2002 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,014 owner complaints filed for this model year. This is the 9th highest complaint count among 19 Focus model years with reports.
Of the 2002 reports, 85 involved a crash and 24 involved a fire. 82 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: electrical system
285 reports, newest first. Show all
Suspension, Electrical system, Exterior lighting, Jan 21, 2023
I drive a 2002 Ford Focus Sedan. My engine light is on, warning light for trunk door ajar light is on (even though the trunk is securely locked, my front headlights due not work consistently (sometimes work, sometimes don't). My trunk does not always latch secure after I close it as well. I took my car to Advanced Auto Parts and had my engine light diagnosed. Engine codes that resulted were: B1318, B1881, C1947, B2438, B2434, P0457. The representative tested my battery and found that the voltage was slightly lower than it should be. My concern is for my safety as well as the safety of others. Do we have some manufacturer defects on this particular vehicle? Have other concerns which could be the result of vehicle wear and tear, or/and due to manufacturer defects as well. Inner tie rods need replaced as well as control arms/bushings, as reported to me by a mechanic. I have seen recall reports related to the 2002 Ford Focus in which there has been issues directly related to what I'm reporting, which is another reason I'm filing a report. Thank you. The contact wanted to add that the wipers are experiencing an electrical issue as well. When in use, the wipers cannot be switched off when it is at the highest position because it will not return in the downward position.
Power train, Electrical system, Electronic stability control (ESC), Aug 6, 2018
CAR PERIODICUALY LOOSES ALL POWER TO DASH BATERRY EVERYTHING COMPLETLY I'VE REPLACE BATTERY ALTINATOR CLUSTER LIGHT IT SEEMS IF I USE MY LIGHT IT HAPPENS MORE OR ANYTIME I STOP OR SLOW DOW IT STALLS AND WILL NOT START WITHOUT A JUMP THEN IT WILL BE GREAT AGAIN SOMETIMES FOR A DAY SOMETES A WEEK IT S VERY IRRADICUL AND THROTLE GETS STUCK REVING UP HIGH THEN OTHER TESTS IDLES WAY TOO LOW AND DOES
Electrical system, Feb 5, 2018
REAR RIGHT PASSENGER DOOR WILL NOT UNLOCK/OPEN. WHEN TRYING TO UNLOCK I DON'T HEAR THE SOLENOID MOVING. WHEN TRYING TO OPEN FROM EITHER INSIDE OR OUT IF FEELS LIKE THE HANDLE ISN'T MOVING ANYTHING.
Electrical system, Dec 15, 2014
HATCH SWITCH FAILED .GHOST ELECTRICAL PROBLEM HAVING WIPER COME ON AT TIMES.WIRING HARNESS INSIDE RUBBER BOOT LOCATED WHERE HINGES BETWEEN HATCH AND VEHICLE BODY DEVELOPE BARE AND BROKEN WIRES. FOUND THIS AFTER CHECKING ALL FUSES AND SWITCHES. THIS IS APPARENTLY COMMON AS SEEN ON YOU TUBE AND SEEMS TO HAVE BEEN PREVIOUSLY REPORTED. PLEASE REPLY AS TO WHY THERE HAS BEEN NO RECALL. SURELY DEALERS HAVE ENCOUNTERED THIS DEFECT. LIKE ONE INDIVIDUAL SAID HIS DOG COULD HAVE FLEW OUT THE REAR GOING 70. NOT TO MENTION FIRE.MINE BLEW NO FUSES. *TR
Electrical system, Oct 28, 2014
EVER SINCE I HAVE HAD THIS CAR AND SINCE THE WARRANTY RAN OUT IN 2005, I HAVE NOTHING BUT REPAIRS. FIRST, THE RADIO NEEDED TO BE REPLACES, THEN THE BRAKES, THEN THE LOCKS ON BOTH DOORS AND THEN THE BRAKES AGAIN, HIGH BEAM LIGHT NEVER GOES OFF, ALWAYS ON AND NOW THE RADIATOR. THIS CAR IS 12 YEARS OLD, HAS LESS THAN 50,000 MILES ON IT AND IT HAS BEEN NOTHING BUT TROUBLE. I LIVE ON A LIMITED INCOME AND CANNOT AFFORD ALL THESE REPAIRS AND FORD COULD CARE LESS. IF I EVER BUY ANOTHER CAR, IT WILL NOT BE A FORD. THIS IS WHY THE NAME STANDS FOR: FIX OR REPAIR DAILY. I AM NOT ASKING FOR MONEY BUT IF YOU WANT TO THROW SOME MY WAY THANKS AND IF NOT THANKS. *TR
Electrical system, Oct 15, 2014
IGNITION CYLINDER IN STEERING COLUMN IS FROZEN. KEY INSERTS BUT WILL NOT TURN AT ALL. CANNOT START THE CAR, SHIFT INTO NEUTRAL, ETC. *TR
Electrical system, Aug 28, 2014
ALTERNATOR PULLING TO MUCH FIRE FROM THE BATTERY. *TR
Electrical system, Engine, Jul 24, 2014
CAR WHEN WARMED UP AND DURING INTERCITY DRIVING WILL RANDOMLY CUT OUT WHEN THE ACCELERATOR IS NOT DEPRESSED. CAR SHUTS OFF AND BECOMES HARD TO STEER AND CONTROL. HAVE ALMOST BEEN HIT AND NO ONE CAN FIGURE OUT WHAT'S WRONG. IT DOES THIS INTERMITTENTLY. ALSO THE CAR HAS THE UPDATED THERMOSTAT HOUSING AND THE THERMOSTAT STILL TENDS TO OVERHEAT. HAVE CONTACTED FORD AND CALL CENTER EMPLOYEE DID NOT SEEM TOO ENTHUSIASTIC TO HELP. OFFERED TO FIND ME A FORD DEALER BUT NOT SOMEONE FROM THEIR SAFETY OFFICE. ALSO, CAR HAD OLD STYLE IGNITION CYLINDER WHICH LOCKED BACK IN FEBRUARY. THIS SEEMS TO BE A COMMON PROBLEM... AFTERMARKET HAVE THE SAME DESIGN. *TR
Electrical system, Feb 6, 2014
DECKLID WIRING HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE HINGE. SIMILAR TO NHTSA RECALL ID# 00V411000. CONSEQUENCES: THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH. *TR
Electrical system, Structure, Dec 14, 2013
VEHICLE TOWED TO FORD DEALER BECAUSE IT WOULD NOT START. UPON INSPECTION, DEALERSHIP FOUND FRONT SUB FRAME COMPLETELY RUSTED THROUGH. SAID IT IS "ONE POTHOLE AWAY FROM THE ENGINE FALLING OUT; TOTALLY UNSAFE TO DRIVE." RUSTING ALSO CAUSED CORROSION IN WIRES FROM IGNITION TO STARTER, RESULTING IN CAR NOT STARTING. THIS CAR WAS PURCHASED BRAND NEW, HAS BEEN GARAGE KEPT, ONLY DRIVEN 5,000 MILES PER YEAR BY ELDERLY COUPLE. OBVIOUSLY THE METAL USED IN SUB FRAME WAS NOT PROPERLY COATED. WILL COST THOUSANDS OF DOLLARS TO FIX, IF IT IS DEEMED WORTH FIXING! SOMEONE COULD HAVE BEEN SERIOUSLY HURT OR KILLED IF THIS ENGINE HAD INDEED FALLEN OUT WHILE IN MOTION! *TR
Electrical system, Exterior lighting, Engine, Sep 9, 2013
WHILE WAITING AT A CONSTRUCTION SITE THE ENGINE DIED AND WOULD NOT START (THE ENGINE INDICATOR LIT). THE BRAKE LIGHTS, POWER WINDOWS, AND REAR HATCH RELEASE ALSO FAILED TO FUNCTION. THE VEHICLE WAS TOWED AND THE PERSONAL MECHANIC REPORTED THE ELECTRICAL HARNESS TO THE REAR HATCH HAD FAILED WHERE IS PASSED BETWEEN THE BODY AND THE HATCH DOOR. THE HARNESS ELECTRICAL INSULATION WAS CRACKED ON THE ENTIRE BUNDLE OF WIRES AND SHEDDING FRAGMENTS CAUSING SOME WIRES TO SHORT, THE 15 AMP FUSE FOR THE BRAKE LIGHTS HAD EVIDENCE OF HEATING, BUT DID NOT BLOW, RATHER, WIRES LEADING TO THE BRAKE PEDAL SENSOR, THE 15 AMP FUSE, AND ALONG THE HARNESS BACK TO THE SHORT IN THE REAR WIRING HARNESS NEAR THE CENTER BRAKE LIGHT HAD DISCOLORED AND WERE MELTED IN SOME SEGMENTS. FORD CUSTOMER SERVICE SAID TO CONSULT A FORD SERVICE CENTER TO DETERMINE IF THERE WAS A MANUFACTURING DEFECT. THE FORD SERVICE REPRESENTATIVE SAID HE HAD SEEN THIS BEFORE AND SAID IT WAS NOT A MANUFACTURING DEFECT, RATHER IT WAS A DESIGN DEFECT THAT OCCURS AFTER 10 YEARS OR MORE. *TR
Electrical system, Visibility, Engine, Aug 14, 2013
THE MOTOR ON THE SUN ROOF AND ALL OF MY WINDOWS WENT OUT THE HANDLE ON DOOR FOR THE FRONT PASSENGER FELL OFF THE ,REAR DOOR ON THE PASSENGER SIDE ON THE INSIDE JUST FELL APART SOMETIMES YOU CAN'T OPEN THE DOOR FROM THE INSIDE OR THE OUTSIDE ITS LIKE THEY FREEZE UP AND A DAY LATER THEY OPEN (THIS IS A HUGE SAFETY ISSUE ) SOMETIMES MY CAR JUST DIES OUT AND ALL OF THE PANEL GOES BLANK LIKE IT JUST SHUTS DOWN. *TR
Electrical system, Apr 14, 2013
HAVING INTERMINENT ELECTRICAL ISSUES. WOULD START UP AND RUN FINE FOR A PERIOD OF TIME, THEN THE 2002 FORD FOCUS WOULD JUST STOP RUNNING. AS TIME PASSED THE ISSUE GREW WORSE, NOW THE FOCUS WILL NOT RUN AT ALL. THE DEALERSHIP COUD NOT DUPLICATE THE PROBLEM AND COULD NOT FIX IT. *TR
Electrical system, Fuel/propulsion system, Dec 31, 2012
VEHICLE RUNS FINE WHEN WE GO INTO SCHOOL/BUSINESS OR WHAT EVER WE PARK AND COME OUT AND THE VEHICLE DOES NOT START, AFTER 1/2 HOUR TO AN HOUR THE VEHICLE STARTS AND NO PROBLEMS. IT TURNS OVER BUT DOES NOT FIRE. NEW BATTERY DID NOT CHANGE IT. TUNE UP BY A CERTIFIED MECHANIC DID NOT FIX ISSUE, PLUG IT INTO A TEST MACHINE NO CODES GIVEN. THIS DOES NOT HAPPEN ALL THE TIME, EVERY ONCE IN A WHILE. ISSUE IS THAT A YOUNG LADY DRIVES THE VEHICLE, IF SHE IS STUCK IN THE WRONG PARKING LOT WHO KNOWS WHAT CAN HAPPEN. GOD FORBID. *TR
Electrical system, Exterior lighting, Nov 14, 2012
NOTICED THAT MY DASH BOARD HIGH BEAM FOR MY HEADLIGHTS WAS STAYING ON. TOOK TO WHEEL WORKS AND THEY TOLD ME ITS THE WIRING HARNESS FOR MY HEADLIGHTS. THEY TOLD ME IT IS MELTING AND NEED TO TAKE TO THE DEALER. I BOUGHT MY CAR BRAND NEW AND PAID CASH FOR IT WITH EXTRAS ADDED ON TO IT. I HAVE HAD MULTIPLE PROBLEMS WITH THIS CAR AND I GET NO HELP. I NEED TO KNOW IF THIS HAS BEEN ON A RECALL. I AM ON A VERY LIMITED INCOME AND CANNOT AFFORD THIS TO COME OUT OF MY POCKET. *TR
Electrical system, Aug 1, 2012, fire
BATTERY CABLES SHORTED OUT CAUSING SMALL FIRE ON BATTERY CABLES AND MELTING ON BOTH BATTERY CABLES. *TR
Electrical system, Jul 28, 2012, fire
I DROVE MY FORD FOCUS ABOUT 6 MILES TO A STOP LIGHT. WHEN IT TURNED GREEN, I PRESSED THE GAS. THE CAR STALLED LIKE IT WAS OUT OF GAS, REGAINED PARTIAL POWER, AND DISPLAYED THE AIRBAG LIGHT. IT MADE IT TO THE NEXT STOPLIGHT, AND I PULLED IT OVER TO THE SIDE AND TURNED IT OFF AND REMOVED THE KEY. AT THAT POINT A PLUME OF WHITE SMOKE SHOT OUT OF THE DRIVER'S SIDE HOOD. I TOLD MY SON TO GET OUT BECAUSE I KNEW THE CAR WAS ON FIRE. WE WALKED AWAY, AND AS WE DID, THE AMOUNT OF SMOKE INCREASED EXPONENTIALLY. WITHIN MINUTES, THE FRONT END OF THE CAR WAS TOTALLY ENGULFED IN FLAMES. THE WINDSHIELD SHATTERED AND MELTED, THE HOOD WAS CHARRED AND BLACK, THE PLASTIC PARTS OF THE FENDERS AND BUMPERS MELTED AWAY, AND PART OF THE BODY METAL BURNED AWAY ON THE HOOD AND THE FENDERS. EVERYTHING UNDER THE HOOD WAS MELTED, DISTORTED, OR OTHERWISE DESTROYED. I KEPT THE CAR VERY WELL MAINTAINED, MAKING SURE TO FIX EVERYTHING THAT WAS EVER WRONG WITH IT IMMEDIATELY UPON DISCOVERY. I KEPT UP ON ALL OIL CHANGES. IT IS PERPLEXING THAT A CAR WHICH IS SO WELL KEPT WOULD SPONTANEOUSLY SELF-IGNITE, HOWEVER THERE HAVE BEEN ACCOUNTS OF FIRES IN THE FORD FOCUS SINCE 2000, AND MANY SINCE. NOW I HAVE ADDED ONE MORE. THE CAR, OBVIOUSLY, IS A TOTAL LOSS. *TR
Electrical system, Jun 19, 2012
KEY WOULD NOT TURN IN THE IGNITION LOCK CYLINDER. IGNITION KEY COULD BE INSERTED ALL THE WAY INTO THE LOCK CYLINDER, BUT KEY WOULD NOT TURN FORWARDS OR BACKWARDS TO EITHER ENGAGE THE STARTER OR TURN ON ACCESSORIES. TRIED MOVING THE STEERING WHEEL TO FREE UP THE CYLINDER AND MADE SURE THE CAR WAS IN PARK TO TRY AND TURN THE CYLINDER. NOTHING. WAS TOLD BY THE AAA MECHANIC THAT THIS IS A COMMON ISSUE WITH EARLY MODEL YEAR FORD FOCUSES. THE ISSUE, PER THE AAA TOW TRUCK OPERATOR COULD BE TEMPORARILY RESOLVED BY USING SOME WD40 ON THE KEY AND A COUPLE OF QUICK TAPS TO THE KEY WHILE IN THE LOCK CYLINDER. THIS FIX DID NOT WORK AT THIS TIME. HAD TO HAVE MY CAR TOWED TO THE DEALER SINCE THIS WAS NOT A FIX I COULD MAKE ON MY OWN (I COULD REPLACE THE CYLINDER MYSELF, BUT THE CAR'S PASSIVE ALARM WOULD NEED TO BE RE-SET BY THE DEALER). RESULTING CHARGE WAS $378.50 FOR A PART I COULD HAVE FIXED FOR $60-70. MY LOCK CYLINDER NEEDED TO BE RE-KEYED BY THE LOCAL FORD DEALER. SAFETY ISSUE: COULD HAVE BEEN STRANDED. CAR FAILURE OCCURRED ON VERY COLD DAY. *JS
Electrical system, Mar 20, 2012
TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT ATTEMPTED TO START THE IGNITION NUMEROUS TIMES HOWEVER, THE IGNITION KEY FAILED TO TURN IN ANY DIRECTION. THE KEY WAS EVENTUALLY RELEASED FROM THE IGNITION SWITCH. THE CONTACT PLANNED TO HAVE THE VEHICLE TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
Electrical system, Mar 5, 2012
I HAD MY 81 YEAROLD MOTHER WITH ME, I TURNED OFF THE CAR AND WHEN I TRIED TO START IT THE KEY WOULD NOT TURN. IT WAS NOT UNTIL 5 DAYS LATER THAT MY MECHANIC SON IN LAW WAS ABLE TO LOOK AT IT AND TELL ME THE PROBLEM AND THAT A FORD GARAGE HAD TO FIXIT. THEIR PRICES VARY FROM 350.00 TO 450.00 TO REPLACE MY IGNITION SWITCH ASSEMBLY. IT IS A 48.00 PART. FORD REFUSES TO RECALL BECAUSE THEY CLAIM IT IS NOT A SAFETY ISSUE. IT IS IF SOMEONE HAS A HEART ATTACK OR A STROKE BECAUSE OF THE STRESS OF BEING STRANDED IN THE MIDDLE OF NOWHERE OR BECAUSE IT IS OVER 100 DEGREES AND YOU CAN'T WALK TO A PHONE OR TURN ON THE AIR CONDITIONER. NOT EVERYONE HAS A CELL PHONE. IT IS COVERED UNDER WARRANTY BUT THE PROBLEM DOES NOT OCCUR UNTIL IT IS OUT OF WARRANTY AND IT HAS TO BE REPAIRED EVERY TIME BY FORD. IT IS A SAFETY HAZARD ESPECIALLY FOR THE ELDERLY. *TR
Electrical system, Visibility, Dec 14, 2011
THE MOTOR ON THE SUN ROOF WENT OUT WHILE THE VEHICLE WAS STILL UNDER WARRANTY I HAD IT FIXED THEN AFTER THE WARRANTY EXPIRED IT WENT OUT AGAIN AND I COULDN'T AFFORD TO GET IT FIXED, THE MOTOR FOR THE REAR WINDOWS WENT OUT (BOTH PASSENGER SIDES) THE FRONT PASSENGER DOOR DOES NOT LOCK BECAUSE THE MOTOR WENT OUT, AND KNOW THE DRIVERS SIDE WINDOW IS STARTING TO MAKE A NOISE LIKE IT GOING TO GO OUT ALSO AND THE DOOR LOCK IS MAKING NOISE LIKE ITS GOING TO GO OUT. THIS IS A HUGE SAFETY ISSUE FIRST OF ALL WHEN CARRYING SMALL CHILDREN IN THE BACK AND ANOTHER SAFETY ISSUE WITH THE DOORS NOT LOCKING MAKES IT MUCH EASIER FOR SOMEONE TO CAR JACK YOU. I HAVE NEVER HAD A VEHICLE THAT THE ELECTRIC WINDOWS AND DOORS AND THE MOON ROOF WENT OUT THIS HAS TO BE A DEFECT I HAVE GONE TO THE DEALERSHIP TO COMPLAIN AFTER THE WARRANTY HAD EXPIRED AND I WAS TOLD THAT THERE ARE NO RECALLS AND THEY CAN'T HELP ME UNLESS I PAY. I CAN'T EVEN LOCK THE DOOR USING A KEY BECAUSE IT DOESN'T WORK. *TR
Electrical system, Dec 13, 2011, fire
TL* THE CONTACT OWNS A 2002 FORD FOCUS. WHILE PARKED, THE VEHICLE IGNITED INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE MASSIVE FLAMES AND INFORMED THE CONTACT THAT THE FIRE ORIGINATED WITHIN THE BATTERY. THE VEHICLE WAS DECLARED AS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
Electrical system, Sep 21, 2011
KEY WILL NOT TURN IN THE IGNITION, THEREBY PREVENTING THE CAR FROM STARTING. *TR
Engine and engine cooling, Electrical system, Aug 8, 2011
VEHICLE FAILED TO START AFTER COMPLETING A 30 MINUTE DRIVE AND BEING TURNED OFF FOR ABOUT 5 MINUTES. CLICKING NOISES LIKE STARTER FAILING TO ENGAGE OR LOW BATTERY ENSUED. WHEN HOOD WAS LIFTED AND BATTERY COVER REMOVED AND CABLES AND CONNECTIONS WERE INSPECTED, IT WAS OBSERVED THAT THE POSITIVE CABLE OFF THE BACK OF THE POSITIVE BATTERY HARNESS WAS EXPOSED, THE INSULATION BEING ALMOST COMPLETELY MELTED. THE EXPOSED WIRES SHOWED SIGNS OF FRAYING AND BURNING. AFTER ATTEMPTING TO JUMP START THE VEHICLE ABOUT 3 TIMES AND WAITING ABOUT 20 MINUTES, THE VEHICLE STARTED. THE VEHICLE WAS DRIVEN ABOUT 20 MILES TO A SERVICE STATION AND INSPECTED BY THEIR MECHANICS. IT WAS DECIDED FOR SAFETY REASONS(FIRE HAZARD) TO LEAVE VEHICLE. IN 45 YEARS I HAVE NEVER KNOWN A BATTERY CABLE TO MELT EVEN THOUGH I HAVE HAD BAD CONNECTIONS, CORRODED TERMINALS AND HARNESS TO THE BATTERY AND EVEN BAD STARTERS. ALL OF THE ABOVE REASONS WERE THE ONLY SOLUTIONS OFFERED TO ME.
Electrical system, Latches/locks/linkages, Jun 10, 2011
WENT TO LEAVE WORK YESTERDAY AND THE KEY WON'T TURN AT ALL IN MY 2002 FORD FOCUS. AFTER A QUICK INTERNET SEARCH, IT SEEMS TO BE A HUGE PROBLEM AND CONSISTENT FAILURE ON FORDS PART...BUT THEY REFUSE TO ISSUE A RECALL. FROM WHAT I'VE READ, THE DEALERSHIP CHARGES $350-450 TO REPLACE THIS PART, AND THEY REPLACE IT WITH THE SAME FAULTY DESIGNED PART THAT WAS CAUSING THE PROBLEM IN THE FIRST PLACE! *TR