2003 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,017 owner complaints filed for this model year. This is the 8th highest complaint count among 19 Focus model years with reports.
Of the 2003 reports, 53 involved a crash and 19 involved a fire. 52 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints
1,017 reports, newest first.
Electrical system, Mar 19, 2007
2003 FORD FOCUS - AN APPARENT "KNOWN DEFECT" YET STILL NOT A RECALL OR REIMBURSABLE EXPENSE TO FIX. WE ARE UNABLE TO START THE CAR. THE KEY GOES INTO THE IGNITION, BUT WON'T TURN THE SWITCH... FORD'S FIX IS TO REPLACE THE CYLINDER AT OVER $300.00 AND A NEW SECURITY KEY AT $150.00.
Electrical system, Equipment, Mar 17, 2007
THE KEY STUCK IN THE IGNITION SWITCH ON MY 2003 FOCUS PZEV. WHEN IT FINALLY RELEASED IT WOULD NO LONGER TURN. I HAD THE VEIHICLE TOWED BY AAA AND HAD A AAA LOCKSMITH COME TO REPAIR THE IGNITION WHICH I WAS TOLD IS NOT COVERED UNDER MY WARRENTY, AT A COST OF $300. THE LOCKSMITH SAID IT IS A COMMON PROBLEM ON THE FOCUS. ONE MONTH LATER THE LOCKSMITH HAD TO COME BACK OUT TO REPAIR IT AGAIN. A YEAR LATER I MUST TURN THE KEY BACK A NOTCH TO REMOVE IT FROM THE IGNITION. IT WILL COST ME ANOTHER $300 TO HAVE THE REPAIR REPEATED. THE LOCKSMITH SAYS THAT THE PROBLEM IS WITH THE PART ITSELF AND WILL CONTINUE TO HAPPEN.
Power train, Mar 10, 2007, fire
MY DAUGHTER DRIVES A 2003 FORD FOCUS SVT. ON FEBRUARY 28, 2007 SHE WAS RETURNING TO EASTON, PA FROM STATE COLLEGE, PA WHEN THE TRANSMISSION DESTROYED ITSELF RESULTING IN A CATASTROPHIC FAILURE OF THE GEARBOX, FLYWHEEL,BELL HOUSING AND PRESSURE PLATE. THIS TOOK PLACE ON I-80 . I FEEL YOU SHOULD BE INFORMED DUE TO THE AMOUNT OF DAMAGE AND SEVERITY OF THE EXPLOSION. A FIRE DID RESULT FROM THE FAILURE/EXPLOSION. I HAVE CONTACTED FORD (STATE COLLEGE FORD) AND THEIR ESP REPRESENTATIVE HAS CLAIMED THE DO NOT COVER PRESSURE PLATE FAILURE PAST 12,000 MILES AND HAVE DECLINED TO ADMIT THIS IS A SERIOUS SITUATION. *JB
Electrical system, Mar 2, 2007
I'VE HAD MY 2003 FORD FOCUS WAGON IN TWICE FOR REPAIR OF THE IGNITION LOCK. THE FIRST TIME I HAD THE PROBLEM THE STEERING WHEEL WOULDN'T RELEASE AS THE KEY WOULDN'T FIT INTO THE IGNITION. TOOK IT TO THE DEALER AND THEY REMOVED THE LOCK CYLINDER. IT WAS CLEANED AND LUBED AND OPERATING NORMALLY ON 26 JANUARY 2007. ABOUT A MONTH LATER I WAS HAVING THE SAME PROBLEM. THIS TIME I HAD TO HAVE IT TOWED TO THE DEALER. THIS CAR ONLY HAS 13,000 MILES ON IT! THEY HAD TO DRILL OUT THE IGNITION LOCK CYLINDER AND REPLACE IT. I HOPE THIS TIME IT WILL LAST LONGER THAN A MONTH! THIS WAS A VERY COSTLY SERVICE! $267.00 FOR LABOR AND $99.91 FOR THE PART! I HAVEN'T SEEN ANY RECALLS ON THIS YET BUT IF THEY DO HAVE ONE I'M HOPING TO GET MY MONEY BACK AS THIS HAS BEEN A VERY COSTLY SERVICE TO ME - ALMOST $600.00 TOTAL FOR BOTH INSTANCES! *JB
Electrical system, Mar 1, 2007
TL*- THE CONTACT STATED THAT WHEN DRIVING THE 2003 FORD FOCUS THE VEHICLE SHIFTED INTO NEUTRAL, THEN SHIFTED BACK INTO DRIVE. THIS WOULD LAST ANYWHERE FROM A FEW SECONDS TO A COUPLE OF MINUTES. THE CONTACT STATED THAT THE DASHBOARD LIGHTS AND RADIO WOULD FLICKER ON AND OFF, AS WELL AS THE LIGHTING SYSTEM, INCLUDING THE HEADLIGHTS. THE CONTACT STATED THAT THE DOORS WILL ALSO LOCK AND SHE WASUNABLE TO EXIT THE VEHICLE. WHEN THIS HAPPENED SHE ATTEMPTED TO GET OUT OF THE VEHICLE BY MANUALLY HITTING THE UNLOCK SWITCH. THE VEHICLE LOCKS FINALLY OPENED AFTER APPROXIMATELY TWENTY MINUTES. THE MECHANIC ADVISED THE CONTACT TO HAVE ELECTRICAL SYSTEM REPROGRAMMED, WHICH WAS DONE IN NOVEMBER 2006, BUT SHE CONTINUED TO HAVE THE SAME PROBLEMS. THE VEHICLE STALLED WHEN EXITING THE INTERSTATE WHILE DRIVING AT 45 MPH. THERE WERE NO WARNING LIGHTS BEFORE THE VEHICLE LOST POWER. THE CONTACT WAS UNABLE TO RESTART VEHICLE, AND HAD VEHICLE TOWED TO A MECHANIC. THE MECHANIC INFORMED CONTACT HE DID NOT KNOW WHY THE VEHICLE LOST POWER. THE VEHICLE CURRENTLY HAD 57000 MILES. *AK UPDATED 03/30/07. *JB
Suspension, Feb 27, 2007
I WAS TURNING ON TO MY STREET WHEN I HEARD AVERY LOUD BANG AND MY CAR STOPPED IMMEDIATELY. AS I SAT THERE IN SHOCK IT APPEARED THAT MY CAR WAS TILTED DOWN ON THE LEFT SIDE. I GOT OUT OF MY CAR AND SURE ENOUGH IT WAS LEANING. THE BODY OF MY CAR WAS RESTING ON THE TOP OF THE TIRE. SINCE I COULDN'T DRIVE IT I CALLED A TOW TRUCK AND HAD IT TOWED TO A GARAGE TO BE LOOKED AT. AFTER MY CAR WAS INSPECTED FOR THE REASON FOR THE BANG I WAS TOLD THAT THE FRONT COIL SPRING WAS BROKEN IN TWO PLACES. ALSO, THE SWAY BAR WAS BROKEN AND THE FRONT STRUT MOUNT AND BEARING WERE BROKEN. WHAT COULD I DO BUT HAVE THE REPAIRS MADE. I HAD TWO NEW FRONT COIL SPRINGS PUT ON (I WASN'T TAKING ANY CHANCES WITH THE OTHER SPRING), A NEW SWAY BAR, A NEW STRUT MOUNT AND BEARING PUT ON AT A COST OF $444.64. I HAD JUST COME OFF OF THE HIGHWAY WHERE THE SPEED LIMIT IS 65 MPH. IF THE SPRING WOULD HAVE BROKEN THERE, I SHUDDER TO THINK WHAT THE OUTCOME WOULD HAVE BEEN. I STILL HAVE THE BROKEN SPRING. IT STILL HAS THE PROTECTIVE COATING ON IT. SO CORROSION COULD NOT HAVE BEEN A FACTOR. *NM
Electrical system, Feb 18, 2007
I HAVE OWNED 3 FORD FOCUS: ONE 2000 AND TWO 2003. ALL THREE VEHICLES HAVE HAD AN IGNITION CYLINDER FAILURE WHICH COST IN EXCESS OF $300 EACH TIME. THE KEY WILL NOT TURN IN THE IGNITION AND THIS HAPPENS WITHOUT WARNING. ON THREE OCCASIONS I HAVE BEEN STRANDED AND HAD TO CALL AAA TO GET BE TO A GARAGE FOR REPAIR. I HAVE CITED ONLY THE MOST RECENT INCIDENT IN THIS COMPLAINT. THIS IS A KNOWN PROBLEM AND I FAIL TO SEE WHY A RECALL WAS NEVER ISSUED. FORD SHOULD BE HELD ACCOUNTABLE. *NM
Electrical system, Jan 31, 2007
I HAVE A 2003 FORD FOCUS. THE FAULT IS THAT WHEN I PUT THE KEY IN THE IGNITION, THE KEY WILL NOT TURN AT ALL. IT IS LOCKED IN PLACE. IT HAPPENED ONCE THIS SUMMER ON THIS CAR AND ON A 2002 FOCUS I SOLD TO A FRIEND WHOM WORKS WITH ME. I CALLED THE FORD DEALERSHIP TO SEE IF THEY HAVE SEEN THIS PROBLEM, WHICH THEY HAD. THEY TOLD ME I COULD TAP IT WITH A RUBBER HAMMER TO GET IT TO UNLOCK. SURE THING, IT DID. I CHECKED FOR RECALLS, WHICH NONE WERE FOUND. I CHECKED FOR TSB'S, SURE ENOUGH, THERE ARE NUMEROUS REPORTS OF THIS PROBLEM. THIS APPEARD TO BE A MAJOR DEFECT. I BELIEVE THIS COULD BE A SERIOUS SAFETY PROBLEM IF FOR INSTANCE SOMEONE WENT FOR A DRIVE DURING THE WINTER IN THE REMOTE MOUNTAINS AND STOPED TO GOT FOR A WALK. UPON RETURN, THE DEFECTIVE IGNITION WOULDN'T WORK AND THEY'RE STRANDED. FORD DIDN'T APPEAR TO WANT TO LISTEN TO MY COMPLAINTS. LOOK AT THE TSB'S AND YOU'LL REALLY GET A GOOD PICTURE OF THE VOLUME OF IGNATION PROBLEMS.
Electrical system, Jan 23, 2007
MY KEY STOPPED WORKING, OR WOULD ONLY WORK INTERMITTENTLY FOR THE PAST MONTH. I STARTED CARRYING MY SPARE KEY AT ALL TIMES SO I WOULDN'T GET STRANDED. I FINALLY HAD A 2ND KEY MADE ($125 AT DEALERSHIP). THE NEW KEY FAILED TO WORK LATER THE SAME DAY. MORE INTERMITTENT IGNITION PROBLEMS FOR NEXT 2 WEEKS. THIS PAST SATURDAY BOTH KEYS FAILED. WHEN I COULD FINALLY GET THE CAR TO START I CAME HOME AND STARTED RESEARCHING ON WEB. FOUND THIS IS A WIDESPREAD WELL-KNOWN PROBLEM. HAVE APPT. AT DEALERSHIP TOMORROW FOR TOTAL IGNITION REPLACEMENT, MY TIME, MY DIME. IT WILL BE A FEW HUNDRED DOLLARS. I ALREADY WORK A FULL TIME AND PART-TIME JOB TO MAKE ENDS MEET. I CANNOT AFFORD THIS. I CAN'T AFFORD TO BE STRANDED SOMEPLACE IN THE MIDDLE OF THE NIGHT, EITHER. FORD DAMNED WELL KNOWS ABOUT THIS, AND JUST IGNORES THEIR CUSTOMERS. THIS IS THE 5TH FORD I'VE OWNED IN 20 YEARS. IT WILL BE MY LAST. *JB
Electrical system, Jan 15, 2007
KEY WILL NOT TURN INSIDE THE IGNITION. THIS HAPPENED SEVERAL WEEKS AGO AS WELL, BUT I WAS ABLE TO JIGGLE IT LOOSE. THIS TIME IT IS STUCK AND 40 MINUTES OF JIGGLING, WD40, AND FRUSTRATION DID NOT WORK. I AM STILL WORKING ON WHAT TO DO ABOUT IT. *NM
Electrical system, Jan 12, 2007
THE KEY INSERTION CYLINDER (LOCATED NEXT TO THE STEERING WHEEL): IT WILL EVENTUALLY LOCK INTO PLACE AND WILL NOT TURN -- MAKING IT IMPOSSIBLE TO TURN THE KEY AND DRIVE. THE SAFETY HAZARD: WHEN MY 2003 FORD FOCUS LOST POWER AND NEEDED TO BE RESTARTED ON THE ROAD, THE KEY INSERTION CYLINDER LOCKS INTO PLACE, MAKING IT DANGEROUS TO TURN THE WHEEL -- BECAUSE THE STEERING WHEEL LOCKS WHEN THE KEY CYLINDER IS IN THE "KEY INSERT/BEGIN" POSITION. THERE ARE SEVERAL HORROR STORIES, ON THE INTERNET, ABOUT FORD FOCUS VEHICLE OWNERS WHO HAVE BEEN STRANDED BECAUSE OF A FAULTY KEY IGNITION CYLINDER; OR THEIR CAR WILL NOT TURN OFF BECAUSE THEIR KEY IS STUCK IN THE START POSITION. FORD DEALERSHIPS WILL ONLY COVER THIS ITEM IF IT WARRANTED, BUT NEGLECT THE PRODUCT DESIGN AND REFUSE TO CONSIDER A PRODUCT RECALL. THIS TYPICAL ITEM COST OVER $250 WITH LABOR. EVENTUALLY, EVEN WITH A NEW KEY CYLINDER, THE PROBLEM WILL START TO EXIST AGAIN, COSTING THE CONSUMER AND CREATING A SERIOUS HAZARD FOR OUR CITIZENS ON AMERICAN ROADWAYS. THE PROBLEM IS CURRENT IN MY VEHICLE AND I AM AUTHORIZING THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION TO USE MY VEHICLE AS AN INVESTIGATIVE TOOL. *JB
Electrical system, Jan 11, 2007
FORD FOCUS 2003 FOR SEVERAL OCCASIONS THE IGNITION LOCK KEY CYLINDER HAD NOT WORKED, I WAS NOT ABLE TO TURN THE KEY AND GET THE CAR TO START. CONSEQUENCES, FIRST I WAS NOT ABLE TO TAKE MY CHILD TO THE EMERGENCY ROOM UNTIL ANOTHER VEHICLE ARRIVED, ANOTHER CONSEQUENCE, I WAS LATE TO WORK, THEN IT WAS IN THE MIDDLE OF THE NIGHT ON A DANGEROUS AREA OF TOWN, RISKING MY LIFE. FINALLY IT GOT STUCK AT THE AIRPORT AND HAD TO CALL A TOW TRUCK. *JB
Electrical system, Jan 8, 2007
FORD FOCUS 2003: THE IGNITION MECHANISM STOPPED WORKING WITH NO WARNING. THE KEY COULD NOT BE FULLY INSERTED INTO THE IGNITION OR TURNED. SUBSEQUENTLY, THE CAR COULD NOT BE STARTED. AT FIRST, THE KEY COULD BE TAPPED INTO THE IGNITION, BUT THAT ONLY WORKED A FEW TIMES. EVENTUALLY I HAD TO HAVE THE WHOLE TUMBLER MECHANISMS REPLACED IN THE IGNITION. *NM
Electrical system, Jan 5, 2007
MY CAR IS ONLY THREE AND A HALF YEARS OLD AND FOR THE LAST 8 TO 10 MONTHS I HAVE BEEN HAVING PROBLEMS WITH THE IGNITION SWITCH. IF I TURN THE CAR OFF IT IS VERY, VERY HARD TO GET THE KEY TO TURN OVER. I TOOK IT TO A LOCKSMITH WHO SAID THAT THEY HAVE BEEN GETTING A LOT OF PEOPLE WHO OWN FORD AND MERCURY VEHICLES COMING IN WITH THE SAME KIND OF PROBLEMS. THEY ALSO SAID THAT FORD HAS REDESIGNED THEIR SWITCHES SEVERAL TIMES AND STILL COME UP WITH THE SAME PROBLEMS THAT I AM EXPERIENCING. I WAS WONDERING WHY NO KIND OF RECALL HAS BEEN ISSUED. *JB
Visibility, Jan 4, 2007
NHTSA PREVIOUS REPORT 01V258000 (RECALL ID 01D-258) FOR FORD FOCUS WINDSHIELD WIPER MOTOR PROBLEMS - 2001/2002 VEHICLES. I HAVE A 2003 FORD FOCUS WITH IDENTICAL PROBLEMS, WIPER DOES NOT STOW - AS THERE ARE OTHER REPORTED VEHICLES - WILL NHTSA DIRECT FORD TO "RECALL" OR FIX LATER MODEL YEAR FOR THIS SAME ISSUE? THE VIRGINIA SAFETY INSPECTION FAILED MY CAR FOR THIS ISSUE - STATED FORD WOULD FIX, FORD DEALER HAS NO REQUIREMENT, AS THIS IS NOT A "RECALLED YEAR". *JB
Electrical system, Jan 1, 2007
THE IGNITION LOCK FREEZES AND WILL NOT TURN, WHICH DOES NOT ALLOW THE CAR TO START. THIS PROBLEM HAS HAPPENED ON NUMEROUS OCCASIONS. THE CONSEQUENCES HAVE INCLUDED LOSS OF VEHICLE USE, TOWING EXPENSES, AND UNWANTED STRESS. *NM
Electrical system, Dec 29, 2006
THE IGNITION STARTED LOCKING SEVERAL MONTHS AGO, BUT EVENTUALLY WOULD WORK AFTER PLAYING WITH THE KEY TO START. TODAY, WHILE OUT AT A SHOPPING CENTER, IT LOCKED UP COMPLETELY, CAUSING ME TO HAVE TO TOW THE CAR TO THE DEALER. THIS CAR IS A 2003 WITH ONLY 13000 MILES ON IT.
Electrical system, Dec 25, 2006
IGNITION LOCK OF FORD FOCUS 2003 BROKE AND WE WERE UNABLE TO MOVE THE CAR AWAY FROM A DRIVEWAY THAT WAS BLOCKED SINCE IT WAS NOT POSSIBLE TO TURN THE IGNITION KEY. ONE MECHANIC WAS PAID TO TRY TO START THE CAR BUT HE WAS NOT SUCCESSFUL (BUT HE WAS STILL PAID). EVENTUALLY, WE LEARNED FROM THE WWW THAT THIS WAS A WIDE-SPREAD PROBLEM. A LOCKSMITH WAS CALLED WHO REPLACED THE LOCK AND WAS PAID. IN ADDITION TO THE FINANCIAL EXPENSE, TRANSPORTATION TO AND FROM THE LOCATION OF THE CAR AND THE TIME SPENT WERE SIGNIFICANT COSTS. *NM
Visibility, Dec 21, 2006
THE WIPERS ON THIS CAR DO THE EXACT SAME THING MY 2000 FORD FOCUS DID THAT HAD A RECALL THEY DON NOT WANT TO RETURN TO THE HOME POSITION. *NM
Electrical system, Dec 18, 2006
IGNITION CYLINDER LOCKS WHEN TURNING THE KEY ON A 2003 FORD FOCUS ZX3. THE CAR CANNOT BE STARTED MOST OF THE TIME. THIS IS DANGEROUS IF THE CAR STALLS. *NM
Electrical system, Latches/locks/linkages, Dec 18, 2006
DT*: THE CONTACT STATED WHILE PARKED, THE STEERING WHEEL WOULD NOT UNLOCK. THE VEHICLE WAS TOWED TO THE DEALER WHO DETERMINED THE IGNITION CYLINDER NEEDED TO BE REPLACED. ALSO, THE TRUNK WOULD NOT CLOSE. THE DEALER WAS NOT CONTACTED.
Engine and engine cooling, Dec 15, 2006
DT*: THE CONTACT STATED WHEN THE VEHICLE WAS ACCELERATED TO 35 MPH; THE EGR TUBE CAME LOOSE FROM THE MANIFOLD FOR THE SECOND TIME, MADE A LOUD NOISE, AND ALLOWED ESCAPING EXHAUST FUMES TO ENTER THE PASSENGER COMPARTMENT. THE SERVICE DEALER AND THE MANUFACTURER WERE NOTIFIED. UPDATED 01/30/07. *JB
Electrical system, Dec 11, 2006
I HAVE OWNED 2 FORD FOCUSES, A 2000 AND NOW A 2003 MODEL. BOTH VEHICLES HAVE HAD THE IGNITION LOCK UP AND I WAS CHARGED $400 TO FIX IT. OBVIOUSLY, FORD MOTOR COMPANY IS COMFORTABLE ENOUGH WITH THIS DESIGN FLAW THAT THERE HAVE BEEN NO RECALLS, AND THE CONSUMER IS LEFT HOLDING THE BILL. THERE ARE OVER 400 COMPLAINTS ABOUT THIS LOGGED ON THE FOLLOWING WEBSITE: HTTP://FORUMS.FOCALJET.COM/PROBLEMS-SERVICE-RECALLS/416401-PLEASE-POST-IF-YOUR-IGNITION-HAS-LOCKED.HTML WHAT DOES IT TAKE TO GET THIS COMPANY TO ADMIT THEY ARE PUTTING OUT A FAULTY PRODUCT? *JB
Electrical system, Dec 11, 2006
DT*: THE CONTACT STATED THE IGNITION SWITCH JAMMED AND THE SWITCH WOULD NOT TURN. THE SERVICE DEALER AND MANUFACTURER WERE NOT CONTACTED.
Electrical system, Dec 5, 2006
SECOND OCCURRENCE OF KEY BEING PUT IN IGNITION, STEERING WHEEL LOCKING UP AND INABILITY TO START CAR. VEHICLE HAD TO BE TOWED TO DEALERSHIP AND REPAIRED. FIRST TIME (11/2004) UNDER WARRANTY, SECOND TIME(12/5/06) CHARGED $300, REDUCED TO $80 UNDER PROTEST FOR A KNOWN PROBLEM. NO WONDER FORD IS GOING UNDER! *JB