2001 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,790 owner complaints filed for this model year. This is the 5th highest complaint count among 19 Focus model years with reports.
Of the 2001 reports, 173 involved a crash and 49 involved a fire. 136 people were injured and 8 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerMar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V108000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Representative owner complaints: suspension
153 reports, newest first. Show all
Suspension, Wheels, Dec 21, 2021, crash
The contact owns a 2001 Ford Focus. The contact stated that while driving her vehicle at approximately 35 MPH, the ball joint snapped on the vehicle's passengers side. The contact stated there were no warning lights illuminated nor any indication of a failure prior to the ball joint snapping. The contact stated that when the failure happened to her vehicle it caused her to crash into a ditch. The contact stated that no injuries were sustained and the vehicle was towed to the residence where it remains currently. The contact stated that she did contact the dealer as well as the manufacturer who advised her to contact NHTSA. The failure mileage was 190,000.
Suspension, Jul 8, 2020
WHILE I FIND RUST RECALLS FOR 2001 FOCUS FUSIONS AND WINDSTARS FORD CLAIMS THERE IS NO RECALL FOR FRAME COLLAPS FROM EXCESSIVE RUST PROBLEMS. WE PULLED OUT OF OUR DRIVE HEADED UP A BLIND HILL AND THE FRONT END TOTALLY COLLAPSED LEAVING US AS AN EASY TARGET. SEVERAL GOOD FOLKS JUMPED INTO ACTION TO HELP US GET THE MESS SAFELY OFF OF THE STATE HIGHWAY BY BLOCKING TRAFFIC AND HELPING US DRAG IT BACK INTO OUR DRIVEWAY. WE ARE IN OUR 70'S AND ONLY DRIVE THE CAR 7-8 THOUSAND MILES A YEAR. IT HAS BEEN BABIED AND MAINTAINED BY THE BOOK IT ENTIRE LIFETIME . CONVERSATIONS WITH FORD HAVE GOTTEN US NO WHERE! WHERE DO WE TURN ?
Suspension, Feb 4, 2016
2001 FORD FOCUS WITH 146K MILES. ADULT DRIVEN ONE OWNER AND WELL CARED SINCE NEW. NOTICED CLUNKING SOUND SO TOOK IT IN FOR BRAKES TO THE FORD DEALER. WAS TOLD BY DEALER THEY CAN'T FIX AS ENTIRE SUBFRAME IS ROTTED AND "I WAS ONE POTHOLE FROM THE ENGINE FALLING OUT". IT APPEARS THAT DEALERS USE THIS LINE AS I FOUND OTHER COMPLAINTS WITH THE EXACT SAME WORDING. HOW CAN YOU RECALL THE ESCAPE AND WINDSTAR FOR THE SAME PROBLEM AND NOT THE FOCUS? BECAUSE FOCUS OWNERS DON'T HAVE THE SAME MONEY THAT THOSE OTHER HIGHER END CARS HAVE? I WAS DRIVING MY NEW BABY AROUND IN THIS CAR AND THANK GOD I DIDN'T HIT THAT ONE MORE POTHOLE OR BOTH OUR LIVES COULD HAVE BEEN ENDED! ALL IT TAKES IS AN INTERNET SEARCH TO REALIZE THAT THIS IS A COMMON PROBLEM. THE SUBFRAME IS A VERY IMPORTANT COMPONENT TO A CAR THAT SHOULD NOT JUST RUST AWAY IN 14 YEARS! CLEARLY THE DESIGN OR MATERIALS USED WERE AT FAULT FOR THIS. FORD NEEDS TO RECALL THESE CARS BEFORE MORE PEOPLE ARE KILLED OR INJURED!
Steering, Suspension, Dec 15, 2015
TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING, THE VEHICLE PULLED TO THE RIGHT INDEPENDENTLY AND THE CONTACT LOST CONTROL OF THE STEERING WHEEL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE LOWER CONTROL ARM, BALL JOINT ASSEMBLY, AND AXLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT DID NOT KNOW IF THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 02V289000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 165,611.
Suspension, Feb 6, 2015
RIGHT FRONT COIL SPRING BROKE AS I WAS DRIVING TO THE MECHANIC TO HAVE A BALL JOINT ON MY LEFT FRONT TIRE REPLACED. HEARD A CLANGING NOISE WHILE DRIVING. I THOUGHT IT WAS FROM THE BAD BALL JOINT, WHEN MECHANIC CHECKED HE SAID THE COIL SPRING HAD SNAPPED. CALLED FORD ABOUT SAFETY RECALL WHICH CAME UP WHEN I PUT MY VIN NUMBER INTO THEIR WEBSITE. I WAS INFORMED THAT THE WARRANTY PERIOD WAS OVER AND MY CAR WAS NOT COVERED. IT COST ME 600.00 TO HAVE BOTH REPAIRS DONE BY A MECHANIC. I FILED A COMPLAINT WITH FORD WHILE ON THE PHONE WITH THEM AND THEIR ADVICE WAS TO SAVE MY RECEIPT AND IF A RECALL GOES INTO EFFECT FOR THIS PROBLEM, I WILL GET REIMBURSED. I HAVE SEEN HUNDREDS OF COMPLAINTS ABOUT THIS PROBLEM, YET FORD JUST IGNORES THE ISSUE AS IT IS STILL HAPPENING. NOW TODAY MY BACK WINDOW MADE A NOISE AND THE WINDOW FELL DOWN AND WON'T GO BACK UP. I'VE ALREADY HAD A NEW BATTERY, ALTERNATOR, PLUGS AND COIL PACK REPLACED BECAUSE OF SURGING AND STALLING. I AM ALSO GETTING POOR GAS MILEAGE. I WAS TOLD BY FORD THAT THERE ARE NO OPEN RECALLS ON MY CAR YET I HAVE AND AM HAVING THE SAME PROBLEMS THAT MANY OF THE RECALLS IN EFFECT ARE LISTING. VERY POOR CUSTOMER SERVICE BY FORD. *JS
Suspension, Oct 27, 2014
CHECKED YOUR SITE FOR RECALLS. FOUND FIELD SERVICE ACTION NUMBER:03M02 RE: COIL SPRINGS. PREVIOUSLY CHECKED FOR RECALLS TWO YEAR AGO. THIS NOTICE WAS NOT ON YOUR SITE THEN. AS THE ORIGINAL OWNER, I HAVE MADE IT A POINT TO KEEP ABREAST OF ALL RECALLS. I WAS NEVER NOTIFIED OF THIS NOTICE BY FORD. USED THE SAME DEALER FOR REPAIRS FOR THE LAST 5 YEARS. CALLED FORD TODAY. FORD SAID THE DEALER HAD A COPY OF THIS NOTICE. NEVER INFORMED OF THIS BY THE DEALER (AUTO NATION, BELLEVUE DEALERSHIP). YOUR SITE POSTING OF THE NOTICE SAID IT EXPIRED AFTER 10 YEAR OR 150,000 MILES. FORD SAID I WAS OUT OF LUCK AS "WHAT EVER CAME FIRST, YEARS OR MILEAGE". I SUSPECT THAT FORD NEVER NOTIFIED NHTSA OF THIS PROBLEM & I ALSO SUSPECT FORD IS DOING A CYA. *TR
Suspension, Apr 15, 2014
RIGHT FRONT COIL SPRING BROKE WHILE DRIVING ON THE ROAD. THE BROKEN SPRING PENETRATED THE RIGHT FRONT TIRE AND IMMEDIATELY DISABLED THE VEHICLE. IT HAS BEEN DOCUMENTED THAT THIS IS A COMMON PROBLEM FOR THIS VEHICLE, AND IT WAS DETERMINED THAT THE SPRINGS WERE MANUFACTURED IMPROPERLY AND DO NOT RESIST CORROSION. FORD HAS RECOGNIZED THE PROBELM THROUGH SEVERAL TSBS AND EVEN HAD A CUSTOMER SATISFACTION PROGRAM 03M02 WITH AT LEAST 2 SUPPLEMENTS CONCERNING THE ISSUE AND REPLACEMENT OF THE FAULTY PARTS. I SPOKE WITH A LOCAL FORD DEALER (HONDRU) AND THEY TOLD ME THE PROGRAM EXPIRED AND THE CAR IS NO LONGER COVERED. I THEN SPOKE WITH A FORD REPRESENTATIVE THROUGH DIRECT CUSTOMER SERVICE AND THEY CONFIRMED THIS WAS THE CASE. THEY CONFIRMED THE CONVERSATION WITH NUMBER CAS4271469-Z6W0F2. THE REPRESENTATIVE'S NAME WAS KENDRA. I AM DEEPLY CONCERNED ABOUT THIS BECAUSE IT IS A SIGNIFICANT SAFETY RISK TO ME AN MY FAMILY. THE COIL SPRING IS A SIGNIFICANT COMPONENT OF THE SUSPENSION, AND WHEN IT BRAKES THE DRIVER'S ABILITY TO CONTROL THE CAR IS EXTREMELY COMPROMISED. TO MAKE THINGS WORSE, THE BROKEN SPRING DESTROYS THE TIRE IMMEDIATELY, FURTHER REDUCING THE ABILITY TO CONTROL THE CAR. SINCE IT WAS DOCUMENTED THAT THERE WAS A FAULT IN THE MANUFACTURING PROCESS, AND FORD AND NHTSA KNEW ABOUT THE PROBLEM, THESE PARTS SHOULD HAVE BEEN REPLACED UNDER A RECALL DUE TO THE SAFETY CONCERNS. *TT
Suspension, Seat belts, Structure, Apr 8, 2014
SUBFRAME IS RUSTED THROUGH. *TR
Suspension, Dec 30, 2012, crash
FRONT RIGHT LOWER BALLED JOINT SEPARATED AND BROKE THE CONTROL ARM ALMOST SEPARATED THE WHEEL FROM THE CAR. THE CAR HAS NOT BEEN REPAIRED. *TR
Suspension, Structure, Nov 20, 2012
HEARD CLUNKING NOISE-REAR SUBFRAME IS COMPLETELY ROTTED AND BROKEN ON BOTH SIDES. *TR
Suspension, Nov 14, 2012
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING 5MPH THERE WAS A CLUNKING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSE THAT THE FRONT COIL SPRINGS FRACTURED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 122,000.
Steering, Suspension, Structure, Engine, May 10, 2012
MY LAST OIL CHANGE I WAS INFORM THE FRONT SUBFRAME IS BADLY RUSTED, TO THE POINT THE MECHANIC COULD PUSH A SCREW DRIVER THROUGH IT IN SPOTS. HE INFORMED ME THAT DRIVING IT WAS A MAJOR SAFETY RISK, AS THE FRAME COULD FAIL, CAUSING AN ACCIDENT. HE SAID FORD HAS NOT ISSUED A RECALL. THEY MUST BE WAITING FOR A HIGHER BODY COUNT WHEN THE FRONT END OF THE CAR FAILS WHILE GOING DOWN THE INTERSTATE. *TR
Suspension, Feb 8, 2012
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS DRIVING 40 MPH WHEN THE STEERING WHEEL BECAME LOOSE AND A CLUNKING NOISE EMITTED FROM THE FRONT OF THE VEHICLE. THE POWER STEERING ALSO FAILED, CAUSING THE VEHICLE TO STEER TO THE LEFT ABNORMALLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE PRIVATE MECHANIC CONFIRMED THAT THE FRONT SPRING FROM THE STRUTS HAD DETACHED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 44,099.
Suspension, Structure, Nov 25, 2011, crash
ON MAY 9, 2011 MY CAR WENT FOR EMERGENCY REPAIRS TO BILL WILCOX'S CHARLON FORD AGENCY OF RIDGECREST, CA. AFTER $1725 REPAIRS, I EXPERIENCED A REDUCTION IN MILEAGE, DROPPING FROM 30-31MPG TO 25-26 MPG, A 17 TO 18 % DROP. THAT BEGAN IMMEDIATELY, WITH THE INITIAL PURCHASE OF GAS - IN VISALIA; AND, IT WAS LATER CONFIRMED WAS CAUSED BY THE IMPROPER USE OF A TORCH ON A SUSPENSION CROSS MEMBER. THE CAR WAS TAKEN TO ROB HOLBROOK'S AUTO CREW IN CLEARFIELD, UTAH, CHECKED FOR UNDERCARRIAGE DAMAGE AND EVIDENCE THAT CHARLON FORD'S REPAIRS CAUSED THE PROBLEMS. HE IS A LICENSED SAFETY INSPECTOR FOR THE STATE OF UTAH. WIDESPREAD DAMAGE TO THAT MAIN CROSS MEMBER, WHERE THE ATTACHMENT FOR THE REAR MOTOR MOUNT IS AFFIXED TO THAT PORTION OF THE SUB FRAME, WAS CONFIRMED. THE SUB FRAME WAS QUITE DISTORTED, BOWED IN AND OUT, AND EXHIBITED EVIDENCE THAT THE MOUNT HAD BEEN REMOVED BY USE OF A TORCH SO THE REAR DOG BONE MOTOR MOUNT COULD BE REPLACED. DEFORMATION OF THAT CROSS MEMBER AND RESULTANT CHANGES TO THE SUSPENSION WERE THE REASONS FOR LOW MPG AND TIRE WEAR BECAUSE OF IMPROPER CAMBER. BILL WILCOX, STATED TO CALIFORNIA BAR THAT TOE-IN WAS ONLY ADJUSTED WHILE THE CAMBER WAS OVERLOOKED OR COULD NOT BE ADJUSTED. BUT, THE USE OF A TORCH TO THIS UNIT IS NOT CALLED FOR - UNLESS IT IS TO REPLACE THAT UNIT. LEAVING THE SUSPENSION CROSS MEMBER IN THAT CONDITION, LEADS TO A STRESS POINT THAT COULD LEAD TO CRACKING AND TEARING, AND COULD PREMATURELY CAUSE RUSTING WHICH WEAKEN THOSE ATTACHMENTS TO THE SUSPENSION. IF REPAIRS ARE MADE IT IS IMPERATIVE THAT IT AND SURROUNDING STRUCTURES BE RETURNED TO PROPER DIMENSIONS. BUT PROBLEMS ARISE WHEN IMPROPER HEAT AFFECTS STRENGTH AND CREATES PERMANENT SOFTNESS AND INCREASING BRITTLENESS. THE CROSS MEMBER HAD TO BE REPLACED AND A NEW ALIGNMENT PERFORMED - AT A COST OF $851.74. *TR
Steering, Suspension, Engine and engine cooling, Oct 29, 2011
I'VE HAD NUMEROUS PROBLEMS WITH MY FORD FOCUS AND DESPITE REGULAR MAINTENANCE I'VE BEEN STRANDED ON THE SIDE OF A HIGHWAY COUNTLESS TIMES.THUS FAR I'VE REPLACED THE ENGINE TWICE. TWICE I'VE HAD TO REPLACE THE ALTERNATOR. MY THROTTLE DOES NOT RETURN TO IDLE AND HAS UNEXPECTED MOMENTS OF ACCELERATION AND I'VE HAD TO REPLACE THE ENGINE THROTTLE SENSOR. BOTH OF MY FRONT COIL SPRINGS HAVE BROKEN AND WERE VERY CLOSE TO PUNCTURING MY TIRES. AFTER TAKING MY VEHICLE TO NUMEROUS MECHANICS NONE OF THEM HAVE BEEN ABLE TO DIAGNOSE WHY MY CAR SHAKES SO BADLY. I HAVE VERY POOR VISIBILITY AT NIGHT WITH THE EXTERIOR LIGHTING WHICH IS SIGNIFICANTLY LESS COMPARED TO OTHER VEHICLES. MY FAN HAS HAD TO BE REPLACED SINCE IT WAS MALFUNCTIONING AND MY CAR WAS HAVING PROBLEMS OVERHEATING AS WELL. DURING THE COURSE OF ALL OF THESE CAR MALFUNCTIONS, I'VE BEEN IN DANGEROUS SITUATIONS ON THE SIDE OF THE HIGHWAY AND IN RISKY NEIGHBORHOODS AT NIGHT. THIS CAR HAS PROVEN TO BE VERY UNRELIABLE AND UNSAFE. *TR
Suspension, Aug 29, 2011
COIL SPRING ON FRONT PASSENGER SIDE BROKE WHILE DRIVING ON THE HIGHWAY. UNABLE TO MOVE THE VEHICLE BECAUSE A METAL OBJECT FROM BROKEN SPRING JAMMED INTO THE FRONT TIRE. THE CAR IS OLD, BUT HAS BEEN KEPT INSIDE A GARAGE AND HAS LOW MILEAGE.
Suspension, Dec 30, 2010
2001 FORD FOCUS SE, VIN [XXX], 62000 MI. - BOTH FRONT COIL SPRINGS ARE BROKEN, MANY PEOPLE HAVE HAD THE SAME PROBLEM AND FORD ONLY ISSUED EXTENDED WARRANTY NUMBER 03M02 FOR 1999/2003 MODEL YEARS. I HAVE HAD THE CAR FOR ALMOST 2 YEARS AND NEVER RECEIVED ANY INFO FROM FORD ABOUT THE PROBLEM. SPRING BREAKS AND RUBS AGAINST TIRE AND CAUSES BLOW OUT. FAULTY SPRINGS. FORD ADMITS DEFECT BUT SAID I WAS PAST WARRANTY DATE AS OF 09/26/2010 THEY WOULD NO LONGER COVER THE PROBLEM - DISGRACEFUL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Suspension, Exterior lighting, Nov 30, 2010
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A LEFT TURN, HE HEARD NOISES. THE VEHICLE WAS INSPECTED BY THE DEALER WHO STATED THAT THE LEFT REAR COIL SPRINGS HAD FRACTURED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO STATED THAT THERE WAS A PROBLEM WITH THE HEADLIGHT LENSES WHICH BECAME FOGGY OVER TIME. THE DEALER STATED THAT THEY HAD CHANGED HEADLIGHT MANUFACTURERS BECAUSE OF THE PROBLEM. THE FAILURE MILEAGE WAS APPROXIMATELY 81,800. UPDATED 1/19/2010 *CN UPDATED 03/25/11*JB
Suspension, Exterior lighting, Seat belts, Vehicle speed control, Seats, Sep 30, 2010
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT SHE EXPERIENCED NUMEROUS ISSUES WITH THE VEHICLE WHICH INCLUDED THE PASSENGER SIDE STRUTS WHICH HAD TO BE REPLACED TWICE. THE VEHICLE WOULD SIT SIDEWAYS WHEN PARKED. THE BACK OF THE FRONT PASSENGER SEAT WOULD NOT LOCK INTO PLACE, SO IT SLID FORWARD WHILE THE VEHICLE WAS IN MOTION. THE HEADLIGHTS WERE TOO DIM AND DID NOT PROVIDE ADEQUATE LIGHTING ON THE ROAD. THE FRONT DRIVER'S SIDE SEAT BELT ALARM WOULD RING ALTHOUGH THE SEAT BELT WAS ENGAGED AND THE LATCH WOULD ALSO POP OPEN SUDDENLY AT TIMES. THE VEHICLE STALLED WHILE THE CONTACT WAS DRIVING AND WOULD ACCELERATE SUDDENLY. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE REPAIRS WOULD HAVE TO BE PERFORMED AT THE CONTACT'S EXPENSE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 107,000.
Suspension, Structure, May 15, 2010
2001 FOCUS 112K MI. BOUGHT FROM LOCAL FORD DEALER, 1 YR OLD W, 21K ON IT. A RECENT INSPECTION BY MY OWN MECHANIC TELLS ME THAT THE REAR SUB FRAME IS ROTTED AND IT IS DANGEROUS TO DRIVE IT. ESPECIALLY AT HIGHWAY SPEEDS. THE LOCAL DEALER LAUGHED WHEN I INQUIRED ABOUT A NINE YEAR OLD CAR W/ RUSTED FRAME. *TR
Suspension, May 14, 2010
I WAS PULLING OUT THE DRIVEWAY WHEN THE REAR AXLE SNAPPED IN TWO. THIS IS GOING TO KILL SOMEONE. *TR
Suspension, Apr 8, 2010
2001 FORD FOCUS, FRONT STRUT SPRING BROKE IN 2 PLACES. I JUST GOT IN THE CAR AND IT SOUNDED LIKE A RIFLE SHOT WENT OFF....STARTED TO DRIVE OFF AND STOPPED FOR THE 'CLUNKING' SOUND. DROVE TO NEAR BY REPAIR SHOP, SAID THE TROUBLE WAS THE SPRING. CHECKED RECALLS, IN CASE...2000 MODELS HAD RECALL FOR SPRING BREAKAGE, BUT NOT THE 2001 MODELS. HAVE WRITTEN TO FORD AND AM SUBMITTING VEHICLE INFO TOMORROW FOR CONSIDERATION. *TR
Steering, Suspension, Air bags, Apr 29, 2009, crash
MY DAUGHTER WAS DRIVING 2001 FORD FOCUS SE WAGON APPROXIMATELY 45MPH WHEN SHE DESCRIBED STEERING LOCKED UP IN TURN THEN SHE HEARD TIRES SQUEALING AND VEHICLE JERKED HARD LEFT CAUSING HER TO GO OFF THE ROAD, HIT A ROCK WALL AND FLIPPED THE CAR END OVER END. THE AIR BAGS DID NOT DEPLOY. SHE LANDED UPSIDE DOWN BUT WAS ABLE TO EXIT VEHICLE THROUGH BROKEN WINDOW. SHE RECEIVED CUTS AND BRUISES AND WAS TAKEN TO EMERGENCY ROOM FOR X-RAYS WHERE THEY SAID SHE HAD NO SERIOUS INJURIES AND WAS RELEASED. ON SCENE INVESTIGATION BY POLICE AND TOW TRUCK OPERATED SUGGESTED BALL JOINT FAILURE OR OTHER STEERING/SUSPENSION FAILURE. CAR WAS TOTALED. *TR
Steering, Suspension, Service brakes, Hydraulic, Electrical system, Visibility, Sep 12, 2008
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING NUMEROUS FAILURES. THE MAIN FAILURES WERE THE ELECTRICAL SYSTEM, BRAKE SYSTEM, BENT TIE ROD, SHAKING AND VIBRATING, REAR WINDOW MECHANISMS, AND FLOODING AFTER IT RAINS. THE LEAK OCCURS ON THE PASSENGER SIDE AND THE WATER RISES 2 TO 3 INCHES. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER DUE TO THE INSPECTION COSTS. THE FAILURE MILEAGE WAS 130,473.
Suspension, Service brakes, Hydraulic, Electrical system, Latches/locks/linkages, Tires, Equipment, Aug 25, 2008
I WILL START WITH THE FACT THE CAR IS ON IT'S FOURTH BATTERY. IT HAS HAD THE WIRING HARNESS REPLACED ALONG WITH EVERY SENSOR IN THE CAR SOME TWICE. THERE WAS A STEERING COLUMN RECALL DONE ON IT. THE TWO BACK WINDOWS TRACKS HAVE BEEN BROKE A TOTAL OF SIX TIMES. THE DOOR HANDLES BRAKE THREE SO FAR. THE STEREO IS BROKE FOR THE SECOND TIME. I HAVE HAD TO DO THE BRAKES TWICE SO FAR AND ALL THIS AND THE CAR ONLY HAS 63,498.8 MILES . *TR