2002 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,014 owner complaints filed for this model year. This is the 9th highest complaint count among 19 Focus model years with reports.
Of the 2002 reports, 85 involved a crash and 24 involved a fire. 82 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: electrical system
285 reports, newest first. Show all
Electrical system, May 22, 2006
I WAS LEAVING WORK LATE ONE NIGHT AND COULD NOT GET MY 2002 FORD FOCUS ZX3 TO START. THE IGNITION WAS LOCKED AND SO WAS THE STEERING WHEEL. NO AMOUNT OF TURNING THE WHEEL OR JINGLING THE KEY WORKED. THE CAR RECOGNIZED THAT THERE WAS A KEY IN THE IGNITION AS IT BEGAN TO 'DING' BUT NO MATTER WHAT I DID THE KEY WOULD NOT TURN IN THE IGNITION. LUCKILY THERE WAS A COMPANY CAR AVAILABLE THAT I COULD TAKE HOME. I COMMUTE OVER 50 MILES ONE WAY TO WORK. WALKING, BUS AND TAXI ARE NOT AVAILABLE OPTIONS FOR ME. I AM A YOUNG WOMAN WORKING IN DOWNTOWN PHOENIX AND I NO LONGER FEEL SECURE IN MY VEHICLE. I HAVE RESEARCHED THIS EXTENSIVELY ON THE INTERNET. IT COULD BE A WORN KEY TIP, THE KEYS ARE MICROCHIPPED FOR ANTI-THEFT SECURITY SO A NEW ONE CAN ONLY BE MADE AT THE DEALERSHIP AND MUST BE THE SAME NUMBER AS YOUR KEY. IT COULD BE FAULTY TUMBLERS, FORD CREATED THEIR OWN IGNITION TO SAVE MONEY AND THE TUMBLERS MAY NOT FALL CORRECTLY, OR FALL TO FAR IN TO ALLOW THE KEY TO FIT! THERE IS NO CURRENT RECALL, A P05 IS IN PROGRESS, AND THERE ARE NO TECHNICAL SERVICE BULLETINS LISTED. IF MY CAR IS NO LONGER UNDER WARRANTY, DESPITE MY PURCHASE OF THE EXTENDED WARRANTY IT WILL COST ANYWHERE FROM $35.00 FOR A NEW MICROCHIPPED KEY, TO $500 FOR DRILLING A NEW IGNITION AND NEW KEYS, A TOW, AND LABOR. AUTOMOTIVETALK.NET HAS BEEN THE MOST HELPFUL WEBSITE SO FAR, BUT I WANTED TO ADD MY VOICE TO THE LIST IN ORDER TO GET A RECALL ROLLING AND HAVE FORD PAY FOR THIS CHEAP IGNITION THAT FAILS REPEATEDLY. I WILL REFUSE TO PAY FOR THE REPLACEMENT COST ON THIS OBVIOUSLY POORLY ENGINEERED PART. *NM
Electrical system, May 12, 2006
THE IGNITION SWITCH LOCKED UP IN MY CAR. I HAVE HAD THREE OTHER FRIENDS WITH THE SAME CAR SAY THAT THERE IGNITION SWITCH DID THE SAME THING. *JB
Electrical system, May 12, 2006
IGNITION SWITCH ON MY 2002 FORD FOCUS WITH 34,000 MILES FAILED. REQUIRED A TOW AND REPLACEMENT. TOTAL COST OF REPLACEMENT WAS $290. FORD WILL NOT ACKNOWLEDGE THAT THERE IS A QUALITY PROBLEM WITH THE IGNITIONS. THERE ARE LOTS OF FAILURES OF THEM. THIS SHOULD BE RECALLED. THANKS TOM ROLLAND. *JB
Electrical system, May 10, 2006
DT*: THE CONTACT STATED WHILE ATTEMPTING TO START THE VEHICLE THE IGNITION LOCKED UP, AFTER MULTIPLE ATTEMPTS THE VEHICLE STARTED. THIS PROBLEM CONTINUED INTERMITTENTLY, BUT THE VEHICLE WAS NOT INSPECTED BY A MECHANIC. THE VEHICLE THEN STALLED WITHOUT WARNING AT AN INTERSECTION AND THE IGNITION LOCKED UP, A LOCKSMITH WAS CONTACTED TO REPLACE THE IGNITION. THE IGNITION LOCKED UP A FINAL TIME AND THE VEHICLE WAS TOWED THE CONTACT'S RESIDENCE. THE DEALERSHIP WAS ALERTED AND AN IGNITION SWITCH WAS ORDERED, BUT THE VEHICLE HAS NOT BEEN REPAIRED.
Electrical system, May 8, 2006
THE IGNITION SWITCH LOCKED UP, NOT ALLOWING THE KEY TO TURN. *NM
Electrical system, May 2, 2006
TURNED ON MY LIGHT SWITCH TO DRIVE HOME AT NIGHT AND NOTICED MY DASH LIGHTS WERE NON-OPERATIONAL. GOT OUT OF MY CAR AND DID A WALK AROUND AND FOUND THAT MY TAIL LIGHTS WERE NOT WORKING EITHER. I DID AN INTERNET SEARCH AND FOUND POSTINGS REGARDING THIS FAILURE ON OTHER FOCUSES. I'VE PROVIDED A LINK HTTP://FORUMS.FOCALJET.COM/TEAM-TECH/457187-TAILLIGHTS-OUT-PROBLEM-FOUND-SERIOUS-SAFETY-HAZARD.HTML?HIGHLIGHT=DASH+LIGHTS+TAIL I CALLED FORD THEY DID NOT CARE AND WOULD NOT HELP. I AM THE ORIGINAL OWNER AND THE CAR HAS 45,000 MILES ON IT. *JB
Electrical system, Apr 29, 2006
I HAVE A 2002 FORD FOCUS AND MY IGNITION LOCKED UP AGAIN AND THIS TIME I COULD NOT START MY CAR I WAS STRANDED FOR AN 2 HOURS WAITING FOR A TOW TRUCK TO GET THE CAR. WHEN I PARKED THE CAR IT WAS NOT STRAIGHT SO I CAOULD NOT PARK IT STRAIGHT TO WAIT TO GET IT FIXED . I CALLED A REPAIR GUYS AND HE SAID THAT THIS IS VERY COMMON WHAT CAN WE DO ABOUT THIS. I WAS TOLD IT IS GOING TO COST ME ABOUT $300.00 I AM A SINGLE PARENT HOW DOES FORD MOTOR COMPANY BELIEVE THAT WE HAVE ANY TRUST IN THE VEHICLE WHEN THEY KNOW THAT THIS IS AN ISSUE AND DO NOT FIX IT AT THERE COST IN STEAD OF OURS. *NM
Electrical system, Apr 27, 2006, fire
55,000 MILES ON THE VEHICLE. ON 3/25/05, WHILE PARKED & LOCKED, THE IGNITION MALFUNCTIONED ON ITS OWN, RESULTING IN A FIRE THAT BURNED THE STEERING COLUMN. THE FIRE CAUSED OTHER DAMAGES AND HEAVY SMOKE WITHIN THE SEALED PASSENGER COMPARTMENT. THE FIRE EXTINGUISHED ITSELF WITH THE LACK OF OXYGEN. PICTURES OF THE WIRING HARNESS, STEERING COLUMN AND INTERIOR ARE AVAILABLE WITH THE INSURANCE COMPANY CLAIM FILE. *NM
Electrical system, Apr 27, 2006
MY 2002 FORD FOCUS HAS A IGNITION LOCK PROBLEM. THE KEY IS IMPOSSIBLE TO TURN. I HAD TO CALL A TOW TRUCK AND ALSO PAY $400 PLUS TAX TO FIX THIS PROBLEM THAT I HAVE FOUND OUT IS WIDESPREAD. *NM
Electrical system, Apr 23, 2006
IGNITION SWITCH WILL NOT TURN. *NM
Electrical system, Apr 7, 2006
HAVE HAD AN IGNITION FREEZING UP PROBLEM AND RESEARCHED IT ONLINE AND NOTICED THIS HAS BEEN AN ON GOING PROBLEM WITH FORD. I HAVE A 2002 FORD FOCUS. FIRST TIME I HAVE HAD A CAR IGNITION FREEZE UP. *JB
Electrical system, Mar 24, 2006
THE IGNITION SWITCH OF THE FORD FOCUS YEARS 2000-2002 FOR SURE MAY BE OTHER YEARS BECOME JAMMED WHICH COULD LEAD TO CRASHES. I AM WORRIED EVERY TIME I DRIVE MY CAR. THIS ITEM NEEDS TO BE RECALLED BY FORD MOTOR COMPANY. *JB
Electrical system, Feb 3, 2006, crash
THREE INSTANCES. VEHICLE ELECTRICAL SYSTEM (DASH, GAUGES, LAMPS, ETC) SUDDENLY GO DEAD. ENGINE THEN SURGES AND STALLS. POWER STEERING AND POWER BRAKES FAIL. VEHICLE FAILS TO RESTART. 1ST INSTANCE (12/2004): DEALER HAD FAILED TO PROPERLY RECONNECT ELECTRICAL CONNECTORS AFTER RECALL SERVICE. ACCIDENT OCCURRED, MINOR INJURIES. 2ND INSTANCE (1/22/2006): DEALER FOUND NO PROBLEM. VEHICLE RESTARTED. 3. 3RD INSTANCE (2/3/2006): DEALER FOUND FAULTY ALTERNATOR/ALTERNATOR WIRING. *NM
Electrical system, Jan 28, 2006
IGNITION DOES NOT TURN ON 2002 FORD FOCUS. I CANNOT TURN THE KEY. I HAVE LOOKED AROUND ON THE INTERNET AND THERE WERE A LOT OF PEOPLE WHO HAD THIS SAME PROBLEM. I FIXED IT BY TAPPING THE KEY WITH A HAMMER AS I TURNED THE KEY. THE DEALERSHIP WANTED ME TO PAY THEM $400 TO FIX THIS PROBLEM, BUT I THOUGHT FORD SHOULD JUST FIX IT BEFORE THEY MAKE THEIR WORTHLESS CARS.*AK
Electrical system, Jan 19, 2006
THE IGNITION SOLENOID FAILS ON THIS MODEL. UPON SEARCHING ONLINE AND TALKING TO A FEW LOCKSMITHS IT WOULD SEEM THE IGNITION IS SUBSTANDARD/FAULTY IN MY CAR. HOW EXACTLY DOES A KEYED LOCK FAIL? IS THIS A KNOWN ISSUE? *NM
Electrical system, Jan 10, 2006
ON 01/10/06 THE IGNITION OF MY FORD FOCUS ZX3 (2002, 46000 MILES)) LOCKED UP. I WAS UNABLE TO TURN THE KEY AND START THE CAR, BLOCKING THE ENTRANCE TO A PARKING GARAGE. AN AUTOMOTIVE TECHNICIAN WAS ABLE TO HOT-WIRE THE CAR SO I COULD DRIVE IT TO THE CLOSEST DEALERSHIP. I HAVE CONTACTED FORD OVER THE PHONE BECAUSE I DID PURCHASE THE EXTENDED WARRANTY WITH THE CAR. FORD DOES NOT FEEL RESPONSIBLE FOR THIS INCIDENT AND WILL NOT COVER THE REPAIR COST UNDER THE EXTENDED WARRANTY. I HAVE RESEARCHED THIS ISSUE ONLINE AND WAS ABLE TO FIND SEVERAL THOUSANDS OF OTHER FORD OWNERS WITH THE EXACT SAME PROBLEM. THE LOCKING OF THE STEERING COLUMN SEEMS TO HAPPEN OVER AND OVER AGAIN, AS THE LOCKS THAT ARE BEING USED AS A REPLACEMENT ARE OF THE SAME BAD QUALITY AS THE ORIGINALS. *JB
Power train, Electrical system, Jan 10, 2006
IGNITION WILL NOT TURN. CLUTCH MASTER CYLINDER LEAKS. *JB
Electrical system, Jan 9, 2006
I JUST BOUGHT A 2002 FORD FOCUS. MY KEY WONT TURN AND MY STEERING WHEEL IS LOCKED UP. ON-LINE I HAVE NOTICED THIS IS A HUGE PROBLEM WITH FOCUSES. I AM GOING TO GET IT FIXED, BUT AM CONCERNED BECAUSE IT SEEMS TO BE A BIG PROBLEM THAT WILL CONTINUE TO RE-OCCUR. I HAVE BEEN WITHOUT A CAR FOR SOMETIME, AND WAS STRANDED. LUCKILY IT HAPPENED AT MY APARTMENT AND I DID NOT HAVE TO HAVE THE CAR TOWED IMMEDIATELY. *NM
Electrical system, Dec 22, 2005
IGNITION SWITCH LOCK-UP. NO PREVIOUS PROBLEMS. NOT COVERED BY WARRANTY. VEHICLE ONLY HAS 55,000 MILES. COST TO REPAIR APPROXIMATELY $300. *NM
Electrical system, Nov 23, 2005
DT: THE CONTACT STATED THE IGNITION LOCKED, AND THE KEY/STEERING WHEEL WOULD NOT TURN. THE VEHICLE WAS TOWED TO THE DEALERSHIP, AND THEY FOUND THE IGNITION CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, AND THERE HAVE BEEN NO PROBLEMS SINCE THEN. *AK
Electrical system, Nov 3, 2005
2002 FORD FOCUS ZTS LOCKED IGNITION --TUMBLERS WERE OUT OF SYNCH? FOUND OUT THAT THIS WAS A COMMON PROBLEM BUT THE DEALER WON'T AUTHORIZED TO FIX IT WITHOUT CHARGE. PAID $293 FOR REPAIR. SEEM TO BE A PROBLEM WHICH COULD BE A RECALL ISSUE. THANK YOU FOR YOUR CONCERN. *NM
Electrical system, Oct 20, 2005
1. MOST RAIN OR SNOW (WET CONDITION) DRIVING CAUSES PARTIAL OR COMPLETE FAILURES OF HORNS 2. IF CAR IS DRIVE IN WET OR SNOW CONDITIONS, THE HORNS FAIL. THIS IS A PARTIAL FAILURE WHERE HORN ARE BARELY AUDIBLE, OR IN HEAVY WET AND COLD ( FREEZING CONDITIONS) HORNS FAIL COMPLETELY. IN ALL CASES TO DATE, OVER TIME,( USUALLY WEEKS ) HORN RETURNS TO NORMAL FUNCTION DURING DRY/AND WARM UP PERIODS. DO DATE NO CONSEQUENCES. (3) FORD DEALERSHIP HAS REPLACED HORNS 2 TIMES (THERE IS A FORD SERVICE BULLETIN) HOWEVER, HAS NOT CHANGED THE CONDITION, IT CONTINUES. OLD PART KEPT BY DEALER. *JB
Electrical system, Oct 11, 2005
FORD FOCUS 2002 ZX5 OVER 65,000 MILES RECENT OFL CHANGE APPROX. 3 WEEKS AGO. ENGINE CUTTING OFF AFTER TURNING OVER WHEN SHIFTING FROM PARK INTO DRIVE ALMOST EVERY DAY. ENGINE CUTTING OFF WHILE DRIVING AT ANY SPEEDS BUT MOST NOTABLY DURING OR AFTER A TURN - WITH LOSS OF POWER STEERING - ABLE TO RESTART IN NEUTRAL WHILE IN MOTION - THIS HAPPENS AN AVERAGE OF EVERY 3-4 DAYS. CONSTANT NOISE FROM THE REAR LEFT TIRE ASSEMBLY. FRONT BRAKES REPLACED ABOUT 1 AND HALF YEARS AGO. RIGHT REAR BRAKE ASSEMBLY REPLACED 4 MONTHS AGO ALONG WITH CRACKED THERMAL HOUSING THAT HAD DEVELOPED A LEAK - OVER $900 REPAIR W/LABOR. CAR HAS NOT BEEN IN AN ACCIDENT THAT I AM AWARE OF- OTHER THAN LOSS OF DRIVER SIDE MIRROR WHILE IT WAS PARKED 2 YEARS AGO. OTHER ISSUES WITH THIS VEHICLE HAVE BEEN W/THE SHIFTING. UNABLE TO SHIFT OUT OF PARK - W/O USING THE SHIFT RELEASE. REPLACED SHIFTER AND STILL HAVING PROBLEMS WITH IT. CAN NOT AFFORD TO TAKE CAR IN AT THIS TIME - WAS TOLD BY SERVICE REP THAT THE DIAGNOSTIC WOULD COST APPROX. $80 ALONE JUST TO SEE IF THEY COULD FIND THE PROBLEM. ORIGINAL OWNER. TAKING CAR TO DEALER THIS WEEKEND. ANY HELP WOULD BE APPRECIATED. *NM
Electrical system, Sep 29, 2005
COULD NOT REMOVE IGNITION KEY NOR START THE VEHICLE. COMPLETE IGNITION KEY FAILURE. *JB
Electrical system, Sep 27, 2005
DT: THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT STATED THAT WHEN HE INSERTED THE KEY INTO THE IGNITION, IT LOCKED AND DID NOT ALLOW THE CONSUMER TO START THE VEHICLE. THE CONSUMER DID HAVE THE CYLINDER LOCK REPLACED IN THE IGNITION. THIS DID REMEDY THE PROBLEM. THE DEALERSHIP WAS AWARE THAT THERE WAS A PROBLEM WITH THE IGNITION ON THIS TYPE OF VEHICLE. THE MANUFACTURER STATED THAT THIS SPECIFIC PART WAS NOT COVERED UNDER THE WARRANTY, AND THERE WAS NO RECALL. THE CONSUMER DID HAVE TO COVER THE COST OF THE REPAIR.*AK