2002 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,014 owner complaints filed for this model year. This is the 9th highest complaint count among 19 Focus model years with reports.
Of the 2002 reports, 85 involved a crash and 24 involved a fire. 82 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: suspension
122 reports, newest first. Show all
Suspension, Feb 24, 2004
2002 FORD FOCUS, 48,000 MILES AND I AM NOW ON MY THIRD SET OF TIRES ON THE FRONT. CAR SUSPENSION IN FRONT IS VERY LOOSE, EXPECIALLY DURING HIGHWAY DRIVING, THROUGH SMALL PUDDLES OF WATER CAR SEEMS TO HYDRO-PLANE, AND ON ICE OR SNOW. THE CAR AT TIMES SEEMS TO BE ALL OVER THE ROAD AND I FEEL IT IS UNSAFE TO DRIVE. I HAVE HAD NEW BRAKES, TIRES, AND ALIAGNMENT, AND THE STRUTS CHECKS, AND THE RPOBLEM STILL EXISTS AND SEEMS TO BE GETTING WORSE. PLEASE ADVISE.*AK
Suspension, Jan 26, 2004, crash
ONE OF THE FRONT BALL JOINTS CAME APART AND CAUSED THE VEHICLE TO CRASH INTO A DITCH. FORD IS SENDING A TECHNICIAN TO ASSESS THE VEHICLE. PLEASE PROVIDE FURTHER DETAILS. *NM
Steering, Suspension, Jan 15, 2004, crash
THE MILEAGE ON MY FOCUS WAS 47000 KM AND THE COST WAS $5500.00. THE DATE WAS JULY BUT I AM AT WORK AND NOT SURE OF EXACTLY WHAT DAY. MY FOCUS WAS MAKING A CLUNKING SOUND SIMILAR IN NATURE TO TRACTION CONTROL KICKING IN. IT WAS IN TO BE SERVICED ON A FRIDAY AND THEY SAID THEY COULD NOT REPEAT THE SOUND. ALSO AT THAT TIME IT WAS HAVING REGULAR MAINTENANCE TIRE ROTATION AND OIL CHANGE. ON THE FOLLOWING TUESDAY DRIVING IN THE TOWN I LIVE IN (LUCKILY THE SPEED LIMIT IS ONLY 30 KM/HR) I EXPERIENCED THE STEERING WHEEL PULL TO THE RIGHT AND I HAD HIT A PARKED CAR. HAD I BEEN ON THE HIGHWAY ME AND MY 2 CHILDREN WOULD HAVE BEEN A FATALITY. THE COST QOUTED TO YOU OF 5500.00 IS NOT INCLUDING THE COST TO FIX THE OTHER VEHICLE. AS WELL FORD MOTOR CO. IS TAKING NO RESPONSILBILTY WHATSOEVER AND I NEED PROOF TO GET MY INSURANCE CO TO FIND FAULT TO SOMEONE OTHER THAN MYSELF.
Suspension, Wheels, Jan 15, 2004
THE FRONT DRIVER'S WHEEL BEARING AND HUB WENT OUT AT ABOUT 7,000. THE CAR MADE A VERY LOUD NOISE. FORD REPAIRED THIS PROBLEM. CAR HAD TO HAVE BRAKE PADS AT 28,000 MILES. THE WEAR ON THE DRIVER'S SIDE FRONT WAS MUCH WORST THAN THE OTHERS. REPAIR PERSON SAID THAT THE CALIPERS WERE DEFECTIVE. COST 100. DOLLARS. THE FRONT PASSENGER'S SIDE WHEEL BEARING AND HUB WENT OUT AT 29,000. I PAID FOR REPAIR OF WHEEL $150. I WAS TOLD THAT THE DRIVER'S SIDE WAS GOING OUT AGAIN. THERE IS OBVIOUSLY A PROBLEM WITH THE FRONT SUSPENSION OF THIS CAR. I AM NOW FACED WITH REPAIRS OF THE OTHER SIDE FOR A SECOND TIME AND THE CAR IS ONLY 18 MONTHS OLD. I AM WORRIED THAT THE WHEELS WILL COME OFF.
Steering, Suspension, Engine and engine cooling, Tires, Wheels, Jan 15, 2004
PROBLEM I'M STILL HAVING AND WAS REPORTED TO DEALERSHIP IS CAR PULLS TO LEFT, ( NOT CORRECTED) BACK END OF CAR OR TIRES BOUNCE ON ROAD AND ESPECIALLY WHEN HITTING A BUMP, CANNOT STAY ON ROAD IN SLUSH OR SNOW, BACK END IS ALL OVER ROAD, ( NOTHING DONE) TIRES ARE COMPLETELY GROVED IN MANY SPOTS ON THE TIRES, CAUSED BY REAR END BOUNCING ON ROAD, FIRESTONE WON'T REPLACE THEY SAY IT IS FOCAS'S REAR END AND IT WEARS OUT THE TIRES, DEALER OR FORD WON'T DO ANYTHING ABOUT REAR END OR TIRES, CAR VIBRATES BADLY, REAR DOORS BARLEY OPEN ARE SO STIFF, LOOKS LIKE DOOR LOCKS ARE COROADED NOTHING WAS DONE BY DEALERSHIP EVEN THOUGH THEY SAID THEY LUBRICATED, NOTHING IS ON THE LOCKS TO SHOW LUBRICATION OF LOCKS.
Suspension, Air bags, Wheels, Jan 15, 2004, crash
ON NOVEMBER 23 2002 I WAS IN A ACCIDENT WHERE I BROKE MY NOSE AND HAD NUMEROUS BURISES. THE REASON I GOT INTO AN ACCIDENT WAS BECAUSE MY WHEEL AND SUSPENSION BROKE & SEEM TO COME APART. I HAD COMPLAINED TO FORD THAT MY WHEEL HAD BEEN SHAKING AND THAT THERE WAS SOMETHING WRONG WITH IT. I HAD TAKEN IT BACK 4 TIMES TO GET FIXED BUT EVERYTIME I GOT IT BACK AND IT WOULD SHAKE JUST AS BAD. ALSO WHEN I GOT INTO THE ACCIDENT MY AIRBAGS DIDNT DEPLOY AT ALL I RECEIVED A BROKEN NOSE FROM HITTING MY HEAD ON THE STEERING WHEEL. THE CAR WAS SHAKING REALLY BAD AND IT SEEM TO PULL ME OFF THE ROAD THEN ALL OF A SUDDEN IT WAS LIKE A SNAP AND IT WENT THE OTHER DIRECTION. I FLEW SIDEWAYS UP IN THE AIR AND HIT TWO OAK TREES LUCKLY I DIDN'T DIE FROM THIS ACCIDENT IF YOU WOULD SEE THE PICTURES YOU WOULD THINK HOW DID SHE SURVIVE. IF THE CAR WOULD HAVE HIT THE OAK TREES TWO FEET CLOSER TO MY DOOR I WOULDN'T BE HERE TO TELL YOU THIS. THE CAR SPLIT IN HALF & WAS TOTALED.
Steering, Suspension, Jan 15, 2004, crash
THIS PROBLEM JUST HAPPENED YESTERDAY. MY DAUGHTER WAS MAKING A TURN, AND THE CVC JOINT COMPLETELY FELL APART. SHE LOST ALL STEERING CAUSING HER TO HIT A CURB. WE HAD THE CAR TOWED TO THE DEALER WHERE WE BOUGHT IT ONLY A MONTH AGO. THEY ARE REFUSING TO FIX THE CAR SAYING THAT SHE WAS IN AN ACCIDENT CAUSING THE JOINT TO FALL APART. THIS IS NOT THE CASE. WE ARE NOT SURE WHAT TO DO, AND NEED HELP. THIS IS A TERRIBLE DEFECT, AND IF SHE HADN'T HAVE BEEN GOING SLOW, SHE COULD HAVE BEEN KILLED. IS THERE ANYONE WHO CAN HELP US, AS WERE NOT SURE WHAT STEPS TO TAKE TO GET THE PUBLIC ATTENTION ABOUT A POSSIBLE KILLER.
Steering, Suspension, Service brakes, Hydraulic, Fuel system, Gasoline, Jan 15, 2004
FUEL PUMP WAS REPLACED TWICE FROM JANUARY TO JUNE STERRING WHEEL AND CAR SHAKE WHILE STOPPING AND DRIVING AT 50 MPH OR ABOVE BRAKES HAVE BEEN CHECKED 3 TIMES FINALLY HAD REPLACED AND ROTORS, NO CHANGE IN PERFORMANCE
Steering, Suspension, Jan 15, 2004
MY 2002 FORD FOCUS STARTED HAVING PROBLEMS AFTER 5000 MILES. IT STARTED WITH A NOISE COMING FROM THE FRONT LEFT WHEEL AREA. FROM THERE THE STEERING SEEMED SHAKEY AT TIMES AT HIGHWAY SPEEDS. ONCE, THE CAR PULLED TO THE LEFT SUDDENLY ON THE HIGHWAY. THE DEALERSHIP HAS CHANGED THE TRANSMISSION, FRONT BEARING, AND KNUCKLE, ON THE CAR IN THE PAST TWO MONTHS. THE CAR IS STILL NOT FIXED. THE MOST NOTICEABLE PROBLEM IS THE HOWLING GRINDING NOISE COMING FROM THE FRONT LEFT WHEEL. IT CAN BE HEARD MOSTLY AROUND 50 TO 60 MPH. IT IS STILL UNKNOWN WHAT IS WRONG WITH THE CAR.
Suspension, Tires, Jan 4, 2004
FROM A CONSUMER PROTECTION SECTION OF THE ATTORNEY GENERAL. CONSUMER WAS EXPERIENCING NOISE WHILE DRIVING AND ROUNDING CURVES. DEALER FOUND NOTHING. TOOK TO A DIFFERENT DEALER AND FOUND TIRES WERE WORN AND LOOSE REAR SWAY BAR. *LA ALL FOUR TIRES WERE REPLACED AND ALIGNED. CONSUMER WOULD LIKE REIMBURSEMENT FOR COST OF TIRES AND THE ALIGNMENT. IN ADDITION, CONSUMER THINKS FORD SHOULD CONDUCT AN INVESTIGATION INTO THIS DEFECT AND CORRECT IT. *PH
Suspension, Dec 17, 2003
WHILE DRIVING REAR WHEEL BEARING VIBRATED,MAKING A LOUD NOISE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Suspension, Nov 13, 2003
FRONT END MADE A VERY LOUD CLANGING NOISE LASTED ABOUT 10 MINUTES, PULLED OFF HIGHWAY LOOKED UNDER VEHICLE COULD NOT SEE ANYTHING WRONG, ON SEVERAL OCCASIONS WHILE DRIVING BETWEEN 55-65 MPH CAR WOULD JERK VERY BAD, DEALER COULD NOT SOLVE OR FIND A PROBLEM, VEHICLE AT REPAIR SHOP NOW. *LA
Suspension, Electrical system, Visibility, Latches/locks/linkages, Nov 13, 2003
WHILE DRIVING I LOST ALL POWER TO THE CAR. IT COMPLETELY SHUT DOWN AND I COULD NOT START IT. IT HAS BEEN TOWED TO DEALERSHIP TO BE FIXED TWICE. I DO NOT FEEL SAFE DRIVING THIS CAR WITH MY KIDS IN IT. I DON'T THINK THE PROBLEM IS FIXED AND I'M WAITING FOR THIS TO HAPPEN AGAIN. NOW I NEED TO TAKE IT BACK TO THE DEALERSHIP AGAIN BECAUSE THERE IS A BAD VIBRATION IN THE FRONT END. I HAD IT THERE PREVIOUSLY FOR THIS ALSO, AND THEY SAID IT NEEDED THE TIRES ROTATED AND BALANCED. EVEN THOUGH IT IS STILL UNDER WARRANTY, THEY CHARGED ME $36.00....THE VIBRATION IS WORSE NOW SO OBVIOUSLY THAT WASN'T THE PROBLEM. OH I FORGOT TO MENTION THAT THE TRUNK WON'T LATCH PROPERLY AND THE WINDSHIELD WIPERS WON'T GO THE WHOLE WAY DOWN WHEN YOU TURN THEM OFF. THIS CAR IS NOT SAFE TO DRIVE. THE DEALERSHIP ACTS LIKE THEY HAVEN'T HAD ANY COMPLAINTS WITH THIS CAR! *LA
Suspension, Tires, Sep 30, 2003
ABNORMAL TIRE WEAR
Suspension, Tires, Sep 21, 2003
TIRES WEAR OUT EVERY 10,000 MILES HAVE REPLACED TIRES 5 TIMES NOW WAS TOLD IT WAS BECAUSE WE DIDN'T ROTATE. 3 LINE UPS DONE AND ROTATED EVERY 5000 MILES WE ARE NOW ON SET NUMBER 6 OF TIRES AND THE DEALER CAN NOT EXPLAIN WHY WE CANT GET EVEN 1/2 THE LIFE OF THE TIRE. *JB
Suspension, Sep 12, 2003
VEHICLE'S CONTROL ARM BROKE CAUSING STEERING TO FAIL. PLEASE PROVIDE ADDITIONAL INFORMATION. *PH
Suspension, Sep 8, 2003
SWAY BAR FAILS PREMATURELY.*AK
Suspension, Sep 8, 2003
PREMATURE REAR TIRE WEAR. 6 TIRES WERE REPLACED BEFORE 27,000 MILES. DEALER SAYS ALIGNMENT IS AT FORD SPECIFICATIONS. DEALER SAID ROTATION AT 3000 MILES IS REQUIRED ON THIS VEHICLE TO PREVENT THIS PROBLEM. OVERHEARD TECH TELLING SERVICE MANAGER THAT THESE CARS DON'T HAVE ENOUGH ADJUSTMENT FOR CAMBER. TIRES CAN NOT BE ROTATED AFTER 5000 MILES BECAUSE THEY CUP OUT AND WHEN MOVED TO THE FRONT CAUSE SEVERE VIBRATION.*AK
Steering, Suspension, Aug 31, 2003
PROBLEMS WITH 2002 FORD FOCUS STEERING AND SUSPENSION.*MR *CB
Steering, Suspension, Aug 25, 2003
STEERING WHEEL LOST CONTROL WHILE DRIVING AT NORMAL SPEED. AS RESULT, LOWER AND UPPER BALL JOINTS AND BRAKE WERE DAMAGED. DEALER NOTIFIED. *AK UPDATED 1/11/2006. THERE WAS POPPING AND CLICKING IN THE STEERING WHEEL WHILE TURNING. THIS CAUSED THE CONSUMER TO LOSE CONTROL AND HIT A CURB. THE IMPACT RESULTED IN A BLOWN TIRE. *NM
Suspension, Jul 23, 2003
LEFT REAR WHEEL TIPPING IN AT TOP SO MUCH THAT YOU COULD SEE IT BEFORE 3500 MILES. THIS CAUSES THE REAR END TO BE MUCH "LOOSER" THAN IS NORMAL OR ACEPTABLE. FORD PROVIDES NO ADJUSTMENT FOR CAMBER IN REAR AND THIS CAUSED LEFT REAR TIRE TO HAVE A CUPPING PATTERN ON THE INSIDE EDGE. APPARENTLY IF THE CAMBER ISN'T CORRECT TO BEGIN IT WILL THROW OFF THE WHOLE ALIGNMENT. ONE DEALER CHECKED AND SAID IT WAS IN SPEC. AT 15,000 MI. FOUND DEALER WHO UNDERSTOOD THE PROBLEM AND INSTALLED A JUST RELEASED SHIM KIT. FORD REFUSING TO COVER KIT, ALIGNMENT, OR TIRE UNDER " BUMPER-TO-BUMPER" WARRANTY (TRYING TO CLAIM IT IS A NORMAL WEAR ITEM, OR A TIRE PROBLEM, OTHER TIRES ARE FINE!). HAD TO PAY $142 + TIRE SO THAT THE REAR END DOESN'T COME AROUND CAUSE AN ACCIDENT.*AK
Suspension, Structure, Jul 22, 2003
I HAVE DRIVEN MY FORD FOCUS SE WAGON NOW FOR ABOUT TWO YEARS. IT IS A COMPANY CAR FOR WHICH I DRIVE APPROXIMATELY 50,000MILES PER YEAR. I HAVE HAD TO REPLACE THE REAR TIRES THREE TIMES SINCE RECEIVING THE VEHICLE DECEMBER 2001. EVERY 20,000 MILES THE REAR ALIGNMENT GETS LOOSE AND ESPECIALLY IN WINTER DRIVING ON WET PAVEMENT, I FEAR FOR MY LIFE BECAUSE WHEN I CANNOT TRAVEL AT THE SPEEDS OF SURROUNDING TRAFFIC FLOW. THERE IS A VIBRATION IN THE REAR TIRES CAUSED POSSIBLY TO A BENT FRAME OR POOR DESIGN. I HAVE NEVER REPLACED THE FRONT TIRES OR EVEN ROTATED THEM SINCE NEW! THEY ARE STILL PLENTY ADEQUATE FOR TRACTION. THE REAR ALIGNMENT PROBLEM SEVERELY HAMPERS THE FUEL ECONOMY OF THE VEHICLE BECAUSE IT FEELS AS THOUGH I AM DRAGGING THE REAR END AROUND EVERYWHERE I GO. I AM TURNING THE VEHICLE IN THIS NEXT MONTH FOR A REPLACEMENT AND I HAVE DECIDED I WILL NEVER PURCHASE A FORD VEHICLE AGAIN DUE TO THE HISTORY OF BAD LUCK I HAVE HAD WITH FORDS IN THE PAST.
Suspension, Jul 11, 2003, crash
I WAS MAKING A LEFT TURN AT 15-20 MPH AND FELT THE FRONT END DIPPED THEN THE STEERING WHEEL JERKED OUT OF MY HANDS AND THE CAR DROVE INTO A CURB CAUSING MAJOR DAMAGE.*AK
Suspension, Equipment, Jun 5, 2003
I HAVE HAD MY A/C WORKED ON AT LEAST 3 TIMES. ALSO HAVE HEAVY VIBRATIONS WHEN I JUST HAD IT ALIGNED 5/04/03. AND STILL HAVING HEAVY VIBRATIONS.AK
Suspension, May 8, 2003
THE VEHICLE HAD A NOISE IN THE REAR END, DUE TO TIRE CUPPING. WHICH WAS CAUSED BY THE REAR SUSPENSION NOT SETTLING AND NOT BEING ALIGNED. *JB THE CONSUMER WAS TOLD THAT FORD HAD AN A CAMBER KIT TO INSTALL TO SOLVE THE SETTLING. *SCC