2003 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,017 owner complaints filed for this model year. This is the 8th highest complaint count among 19 Focus model years with reports.
Of the 2003 reports, 53 involved a crash and 19 involved a fire. 52 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
65 reports, newest first. Show all
Engine and engine cooling, Feb 10, 2004
2003 FORD FOCUS ZX3 PZEV ENGINE STALLS INTERMITTENTLY WITHOUT WARNING WHILE DRIVING. ALL THE INSTRUMENTS ON THE DASH (SPEEDOMETER, ODOMETER, TACHOMETER, OIL PRESSURE, ETC.) BECOME INOPERATIVE. MUST BRING THE CAR TO A STOP, PUT IT IN PARK, AND TURN THE KEY TO THE OFF POSITION BEFORE CAR CAN BE RESTARTED. PROBLEM BEGAN WITH LESS THAN 500 MILES ON THE CAR. IN THE THREE MONTHS I'VE OWNED THE CAR IT HAS STALLED AT LEAST 20 TIMES. HAVE HAD IT TO TWO DIFFERENT FORD SERVICE CENTERS A COMBINED TOTAL OF FIVE TIMES AND NO ONE HAS BEEN ABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE CAR IS STILL AT THE DEALERSHIP WHILE THEY WAIT FOR A SPECIAL FORD TECHNICIAN TO COME AND TRY AND DETERMINE WHAT IS WRONG. *AK
Engine and engine cooling, Feb 10, 2004, fire
PURCHASED 2003 FORD FOCUS IN SEPTEMBER, 2003. THERE WAS NOT EVEN 3,000 MILES ON THIS CAR. MY HUSBAND DROVE IT 2 BLOCKS TO THE STORE ON SATURDAY, FEBRUARY 7, 2004, WENT INTO THE STORE TO GET ONE ITEM AND ONLY IN THE STORE 5 MINUTES, CAME OUT AND MY CAR WAS ON FIRE UNDER THE HOOD OF THE CAR.*AK
Engine and engine cooling, Jan 15, 2004
WHILE DRIVING THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A MECHANIC. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
Engine and engine cooling, Dec 26, 2003
ENGINE CUTS OUT WHILE DRIVING FOR NO APPARENT REASONS AND WITH NO WARNING. *AK
Engine and engine cooling, Nov 18, 2003, fire
WHILE DRIVING AT 35 MPH AND WITH NO WARNING VEHICLE CAUGHT ON FIRE, HEAVY BLACK SMOKE AND FLAMES CAME FROM UNDER THE HOOD. THE DEALER WAS NOTIFIED. *AK NO WARNING LIGHT ILLUMINATED TO INDICATE THERE WAS ANY KIND OF PROBLEM. *NLM
Engine and engine cooling, Sep 24, 2003
WHILE TRAVELING AT HIGHWAY SPEED VEHICLE SHUT DOWN. VEHICLE WAS TOWED TO FORD. *AK
Engine and engine cooling, Sep 23, 2003
PROBLEMS WITH WATER IN VEHICLE'S ENGINE.*MR CONSUMER DROVE OVER A PUDDLE AND VEHICLE WAS SPLASHED ON BY ANOTHER VEHICLE IN THE OPPOSITE LANE. APPROX. 50 FEET FROM A TRAFFIC LIGHT, THE VEHICLE CUT OFF AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE THE VEHICLE WAS PURCHASED. THE NEXT MORNING SOMEONE FROM THE SERVICE DEPT. STATED THE ENGINE WAS FLOODED AND NEEDED TO BE REPLACED AT $5000. THIS WASN'T COVERED BY THE WARRANTY. THE DEALER WOULDN'T OFFER A RENTAL VEHICLE SO THE CONSUMER FELT HE HAD NO CHOICE BUT TO HAVE THE WORK DONE. AN INDEPENDENT COURT CERTIFIED AUTO EXPERT STATED IN HIS OPINION THERE WAS A DESIGN DEFECT. THE VEHICLE WAS INCAPABLE OF BEING DRIVEN THROUGH PUDDLES DUE TO LOW AIR INTAKE. *PH *JB THE CONSUMER REQUESTED REIMBURSEMENT. *SC
Engine and engine cooling, Aug 29, 2003
FOIA REQUEST CYS OF ALL CORRESPONDENCE BETWEEN NHTSA & INTERNATIONAL ENGINE GROUP RE THE 6.0 POWERSTROKE ENGINE USED IN THE 2003 FORD F250-F550 SUPER DUTY TRUCKS & THE 2003 FORD EXCURSION. *MR *NLM *JB
Engine and engine cooling, Aug 21, 2003
MY 2000 FORD FOCUS WITH 70080 MILES SUFFERED ENGINE FAILUE WHILE AT HIGHWAY SPEED. THE ENGINE WILL NOT REMAIN RUNNING UNLESS THE ACCELLERATOR PEDAL IS HELD OFF OF IDLE. THE ENGINE WILL NOT CRANK AND STAY AT IDLE WITHOUT OPERATOR INTERVENTION. *AK THE UNIT HAS BEEN REMOVED FROM SERVICE PENDING REPAIR. THERE IS A RUMBLING SOUND FROM THE RIGHT FRONT OF THE VEHICLE AND THE STEERING WHEEL SHAKES (+-0.5" AT 3 HERTZ) WHEN AT 55MPH AND ABOVE.
Engine and engine cooling, Jul 23, 2003
WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD. *AK
Engine and engine cooling, Jul 22, 2003
WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING VEHICLE SHUT DOWN. *AK
Engine and engine cooling, Jun 30, 2003
VEHICLE REPEATEDLY STALLS OR RUNS COARSE WHEN COLD. VEHICLE MISSES REPEATEDLY. THIS HAS NOW OCCURED 7 TIMES IN TWO WEEKS.*AK
Engine and engine cooling, Fuel system, Gasoline, Jun 26, 2003
2003 FORD FOCUS SVT. (850 MILES) CAR HAS A HIGH SPEED SURGE AND A BAD MISS OFF THE LINE. NO MATTER HOW MUCH YOU PLAY WITH THE CLUTCH PEDAL AND THE GAS THE CAR ALWAYS FALLS ON ITS FACE THEN PICKS BACK UP.(REALY BAD WHEN ITS COLD) ITS BEEN AT THE DEALERSHIP 3 TIMES. THE 1ST TIME THEY SAID IT WAS A PINCHED FUEL LINE AND THE GAS TANK HAD TO BE DROPED. 2ND TIME WAS THE SAME A PINCHED FUEL LINE. AND NOW THE 3RD TIME THEIR TELLING ME THAT IM NOT THE ONLY ONE WITH THE PROBLEM AND JUST WAIT TILL FORD FIGURES IT OUT. IM PRETTY SURE IT HAD NOTHING TO DO WITH THE FUEL LINE.(WHO KNOW HOW LONG I WILL HAVE TO DEAL WITH FORD ON THIS MATTER). *AK
Engine and engine cooling, Feb 28, 2003
WHILE DRIVING HOME FROM A DOCTOR'S APPOINTMENT MY 2003 FORD FOCUS STALLED AND WOULD NOT RESTART. AFTER 3 TRIES THE CAR FINALLY RESTARTED AND I DROVE IT TO THE DEALERSHIP TO HAVE IT REPAIRED. THEY SAID THE MASS AIR FLOW SYSTEM WAS BAD AND WOULD HAVE TO BE REPLACED. THE CAR ONLY HAS 1500 MILES ON IT AND IS LESS THAN 2 MONTHS OLD. *JB
Engine and engine cooling, Feb 20, 2003
THE VEHICLE STALLED, WHICH CAUSED CONSUMER TO LOSE SLIGHT CONTROL OF THE VEHICLE.*JB