2003 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,017 owner complaints filed for this model year. This is the 8th highest complaint count among 19 Focus model years with reports.
Of the 2003 reports, 53 involved a crash and 19 involved a fire. 52 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints: power train
57 reports, newest first. Show all
Power train, Nov 6, 2003
2003 SVT FORD FOCUS: FLYWHEEL, PRESSURE PLATE, CLUTCH ASSEMBLY FAILURE. MULTIPLE CASES HAVE BEEN SUBMITTED TO DEALERS. VEHICLE HAS BEEN IN SHOP FOR 15 BUSINESS DAYS WITH NO END IN SIGHT. I HAVE ALSO HEARD OF BELLHOUSING CRACKING HOWEVER I'M NOT SURE IF THIS WAS A CASE WITH MY CAR, NO INFORMATION ABOUT THAT FROM DEALER.*AK
Power train, Sep 12, 2003
REPLACED THE AXLE AND TRANSMISSION AND WAS PICKED UP ON 8/26/03. IT HAD EXACTLY 725 MILES. ON 9/5/03 IT BROKE DOWN AGAIN WITH THE TRANSMISSION GETTING STUCK IN A FORWARD GEAR. IT HAD EXACTLY 1024 MILES. REMAINS IN THE SHOP TO THIS DAY. 9/12/03. *PH
Power train, Sep 12, 2003
I BOUGHT A 2003 FORD FOCUS LX ON 7/23/03. IT BROKE DOWN ON 8/18/03 IN SPRINGGOLD, GA. WITH A BROKEN AXLE AND A BROKEN TRANSMISSION. SALE FORD REPLACED THE AXLE AND TRANSMISSION AND WAS PICKED UP ON 8/26/03. IT HAD EXACTLY 725 MILES. ON 9/5/03 IT BROKE DOWN AGAIN WITH THE TRANSMISSION GETTING STUCK IN A FORWARD GEAR. IT HAD EXACTLY 1024 MILES. REMAINS IN THE SHOP TO THIS DAY. 9/12/03. *PH
Power train, Exterior lighting, Latches/locks/linkages, Jul 3, 2003
WHILE DRIVING THE VEHICLE STALLED. THE CONSUMER RESTARTED THE VEHICLE BUT SOON AFTER THE VEHICLE STALLED AGAIN. AFTER DOING THIS FOR THE FOURTH TIME THE VEHICLE WAS TOWED TO THE DEALERSHIP. IT WAS DETERMINED THAT THE PCM FAILED. THE LEFT BRAKE LIGHT BULB BURNED OUT. THE POWER DOOR LOCKS WERE INOPERATIVE. *NLM *CB *NLM
Power train, Apr 30, 2003
TRANSMISSION SUDDENLY DROPS DOWN ONE OR TWO GEARS, CRUISE CONTROL KICKS OFF, TRANSMISSION TROUBLE LIGHT IN DASH COMES ON, THEN GOES AWAY, DEALER CHECKED ON 04/28/03 AND FOUND NO CAUSE CODE, DEALER PERFORMED FLUID PUMP CHECK AND TESTED OK, TRANSMISSION DID THE SAME THING AGAIN ON 04/29/03. *JB
Service brakes, Hydraulic, Power train, Apr 28, 2003
WHEN THE CAR IS PUT INTO REVERSE IT DOES NOT WANT TO MOVE. IF YOU INCREASE THE RPM'S, IT STILL JUST SETS THERE. THE PROBLEM HAS BEEN VERY INCONSISTENT. REVERSE SEEMS TO BE AT THIS POINT, THE ONLY PLACE IT OCCURS. IN ONE OF THE ATTEMPTS TO FIX THE PROBLEM, THE TECHNICIAN FOUND THAT 3 OF THE 4 CALIPERS WERE FROZE/DRIED UP. THIS DOES NOT SET WELL WITH ME AND I SEE IT AS A POSSIBLY DANGEROUS SITUATION. *NLM
Power train, Apr 25, 2003
THE TRANSMISSION MADE A "SHUTTERING AND FLIPPING" SOUND WHILE IN REVERSE. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE TRANSMISSION WAS REPLACED, HOWEVER THE VEHICLE CONTINUED TO EXPERIENCE THE SAME PROBLEM. *JB