE. CONFIRMATION OF RECEIPT OF THIS INFORMATION IS REQUESTED. *NM *SC *JB
Suspension, Mar 10, 2005
1. SEVERAL LOUD POPPING NOISES EVERY TIME THE STEERING WHEEL TURNED FROM LEFT TO RIGHT OR RIGHT TO LEFT FULL. 2. DRIVERS SIDE COIL SPRING BROKE, 3. REPLACES FRONT COIL SPRINGS.*AK
Suspension, Feb 8, 2005
IN 2000 I BROUGHT MY FORD FOCUS 2000 IN FOR A RECALL ON THE LEFT REAR WHEEL BEARING. THE DEALER SUPPOSEDLY FIXED THE PROBLEM. IN 2001, MY RIGHT REAR WHEEL ALMOST COMPLETELY SEPARATED FROM MY VEHICLE, AND THE CAR FISHTAILED WHEN DRIVEN. I BROUGHT THE CAR INTO A FORD DEALER WHO DIAGNOSED THE PROBLEM AS A BAD BEARING IN THE RIGHT REAR WHEEL. THEY REPLACED THE BEARING, ABS SENSOR, AND SPINDLE UNDER WARRANTY. ON FEB 3, 2005, MY ABS LIGHT CAME ON, FOLLOWED BY LOUD METALLIC POPPING AND GRINDING NOISES WHEN BRAKING OR ACCELERATING. THE CAR DID NOT SEEM SAFE TO DRIVE, SO I IMMEDIATELY BROUGHT THE CAR INTO THE NEAREST FORD DEALER. THE PROBLEM WAS AGAIN DIAGNOSED AS A FAULTY BEARING IN THE LEFT REAR WHEEL, THE VERY SAME THAT WAS REPLACED IN 2000. THIS CAUSED THE ABS SENSOR TO GO BAD AND NOTCHED LARGE CHUNKS OF METAL OUT OF THE SPINDLE, AND POTENTIALLY COULD HAVE CAUSED FAILURE OF THE BREAKS OR COMPLETE SEPARATION OF THE WHEEL FROM THE VEHICLE. THE DEALER CLAIMED THERE WAS NOTHING WRONG WITH THE DESIGN OR THE BEARINGS BEING PUT IN, AND IT WAS JUST COINCIDENCE THAT I HAD TO BRING IT IN 3 TIMES FOR PROBLEMS WITH 3 IDENTICAL BEARINGS. THEY OBVIOUSLY HAVE NOT SOLVED THE PROBLEM IDENTIFIED IN THE 2000 RECALL, BUT HAVE GOTTEN AROUND IT WITH 12 MONTH WARRANTY PERIODS, FORCING CUSTOMERS TO REPLACE THE BEARINGS SPENDING OVER $650 A POP EVERY YEAR OR SO.*AK
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Tires, Jan 31, 2005
THE VEHICLE'S BRAKES HAD TO BE REPLACED ABOUT EVERY THREE MONTHS. *NM THE REAR END WAS UNABLE TO BE LINED UP, IF SO, THE VEHICLE WOULD FISHTAIL BACK AND FORTH AND THE CONSUMER WOULD UNABLE TO DRIVE THE VEHICLE. THE TIRES WERE OUT OF ROUND AND THE VEHICLE WOULD RUN ROUGH, ESPECIALLY WHEN GOING UP HILLS. *SC *JB
Suspension, Jan 31, 2005
VEHICLE IS LOSING ITS FRONT BEARINGS. THERE IS A NOISE COMING FROM THE FRONT OF THE VEHICLE. OWNER TOOK THE VEHICLE TO THE DEALER, WHO CONFIRMED THIS DEFECT. VEHICLE IS NO LONGER UNDER WARRANTY, AND DEALERSHIP IS ASKING FOR $700.00 TO DO REPAIRS.*AK
Suspension, Jan 27, 2005
REAR WHEEL BEARINGS FAILED,RESULTING IN REAR WHELL WOBBLE. *AK. THIS FAILURE MAD EIT HARD TO CONTROL VEHICLE. OWNER NOTIFIED MANUFACTURER. *AK
Suspension, Electrical system, Jan 22, 2005
COMING HOME FROM WORK MY ENGINE LIGHT CAME ON , I TOOK IT TO A FRIEND AND HE CHECK IT AND SAID IT WAS AS CYLINDER MISFIRE HE RESET HE CODE(?) AND SAID THAT HE DIDN'T GUARANTEE THAT IT WOULDN'T COME BACK ON . IT WORK FINE THE REST OF THE DAY , BUT WHEN I WAS AGAIN COMING HOME FROM WORK THE NEXT DAY IT CAME ON AGAIN ,I IMMEDIATELY TURN AROUND AND TOOK IT TO THE GARAGE WHERE I GET REPAIRS DONE . HE ALSO SAID IT WAS A CYLINDER MISFIRE AND SUGGESTS I REPLACE MY SPARK PLUGS AND WIRES , HE ALSO CLEANED SOMETHING ELSE AND SOMETHING IAC ( YOU CAN TELL I DON'T KNOW SQUAT ABOUT CARS)I PAID 149.00 FOR THIS SERVICE . A DAY AND HALF LATER I WAS BACK IN THE GARAGE WITH THE SAME PROBLEM (ENGINE LIGHT ON) THIS TIME HE SAYS IT SOMETHING WITH MY TRANSMISSION CODE AND TO CALL THE CO. AND SEE IF THERE IS OR WAS A RECALL ON IT . SOME THING ABOUT FLASHING THE COMPUTER. I HAVE ONLY HAD THIS CAR SINCE AUGUST 2004 AND HAVE TROUBLE WITH ALL THIS AND WITH THE KEY NOT WORKING BUT THE CAR WAS STILL UNDER A 30 DAY WARRANTY AND THE CAR SALESMAN TOOK CARE OF THAT PROBLEM. I AM JUST WONDERING WHAT NEXT ,HOW MUCH , MONEY DOES NOT GROW ON TREES AROUND HERE. AFTER READING ALL THE COMPLAINTS ON THIS HERE WEBSITE I WONDER WHY I EVEN BOUGHT A FORD FOCUS. I ALSO HAVE VERY SQUEAL BRAKES CONSTANTLY , AND MY REAR PASSENGER TIRE HAS A PROBLEM AND MY SON WON'T EVEN LET ME DRIVE MY CAR TILL I GET IT CHECK OUT THERE IS MORE MONEY. MY CAR ONLY HAS 44,000. MILES ON IT. *JB
Suspension, Jan 21, 2005
COMPLAINT RECEIVED VIA E-MAIL."MY CAR STARTED MAKING A TERRIBLE SCREECHING NOISE. FORTUNATELY, I WAS WITHIN 1/4 MILE FROM A MECHANIC, SO I PULLED IN THERE. THE MECHANIC, DAN, TOLD ME THE FRONT SPRINGS HAD BROKEN ON THE CAR, AND HE EVEN SHOWED ME JUST HOW CLOSE ONE OF THE SPRINGS HAD GOTTEN TO PUNCTURING A TIRE. HAD I DRIVEN TO NAPPANEE, I BELIEVE THE SPRING WOULD HAVE PUNCTURED THE TIRE. WE BOTH LOOKED ON THE INTERNET FOR RECALL INFORMATION SINCE BROKEN SPRINGS SEEMED SO ODD. NOTHING WAS THERE, SO I PAID OVER $300.00 OUT OF POCKET FOR THE REPAIR. NOW, I SEE CARS LIKE MINE ARE HAVING PROBLEMS WITH THE SPRINGS, AND THAT FORD IS COVERING THESE KIND OF REPAIRS FOR TEN YEARS OR 150,000 MILES. I DIDN'T KNOW THAT WHEN I PAID FOR THE REPAIR. I WANT REIMBURSEMENT, BUT MORE IMPORTANTLY, I WOULD LIKE TO SEE FORD MOTOR COMPANY ACKNOWLEDGE THIS SERIOUS SAFETY PROBLEM THROUGH A RECALL RATHER THAN A SERVICE BULLETIN. I CALLED FORD JUST TODAY, AND THE SERVICE PERSON SAID TO TAKE ORIGINAL REPAIR BILLS TO MY DEALER'S SERVICE MANAGER FOR REVIEW. THE DEALER IS SUPPOSED TO SEND THEM TO FORD WHERE A REIMBURSEMENT DECISION WILL BE MADE. THIS CONCERNS ME. I DON'T UNDERSTAND WHY IN THE WORLD THIS OBVIOUS SAFETY MATTER HAS NOT BEEN MADE A RECALLED ITEM. I DIDN'T KNOW THE SPRINGS WERE BROKEN UNTIL THE MECHANIC TOLD ME. SPRINGS, I DO NOT BELIEVE, ARE SOMETHING THE COMMON ORDINARY PERSON CHECKS DURING OIL CHANGES. I WOULD LIKE TO SEE FORD INITIATE AN IMMEDIATE RECALL FOR THE SPRINGS SINCE IT'S SUCH AN IMMEDIATE SAFETY CONCERN. HAD I DRIVEN ON THOSE BROKEN SPRINGS MUCH LONGER AND HAD I BEEN GOING FASTER THAN TOWN SPEEDS, I PROBABLY WOULD NO T BE HERE TO WRITE THIS LETTER TODAY. MY CAR HAS BEEN GREAT OVERALL. YES, I'VE HAD A LOT OF RECALL WORK, BUT I STILL LIKE THE CAR AND DO NOT REGRET BUYING IT. I MIGHT BUY ANOTHER FOCUS. BUT STILL, I THINK FORD IS WRONG FOR NOT DOING A RECALL ON THE SPRINGS." *NM
Suspension, Jan 5, 2005
BROKEN FRONT AND REAR COIL SPRING. EEDED TO REPLACE WITH NEW FRONT AND REAR COIL SPRINGS.*AK
Suspension, Electrical system, Dec 20, 2004
AFTER HAVING THE VEHICLE SERVICED ON TWO DIFFERENT RECALLS VEHICLE PERFORMED POORLY. THE FIRST RECALL WAS FOR BATTERY WIRING CORROSION. CURRENTLY, THE BATTERY FAILED. THE SECOND WAS FOR THE PIN BOLT CONTROLS. STEERING WHEEL SHOOK, AND THE TWO LEFT FRONT TIRES WERE REPLACED FOR EXTENSIVE WEAR, AND A BLOW OUT. THE TIRES WERE REPLACED, AND THE VEHICLE ALIGNED. HOWEVER, VEHICLE CONTINUED TO WEAR OUT, THE TIRES AND THE STEERING WHEEL SHOOK. MANUFACTURER OFFERED NO SOLUTION. NO RECALLS FOUND. *AK.....ALSO, WAS EXPERIENCING PROBLEMS WITH DECREASED POWER. CONSUMER OBJECTED TO PAYING FOR REPAIRS. *AK
Suspension, Dec 15, 2004
FORD EXTENDED THEIR WARRANTY ON REAR WHEEL BEARINGS ON THE 2000 FORD FOCUS, BEACUSE OF PROBLEMS AND SAFETY ISSUES WHICH COULD LEAD TO BALL JOIONT SEPARATION WITH LOSS OF STEERING CONTROL. MY VEHICLE IS NOW EXPERIENCING REAR WHEEL BEARING PROBLEMS, BUT FORD REFUSES TO HAVE THE PROBLEM FIXED AT THEIR EXPENSE, BECAUSE THE EXTENDED WARRANTY PERIOD HAS EXPIRED.*AK
Suspension, Dec 15, 2004
CONSUMER HAS CONTINUOUSLY REPLACED THE WHEEL BEARINGS. TWICE ON THE REAR LEFT, AND THREE TIMES ON THE REAR RIGHT. THERE IS A GRINDING NOISE COMING FROM THE REAR END OF THE VEHICLE. CONSUMER STATES THAT HE HAS HAD THE VEHICLE REPAIRED ON A RECALL NUMBER 011017000 BEFORE. THE PROBLEM HAS NOT BEEN RESOLVED. *NM AT THE TIME OF THE FAILURE THE VEHICLE WAS OUT OF WARRANTY ALTHOUGH IT ONLY HAD 27,000 MILES. THE VEHICLE IS RARELY DRIVEN YET THE REAR BEARINGS WEAR OUT EVERY 3000-5000 MILES. *NM
Suspension, Nov 30, 2004
WHEN TURNING IN EITHER DIRECTION A RUBBING SOUND WAS PRODUCED. THE DEALER STATED THE FRONT STRUTS NEED TO BE REPLACED, BUT THE PART WAS ON BACK ORDER. *JB THE SPRINGS WERE BROKE ON THE DRIVER'S SIDE. 2 STRUTS, 2 SPRINGS, 2 SWAY BAR LINKS AND ALIGNED THE FRONT END WERE REPLACED. THE CONSUMER REQUESTED REIMBURSEMENT. *SC
Suspension, Nov 24, 2004
SPRING ON FRONT PASSENGER SIDE BROKE. COULD HAVE POPPED TIRE CAUSING LOSS OF CONTROL OF VEHICLE. *NM
Suspension, Oct 18, 2004
WHILE DRIVING APPROXIMATELY 35 MPH THE CONSUMER HEARD A NOISE WHICH SOUNDED AS IF IT CAME FROM REAR. THE CONSUMER TOOK THE VEHICLE TO DEALERSHIP AND WAS INFORMED BY A MECHANIC THAT THE REAR WHEEL BEARINGS WERE LOOSE. *JB
Suspension, Oct 14, 2004
WHILE DRIVING, THE RIGHT REAR WHEEL FELL OFF. AFTER THE VEHICLE WAS SERVICED IT WAS DISCOVERED THE SUSPENSION WAS DEFECTIVE. THE WHEEL BEARING HAD FAILED. *JB
Suspension, Oct 12, 2004
THE FRONT RIGHT COIL SPRING HAS BROKE. THE CONSUMER HAS CONTACTED THE FORD MANUFACTURER AND WAS TOLD THAT THEY WOULD NOT DO ANYTHING. CONSUMER SAYS THAT FORD EXTENDED THE WARRANTY, BUT HIS DID NOT COMPLY DUE TO THE YEAR IT WAS BUILT. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB
Suspension, Oct 4, 2004
WHILE DRIVING AT LOW SPEEDS FRONT COIL SPRING SNAPPED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.*AK
Suspension, Tires, Oct 3, 2004
1) NOISE COMING FROM RIGHT FRONT 2) BOTH FRONT SPRINGS AND STRUTS HAD TO BE REPLACED BECAUSE THE RIGHT FRONT SPRING HAD BROKEN AND CUT THE RIGHT FRONT TIRE DOWN THE MIDDLE (WHICH ALSO HAD TO BE REPLACED). THE SPRING ALSO BENT THE STRUT.*AK 3) ALL OLD PARTS ARE AVAILABLE - SEE #2 FOR WHAT WAS DONE TO CORRECT FAILURE. REPAIRS HAD TO BE MADE ON AN EMERGENCY BASIS.
Suspension, Oct 3, 2004
LEFT FRONT SUSPENSION SPRING FRACTURED INSIDE THE SLEEVE AT ONE COIL FROM THE BOTTOM. FRACTURED END OF THE SPRING WAS FORCED AGAINST THE TIRE, DAMAMGING THE TIRE. THIS IS THE SECOND OEM COIL SPRING TO FRACTURE ON THIS CAR, REFERENCE ODI CONFIRMATION NUMBER 10030978 DESCRIBING THE FRACTURE OF THE RIGHT FRONT COIL SPRING. WHY IS THERE NO RECALL ON THESE SPRINGS? WHY HASN'T FORD MOTOR COMPANY'S CUSTOMER SATISFATION PROGRAM 03M02 BEEN EXTENDED TO INCLUDE ALL 2000MY FOCUS INSTEAD OF COVERING ONLY FOCUS'S BUILT UP TP DECEMBER 1999?*AK
Suspension, Sep 21, 2004
VEHICLE MAKES A LOUD NOISE WHEN DRIVING. THE LEFT DRIVER SIDE TIRE IS WORE OUT. CONSUMER FOUND A RECALL ON LUGS AN BOLTS. DEALER STATED WHEEL BEARINGS WORE OUTPREMATURELY. *AK