2002 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,014 owner complaints filed for this model year. This is the 9th highest complaint count among 19 Focus model years with reports.
Of the 2002 reports, 85 involved a crash and 24 involved a fire. 82 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: suspension
122 reports, newest first. Show all
Suspension, Nov 22, 2006
IN LATE OCTOBER 2006 I TOOK MY 2002 FORD FOCUS FOR VIBRATION/GRINDING NOISE COMING FROM FRONT END. FORD WALKER IN CLEARWATER, FLORIDA SAID THAT MY ENGINE/TRANS. MOUNT WERE WORKING PROPERLY. FORD KEPT MY CAR FOR 1 WEEK AND I STILL HAD THE SAME PROBLEM. I TOOK THE CAR BACK TO FORD THE VERY NEXT DAY BECAUSE OF THE SAME PROBLEM. AGAIN THEIR SERVICE MANAGER AND REGIONAL MANAGERS TOLD ME THAT NOTHING WAS WRONG WITH MY CAR. FORD CHARGED ME $100 FOR MY DEDUCTIBLE AND DIDN'T FIXED MY PROBLEM. I THEN TOOK MY CAR TO ANOTHER PLACE WHERE THEY REPLACED MY RIGHT SIDE ENGINE MOUNT WHICH WAS COMPLETELY BROKEN. THE VERY SAME PIECE FORD WALKER LIED TO ME STATING IT WAS WORKING PROPERLY. *JB
Suspension, Tires, Aug 24, 2006
I PURCHASED A 2002 FORD TAURUS SES ON JULY 31,2005. HOWEVER I HAVE BEEN EXPERIENCING A LOUD SOUND WHEN DRIVING LIKE THE WHEEL IS WOBBLING, AND THIS CAUSES THE CAR TO DRIFT SUDDENLY ALMOST CAUSING A ACCIDENT. I'VE BEEN ALSO EXPERIENCING A BURNING SMELL COMING FROM THE VENTS IN THE VEHICLES WHEN THE HEAT WAS NOT IN USE. *JB
Steering, Suspension, Electrical system, Aug 7, 2006
MY 2002 FORD FOCUS SE WAGON HAS HAD INNUMERABLE PROBLEMS. FIRSTLY..MELTING BATTERY CABLES DUE TO POOR AND FAULTY WIRING THAT COULD HAVE CAUSED AN EXPLOSION OF THE BATTERY HAD I NOT HAD TO PAY TO GET IT FIXED ALONG WITH PURCHASE OF TWO NEW BATTERIES THANKS TO THE MELTING BATTERY CABLES CAUSING A SHORT IN THE SYSTEM. IT SUBSEQUENTLY KILLED THE ALTERNATOR WHICH HAD TO BE REPLACED. IT ALSO SUBSEQUENTLY KILLED THE THERMOSTAT AND THE SOLENOID SWITCH WHICH CAUSED OVERHEATING AND DYING PROBLEMS WITH THE CAR WHILE DRIVING. MOST RECENTLY THE PASSENGER SIDE WHEEL BEARING WENT OUT AND WAS CAUSING DRIVING PROBLEMS UNABLE TO CONTROL CAR. NOW MORE RECENTLY, IT HAD TO HAVE A FAULTY TIE ROD PLACED WHICH NEARLY CAUSED ME TO HAVE AN ACCIDENT. AND AS OF LAST FRIDAY, ITS BACK IN THE SHOP AGAIN THIS TIME FOR ENGINE STALLING AT 65 MILES PER HOUR WHICH NEARLY CAUSED YET ANOTHER ACCIDENT BECAUSE I WAS PASSING ANOTHER CAR AND MINE SUDDENLY BEGAN VIBRATING SO BAD AND THEN LOST POWER AND I HAD TO STRUGGLE MY WAY TO THE MEDIAN. THIS CAR IS DANGEROUS AND FORD REFUSES TO DO NOTHING ABOUT IT. I HAVE PAID OUT NEARLY 2000.00 ON ALL THESE PROBLEMS WHICH WERE SIMILAR TO ISSUES ALREADY RECALLED AND YES I AM MAD. I HAVE CALLED FORD AND COMPLAINED BUT TO NO AVAIL. *JB
Suspension, Power train, Other or unspecified, Jul 23, 2006
1. I WAS DRIVING MY 2002 FORD FOCUS WAGON BACK FROM A CAMPING TRIP AND I WAS GOING ABOUT 60 MPH ON THE FREEWAY 2. ALL OF A SUDDEN THERE WAS A "CRACK"/"BANG" FROM THE BACK OF THE CAR, DRIVERS SIDE, THE CAR CONTINUED WITHOUT JOLTING/SWERVING (I.E. NO AFFECT TO THE DRIVING OF THE VEHICLE), HOWEVER, AFTER ANOTHER FEW MILES THE REAR DRIVERS SIDE WHEEL WAS MAKING A HIGH PITCHED SOUND, PLUS CRACKING, PLUS SOME JOLTING AS THE BEARING REALIGNED ITSELF AT TIMES. I STOPPED THE CAR AND THE HEAT FROM THE WHEEL WAS INCREDIBLE, ONE COULD HAVE FRIED AN EGG ON IT (THIS WHEEL WAS MUCH HOTTER THAN THE OTHERS). UNFORTUNATELY THIS HAPPENED ON A STRETCH OF ROAD WHERE THERE ARE NO TOWNS, NO CELL PHONE SIGNAL, ETC, I WAS FORCED TO DRIVE THE CAR TO A TOWN, MAX OF 40 MPH ON A 60 MPH STRETCH OF ROAD, I HAD A BABY IN THE CAR AND WAS SCARRED THAT SOMETHING WOULD HAPPEN TO HER. IN THE TOWN, I LEFT THE CAR, HAD TO CALL A FRIEND TO DRIVE ME HOME. I MUST SAY IT WAS THE MOST UNPLEASANT FEELING IN THE WORLD. IN ADDITION, THIS HAPPENED ON A SATURDAY NIGHT, WHERE ALL CAR SHOPS ARE CLOSED! 3. REPAIR SHOPS OPEN TOMORROW, THE REPAIR IS YET TO TAKE PLACE. *NM
Suspension, Jul 3, 2006
DT*: THE CONTACT STATED, WHILE DRIVING OVER A BUMP IN THE ROAD, AT 45 MPH, THE SUSPENSION FAILED, CAUSING THE WHEEL TO BEND ON IMPACT WITH THE ROAD. THE BENT WHEEL AND ALL SHOCKS WERE REPLACED. THE DEALER INFORMED THE CONTACT OF A SERVICE BULLETIN CONCERNING THE SUSPENSION DIRECTING THE DEALER TO REPLACE SPRINGS ONLY IF BROKEN. WHEN THE MANUFACTURE WAS CONTACTED, REPLACEMENT SPRINGS WERE OFFERED AT COST.
Suspension, Jun 16, 2006
DT*: THE CONTACT STATED WHILE DRIVING 45MPH THE VEHICLE VEERED TOWARD THE RIGHT. A CLUNKING SOUND CAME FROM THE FRONT OF THE VEHICLE. UPON INSPECTION THE INDEPENDENT REPAIR SHOP DETERMINED THE FRONT COIL SPRING FRACTURED. THE FRONT COIL SPRING NEEDED REPLACED.
Suspension, May 30, 2006
THE FRONT RIGHT BEARING AND SPRING NEEDED TO BE REPLACED DUE TO CORROSION. THE BEARING WAS FROZEN AND THE SPRING WAS POPPED OUT SO FAR IT ALMOST POPPED THE FRONT RIGHT TIRE. THE CAR IS A 2002 FORD FOCUS - NOT THAT OLD TO HAVE SOMETHING LIKE THIS CORRODE AND ALMOST CAUSE AN ACCIDENT. I DIDN'T SEE A RECALL ON ANY OF THE PARTS FOR MY CAR OR ANYTHING SUGGESTING SHIELDS SHOULD BE INSTALLED SO THAT IF THE SPRINGS POP AT A HIGH SPEED AT LEAST IT WON'T PUNCTURE THE TIRE. I WOULD LIKE TO SEE A RECALL ON THE PARTS OR HAVE THE NHTSA REQUIRE THAT SHIELDS BE INSTALLED. I SPENT $578 TO CORRECT THE PROBLEM - REPLACED FRONT RIGHT STRUT, MOUNT AND BEARING, SPRING, AND ALIGNMENT. *NM
Suspension, Apr 20, 2006
PASSENGER SIDE COIL SPRING IS FRACTURED. *JB
Steering, Suspension, Jan 18, 2006
DT*: THE CONTACT STATED WHILE DRIVING AT HIGHWAY SPEED THE LEFT REAR WHEEL BEARINGS CAME LOOSE. THE VEHICLE PHYSICALLY FELT AS THOUGH THERE WAS A FLAT TIRE. THE CONTACT PULLED OVER AND PARKED THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP. THE INDEPENDENT REPAIR SHOP PERSONNEL REPLACED THE REAR SPINDLE ASSEMBLY, THE LEFT REAR WHEEL BEARINGS, AS WELL AS THE HUB AND DRUM OF THE SUSPENSION. *NM THE CONTACT'S MECHANIC CALLED FORD BEFOREHE DID WORK ON VEHICLE. IT WAS A METAL TO METAL SOUND. THIS COULD HAVE EASILY BEEN DEADLY. HOWEVER, CONTACT WAS IN RIGHT SLOW LANE AN DWAS ABLE TO PULL OFF THE HIGHWAY. *AK
Steering, Suspension, Jan 11, 2006
DT*: THE CONTACT STATED AFTER DRIVING ON BUMPY ROAD CONDITIONS A CLANKING NOISE WAS COMING FROM THE FRONT SUSPENSION. THE CONTACT INSPECTED THE VEHICLE, AND DETERMINED THE SWAY BAR LINK WORE OUT, AND THE TIE ROD ENDS CRACKED. THE CONTACT REPLACED THE SWAY BAR LINK AND FRONT TIE ROD ENDS. THE VEHICLE WAS NOT SEEN BY A DEALER. *AK UPDATED 2/7/2006 - *NM
Suspension, Latches/locks/linkages, Tires, Wheels, Dec 27, 2005
I PURCHASED MY 2002 FORD FOCUS IN JANUARY OF 2005. I LOVE MY CAR, HAVE FOUND OUT ABOUT OF THINGS THAT COULD GO WRONG LATER. RIGHT NOW I AM HAVING TROUBLE WITH MY FRONT WHEELS. I HAVE PUT SIX USED TIRES ON THE FRONT SINCE I PURCHASED THE FOCUS. IN NOVEMBER I HAD TWO BRAND NEW TIRES PUT ON PLUS IN MAY I HAVE HAD A WHEEL ALIGNMENT DONE. THE CAR STILL SHAKES VERY BAD. FOUND OUT I NEED MY WHEEL HUB BEARING REPLACE, PLUS I FOUND OUT THERE MAY BE A RECALL ON THE REAR BEARING WHICH I HAVE NOT RECEIVED ANYTHING. I SHOULD NOT HAVE TO PAY FOR THESE THINGS TO BE DONE. *JB
Suspension, Dec 2, 2005
DT: CONTACT STATED THERE WAS A NAIL IN THE FRONT PASSENGER'S TIRE. UPON REPLACEMENT OF THE TIRE THE DEALER FOUND THAT THE FRONT PASSENGER COIL SPRING BROKE. THE DEALER REPLACED THE FRONT PASSENGER COIL SPRING. *AK
Suspension, Oct 6, 2005
WE NOTICED A SLIGHT RUBBING WHEN VEHICLE WAS TURNING TO RIGHT WHILE ON VACATION. WITHIN 2 DAYS IT BECAME WORSE, THE THUMPING AND RUBBING SOUND WERE VERY LOUD AND FELT IN THE CAR. WE OPTED TO LEAVE THE CAR. LUCKILY WE DID, AS THE REPAIR SHOP INFORMED US THAT THE WHEEL BEARING WAS COMPLETELY CRACKED, AND NOTED THIS IS NOT COMMON. WE WERE TOLD THAT HAD WE ATTEMPTED TO DRIVE HOME, THE WHEEL WOULD HAVE FALLEN OFF ON THE HIGHWAY, AS IT WAS EXTREMELY LOOSE. THIS IN TURN DAMAGED OUR BACK BRAKES, RESULTING IN NEW ROTORS AND PADS, AND THE SHOP WAS UNABLE TO GET THE EMERGENCY BRAKES BACK ON AS THEY WERE RUSTED ON THE CAR. *NM
Suspension, Tires, Aug 31, 2005
I PURCHASED NEW AN 2002 FORD FOCUS WITH A SERIOUS SUSPENSION PROBLEM. THE VEHICLE HAS WORN THROUGH TWO SETS OF TIRES UNEVENLY ON THE INSIDE OF THE TREAD. ONE SET HAD ACTUALLY WORN DOWN TO THE STEEL BELT BEYOND THE RUBBER CAUSING ITS FAILURE AT 18,000 MILES. THIS INCIDENT CAUSED DAMAGE TO THE FRONT WHEEL, WHICH HAD TO BE REPLACED. I HAVE HAD IT CHECKED BY A PROFESSIONAL AUTOMOTIVE ALIGNMENT SHOP, AND WAS TOLD IT WAS WELL WITHIN FORDS SPECIFICATIONS. AFTER CONTACTING FORD MOTOR COMPANY AND THEIR SPECIAL VEHICLE TEAM THEY BOTH SAID THERE WAS NOT ANYTHING THAT COULD BE DONE. I AM LUCKY THAT THE PROBLEM HAS NOT CAUSED A SERIOUS ACCIDENT WITHIN THE LAST 30,000 MILES AND TWO SETS OF TIRES. I FEEL THIS SAFETY OVERSIGHT IS DUE TO FORD AND ITS FAILURE TO PROPERLY ADJUST THEIR SUSPENSION PARAMETERS TO WORK PROPERLY ON OUR 2002 FORD FOCUS. REPLACED ONE FACTORY WHEEL, INSTALLED SUSPENSION CAMBER ADJUSTMENT PARTS, FOUR NEW TIRES AND HAD VEHICLE RE ALIGNED OUT OF FORDS FACTORY SPECIFICATIONS. *NM
Suspension, Aug 19, 2005
COMPLAINT REGARDING 2002 FORD FOCUS MECHANICAL PROBLEMS.*MR THE VEHICLE'S RIGHT FRONT COIL SPRING BROKE WITHOUT WARNING. THE CONSUMER REQUEST REIMBURSEMENT FROM THE MANUFACTURER BUT HASN'T RECEIVED A REPLY YET. *NM
Suspension, Jul 22, 2005
DT:THE TIRES ON THE CONSUMER'S 2002 FORD FOCUS 2002 WERE SHOWING SEVERE SIGNS OF WEAR AFTER ONLY 17000 MILES. THE FIRST SET OF TIRES WERE REPLACED AT 5000 MILES DUE TO WEAR. AFTER ABOUT 12000 MILES THE SAME WEAR PATTERN REAPPEARED. THESE TIRE WERE RATED AS 60000 MILE TIRES. THE VEHICLE IS CURRENTLY ON IT'S THIRD SET OF TIRES. ONE OF THE TIRE WAS TAKEN TO A FORD DEALERSHIP FOR INSPECTION. THE DEALER FOUND A SERVICE BULLETIN #.03-13-5 ON FORD'S COMPUTER THAT COVERED ALL MODELS OF FORD FOCUS 2000-2004 THAT EXPERIENCED INNER TIRE WEAR. THE UPPER CONTROL ARMS OF THIS MODEL WERE ENGINEERED INCORRECTLY CREATING ADVERSE CAMBER TO THE REAR TIRES. THE REMEDY WAS A RESTRUCTURED CONTROL ARM:UPPER ARM KIT. THE NEWLY RESTRUCTURED CONTROL ARM :UPPER ARM KIT WOULD ONLY BE SENT TO THOSE WHO WERE ELIGIBLE UNDER THE BUMPER TO BUMPER WARRANTY,3 YEAR, 36,000 MILES. CONSUMER FELT THE VEHICLE WAS BOUGHT WITH A FACTORY DEFECT. *AK *NM
Suspension, May 2, 2005
WHILE DRIVING 65 MPH, THE LEFT FRONT WHEEL WENT FLYING OFF CAR. NO TROUBLE PRIOR TO THIS DATE. THE BEARINGS WERE REPLACED WHEN THE CAR WAS TAKEN IN FOR REPAIR.
Suspension, Feb 16, 2005
WHILE DRIVING AT ANY SPEED STEERING WHEEL VIBRATED HEAVILY. DEALERSHIP INFORMED THE CONSUMER THAT THE PROBLEM PERTAINED TO THE WHEEL BEARING. THE PROBLEM WAS NOT RESOLVED. *AK
Suspension, Jan 12, 2005
THE CONSUMER BELIEVES THE MANUFACTURER EXPLAINS THE COILS SPRING RECALL AS IF IT'S NOT A SERIOUS PROBLEM. *NM *SC *JB
Suspension, Oct 7, 2004
REAR INNER TIRE WEAR. THE CONTROL ARMS ON TOP WAS DEFECTIVE, CAUSING THE TIRE TO RUB AGAINST THE BODY AND REAR TO SWIRVE WHEN RIDING OVER A BUM OR POT HOLE. *AK
Suspension, Aug 30, 2004
COMPLAINT REGARDING FRONT COIL SPRINGS ON 2002 FORD FOCUS.*MR THE CONSUMER REPLACED ONE COIL SPRING ON HIS VEHICLE BECAUSE IT WAS BROKEN. THIS SERVICE WAS DONE THE SAME WEEK THE MANUFACTURER RECALLED THE FRONT SPRINGS ON THE SABLE AND TAURUS. *NM
Suspension, Fuel system, Gasoline, Power train, Exterior lighting, Air bags, Latches/locks/linkages, Aug 28, 2004
TRANSMISSION WENT OUT 2 TIMES IN 1 YEAR. DRIVER AIRBAG SHIFTED ON ITS OWN. REAR PASSENGER DOOR DOES NOT UNLOCK/OPEN. FRONT BALL JOINT CRACKED. GAS COVER/DOOR FELL OFF. THE SMELL OF GAS INSIDE CAR AT ALL TIMES. BLINKER WOULD NOT TURN OFF BY ITSELF. KEY CHIME GOES OFF WHEN THE KEY IS OUT. *JB
Suspension, Air bags, Seat belts, Aug 12, 2004, crash
FRONT WHEEL BEARINGS, BALL JOINT AREA ON MY FORD FOCUS 2002 CAME LOOSE AND WHEEL FELL OFF WHILE I WAS TRAVELING ON HIGHWAY. WHEN CAR HIT WALL THE AIRBAG DID NOT OPEN AND SEATBELT DID NOT TIGHTEN. THERE WAS NO WARNING BEFORE ACCIDENT. THOUGHT I WAS GOING TO DIE. LUCKY TO BE ALIVE.*AK
Suspension, Wheels, May 19, 2004
PURCHASED CAR NEW MAY 2002. FOCUS ZTS. IN AUGUST TOOK CAR TO ONTARIO CANADA ON ROADTRIP FROM MISSOURI. WAY BACK FROM TRIP, NOTICED VIBRATIONS FROM BACK OF CAR AT HIGHWAY SPEED. DIDN'T THINK MUCH OF IT BECAUSE OF SIMILAR EXPERIENCE WITH ESCORT. TOOK CAR ON TRIP TO MYRTLE BEACH IN MAY 2003 AND THE VIBRATION WAS MORE THEN OBVIOUS AT 55MPH. WHEN RETURNED FROM TRIP TOOK CAR IN FOR SERVICE. DRIVER SIDE REAR BUSHING ON TIRE ARM WAS WORN. WHEEL WAS TILTED AND TIRE WAS WEARING WRONG. DEALERSHIP REPLACED ARM AND TIRE. TOOK CAR ON ANOTHER TRIP MARCH 2004 NOTICED EXTREME VIBRATION STILL COMING FROM SAME SIDE/BACK OF CAR. SHAKES PLASTIC BAGS IN BACKSEATS. VIBRATES DRIVER SEAT AND STEERINGWHEEL. BECAUSE MOST OF MY DRIVING IS ON REGULAR ROADS IT'S NOT SOMETHING THAT BECOMES OBVIOUS RIGHT AWAY. WILL BE TAKING CAR IN AGAIN ASAP. ALSO HAD A PROBLEM RIGHT AFTER PURCHASING THE CAR WITH THE PASSERNGER SIDE FRONT FLOOR WET AFTER HUGE RAIN. TOOK IT IN FOR REPAIR AND I DON'T THINK THERE HAS BEEN A NOTICEABLE PROBLEM SINCE.*AK
Suspension, Apr 13, 2004
CONSUMER TOOK THE VEHICLE TO DEALER TO BE INSPECTED, AND MECHANIC DETERMINED THAT LEFT REAR BEARING FAILED. *AK