2002 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,014 owner complaints filed for this model year. This is the 9th highest complaint count among 19 Focus model years with reports.
Of the 2002 reports, 85 involved a crash and 24 involved a fire. 82 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
108 reports, newest first. Show all
Engine and engine cooling, Oct 27, 2004
VEHICLE STALLED AT VARIOUS SPEEDS. VEHICLE WAS TAKEN TO THE DEALER ON SEVERAL SEPARATE OCCASIONS. DEALER REPLACED THE AIR INTAKE VALVE TWICE, BUT PROBLEM RECURRED. *AK
Engine and engine cooling, Aug 11, 2004
WHILE DRIVING VEHICLE STALLED. CONSUMER WAS UNABLE TO RESTART VEHICLE, AND HAD IT TOWED TO THE DEALER FOR INSPECTION. HOWEVER, MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK
Engine and engine cooling, Jul 10, 2004
ENGINE JUST DIES WITH NO WARNING WHILE ON THE HIGHWAY,AFTER ENGINE DIES I LOSE POWER STEERING, AND WHEEL WILL NOT TURN. I AM ABLE TO RESTART THE CAR WHILE STILL IN MOTION. THIS IS THE THIRD TIME THIS HAS HAPPENED.*AK
Engine and engine cooling, Jun 30, 2004
I WAS DRIVING ON THE ON-RAMP OF THE PA TURNPIKE WHEN SCALDING WATER FROM UP UNDER THE DASH POURED OUT ONTO MY RIGHT FOOT. I WAS BARELY ABLE TO DRIVE THE CAR TO A SAFE STOP. I SUSTAINED SECOND AND THIRD DEGREE BURNS TO MY RIGHT FOOT. THE WRECKER TOOK THE CAR TO A FORD DEALER IN EMMAUS, PA FOR REPAIRS. THE SERVICE DEPARTMENT ORIGINALLY TOLD ME THAT THE EVAPORATOR LINE WAS PLUGGED, BUT WHEN I PICKED UP MY CAR, THE NARRATIVE ON THE SERVICE FORM SAID THAT THE LINE WAS NOT PLUGGED. THEY REPLACED THE EVAPORATOR WHICH I UNDERSTAND ENTAILED REMOVING THE ENTIRE DASH. I DO NOT KNOW IF THE OLD PART IS AVAILABLE.*AK
Engine and engine cooling, Jun 14, 2004
CHECK ENGINE LIGHT COMONG ON, HAD IT IN SHOP 5 TO 7 TIMES AND THEY SAY IT IS THE EVAP SYSTEM, SHUT OFF THE LIGHT AND SEND ME OUT THE DOOR!! WHAT IS UP WITH THAT? *AK
Engine and engine cooling, May 18, 2004
HEAT SHIELD DROPPED WHILE DRIVING ON WEST RIDGE ROAD CAUSING SPARKS. IT RUPTURED THE FUEL LINE WHICH CAUSED THE FUEL TO SPEW ALL OVER THE ROAD. 911 CONTACTED, ROAD CLOSED AND TACO BELL WHERE THE VEHICLE WAS MOVED, WAS EVACUATED DUE TO THE MASSIVE FUEL LEAK AND FUMES. DEALERSHIP CONTACTED, TOW TRUCK PICKED UP VEHICLE.*AK
Engine and engine cooling, Mar 17, 2004, fire
WHILE DRIVING ON THRUWAY ENGINE QUIT, AND CAR WAS ON FIRE. COURTESY FORD CHECKED CAR AND FOUND PISTON WENT THROUGH BLOCK CAUSING OIL TO CATCH FIRE UNDER CAR AND MELTING FUEL LINES. VEHICLE HAS 60K AND HAS BEEN SERVICED REGULARLY. QUOTED OVER $6000.00 AND WAS TOLD WARRANTY ENDED AT 36K. THIS INCIDENT COULD HAVE BEEN VERY SERIOUS. *NM
Engine and engine cooling, Power train, Mar 11, 2004
WHILE DRIVING AT HIGHWAY SPEEDS ENGINE LOST POWER, NEARLY RESULTING IN A REAR END COLLISION. DEALER WAS NOT ABLE TO DUPLICATE THE PROBLEM. *AK THE TACHOMETER WOULD SUDDENLY RACE UP TO 7000 AND THE WHEELS LOST POWER. THE VEHICLE FELT AS IF IT WERE IN NEUTRAL, AFTER 15-30 SECONDS OR DOWNSHIFTED TO 2ND GEAR, THE VEHICLE RE-ENGAGES AND THE WHEEL POWER WAS RESTORED. THIS WAS AN INTERMITTENT PROBLEM. FORD WAS UNABLE TO DIAGNOSE THE PROBLEM. A FLIGHT RECORDER WAS INSTALLED TWICE. THE ENGINEERS REVEALED THAT THE PROBLEM COULD HAVE BEEN RELATED TO THE SPEED SENSORS AND INPUT SHAFT SENSORS. THE CONSUMER'S HUSBAND EXPERIENCED A COMPLETE LOSS OF POWER. THE VEHICLE WAS UNABLE TO BE MOVED BECAUSE THERE WAS NO POWER STEERING. THE LOSS LASTED 10 SECONDS, THE GEAR WAS PLACED INTO 2ND GEAR, THEN BACK TO DRIVE AND THE POWER STEERING WAS BACK ACTIVE. THIS PROBLEM RETURNED TWO MORE TIMES. ON ONE OF THE INCIDENCES, THE TACHOMETER HAD GONE OVER 7 THEN DROPPED. THE TRANSMISSION SLIPPED INTERMITTENTLY. *SC
Engine and engine cooling, Mar 2, 2004
WHILE DRIVING 35 MPH VEHICLE STALLED. CONSUMER MANAGED TO PULL OVER, AND HAD THE VEHICLE TOWED. DEALERSHIP WAS NOTIFIED, BUT IT DID NOT RESOLVE THE PROBLEM. *AK
Engine and engine cooling, Feb 5, 2004
INTERMITTENTLY AT ANY SPEED, THE VEHICLE WILL SHIFT OUT OF DRIVE AND INTO NEUTRAL THEN BACK INTO DRIVE. THE VEHICLE HAS BEEN TO THE DEALER SEVEN TIMES FOR THIS PROBLEM. THE DEALER WILL NOT DO ANYTHING BECAUSE THEY CAN NOT DUPLICATE THE PROBLEM. THE MANUFACTURER IS AWARE OF THE PROBLEM.
Engine and engine cooling, Jan 29, 2004
CONTROL CABLE ON DUAL STAGE INTAKE MANIFOLD FRACTURED FROM HOUSING, RESULTED IN LOSS OF CONTROL TO VARIABLE INTAKE RUNNERS. VEHICLE EXHIBITED INCREASED IDLE AND DRIVEABILITY PROBLEMS AND STALLING.*AK
Engine and engine cooling, Air bags, Jan 22, 2004, crash
WHILE DRIVING AT ANY SPEED VEHICLE HESITATED AND TOOK A DIP FORWARD AND DOWN TO THE GROUND. THEN, IT ACCELERATED AS IF NOTHING HAPPENED. CONSUMER'S DAUGHTER EXPERIENCED THE SAME THING WHILE DRIVING AND LOST CONTROL OF THE VEHICLE WHICH LANDED IN A DITCH. CONSUMER'S DAUGHTER SUSTAINED BACK INJURIES. CONSUMER WORE SEAT BELTS. HOWEVER, AIR BAGS FAILED TO DEPLOY. *AK
Engine and engine cooling, Jan 22, 2004
AT ANY SPEED ENGINE CHECK LIGHT CAME ON , AND THEN, ENGINE RUMBLED AND STALLED.VEHICLE STALLED TEN TIMES. A RECALL WAS ISSUED, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
Engine and engine cooling, Other or unspecified, Jan 15, 2004
I BOUGHT THE CAR ON OCT 29, 2002. SINCE DAY ONE THE CAR HAS CONSUMED WAY TOO MUCH GAS. IT IS OUTRAGEOUS! IT HAS BECOME A MORTGAGE PMT! MY CAR PMT IS $344 A MONTH I PAY THE SAME IN GAS A MONTH. I USE TO OWN A 1993 FORD ESCORT,STICK,4 CYC AND NEVER DID I EVER SPEND SO MUCH GAS. I AM 49 YRS OLD, DON?T SPEED, AND KNOW THE DIFFERENCE. I HAVE ALSO OWNED MANY STICK,4 CYL CARS AND NONE HAVE EVER SPEND SO MUCH GAS. THERE HAS GOT TO BE A PROBLEM WITH THE CAR IN THAT RESPECT. SECOND: A COUPLE OF MONTHS AGO THE "CHECK ENGINE" LIGHT CAME ON, EVER SINCE THEN, MY CAR WON'T START IN THE MORNINGS, AND WHEN IT HAS BEEN SITTING FOR A AWHILE. I HAVE BROUGHT MY CAR TO THE DEALER 4 TIMES ALREADY, THEY HAVE CHANGED THE FUEL PUMP 3 TIMES, STILL HAVING THE SAME PROBLEM, THIS LAST TIME IN WHICH I PICKED UP THE CAR YESTERDAY, NOV. 11, NOTHING WAS DONE! I ASK QUESTIONS BUT ALL I GET IS THERE IS NOTHING WRONG! BUT SOMETHING IS HAPPENING...NOWADAYS, EVERYTHING IS COMPUTERIZED, ONE THING GOES BAD AND IT AFFECTS THE ENTIRE CAR. SOMETHING IS NOT BEING CHECK, BUT I AM INFORMED, EVERYTHING IS BEING CHECKED! I HAVE HAD IT WITH THE CAR! WITH THE AMOUNT OF GAS THAT IS BEING CONSUMED & THE NOT STARTING JUST DON?T KNOW WHAT TO DO! THERE IS SOMETHING MAJORLY WRONG WITH THIS CAR! I CAN'T STAY THIS WAY, IT IS NOT FAIR, IT?S SO EXPENSIVE TO OWN A CAR NOWADAYS. THE STRESS OF BEING LEFT ANYWHERE, BEING LATE FOR WORK MOST OF THE TIME DUE TO THE CAR NOT STARTING. WHY SHOULD I PAY FOR SOMETHING THAT IS NOT WORKING PROPERLY? I WORK, LIVING PAY CHECK TO PAY CHECK, I AM HAVING WAY TOO MUCH STRESS & NOW I AM @ A POINT WHERE IT HAS EFFECTED MY WORK, POSSIBLY I WILL LOOSE MY JOB.
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Electrical system, Exterior lighting, Visibility, Structure, Tires, Equipment, Other or unspecified, Jan 15, 2004
THERE IS A LINE THAT WENT STRAIGHT INTO THE ENGINE'S INTAKE THAT HAS BEEN LEAKING FLUID SINCE 2,000 MILES AND WAS INSPECTED BY DELER WHO TOLD TO ME THAT IT WAS NOTHING. BUT THE ENGINE CASE SHOULD NOT HAVE A LARGE LEAK OF FLUID THAT SOON. FINALLY NOW, THEY HAVE DONE SOMETHING ON THIS AND REPLACED THE HOSE, AS IT WAS SEEN ONCE MORE AND KNOWS OF ALL THE TIMES REPORTED. I HOPE THIS IS JUST NOT A EASY FIX OR THIS NOW HASN'T CAUSED ANY DAMANGE TO THE INSIDE OF THE ENGINE ITSELF, AS THE ENGINE HAS BEEN IN THE SHOP FOR RIDING ROUGH. THEY TOLD ME LAST TIME THAT THE PART OF THE TRANSMISSION THAT WAS FIXED WOULD FIX THIS. I THINK IT IS DUE TO THE OIL LEAK ON THE TOP OF THE ENGINE CASE SINCE IT WAS NEW. A NEW CAR SHOULD NEVER HAVE A OIL LEAK ON A ENGINE CASE.
Steering, Suspension, Engine and engine cooling, Tires, Wheels, Jan 15, 2004
PROBLEM I'M STILL HAVING AND WAS REPORTED TO DEALERSHIP IS CAR PULLS TO LEFT, ( NOT CORRECTED) BACK END OF CAR OR TIRES BOUNCE ON ROAD AND ESPECIALLY WHEN HITTING A BUMP, CANNOT STAY ON ROAD IN SLUSH OR SNOW, BACK END IS ALL OVER ROAD, ( NOTHING DONE) TIRES ARE COMPLETELY GROVED IN MANY SPOTS ON THE TIRES, CAUSED BY REAR END BOUNCING ON ROAD, FIRESTONE WON'T REPLACE THEY SAY IT IS FOCAS'S REAR END AND IT WEARS OUT THE TIRES, DEALER OR FORD WON'T DO ANYTHING ABOUT REAR END OR TIRES, CAR VIBRATES BADLY, REAR DOORS BARLEY OPEN ARE SO STIFF, LOOKS LIKE DOOR LOCKS ARE COROADED NOTHING WAS DONE BY DEALERSHIP EVEN THOUGH THEY SAID THEY LUBRICATED, NOTHING IS ON THE LOCKS TO SHOW LUBRICATION OF LOCKS.
Engine and engine cooling, Jan 15, 2004
THE CAR IS A 2002 SVT FOCUS. THE ENGINE HAS A SEVERE MISS/SURGE UNDER NORMAL DRIVING CONDITIONS. THE LAST TICKET ON THE VEHICLE STATES THAT THERE IS NO FIX AT THIS TIME. OCTOBER 27, 2003 UPDATE: THANK YOU FOR YOUR HELP ON THIS MATTER. FORD PURCHASED THE VEHICLE BACK, REFUNDED ALL OF THE PAYMENTS MADE, AND COMPENSATED ME FOR ANY AFTERMARKET PARTS I HAD THE RECEIPT FOR. FORD WENT OUT OF ITS WAY TO MAKE ME HAPPY. THANK YOU.
Engine and engine cooling, Equipment, Jan 15, 2004, fire
ON NOVEMBER 9, 2002 WHILE DOING ERRANDS I NOTICED SMOKE COMING FROM THE ENGINE AREA OF 2002 FORD FOCUS (5 MONTHS OLD). IT WAS A WET AND RAINY DAY AND THE WINDOWS WERE FOGGING-UP. I HAD TO ROLL THE WINDOWS DOWN TO DEFROST THE LIGHT MIST ON THE WINDOWS, AS THE DEFROST BUTTON WOULD NOT WORK. THE SMOKE BECAME SO THICK I DECIDED TO PULLED OVER AND CALL FOR FORD ROAD SERVICE. BY THE TIME I WAS GIVING THE REP. MY LOCATION PEOPLE WERE RUNNING FROM THIER HOMES TO MOVE THIER CARS. I TOLD THE REP. THE CAR IS ON FIRE. I HUNG-UP AND CALLED THE FIRE DEPARTMENT. THE FIRE DEPARTMENT RESPONDED IN LESS THAN A MINUTE. I RAN BACK TO MY NEW CAR AND WATCHED AS IT BURNED. THE FIRE DEPARTEMENT SAID THE ENGINE FIRE WAS CAUSED BY AN ELECTRICAL SHORT. I WAS ALSO TOLD THAT I PULLED OVER JUST IN TIME. MY INSURANCE COMPANY HAS NOT BEEN HELPFUL. FORD ASSURED ME THAT THEY WOULD TAKE CARE OF EVERYTHING. I AM WAITING FOR FORD MOTOR TO TAKE CAR OF EVERYTHING. I TOLD THEM IN A FAX I SENT LAST WEEK THAT I WANT THAT "BLUE OVAL" SERVICE THEY CONSTANTLY TALK ABOUT - MAYBE SOMEDAY. THANKS, DENISE KEYES
Engine and engine cooling, Jan 15, 2004
HEATING/VENT PRODUCES A DISGUSTING SMELL. REPAIRS INDICATED OIL LEAK NEAR HEATER - UNKNOWN ORIGIN. SMELL ABATED BUT STILL IT PRODUCES ANNOYING SMELLS THAT REQUIRES WINDOWS TO BE KEPT OPEN. WILL HAVE TO GO BACK TO SELLING DEALERSHIP 4TH TIME FOR FURTHER INVESTIGATION. IS THERE A BETTER WAY AND ANOTHER SHOP IN CLEVELAND, OH THAT CAN MAKE AN INDEPENDENT ASSESSMENT OF THE PROBLEM? THANKS.
Engine and engine cooling, Visibility, Jan 15, 2004
THE ENGINE EXPERIENCED COMPLETE FAILURE AT 55 MPH WITH NO WARNING SIGN. IT HAS NOT BEEN TAKEN TO THE DEALER FOR INSPECTION. SUNROOF WAS STUCK IN OPEN POSITION AND WOULD NOT CLOSE PROPERLY UNLESS MANIPULATED BY HAND. DEALER FIXED THE PROBLEM THE FOLLOWING DAY.
Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Visibility, Tires, Equipment, Nov 17, 2003
9 REPAIR ISSUES IN 8,000 MILES. 1. GRINDING BRAKES. 2. SUNROOF FAILED TO CLOSE. 3. ENGINE SENSOR FAILED. 4. TIRE DEVELOPED A BUBBLE. 5. INTAKE RUNNER FAILED. 6. STEREO JAMMED. 7. HORN FAILED. 8. DEFECTIVE CONTROL ASSEMBLY. 9. DEFECTIVE MANIFOLD ASSEMBLY. *LA
Engine and engine cooling, Nov 11, 2003
I BOUGHT MY FORD FOCUS ZX5 ON OCTOBER OF 2002. A MONTH AFTER I HAD IT I TOOK IT THROUGH THE CAR WASH AND IT STALLED. EVER SINCE THEN I HAD HAVE PROBLEMS STARTING IT. I BROUGHT IT IN AND WAS TOLD THAT THERE WAS NOTHING WRONG WITH THE CAR. ON JULY 21, 2003 CAR STALLED GOING THROUGH AN INTERSECTION WITH ON-COMING TRAFFIC, I GOT THE CAR TO START AND I BROUGHT IT IN TO THE DEALERSHIP AND AGAIN THEY CAN'T FIND ANYTHING WRONG WITH THE CAR. THEY REFERRED ME TO THE DISPUTE SETTLEMENT BOARD. I FILLED OUT ALL THE INFORMATION AND SUBMITTED IT. ON SEPTEMBER 11, 2003 THE BOARD DECIDED THAT THEY DID NOT FIND A PROBLEM SO I HAD A FORD ENGINEER COME OUT. HE FINALLY CAME OUT IN OCTOBER AND SAID THERE WAS NOTHING WRONG WITH THE CAR. I DO NOT FEEL SAFE IN THIS VEHICLE. I TRIED TO GET RID OF THIS VEHICLE BUT I OWE $10,000.00 MORE THAN IT IS WORTH. PLEASE HELP. I DON'T KNOW WHAT ELSE TO DO.*AK
Engine and engine cooling, Power train, Electrical system, Nov 7, 2003
ENGINE STALLED AFTER I HAD DRIVEN TWO MILES WITH NO WARNING. I HAD JUST DOWN-SHIFTED INTO 2ND GEAR AS I WAS SLOWING TO MAKE A TURN AND THE CAR STALLED ACROSS TWO TRAFFIC LANES AND WOULD NOT RESTART. THE OIL LIGHT, BATTERY LIGHT, AND ONE OTHER LIGHT CAME ON (ALTERNATOR I THINK). THE CAR WAS MANUALLY PUSHED OUT OF TRAFFIC LANES IN NEUTRAL GEAR BY TWO MOTORISTS WHO STOPPED TO HELP. THEY WERE ALSO UNABLE TO RESTART THE VEHICLE. AFTER APPROXIMATELY 10 MINUTES THE ENGINE STARTED. I HAD THE CAR TOWED AND AFTER 5 DAYS THE DEALERSHIP STILL CANNOT FIND ANYTHING WRONG. APPARENTLY THE ONBOARD COMPUTER DID NOT CAPTURE THE PROBLEM. I AM EXTREMELY CONCERNED BECAUSE THE CAR STALLED WITHOUT WARNING AT APPROXIMATELY 25 MILES AN HOUR. HAD I BEEN ON THE INTERSTATE AS SCHEDULED (I WAS RUNNING LATE AND HAD TO DROP MY DAUGHTER OFF BEFORE GOING HOME TO PICK UP MY LAPTOP) I WOULD ALMOST CERTAINLY HAVE BEEN INVOLVED IN AN ACCIDENT BECAUSE I HAD NO TIME TO MANEUVER OUT OF TRAFFIC AFTER THE ENGINE STALLED. IT WAS 75 DEGREE DAY (MONDAY 11/3/03) SO OUTSIDE TEMPERATURE COULD NOT HAVE BEEN A FACTOR. *LA
Engine and engine cooling, Oct 13, 2003
MY CAR JUST DIES WHEN I AM DRIVING. THE LIGHTS IN MY DASH ALL LIGHT UP, MY POWER STEERING GOES OUT, AND MY CAR JUST TURNS OFF WHILE I AM DRIVING. THIS HAS HAPPENED AT LEAST 7 TIMES. I HAVE ALREADY TAKEN IT IN 4 TIMES TO GET IT FIXED. *LA
Engine and engine cooling, Sep 17, 2003
SINCE 7/7/03 MY 2002 ZX5 FORD FOCUS HAS STALLED AND NOT RESTARTED RIGHT AWAY AT LEAST 15 TIMES. I'VE HAD IT TOWED TO THE DEALERSHIP 5 TIMES. THEY HAVE HAD IT THERE FOR 50 DAYS SINCE 7/7/03. EACH TIME EXCEPT THIS LAST ONE THEY CLAIM THEY FIND WHAT IS WRONG WITH IT ON THE COMPUTER AND DO THE REPAIR. IT HAS ALL BEEN UNDER WARRANTY. I WORK AT NIGHT, I'VE STALLED IN FRONT OF ON COMING TRAFFIC, I HAVE STALLED GOING 35 MILES AN HOUR, I HAVE STALLED ON A BLIND CORNER. I'VE HAD TO WALK HOME MANY OF THESE TIMES AT 3 OR 4 IN THE MORNING AND LEAVE THE CAR IN AN UNSAFE POSITION. *JB