2002 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,014 owner complaints filed for this model year. This is the 9th highest complaint count among 19 Focus model years with reports.
Of the 2002 reports, 85 involved a crash and 24 involved a fire. 82 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints
1,014 reports, newest first.
Fuel system, Gasoline, Sep 29, 2009
2002 FORD FOCUS EXHIBITS ENGINE HESITATION WHEN THE FUEL TANK IS BELOW 1/4 FULL. THERE ARE ACCELERATION PROBLEMS AND THE CAR HAS COMPLETELY LOST POWER ON AT LEAST ONE OCCASION WHILE DRIVING ON THE HIGHWAY. THIS BEGAN TO HAPPEN WITH 80,000KM ON THE CAR AND NOW ALWAYS HAPPENS WHEN DRIVING AT HIGHWAY SPEEDS WITH ONLY 1/4 TANK OF GAS. COMPLAINTS TO FORD ABOUT HOW THIS IS THE EXACT SAME CONDITION THAT CAUSED THEM TO ISSUE A RECALL ON 2000 AND 2001 FOCUSES (03N01) HAVE NOT RESULTED IN ANY OFFER TO REPLACE THE FUEL PUMP FOR FREE. *TR
Suspension, Sep 17, 2009
FRONT PASSENGER SIDE COIL SPRING HAD TO BE REPLACED BECAUSE OF BREAKAGE. LOSS CONTROL OF CAR OVER BUMP AT LESS THAN 20 MPH SPEED! *TR
Electrical system, Sep 9, 2009
I OWN A 2002 FORD FOCUS. LAST NIGHT I WAS AT SCHOOL , A VERY LATE CLASS THAT ENDS AT 10:15PM, AND WHEN I WENT TO TURN MY KEY IT WAS STUCK. AFTER MANY FAILED ATTEMPTS IN A PARKING LOT THAT IS BASICALLY EMPTY BY THAT TIME AND BEING SO CLOSE TO DOWNTOWN AND THE LIGHT RAIL I WAS VERY AFRAID OF BEING STRANDED IN ALONE AS I DID NOT HAVE MY CELL PHONE ON ME. FINALLY SECURITY CAME AROUND AFTER ABOUT 1/2 HOUR AND LET ME CALL MY HUSBAND AND ALSO LOOKED ON THE INTERNET TO SEE IF THIS HAD BEEN REPORTED BEFORE BY ANY CAR OWNERS. TURNS OUT THAT THIS IS THE MOST COMMON PROBLEM IN 90% OF FORD FOCUS YEARS 2000-2003. I AM AMAZED THAT THIS IS PUBLIC KNOWLEDGE AND FORD THEMSELVES EVEN ACKNOWLEDGE THIS AND THERE HAS BEEN NO RECALL? MAYBE IT WILL TAKE SOMETHING REALLY BAD TO HAPPEN TO SOMEONE BEFORE FORD REALIZES HOW DANGEROUS THIS CAN BE? I SURE HOPE THAT SOMEONE WILL REALIZE THIS IS A HUGE ISSUE BECAUSE HAD THAT SECURITY OFFICER NOT COME BUY I WOULD HAVE BEEN STUCK THERE SINCE MY HUSBAND WORKS NIGHTS. THE NEXT DAY ,TODAY, I AM NOT ABLE TO TURN THE SWITCH ONCE AGAIN BUT THIS TIME I AM IN THE COMFORT OF MY OWN HOME. PLEASE I HOPE YOU ARE ABLE TO SEE THE SAFETY HAZARD IN THIS ISSUE THAT FORD FAILS TO SEE AND ASK THAT A RECALL BE MADE. *TR
Electrical system, Sep 8, 2009
SUDDEN ONSET, GOT IN MY CAR, PUT MY KEY IN THE IGNITION AND THE KEY WOULD NOT TURN TO START THE CAR NO MATTER WHAT I DID. RESEARCHED THE PROBLEM, TENS OF THOUSANDS OF COMPLAINTS FROM 1999 TO PRESENT, OWNERS ARE STRANDED IN DIFF. SITUATIONS, FREEZING COLD, EXTREME HEAT, WITH BABIES/CHILDREN, STRANDED WITHOUT THE ABILITY TO COMMUNICATE, YOUNG WOMEN (AS IN MY CASE), AT NIGHT, ETC. COST TO REPAIR UP TO $750. AM TRYING TO FIX IT ON MY OWN, CAN'T AFFORD A DEALER REPAIR! FORD IS AWARE THE PROBLEM IS WITH POOR QUALITY METAL USED TO MAKE THE PART. I WROTE TO FORD, THEY SAY BRING MY CAR IN TO "HAVE IT LOOKED AT" BUT QUALIFY, SAYING: IT IS NOT A WARRANTY REPAIR AND TO HAVE IT EXAMINED MAY COST ME. MANY OTHER OWNERS HAVE POSTED TEMPORARY AND LOWER COST FIXES ON-LINE AS FORD IS NOT WILLING TO DO A RECALL STATING IT IS "NOT A SAFETY ISSUE". THIS IS A SAFETY ISSUE. IF SOMEONE IS STRANDED IN EXTREME HEAT OR COLD OR A YOUNG WOMAN IS STRANDED BECAUSE A KEY WON'T WORK, WE ARE AT RISK AND UNSAFE. A YOUNG CHILD COULD DIE FROM EXPOSURE, BECOME SICK, A YOUNG WOMAN COULD BE RAPED OR KILLED. FORD IS RISKING OUR SAFETY AND IS AT FAULT PARTICULARLY BECAUSE THEY ARE AWARE THERE IS A PROBLEM AND CAN DO SOMETHING PROACTIVELY TO FIX THE SITUATION. THAT THIS DOCUMENTED SITUATION HAS GONE ON FOR YEARS IS OUTRAGEOUS. IT'S FRIGHTENING TO GET IN YOUR CAR AT NIGHT, NOT HAVE YOUR KEY WORK, NOT KNOW WHAT'S WRONG OR BE ABLE TO DO ANYTHING! WHEN WE ARE STRANDED BECAUSE FORD WILLINGLY PUT SUBSTANDARD PARTS IN A VEHICLE, WE ARE UNSAFE. PRIOR TO OWNING THIS CAR I HAD A 1973 VW BUG, MY KEY ALWAYS WORKED WITH THE ORIGINAL PARTS. TO BE EXPECTED TO PAY UPWARDS OF $750 FOR A PART AND LABOR FOR SOMETHING THAT SHOULD LAST THE LIFE OF THE VEHICLE, THAT'S TIED TO SAFETY IS UNACCEPTABLE. OUR CARS ARE UNSAFE, RISKING DAMAGE WAITING FOR REPAIR DEPENDING ON WHERE THEY ARE STRANDED! MY SAFETY IS NOT IMPORTANT NOR AN ISSUE FOR FORD, THEY DON'T CARE ABOUT MY CAR, MY TRUST WAS MISPLACED, MY CAR WAS NOT BUILT TOUGH. *TR
Electrical system, Jul 28, 2009
TL*THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING BETWEEN 35-40 MPH, THE CONTACT PULLED THE VEHICLE OVER AND TURNED OFF THE IGNITION. THE ENGINE WAS RESTARTED; HOWEVER, THE IGNITION KEY FAILED TO TURN. ROADSIDE ASSISTANCE TOWED THE VEHICLE TO HIS RESIDENCE. THE AUTHORIZED DEALER STATED THAT THIS WAS A COMMON ISSUE WITH THIS VEHICLE, AND THEY REPLACED THE IGNITION SWITCH. THE FAILURE AND CURRENT MILEAGES WERE 134,000.
Electrical system, Jul 23, 2009
I OWN A 2002 FORD FOCUS , THE KEY FAILS TO TURN IN THE IGNITION OVER AND OVER AGAIN. I'M A YOUNG WOMAN WORKING LATE HOURS 45 MILES AWAY FROM HOME 5 TIMES A WEEK AND I'VE BEEN STRANDED SEVERAL TIMES. I'VE BEEN DEALING WITH THIS PROBLEM FOR YEARS. TO MY KNOWLEDGE, THERE ARE OVER 3, 045 COMPLAINTS ONLINE. THERE IS ALSO A PETITION. THIS IS A SAFETY HAZARD AND SHOULD BE RECALLED. IT'S DANGEROUS NOT BEING ABLE TO START YOUR CAR LATE AT NIGHT OR ANYWHERE AT ANYTIME FOR THAT MATTER. EVEN WHEN YOU REPLACE THE IGNITION CYLINDER, IT HAPPENS AGAIN AND AGAIN. IT'S A DEFECT. PLEASE HELP US! IT'S REALLY INCONVENIENT , UNSAFE AND VERY DISAPPOINTING.*TR
Suspension, Jul 13, 2009
MY 2002 FORD FOCUS HAS ONLY 41,000 MILES ON IT AND THE FRONT RIGHT COIL SPRING BROKE ON ME LAST WEEK. FORTUNATELY I DID NOT CRASH OR LOOSE MY BRAKES BUT IT HAS POTENTIAL FOR A CATASTROPHIC EVENT. I AM HOPING FORD WILL RECALL THESE AS THEY DID WITH THE EARLIER MODELS. *TR
Electrical system, Jul 6, 2009
2002 FORD FOCUS, KEY WOULD NOT TURN IN THE IGNITION, STRANDING MY SON SOME DISTANCE FROM HOME. HAD TO HAVE THE CAR TOWED TO A DEALER AND PAID $285 TO HAVE THIS FIXED (NOT INCLUDING TOWING). *TR
Steering, Jun 30, 2009
DRIVING AND THE CAR STARTED TO MAKE NOISE WHEN THE WHEELS WERE TURNED. CHECKED THE POWER STEERING FLUID AND BELT, AND ADDED MORE POWER STEERING FLUID. THE PROBLEM STILL CONTINUED. THE POWER STEERING LINE WAS RUBBING ON THE FRAME OF THE CAR, AND RUB OPEN CAUSING A LEAK IN THE LINE. THIS STOPPED THE POWER STEERING FROM WORKING. WE TOOK THE LINE OUT, WITH A LOT OF EFFORT, AND TIME. THEN BOUGHT A NEW PART FOR $55 AND THEN HAD TO PUT IT IN. ALTHOUGH WE HAVE NOT GOT THE PART YET, BUT IT SEEMS AS IF PUTTING IT BACK IN WILL NOT BE EASY. *TR
Suspension, Structure, Jun 26, 2009
TL*THE CONTACT OWNS A 2003 FORD FOCUS. THE CONTACT TOOK HIS VEHICLE TO THE DEALER FOR ROUTINE INSPECTION. HE WAS ADVISED THAT THE FRONT CROSS MEMBER HAD EXCESSIVE CORROSION. HE CALLED AN AUTHORIZED DEALER AND WAS INFORMED THAT THE COMPONENT NEEDED TO BE REPLACED AT THE COST OF $800. HE IS IN THE PROCESS OF HAVING THE VEHICLE REPAIRED. THE MANUFACTURER STATED THAT THE COMPONENT WAS NOT COVERED UNDER WARRANTY. THE CONTACT HAS POSSESSION OF THE FAILED COMPONENT. THE FAILURE AND CURRENT MILEAGES WERE 60,000. UPDATED 07/28/09. *LJ THE CONSUMER WAS INFORMED THE EXCESSIVE CORROSION WAS THE RESULT OF NOT HAVING ADEQUATE CORROSION PROTECTION AT THE TIME OF MANUFACTURING AND IT WAS IN DANGER OF FAILING. UPDATED 07/31/09.,*JB
Electrical system, Jun 14, 2009
ON THE 2002 FORD FOCUS, THE KEY WON'T TURN IN THE IGNITION SWITCH AND THEREBY LOCKS THE CAR IN ITS PRESENT POSITION. THE CAR CAN'T BE MOVED SO THE DRIVER IS PRONE TO BE STRANDED AND THE CAR COULD BE TOWED OR VANDALIZED IF ALLOWED TO REMAIN IN A CITY STREET PARKING SPACE. THIS COULD ALSO BE DANGEROUS IF THERE IS AN EMERGENCY AND THE DRIVER NEEDS TO GET SOMEWHERE QUICKLY. FORD SHOULD ISSUE A RECALL. *TR
Electrical system, Jun 4, 2009
THE IGNITION LOCK ON MY 2002 FORD FOCUS IS DEFECTIVE. IT TAKES A LOT OF JIGGLING OF THE KEY TO GET IT TO TURN. SOMETIMES IT TAKES UP TO 10 MINUTES TO GET THE KEY TURNED. I'M AFRAID AT SOME POINT I WON'T BE ABLE TO TURN IT PERIOD. I HAVE READ MANY REPORTS ONLINE ABOUT FORD FOCUS BETWEEN 2000 AND 2003 HAVING THE SAME PROBLEM. *TR
Electrical system, Jun 2, 2009
DROVE TO THE STORE, TURNED THE CAR OFF BUT THE KEY WAS STUCK IN THE IGNITION. *TR
Latches/locks/linkages, May 22, 2009
TL*THE CONTACT OWNS A 2002 FORD FOCUS. ON MAY 20, 2009, WHEN THE CONTACT ATTEMPTED TO OPEN THE REAR PASSENGER SIDE DOOR, HE WAS UNABLE TO UNLATCH THE LOCK. HE TOOK THE VEHICLE TO THE DEALER AND THEY FOUND THAT THE REAR PASSENGER SIDE DOOR LATCH MOTOR FAILED. A NEW MOTOR WOULD COST $400. THE MANUFACTURER STATED THAT THERE WAS NO RECALL FOR THE FAILURE; THEREFORE, THEY WOULD NOT ASSIST. THE CURRENT AND FAILURE MILEAGES WERE 129,000.
Service brakes, Hydraulic, Vehicle speed control, May 22, 2009
ABS AND BRAKE LIGHTS HAS CONTINUED TO BE ON AND CRUISE CONTROL HAS STOPPED WORKING. *TR
Fuel system, Gasoline, May 14, 2009
2002 FORD FOCUS BOUGHT THE END OF MARCH 2009, NOW SITS IN DRIVEWAY, BECAUSE FORD WILL NOT FIX FUEL DELIVERY MODULE FAILURE, BECAUSE OF VIN# NOT ON LIST AS BEING ONE OF THE 671000 UNITS AFFECTED. THE CAR IS DOING THE SAME THING AS ALL THE OTHER 671000 THAT WERE AFFECTED, SURGING, LOSS OF POWER, STALLING, HESITATION. WE WERE GOING DOWN THE ROAD, CHANGED LANES AND IT STARTED DOING THIS, NOW I HAVE HAD 3 MECHANICS WORK ON THIS CAR, NO HELP REPLACED FUEL PUMP, BATTERY, FUEL FILTER ETC, NO LUCK. IT STARTS WHEN IT WANTS WILL RUN THEN IT STARTS LOSING POWER, STALLS. WE DID EXPECT PROBLEMS WITH USED CAR, BUT NOT ONE THAT SHOULD HAVE BEEN INCLUDED IN A RECALL AND FIXED. IF ACCIDENT HAPPENS BECAUSE OF THIS PROBLEM FORD WILL BE AT FAULT. *TR
Visibility, May 12, 2009
I HAVE A 2002 FORD FOCUS. ABOUT A YEAR AGO MY LEFT REAR WINDOW REGULATOR WENT OUT WHILE I WAS DRIVING DOWN I24. THE SOUND OF THE WINDOW SLAMMING DOWN SCARED ME SO BAD I ALMOST DROVE OFF THE ROAD AT 70MPH WITH 3 KIDS IN THE CAR. THE SOUND WAS LIKE A GUNSHOT. ABOUT 2 MONTHS LATER THE RIGHT REAR WINDOW REGULATOR WENT OUT THIS TIME I WAS DRIVING MY 3 YEAR OLD SON TO THE BABYSITTER. THE SOUND WAS SO LOUD I SWERVED ALMOST HITTING THE CAR NEXT TO ME. I GOT BOTH WINDOWS FIXED FOR ABOUT 350.00. A WEEK AGO THE LEFT WINDOW REGULATOR WENT OUT AGAIN. I AM NOW AFRAID TO DRIVE THIS CAR FOR FEAR THE NEXT WINDOW WILL GO OUT AND STARTLE ME INTO AN ACCIDENT. *TR
Fuel system, Gasoline, Apr 27, 2009
MY 2002 FORD FOCUS ZTS SUDDENLY STALLED IN HEAVY, FAST MOVING TRAFFIC. I HAD TO WRESTLE THE CAR TO THE CURB WITHOUT POWER STEERING OR POWER BRAKES WHILE AT THE SAME TIME AVOIDING TRAFFIC. I TOOK IT TO THE SHOP AND THEY SAID THE FUEL PUMP HAS FAILED AND NEEDED REPLACEMENT. TOTAL COST ESTIMATE IS NEARLY $800. THIS IS A COMMON PROBLEM IN 2001 AND 2000 MODELS AND THIS PART IS EVEN COVERED IN AN EXTENDED WARRANTY FOR THOSE YEARS. HOWEVER, THE 2002 IS NOT COVERED. I THINK THAT THIS SHOULD BE A SAFELY CONCERN FOR FORD BUT I THINK THEY ARE DOING THE BARE MINIMUM. I WILL NEVER BUY ANOTHER FORD AGAIN. NO WONDER THEY ARE HAVING SUCH DIFFICULT TIMES AT FORD! *TR
Suspension, Apr 24, 2009
DRIVING HOME FROM THE STORE AND I HEARD A SNAPPING SOUND IN THE FRONT OF THE CAR I TOOK THE CAR TO THE SERVICE STATION THEY LOOKED UNDER THE CAR AND SAID IT IS A BROKEN SPRING AND IT WAS DANGEROUS TO DRIVE. *TR
Electrical system, Apr 23, 2009
I HAD COME BACK TO MY 2002 FORD FOCUS SE, PUT THE IGNITION KEY INTO THE IGNITION SWITCH & THE SWITCH WOULD NOT TURN. I HAD TO PAY $45.00 TO HAVE MY CAR TOWED TO A GARAGE. THE MECHANIC CHARGED ME $400.00 TO REPLACE THE WHOLE UPPER PART OF THE STEERING COLUMN & REDO THE IGNITION SWITCH THAT CAME ON IT. *TR
Engine and engine cooling, Apr 18, 2009
DETAILS: THE CAR'S CHECK ENGINE LIGHT CAME ON AND STARTED STALLING, HAD IT CHECKED AND WAS TOLD IT NEEDED A TIMING BELT AND TUNE UP. AFTER $1400 LATER AND STILL THE SAME PROBLEM THAT THE CAR WAS ONLY RUNNING ON 3 CYLINDERS AND WAS RECOMMENDED TO PUT AN ADDITIVE IN THE ENGINE TO TRY TO LOOSEN UP STUCK VALVES... STILL SAME PROBLEM . THEN TEARING THE ENGINE APART FOUND DAMAGE DONE TO # 4 CYLINDER . *TR
Steering, Apr 13, 2009
THE KEY WILL NOT TURN IN THE IGNITION, WITH THE STEERING WHEEL LOCKING UP. NO AMOUNT OF JIGGLING CAN FIX IT. SO CAR IS UNABLE TO START. (4 TIMES IN A ROW - FINAL TIME, NOT STARTED AFTER HOURS OF TRYING). *TR
Latches/locks/linkages, Apr 12, 2009
I OWN A 2002 FORD FOCUS AND I SIMPLY PARKED MY CAR AT THE GROCERY STORE, LOCKED MY CAR, AND WHEN I CAME BACK I COULD NOT TURN THE KEY IN THE IGNITION TO START THE CAR. THIS IS THE FIRST TIME ITS HAPPEN WHERE I COMPLETELY FAILED TO TURN THE KEY. NOW MY CAR IS SITTING AT THE GROCERY STORE AND NOW I'M READING THAT I'M GOING TO POTENTIALLY PAY 200 TO 400 BUCKS TO GET THIS FIXED. THIS IS VERY, VERY UPSETTING. THANKS FORD FOR YOUR LOUSY IGNITION DESIGN. I'LL NEVER BUY A FORD AGAIN. *TR
Fuel system, Gasoline, Electrical system, Apr 6, 2009
FAULTY IGNITION CYLINDER LOCK, FAILS WITHOUT WARNING. I HAD IT REPLACED 12/15/07 AND IT IS NOW DEFECTIVE AGAIN ON 4/6/09. I HAD IT FIXED LAST TIME FOR $200, BUT IT CAN COST UP TO $400. HOW THIS ISN'T A SAFETY ISSUE IS BEYOND ME. THEN AGAIN THE PINTO'S EXPLODING GAS TANK WASN'T DEEMED A "SAFETY ISSUE" BY FORD, EITHER. *TR
Steering, Apr 1, 2009
TL*THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING APPROXIMATELY 40 MPH ON NORMAL ROAD CONDITIONS, THE STEERING WHEEL LOOSENED WITHOUT WARNING. THE STEERING BEGAN TO WANDER AND FAILED TO RESPOND NORMALLY. IMMEDIATELY, THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND INSPECTED. THE VEHICLE WAS DRIVEN CAUTIOUSLY TO AN AUTHORIZED DEALER AND THEY TIGHTENED THE ADJUSTMENT SCREW AND RE-TIGHTENED THE LOCK NUTS ON THE STEERING WHEEL COLUMN. THE MANUFACTURER HAS BEEN NOTIFIED OF THE MALFUNCTIONS. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 60,000.