2002 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,014 owner complaints filed for this model year. This is the 9th highest complaint count among 19 Focus model years with reports.
Of the 2002 reports, 85 involved a crash and 24 involved a fire. 82 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints
1,014 reports, newest first.
Service brakes, Air, Electrical system, Exterior lighting, Sep 11, 2003
I HAVE A 2002 FORD FOCUS ZX5 4 DR HATCHBACK MY PROBLEMS STARTED ON 7/21/03 WHEN MY BRAKES LIGHTS, HEADLIGHTS, TURN SIGNAL AND RADIO STOPPED WORKING. I TOOK IT INTO THE DEALERSHIP AND IT WAS REPAIRED HOWEVER NOW THE RADIO WILL NO LONGER RESPONSE TO ME TURNING THE VOL. UP OR DOWN AS WELL AS I ONLY ONLY SET THE TIME ON MILITARY TIME. NOW ON 9/7 MY BRAKES HAVE STARTED TO GRIND. ON 9/11 MY CAR NOW VIBRATES WHEN I ACCERATE AT 60 MPH +. IN THE PAST WEEK I HAVE ALSO NOTICED THAT MY CAR WILL ACCELLERATE AND HESITATE WHEN IN MOTION. IN THE LAST THREE MONTHS MY GAS MILEAGE HAS SLOWLY DECLINED AS WELL. I AM TAKING IT INTO THE DEALERSHIP TONIGHT - BUT THOUGHT I NEED TO REPORT. SEEMS THERE ARE MANY OTHERS LIKE ME.
Service brakes, Hydraulic, Vehicle speed control, Sep 11, 2003, crash
I HAVE A 2002 FORD FOCUS SE W/ 5 SPEED MANUAL TRANSMISSION AND CRUISE CONTROL PLUS OTHER OPTIONS. ON DATE LISTED, I WAS TRAVELING AT 65 MPH ON A 4 LANE HWY APPROACHING A TRAFFIC LIGHT. THE CAR WAS IN 5TH GEAR W/ THE CRUISE CONTROL ON. UPON TOUCHING THE BRAKE PEDAL TO TURN OFF THE CRUISE CONTROL AND BEGIN BRAKING, NEITHER EVENT HAPPENED. I TRIED 3X TO GET THE CRUISE CONTROL TO TURN OFF BY PRESSING THE BRAKE PEDAL HARD. IT FAILED ALL THREE TIMES. BY THEN, I WAS RAPIDLY APPROACHING A GROUP OF CARS IN BOTH NORTHBOUND LANES OF GA HWY 365 COMPLETELY STANDING STILL WAITING FOR THE LIGHT TO CHANGE. IN RESPONSE TO A RUNAWAY CAR, I ATTEMPTED TO DRIVE OFF THE RIGHT SHOULDER OF THE ROAD; HOWEVER, THE CAR IMMEDIATELY IN FRONT OF ME DID THE SAME. I STRUCK HER CAR ON THE RIGHT SIDE WITH THE LEFT SIDE OF MY 2002 FORD FOCUS SE. MY PASSENGER REACHED OVER & TURNED THE IGNITION SWITCH TO OFF. I WAS ABLE THEN TO BRAKE THE CAR TO A STOP A FEW FEET FROM A CONCRETE CULVERT. THE LEFT FRONT WHEEL OF MY CAR WAS FOLDED APPROXIMATELY 45 DEGREE ANGLE AND THE ENTIRE FRONT END WAS DOWN ON THE GROUND. THE LEFT FRONT TIRE HAD BLOWN OUT. NEITHER CAR WAS DRIVEABLE. THIS IS THE SECOND TIME THIS CAR HAS FAILED ON TURNING OFF THE CRUISE CONTROL WHEN THE BRAKE PEDAL WAS APPLIED. FURTHER, THE BRAKE WEAR INDICATOR HAD BEGUN SQUELING RECENTLY. THE CAR HAD 13040 MILES ON IT AT THE TIME OF THE ACCIDENT. IT WAS PURCHASED ONE YEAR EARLIER. WILLARD FERGUSON
Service brakes, Hydraulic, Equipment, Sep 9, 2003
2002 FORD FOCUS HAS FAILURE OF FRONT BRAKE CALIPERS, NEEDS REPLACING OF ROTORS, PADS AND CALIPERS UNDER WARRANTY BUT DEALER REFUSES TO AGREE TO THIS ESTIMATE BY MASTER BRAKE. DEALER SAYS I ONLY NEED PADS AND ROTORS MACHINED. CAR ONLY HAS 14,692 MILES ON IT.*AK
Suspension, Sep 8, 2003
SWAY BAR FAILS PREMATURELY.*AK
Suspension, Sep 8, 2003
PREMATURE REAR TIRE WEAR. 6 TIRES WERE REPLACED BEFORE 27,000 MILES. DEALER SAYS ALIGNMENT IS AT FORD SPECIFICATIONS. DEALER SAID ROTATION AT 3000 MILES IS REQUIRED ON THIS VEHICLE TO PREVENT THIS PROBLEM. OVERHEARD TECH TELLING SERVICE MANAGER THAT THESE CARS DON'T HAVE ENOUGH ADJUSTMENT FOR CAMBER. TIRES CAN NOT BE ROTATED AFTER 5000 MILES BECAUSE THEY CUP OUT AND WHEN MOVED TO THE FRONT CAUSE SEVERE VIBRATION.*AK
Air bags, Sep 4, 2003, crash
WHILE DRIVING ABOUT 70MPH ON HIGHWAY AND WITHOUT PRIOR WARNING ANOTHER VEHICLE COLLIDED WITH CONSUMER'S VEHICLE, CAUSING A COLLISION. DRIVER SWUNG AROUND, HITTING THE GUARDRAIL. UPON IMPACT, DRIVER'S SIDE AIR BAG DIDN'T DEPLOY. *AK
Steering, Suspension, Aug 31, 2003
PROBLEMS WITH 2002 FORD FOCUS STEERING AND SUSPENSION.*MR *CB
Engine and engine cooling, Fuel system, Gasoline, Aug 25, 2003
2002 FORD FOCUS SE ENGINE STALLED.*MR CONSUMER HAD THE FUEL PUMP REPLACED EXPECTING TO REMEDY THE PROBLEM. ONCE THE CONSUMER ARRIVED AT THE GAS STATION AND BEGAN TO FILL THE GAS TANK THERE WAS A PUDDLE OF OIL UNDERNEATH THE VEHICLE, IT WAS THEN DETERMINED THE DEALER INSTALLED THE GAS TANK INCORRECTLY WHICH CAUSED THE LEAK. *TS. ON THE THIRD OCCASION, WHILE DRIVING, THE ENGINE STALLED AND RESTARTED AND THE AUTOMATIC TRANSAXLE/COOLING SYSTEM LIGHT ILLUMINATED ON THE DASHBOARD AND THEN WENT OFF. *JB
Steering, Suspension, Aug 25, 2003
STEERING WHEEL LOST CONTROL WHILE DRIVING AT NORMAL SPEED. AS RESULT, LOWER AND UPPER BALL JOINTS AND BRAKE WERE DAMAGED. DEALER NOTIFIED. *AK UPDATED 1/11/2006. THERE WAS POPPING AND CLICKING IN THE STEERING WHEEL WHILE TURNING. THIS CAUSED THE CONSUMER TO LOSE CONTROL AND HIT A CURB. THE IMPACT RESULTED IN A BLOWN TIRE. *NM
Structure, Aug 23, 2003
SEVERE CREAKING/RUBBING SOUND COMING FROM REAR DOOR ON DRIVER'S SIDE OF VEHICLE. NOISE OCCURS WHILE DRIVING AT ALL SPEEDS. SOUNDS AS THOUGH DOOR IS OUT OF ALIGNMENT OR IMPROPERLY MOUNTED. DEALER HAS ATTEMPTED TO DIAGNOSE AND REPAIR THE PROBLEM ON TWO OCCASSIONS (4 DAYS TOTAL OUT OF SERVICE), AND HAS BEEN UNABLE TO FIX. DEALER MOST RECENTLY STATED THAT SOME CREAKING IS NORMAL DUE TO FLEXING/TWISTING OF FRAME OF VEHICLE WHILE DRIVING. CREAKING/RUBBING, MEANWHILE, IS GETTING WORSE.*AK
Latches/locks/linkages, Aug 19, 2003
CONSUMER NOTICED THAT PASSENGER'S SIDE REAR DOOR WAS OPEN. UPON LOCKING DOOR LATCH IT WILL NOT LOCK IN PLACE, CAUSING, CONSUMER TO SECURE VEHICLE. *AK
Service brakes, Hydraulic, Aug 18, 2003
TO MY FOCUS IN TO SERVICE JAN 2003 FOR SQUEAKING BRAKES, ROTORS WERE WARPED, BRAKE SQUEAKING SAID TO BE "NORMAL". THEY MACHINE STRAIGHTENED THE ROTORS AND SAID FORD ENGINEERING LOOKING INTO SQUEAKS. AUG. 2003 TAKE FOCUS IN FOR LOUD VIBRATING SOUND. BRAKES AND ROTORS COMPLETELY SHOT. $440 TO FIX. 13700 MILES ON CAR. *AK
Power train, Electrical system, Aug 14, 2003
ON AUGUST 11, 2003 I TOOK MY CAR INTO KOONS FORD OF ANNAPOLIS, TO HAVE THE HAVE THE IGNITION SWITCH TOOK AT, BECAUSE THE KEY WOULD NOT TURN. I WAS TOLD MY SERVICE MANAGER MIKE SHECKELLS, THE SERVICE ADVISOR PETE, AND FACTORY TECH: 063 - RANDALL BOUNDS, AND A CASHIER THAT THIS HAS BEEN A MAJOR PROBLEM WITH MOST OF THE FORD FOCUS, I FEEL THIS I SHOULD BE ON A RECALL NOTICE IF ITS HAS BEEN A MAJOR PROBLEM WITH THE FOCUSES. THAT THE CONSUMERS SHOULD NOT HAVE TO PAY FOR A MAJOR DEFECT WITH THESE VECHICLE. ALSO, I HAD MY FOCUS IN KOONS FOR OF ANNAPOLIS, ON MAY 10, 2003, TO HAVE NEW BRAKES, OIL CHANGE AND TRANSMISSION PROBLEMS. ON THE TRANSMISSION PROBLEMS BECAUSE IT WAS A INTERMITTENT THAT THEY COULD NOT FIND ANY THING.*AK ON JULY 25, 2003, I LEFT MY CAR FOR SERVICE ON THE TRANSMISSION BECAUSE IT WAS SLIPPING OUT OF GEAR COMPLETELY. THEY HAD THE CAR UNTIL AUGUST 7, 2003, WHICH THEY PUT IN A REMFG TRANSMISSION AND C. I LEFT KOONS FOR WITH 1.5 MILES ON THE TRIP METER, I WENT ANOTHER 17.1 MILES WENT THE TRANSMISSIONS SURGED, I E-MAILED MIKE SHECKELL ON AUGUST 8, 2003 WHICH HE DID NOT ANSWER AS OF THIS DAY. I TALKED TO MIKE SHECKELL ON AUGUST 11, ABOUT THIS PROBLEM AND THE ANSWER I GET IS THEY CAN NOT DO ANY EXCEPT TO LET SOME ONE GO ON AT TEST DIVE WITH ME. THIS IS NOT THE ANSWER BECAUSE IT'S A INTERMITTEN PROBLEM AND SOME ONE WOULD HAVE TO DRIVE IT FOR A FEW DAY BEFORE THE TRANSMISSION WOULD SURGED AGAING. I HAVE KEPT RECORD OF THIS PROBLEM IS SURGED AT 18.5 MILES, 93 MILES AND AT 250.0 MILES ON THE TRIP METER. I FEEL THE TRANSMISSION WAS NOT FIXED AND FIXED RIGHT AND ALSO, FEEL THAT THIS IS A SAFETY PROBLEM. I HAVE DONE BUSINESS WITH KOONS FOR OF ANNPOLIS FOR OVER 20 YEARS. MY DAUGHTER IS SCARED TO RIDE IN THIS CAR NOW, AND I DO NOT FEEL SAFE IN THE CAR NEITHER. I HAVE NEVER HAD THIS TYPE OF BAD SERVICE OR INCOMPETENT SERVICE BEFORE, I ALSO FEEL THEY ARE JUST TELLING ME ANYTHING, BECAUSE OF BEING A FEMALE.
Engine and engine cooling, Aug 7, 2003
CONSUMER NOTICED WHILE ACCELERATING THE ENGINE DIED. DEALER WAS CONTACTED. PLEASE PROVIDE FURTHER INFORMATION. *PH
Structure, Latches/locks/linkages, Equipment, Aug 6, 2003
FORD FOCUS: BACK DOOR WILL NOT ALWAYS LATCH. MY SON ALMOST FELL OUT OF THE CAR, THANKFULLY HE WAS STRAPPED INTO HIS CAR SEAT. I SHUT THE DOOR AND WAS DRIVING AWAY WHEN THE DOOR FLEW OPEN. FOCUS IS WHITE,ONLY 1 1/2 OLD AND HAS RUST SPOTS ALL OVER THE CAR. THE TRUNK OF THE CAR HAS THE MOST RUST.THE RADIO DIAL HAS MELTED FEELS LIKE YOU ARE PLAYING WITH BUBBLE GUM. HAVE ALSO HAD PROBLEMS KEEPING THE CAR ON THE ROAD IN RAIN AND SNOW. I TAKE THE TURNPIKE TO WORK AND FEEL THAT I AM GOING TO SLIDE INTO ANOTHER CAR IF I GO FASTER THEN 25 MILES AN HOUR IN THE RAIN OR SNOW.*AK
Tires, Wheels, Aug 3, 2003
TIRE SIDEWALL TOO SOFT TO PROTECT WHEEL RIM AT RECOMMENDED MFG. PRESSURE. RIM BENT JUST DRIVING OVER COMMON DRIVE WAY CURBS. HAD TO REPLACE ALLOY WHEEL .*AK
Power train, Aug 2, 2003
MY 2002 FORD FOCUS SE WAGON PURCHASED 1 YEAR AGO HAS BEEN AT THE DEALER OVER A WEEK. THE AUTOMATIC TRANSMISSION IS SLIPPING ;CAR IS STILL UNDER WARRANTY. THEY ARE REPLACING IT. I WILL BE CONTACTING FORD MOTOR COMPANY AS I HAVE BEEN DRIVINF FORDS FOR THE LAST 17 YEARS. ALSO HAD PROBLEMS WITH THE DOOR LOCKS.*AK
Tires, Wheels, Aug 1, 2003
CONSUMER STATED THAT AFTER HITTING A POTHOLE THE TIRE ON THE RIGHT CAME APART FROM THE WHEEL. AFTER CAREFULL INSPECTION CONSUMER FOUND ALL OF THE WHEELS ON VEHICLE WERE BENT. *AK
Engine and engine cooling, Aug 1, 2003
WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING THERE WAS AN ODOR COMING FROM INSIDE OF THE VENT AREA. *AK
Vehicle speed control, Jul 31, 2003
CONSUMER WOULD PUT THE CRUISE CONTROL ON AND THE VEHICLE WOULD ACCELERATE WITHOUT WARNING. DEALER NOTIFIED. *PH
Service brakes, Hydraulic, Jul 31, 2003
CONSUMER STATES WHEN STARTING THE VEHICLE IN THE MORNING, THE BRAKES WOULD NOT WORK. *PH
Tires, Jul 29, 2003
WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING PASSENGER'S RIGHT TIRE TREAD SEPARATED FROM THE WHEEL. FIRESTONE, FIRELAWN, P20550/R16. *AK
Wheels, Jul 28, 2003
FORD FOCUS 2003 ZX5 WITH 16" ALLOY WHEELS AND FIRESTONE TIRES SEEMS TO BE SUSCEPTIBLE TO ROAD HAZARD DAMAGE MORE THAN OTHER CARS I HAVE HAD. ONE BUBBLED TIRE, AND ANOTHER PUNCTURED TIRE WITHIN WEEKS OF EACH OTHER.*AK THE FOCUS ALLOY WHEELS ARE THE WORSE PROBLEMS. AT LEAST TWO HAVE BEEN BENT TO THE POINT OF CAUSING STEERING AND VIBRATION PROBLEMS ON CAR. ONE WHEEL HAS TWO VISIBLE BUMPS, AND ONE WHEEL HAS A MASSIVE BUMP FROM SOME UNKNOWN ROAD HOLES. I HAVE NEVER HAD A CAR THAT HAD SUCH WEAK RIMS. I AM NOT REPLACING THE WHEELS UNTIL I TALK TO EITHER FORD OR A LAWYER.
Tires, Jul 26, 2003
ON 25 JULY 2002, I TOOK MY FOCUS TO A TIRE CENTER BEING REFERRED BY FORD DEALERSHIP UPON MY 30,000 MI. SERVICE. THIS IS IN REFERENCE TO PREMATURE TIRE WEAR ON THE SE LOW PROFILE TIRE/ RIM PACKAGE. I ASKED THE TIRE MANAGER TO CHECK THE TIRE AND BEFORE I TOLD HIM WHICH TIRE IT WAS HE WAS ABLE TO TELL ME WHICH TIRE IT WAS: LEFT REAR TIRE. HE STATED THAT IT WAS HIS 3RD FOCUS WITH THE PROBLEM. HE RAISED THE CAR AND SHOWED ME A LARGE CHUNK MISSING AND INCONSISTENT WEAR ON THE INSIDE EDGE OF THE TIRE. OTHER THREE TIRES ARE IN EXCELLENT SHAPE. NO ACCIDENTS WITH THIS VEHICLE IN AREA DESCRIBED. MANAGER STATED HE THINKS IT IS BEING CAUSED BY A MISSING OR SHEARED PIN. *AK
Latches/locks/linkages, Jul 25, 2003
THE DEALER HAD TO REMOVE THE REAR SEATS AND TRUNK LOCK TO GET THE TRUNK TO OPEN. *NLM *SCC *JB