2002 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,014 owner complaints filed for this model year. This is the 9th highest complaint count among 19 Focus model years with reports.
Of the 2002 reports, 85 involved a crash and 24 involved a fire. 82 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: fuel system
68 reports, newest first. Show all
Fuel system, Gasoline, Jun 3, 2013
TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE APPROXIMATE FAILURE MILEAGE WAS 47,000 AND THE CURRENT MILEAGE WAS 48,804. *TR
Fuel system, Gasoline, Nov 28, 2011
BLEW THE FUSE FROM MY FUEL PUMP UPON START UP OF CAR, NEEDED FUSE REPLACED AND GOT THE CAR TO START. HOWEVER, THE FUSE WOULD CONTINUE TO BLOW, THEREFORE NEED NEW FUEL PUMP AND FILTER. TRIED TO REPLACE THE PUMP WITH AN AFTER MARKET PART AND IT WOULDN'T FIT PROPERLY, MEANING I NEED A NEW EXPENSIVE PUMP. *KB
Engine and engine cooling, Fuel system, Gasoline, Nov 27, 2011
WHILE IDLING, MY CAR IS TURNING OFF. IT ALSO DOES SO WHEN ATTEMPTING TO ACCELERATE AFTER SHIFTING THE CAR FROM P TO D. INITIALLY THE GAS CAP LIGHT ON THE DASHBOARD SIGNALED. I REPLACED THE CAP, AND THE CHECK ENGINE LIGHT WAS ILLUMINATED AFTERWARDS. NOW, THE CAR IS TURNING OFF COMPLETELY WHILE IDLING AND ONLY THE CHECK ENGINE LIGHT IS LIT. *TR
Fuel system, Gasoline, Nov 11, 2011
FUEL PUMP STARTED TO CAUSE CAR TO STUTTER, STALL, COMPLETELY DIE. HAS STALLED OUT ON INTERSTATE IN HEAVY TRAFFIC, IN THE MIDDLE OF BUSY AFTERNOON 4-LANE TRAFFIC; BOTH TIMES BARELY MAKING IT OF TRAFFIC AND BEING HIT BY ONCOMING TRAFFIC W/CHILDREN IN THE CAR! CAR MANUFACTURE DATE IS 09/01 IN MEXICO. HAD FUEL PUMP REPLACE AND HAS FAILED BOTH TIMES, COST IS TOO EXPENSIVE FOR ME! ALREADY PAID OVER$1000 FOR PARTS AND LABOR! NO RECALLS ON THIS CAR REGARDING THE FUEL SYSTEM OR THE IGNITION SWITCH LOCKING UP!!! I HAVE SEEN MORE AND MORE OF THESE 2 PROBLEMS WITH THE EARLY FORD FOCUS, WHY HASN'T SOMETHING BEEN DONE YET??????? *TR
Fuel system, Gasoline, Nov 8, 2011
CAR WAS RUNNING FUNNY FOR ABOUT A WEEK. LEAVING A STORE PARKING LOT. I PULLED OUT ON THE HIGHWAY AND CAR STARTED MISSING REAL BAD AND STALLED. WOULD NOT START BACK UP. I HAD IT TOWED TO THE GARAGE AND WAS TOLD AFTER THEY LOOKED AT IT THAT IT NEEDED A NEW FUEL DELIVERY SYSTEM OR FUEL PUMP AND STUFF. ANOTHER KNOWN ISSUE BY FORD MOTOR COMPANY,BUT NOT FOR MY FORD FOCUS. THE GUY I PULLED OUT ON PROBABLY THOUGHT IDIOT. *TR
Fuel system, Gasoline, Aug 22, 2011
TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT WHERE THE ENGINE RESTARTED. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE PROBLEM. THE SIMILAR FAILURE RECURRED; ALTHOUGH THE ENGINE RESTARTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE FUEL PUMP WOULD NEED TO BE REPLACED. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 03V482000 (FUEL SYSTEM, GASOLINE). THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 49,728.
Fuel system, Gasoline, Aug 18, 2011, fire
TL*THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT STATED THAT THE WIRES ON TOP OF THE FUEL PUMP STARTED TO MELT. AS A RESULT, THE VEHICLE WOULD INTERMITTENTLY SURGE FORWARD AND STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE MELTING WIRES WERE CAUSING THE FAILURE. THE FAILURE MILEAGE WAS 132,000 AND THE CURRENT MILEAGE WAS 154,000.
Fuel system, Gasoline, May 13, 2011
TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE PROBLEM. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 83,000 AND CURRENT MILEAGE WAS 89,000. UPDATED 6/8/11 *CN THE CONSUMER BELIEVED THE STALLING WAS DUE TO A CLOGGED FUEL PUMP. UPDATED 06/15/11
Fuel system, Gasoline, Mar 21, 2011
ON MARCH 17, 2011, MY 2002 FORD FOCUS SUDDENLY STALLED OUT AS I WAS ACCELERATING UPHILL, TURNING RIGHT ON A RAMP TO ENTER A BUSY HIGHWAY. FUEL TANK WAS ABOUT . I RESTARTED THE ENGINE A COUPLE TIMES, BUT IT STALLED OUT AGAIN AFTER A FEW SECONDS. IT WAS POTENTIALLY A DANGEROUS SITUATION, BUT LUCKILY I WAS ABLE TO ROLL THE CAR BACK DOWNHILL TO A SAFER LOCATION. (LATER I LEARNED THAT AN IDENTICAL SCENARIO IS DESCRIBED IN FORD DEALER LETTER 03N01, IN WHICH FORD AGREES TO REPLACE FUEL DELIVERY MODULES FOR 2000 AND 2001 MODELS, BUT NOT 2002.) I HAD THE CAR TOWED TO A FORD DEALER, BUT THEY WERE NOT ABLE TO LOOK AT IT TILL THE NEXT MORNING, AT WHICH TIME THE CAR STARTED FINE. FORD RAN MANY TESTS, INCLUDING ELECTRICAL AND MECHANICAL, TOOK IT OUT FOR 3 ' 4 TEST DRIVES AND COULD NOT FIND A PROBLEM. THEY CHARGED $150 FOR THE DIAGNOSTIC LABOR. THIS CAR HAS DONE THIS EVERY YEAR NOW FOR THE PAST 3 YEARS. SIMILAR, BUT NOT IDENTICAL, STALLS OCCURRED ON MARCH 16, 2009, MARCH 10, 2010 AND MARCH 17, 2010. EACH TIME, I HAD TO HAVE THE CAR TOWED. LOCATIONS WERE DIFFERENT, SO IT WAS ALWAYS A DIFFERENT SHOP. NONE OF THEM WERE ABLE TO LOOK AT IT RIGHT AWAY, AND BY THE TIME THEY LOOKED AT IT THE NEXT DAY, THEY COULD NOT FIND THE PROBLEM. HOWEVER, EACH ONE CHARGED ABOUT $150 LABOR. THOSE 3 INCIDENTS ALSO REQUIRED A NEW 15 AMP FUSE FOR THE FUEL PUMP, PERHAPS BECAUSE OF THE REPEATED UNSUCCESSFUL EFFORTS TO RESTART THE CAR AFTER IT STALLED. THIS YEAR, I STOPPED TRYING TO RESTART AFTER 4 UNSUCCESSFUL EFFORTS. THE FUSE DID NOT BLOW THIS YEAR. IN BETWEEN THESE STALLOUTS, USUALLY EXACTLY ONE YEAR APART, THE ENGINE HAS STARTED AND RUN SMOOTHLY, WITH NO INDICATION OF PROBLEMS. EACH TIME A STALL HAS HAPPENED, THE CAR HAS WORKED FINE THE NEXT DAY, WITHOUT ANY ADDITION OF FUEL. THIS INDICATES THAT IT IS NOT A PROBLEM WITH THE QUALITY OR QUANTITY OF FUEL IN THE TANK. THE ONLY EXPLANATION THAT I CAN SEE FOR THESE UNPREDICTABLE FAILURES IS A DEFECT IN THE FUEL DELIVERY SYSTEM. *TR
Fuel system, Gasoline, Apr 2, 2010
2002 FORD FOCUS. CONSUMER REQUESTS REIMBURSEMENT FOR TOWING AND REPAIR EXPENSES RELATED TO PROBLEM THAT SHOULD HAVE BEEN TAKEN CARE OF UNDER RECALL. *TGW THE CONSUMER MENTIONED RECALL #03V482000 THE FUEL PUMP WAS REPLACED.
Fuel system, Gasoline, Feb 21, 2010
FUEL PUMP IN MY 2002 FORD FOCUS FAILED SUDDENLY AS I WAS MERGING ONTO A 50MPH HIGHWAY IN JANUARY 2010. THE CAR JUST LITERALLY DIED, WITHOUT WARNING. FUEL INTAKE STOPPED AND SO DID THE CAR. I WAS LUCKY IT WAS EARLY ON A SUNDAY MORNING AND TRAFFIC WAS LIGHT. IF I HAD BEEN IN HEAVY TRAFFIC, THIS SUDDEN FAILURE WOULD HAVE POSED A GRAVE SAFETY RISK. THE REPAIR COST $700. FORD REFUSED TO COVER ANY OF IT. IN A SEARCH OF INTERNET ARTICLES AND YOUR WEB SITE, I FOUND THIS FUEL PUMP FAILURE TO BE A WELL-DOCUMENTED PROBLEM IN 2000 - 2002 FORD FOCUS'. I AM CONCERNED THAT THEY REPLACED THE ORIGINAL DEFECTIVE PUMP WITH AN EXACT REPLICA OF THE ORIGINAL PUMP, EXPOSING ME TO CONTINUED DANGER. *TR
Fuel system, Gasoline, Oct 13, 2009
THE CAR STARTED TO PUTT PUTT AND THEN IT STALLED OUT I HAD A HAFL OF TANK OF GAS WHEN I HAD TO GET THIS TOWED COME TO FINE OUT THE FUEL PUMP AND FILTER WAS CLOGGED. *TR
Fuel system, Gasoline, Sep 29, 2009
2002 FORD FOCUS EXHIBITS ENGINE HESITATION WHEN THE FUEL TANK IS BELOW 1/4 FULL. THERE ARE ACCELERATION PROBLEMS AND THE CAR HAS COMPLETELY LOST POWER ON AT LEAST ONE OCCASION WHILE DRIVING ON THE HIGHWAY. THIS BEGAN TO HAPPEN WITH 80,000KM ON THE CAR AND NOW ALWAYS HAPPENS WHEN DRIVING AT HIGHWAY SPEEDS WITH ONLY 1/4 TANK OF GAS. COMPLAINTS TO FORD ABOUT HOW THIS IS THE EXACT SAME CONDITION THAT CAUSED THEM TO ISSUE A RECALL ON 2000 AND 2001 FOCUSES (03N01) HAVE NOT RESULTED IN ANY OFFER TO REPLACE THE FUEL PUMP FOR FREE. *TR
Fuel system, Gasoline, May 14, 2009
2002 FORD FOCUS BOUGHT THE END OF MARCH 2009, NOW SITS IN DRIVEWAY, BECAUSE FORD WILL NOT FIX FUEL DELIVERY MODULE FAILURE, BECAUSE OF VIN# NOT ON LIST AS BEING ONE OF THE 671000 UNITS AFFECTED. THE CAR IS DOING THE SAME THING AS ALL THE OTHER 671000 THAT WERE AFFECTED, SURGING, LOSS OF POWER, STALLING, HESITATION. WE WERE GOING DOWN THE ROAD, CHANGED LANES AND IT STARTED DOING THIS, NOW I HAVE HAD 3 MECHANICS WORK ON THIS CAR, NO HELP REPLACED FUEL PUMP, BATTERY, FUEL FILTER ETC, NO LUCK. IT STARTS WHEN IT WANTS WILL RUN THEN IT STARTS LOSING POWER, STALLS. WE DID EXPECT PROBLEMS WITH USED CAR, BUT NOT ONE THAT SHOULD HAVE BEEN INCLUDED IN A RECALL AND FIXED. IF ACCIDENT HAPPENS BECAUSE OF THIS PROBLEM FORD WILL BE AT FAULT. *TR
Fuel system, Gasoline, Apr 27, 2009
MY 2002 FORD FOCUS ZTS SUDDENLY STALLED IN HEAVY, FAST MOVING TRAFFIC. I HAD TO WRESTLE THE CAR TO THE CURB WITHOUT POWER STEERING OR POWER BRAKES WHILE AT THE SAME TIME AVOIDING TRAFFIC. I TOOK IT TO THE SHOP AND THEY SAID THE FUEL PUMP HAS FAILED AND NEEDED REPLACEMENT. TOTAL COST ESTIMATE IS NEARLY $800. THIS IS A COMMON PROBLEM IN 2001 AND 2000 MODELS AND THIS PART IS EVEN COVERED IN AN EXTENDED WARRANTY FOR THOSE YEARS. HOWEVER, THE 2002 IS NOT COVERED. I THINK THAT THIS SHOULD BE A SAFELY CONCERN FOR FORD BUT I THINK THEY ARE DOING THE BARE MINIMUM. I WILL NEVER BUY ANOTHER FORD AGAIN. NO WONDER THEY ARE HAVING SUCH DIFFICULT TIMES AT FORD! *TR
Fuel system, Gasoline, Electrical system, Apr 6, 2009
FAULTY IGNITION CYLINDER LOCK, FAILS WITHOUT WARNING. I HAD IT REPLACED 12/15/07 AND IT IS NOW DEFECTIVE AGAIN ON 4/6/09. I HAD IT FIXED LAST TIME FOR $200, BUT IT CAN COST UP TO $400. HOW THIS ISN'T A SAFETY ISSUE IS BEYOND ME. THEN AGAIN THE PINTO'S EXPLODING GAS TANK WASN'T DEEMED A "SAFETY ISSUE" BY FORD, EITHER. *TR
Fuel system, Gasoline, Jan 28, 2009
I PURCHASED A USED 2002 FORD FOCUS IN FL. WHILE DRIVING IT TO MY HOME IN TN, I EXPERIENCED STALLING AT HWY SPEEDS. I CHANGED THE FUEL FILTER AND CONTINUED ON MY TRIP. IT STALLED AGAIN AND WOULDN'T RESTART. I HAD IT TOWED TO A FORD DEALER THAT DIAGNOSED THE PROBLEM AS THE ALTERNATOR AND BATTERY. I REPLACED THEM BOTH. THE CAR STARTED AND I BEGAN MY TRAVEL BACK HOME. UPON MY RETURN HOME, WHEN I WOULD UTILIZE THE CAR, I WOULD EXPERIENCE STALLING UNDER VARYING CONDITIONS. I TOOK IT TO A MECHANIC WHO COULD NOT FIND THAT PROBLEM, BUT DID REPLACE THE THERMOSTAT. TYPICALLY THE CAR WOULD RUN FOR SEVERAL HOURS BEFORE THE STALLING WOULD BEGIN. I COULD USUALLY ALLOW THE ENGINE TO COOL FOR APPROXIMATELY 20-30 MINUTES AND THE CAR WOULD START. I COULD DRIVE FOR APPROXIMATELY 15 MINUTES BEFORE IT WOULD STALL AGAIN. MY LATEST EXPERIENCE HAPPENED AT HWY SPEEDS. AFTER 30 MINUTES OF TRAVEL THE CAR STALLED AND HAS NOT RESTARTED SINCE. I CONTACTED FORD WHO INFORMED ME THAT MY CAR WAS NOT PART OF THEIR "RECALL (S)" DUE TO WHERE IT WAS ASSEMBLED. I FIND IT VERY "COINCIDENTAL" THAT MY CAR IS EXPERIENCING THE EXACT PROBLEMS THAT THE "RECALLED" CARS EXPERIENCED. IS THERE A COURSE ON ACTION THAT I SHOULD TAKE? *TR
Fuel system, Gasoline, Dec 11, 2008
TL*THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING 30 MPH, THE VEHICLE COMPLETELY FAILED AND SHUT OFF. THE VEHICLE FAILED TO START, BUT THE CONTACT WAS ABLE TO PULL OFF THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE SENDER AND FUEL PUMP FAILED, WHICH CAUSED THE VEHICLE TO SHUT OFF. THE VEHICLE WAS REPAIRED AT THE COST OF $540. THE MANUFACTURER STATED THAT THERE WAS NO CURRENT RECALL FOR THE FUEL PUMP; THEREFORE, NO COMPENSATION WOULD BE MADE. UPDATED 01-26-09 *BFTHE FAILURE MILEAGE WAS 22,600 AND CURRENT MILEAGE WAS 22,700. UPDATED 01/26/09. *JB
Fuel system, Gasoline, Jul 3, 2008
I DRIVE A 2002 FORD FOCUS WAGON, MILEAGE 85,578. TWO DAYS AGO I HAD TROUBLE STARTING IT. I DID GET IT STARTED BUT EVERYTIME I TOOK MY FOOT OFF THE ACCELERATOR THE ENGINE STALL. THERE WAS NO CHECK ENGINE LIGHT WARNING PRIOR TO THIS OR DURING THE EVENT. I WAS ABLE TO DRIVE MY CAR HOME, BUT HAD TO RESTART IT EACH TIME I HAD TO STOP. THE NEXT MORNING IT DROVE FINE BUT I TOOK IT TO A FORD DEALER FOR DIAGNOSIS AND REPAIR. I WAS TOLD IT WAS A FUEL PUMP FAILURE AND IT COST ME OVER A $1000 FOR REPAIR. (PARTS LISTER WERE SENDER, GASKET, KIT, TUBE, GASKET, FILTER). IN RESEARCHING RECALLS I FOUND THAT MODEL YEARS 2000-2001 WERE HAVING THIS EXACT SAME PROBLEMS AND A RECALL WAS DETERMINED FOR THIS. I DO NORMAL DRIVING - 70% HIGHWAY, 30% IN TOWN. MY CAR IS JUST OVER 5 YEARS OLD, I DON'T BELIEVE THAT NORMAL WEAR AND TEAR SHOULD CAUSE THE FUEL PUMP TO FAIL. IT SEEMS TO ME THAT THIS IS SOME KIND OF DEFECT IN THE ORIGINAL PART OR ASSEMBLY. *TR
Fuel system, Gasoline, Mar 5, 2008
APPROXIMATELY 3 WEEKS AGO, WHILE DRIVING ON THE INTERSTATE (~65 MILES PER HOUR), A COOLING SYSTEM LIGHT CAME ON (2002 FORD FOCUS, MANUAL TRANSMISSION, 46,000 MILES), AND INSTANTANEOUSLY, THE CAR STALLED. IT ALMOST THREW ME INTO THE WINDSHIELD. THE CAR RECOVERED AND DID NOT DIE, AND I WAS ABLE TO GET TO WHERE I WAS GOING. IT HAPPENED AGAIN A FEW DAYS LATER WHILE MAKING A RIGHT HAND TURN (~20 MILES PER HOUR). I BROUGHT IT TO PEP BOYS, WHO COULD FIND NOTHING WRONG. IT STALLED AND DIED TWO BLOCKS AWAY FROM PEP BOYS, SO I BROUGHT IT TO THE FORD DEALERSHIP. I ASKED THEM TO CHECK ON ANY RECALLS BECAUSE I HAVE NOTICED THAT MANY FOCUSES HAVE THIS PROBLEM. THEY CALLED ME TO TELL ME THAT IT WAS DEFINITELY THE THERMOSTAT , THERMOSTAT HOUSING ASSEMBLY AND O RING, AND I NEEDED AN OIL CHANGE (WHICH WAS DONE AT PEP BOYS ONE WEEK EARLIER). THEY WANTED $1100.00 TO FIX IT, SO I TOOK MY CAR HOME. TODAY, I DROVE IT TO A MECHANIC, AND IT KILLED TWICE, AND STALLED THREE TIMES (DRIVING NO MORE THAN 30 MPH). THE HAZARD LIGHT CAME ON BY ITSELF WHILE I WAS DRIVING. THE MECHANIC JUST CALLED TO TELL ME THAT THE FUEL PUMP IS BAD, AND THAT IS WHAT WAS CAUSING THE STALLING. IT IS A SHAME THAT I COULD HAVE BEEN KILLED IN THIS CAR, AND NO RECALLS HAVE BEEN DONE ON THE 2002 FORD FOCUS FOR FAULTY FUEL PUMPS. *TR
Fuel system, Gasoline, Dec 11, 2007
MY WIFE WAS DRIVING THE CAR, AND HAD JUST TURNED FROM THE PARKING LOT TO THE ROAD WHEN THE CAR STALLED AND WOULD NOT START AGAIN. SHE WAS ABLE TO COAST TO THE SIDE OF THE ROAD WHERE THE CAR WAS TOWED TO THE FORD DEALERSHIP. FORD HAS TOLD US THAT THE FUEL PUMP FAILED AND NEEDS TO BE REPLACED. THE CAR IS 5 YEARS OLD AND HAS LESS THAN 50,000 MILES ON IT. *TR
Fuel system, Gasoline, Oct 16, 2007
TL*THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE BEGAN HESITATING , SURGING, AND THEN LOST ALL POWER. THE VEHICLE WAS PULLED OFF THE ROAD BEFORE IT COMPLETELY SHUT OFF. THE VEHICLE RESTARTED AFTER BEING PARKED FOR A WHILE. THE DEALER STATED THAT THEY WOULD NOT REPAIR THE VEHICLE UNLESS IT WAS PAID FOR BY THE CONTACT. THE DEALER ALSO STATED THAT THE FUEL DELIVERY MODULE FAILED. THERE WAS AN INVESTIGATION (EA02022) THAT WAS OPENED AND CLOSED. THE CURRENT MILEAGE WAS 125,000 AND FAILURE MILEAGE WAS 71,380 UPDATED 3/4/08 *CN
Fuel system, Gasoline, Jul 31, 2007
2002 FORD FOCUS ZTW WAGON. DIVING ON HIGHWAY AND VEHICLE LOST POWER. PULLED FROM HIGHWAY AND HAD VEHICLE TOWED TO SERVICE CENTER. REPAIR FACILITY REPLACED FUEL FILTER EXPLAINING SYMPTOMS WERE CONSISTENT WITH RESTRICTED FUEL SYSTEM. THREE DAYS LATER VEHICLE EXHIBITS SAME PROBLEM. TOWED TO SERVICE CENTER WHERE A PLUGGED/CLOGGED FUEL PUMP SCREEN WAS FOUND. REPAIR FACILITY STATED THIS WAS A COMMON ISSUE ON PRIOR YEAR (2000 - 2001) FOCUS. RECEIPTS AND USED PARTS AVAILABLE. *JB
Fuel system, Gasoline, Jul 18, 2007
CAR WAS SHAKING VIOLENTLY WHILE IDLING. WAS FINE WHILE DRIVING, BUT WHEN GAS WAS NOT APPLIED IT WOULD SHAKE AND DIE. DEALERSHIP QUOTED $80 JUST TO LOOK AT IT. I WENT TO AUTO ZONE FOR FREE COMPUTER ANALYSIS, WHICH SAID OXYGEN SENSOR NEEDED REPLACED. I REPLACED IT, BUT THE PROBLEM WAS NOT FIXED. A RANDOM GENTLEMAN AT AUTO ZONE SAID IT SOUNDED LIKE AN AIR LEAK. I USED STARTER FLUID TO LIGHTLY SPRAY ON HOSES IN ENGINE TO FIND A LEAK (ENGINE REVS WHEN YOU HIT A HOSE WITH A HOLE). I SPENT 4 DOLLARS REPLACING A SMALL RUBBER ELBOW AND FIXED THE PROBLEM. THE EXISTING ELBOW RIGHT IN THE BACK CENTER OF THE ENGINE WAS BURNT COMPLETELY THROUGH WITH ABOUT A 2 INCH HOLE. *TR
Fuel system, Gasoline, Mar 14, 2007
2002 FORD FOCUS WITH 80,000 STALLED ON FREEWAY AT SPEED OF 60 MPH WITHOUT ANY PRIOR WARNING. POTENTIALLY VERY SERIOUS SITUATION, BUT THERE WAS NO ACCIDENT AND NO ONE WAS INJURED. CAR WAS TOWED TO FORD DEALERSHIP WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP HAD FAILED. WE ARE TRYING TO GET FORD TO REPLACE THE DEFECTIVE FUEL PUMP AS A WARRANTY, BUT NOTHING HAS HAPPENED THUS FAR. *JB