2012 Ford Focus
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,801 owner complaints filed for this model year. This is the highest complaint count among 19 Focus model years with reports.
Of the 2012 reports, 108 involved a crash and 15 involved a fire. 88 people were injured and 5 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, evaporative emissions, canisterJun 9, 2026
Ford Motor Company (Ford) is recalling certain 2012-2018 Focus vehicles previously repaired incorrectly under recall number 18V735. The Canister Purge Valve (CPV) may malfunction, causing the engine to stall unexpectedly while driving.
An engine that stalls while driving increases the risk of a crash.
Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed July 29, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S40. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.
Campaign 26V369000 on NHTSA.gov
Latches/locks/linkages, doors, latchJun 8, 2020
Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Ford will notify owners, and dealers will inspect the latch date codes to confirm if the repair was done correctly, and replace the side door latches if necessary, free of charge. Owners will also have the option to inspect their own vehicle's door latches and enter the date codes into a website to determine if the latches are correct. Owner notification letters were mailed on July 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S30.
Campaign 20V331000 on NHTSA.gov
Fuel system, gasoline, storageJul 5, 2019
Ford Motor Company (Ford) is recalling certain 2012 and 2017 Focus vehicles equipped with 2.0L GDI gasoline engines and 2013-2014 Focus ST vehicles equipped with 2.0L GTDI engines, previously recalled under 18V-735. The affected vehicles did not have the Powertrain Control Module (PCM) updated as intended. Therefore, the Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in the fuel vapor management system.
The excessive vacuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S22.
Campaign 19V515000 on NHTSA.gov
Fuel system, gasoline, storageOct 22, 2018
Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.
The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began August 19, 2019. Owners may contact Ford Customer service at 1-866-436-7332. Ford's number for this recall is 18S32. Note: Until the vehicle is serviced for this concern, owners are advised to keep the fuel tank at least halfway full.
Campaign 18V735000 on NHTSA.gov
Latches/locks/linkages, doors, latchSep 6, 2016
Ford Motor Company (Ford) is recalling certain model year 2012-2015 Ford Focus, 2013-2015 Ford Escape and Ford C-MAX, 2015 Lincoln MKC and Ford Mustang, and 2014-2016 Ford Transit Connect vehicles. A component within the door latches may break, preventing the doors from latching and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Ford will notify owners, and dealers will replace the door latches with an improved part, free of charge. The recall began on January 27, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S30.
Campaign 16V643000 on NHTSA.gov
Exterior lightingAug 1, 2013
Ford is recalling certain model year 2012-2013 Focus BEV vehicles equipped with High Intensity Discharge (HID) headlights, manufactured September 15, 2011, through May 6, 2013; and model year 2013 Focus ST vehicles equipped with High Intensity Discharge (HID) headlights, manufactured February 16, 2012, through May 7, 2013. Due to a wiring incompatability, the front side marker lamps may not function. Thus, these vehicles fail to comply to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Without the proper illumination of the side maker lamps, the vehicle may be less visible in night time conditions, increasing the risk of a crash.
Ford will notify owners, and dealers will modify the headlamp assembly wiring, free of charge. The recall began on August 16, 2013. Owners may contact the Ford customer relationship center at 1-866-436-7332. Ford's recall number is 13C04.
Campaign 13V335000 on NHTSA.gov
EquipmentOct 2, 2012
This recall involves aftermarket parts sold by Yakima Products, Inc. for use on model year 2012 and 2013 Ford Focus vehicles. This recall is being conducted by Yakima, not by Ford. Certain combined Q-Tower and Q128 Clip rooftop rack systems, part numbers 8000124 and 8000728, do not fully contact the door frame.
Without proper contact of the rooftop rack clip to the door frame, there is insufficient clamping pressure and friction. The system may slide off the vehicle when loaded with accessories, possibly becoming a road hazard to other vehicles or causing injury to pedestrians.
Yakima will notify owners, and Yakima or a Yakima dealer will refund the purchase of the Q-Tower and Q-128 Clip system. There is no replacement system available for the 2012-2013 model year Ford Focus. The safety recall began on October 15, 2012. Only vehicles equipped with the vehicle rack system are affected. This recall is being conducted by Yakima, not Ford. Owners may contact Yakima at 1-888-925-4621.
Campaign 12E035000 on NHTSA.gov
Visibility, windshield wiper/washer, switch/wiringApr 5, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2012 FOCUS VEHICLES MANUFACTURED FROM AUGUST 1, 2010, THROUGH OCTOBER 18, 2011. A SEAL IN THE WIRING HARNESS CONNECTOR TO THE PASSENGER SIDE WIPER MOTOR MAY BE MISSING.
WATER OR OTHER CONTAMINANTS MAY ACCUMULATE IN THE CONNECTOR, RESULTING IN AN INTERMITTENT OR INOPERATIVE PASSENGER SIDE WIPER MOTOR, REDUCING VISIBILITY AND INCREASING THE RISK OF A CRASH.
FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND AS NECESSARY, CLEAN AND PROPERLY SEAL THE PASSENGER SIDE WIPER MOTOR CONNECTOR. ANY INOPERATIVE WIPER MOTORS WILL BE REPLACED. THIS SERVICE WILL BE PROVIDED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 21, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 12V149000 on NHTSA.gov
Representative owner complaints: engine
504 reports, newest first. Show all
Engine, Sep 1, 2026
I am submitting this complaint because Ford dealers do not appear to be following Ford Motor Company's published procedure for Customer Satisfaction Program 24N07. I visited two Ford service departments in [XXX] and [XXX]. Both told me they must first perform their own diagnostic evaluation before replacing the canister purge valve (CPV) under 24N07, and that I may be responsible for a diagnostic fee if they do not confirm the issue. Both dealers justified this requirement by stating that it was mandated by Ford corporate. This appears inconsistent with Ford's XXX communication to all U.S. Ford and Lincoln dealers. The 24N07 Technical Instructions already provide a decision process: Step 1 directs technicians to check for specified DTCs, including P0443, OR determine whether the customer reports hesitation, rough idle, or loss of power. Step 2 asks whether any Step 1 condition is present. If yes, Step 3 directs the technician to replace the CPV. (PAGE 16) Nowhere in this procedure does Ford require a separate comprehensive EVAP diagnosis before replacement. Ford's labor operation also includes checking for DTCs as part of the 24N07 service. (PAGE 16) This is especially concerning because CPV-related symptoms can be intermittent. A vehicle may have rough idle, hesitation, loss of power, or a qualifying DTC, but operate normally during the dealer's diagnostic session. Under the dealers' approach, the owner may then be charged a diagnostic fee and still be denied the 24N07 repair. Similar experiences have been reported by other Focus owners online, including diagnostic-fee warnings of approximately $199, $210, $225, and $400. I ask NHTSA to review whether Ford dealers are properly implementing 24N07 and whether dealers are adding diagnostic requirements not contained in Ford's December 4, 2024 instructions. Ford 24N07: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Fuel system, Gasoline, Engine, Aug 11, 2026
The contact owns a 2012 Ford Focus. The contact stated that the vehicle previously failed the vehicle state inspection due to the check engine warning light being illuminated. Additionally, the vehicle stalled intermittently while driving. The contact had to pull over, wait, and then restart the vehicle. The vehicle was taken to the dealer, who performed an unknown recall repair for the canister purge valve, but the failure persisted. The vehicle was then taken to the second dealer, Group 1 Ford of Southwest Houston (6445 Southwest Fwy, Houston, TX 77074), who performed another unknown recall repair for the canister purge valve, but the failure reoccurred. The contact later received notification of NHTSA Campaign Number: 26V369000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealers were made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.
Other or unspecified, Engine, Jul 11, 2026
On XXX I received email from CARFAX regarding my vehicle recall "26S40 PCM REPROGRAMMING FOR FUEL TANK DEFORMATION”. I contacted Ford Cutter Hawaii answering spoke with [XXX] over the phone regarding the recall, she asked me to forward the email then she after she read the email she dismissed the information as not reliable as it came from Carfax. She will only follow up if I got recall notice in the mail. XXX my car stalled in the middle of freeway and got towed. At the time the reading of fuel is low but not empty. The car started and only run for 1-2 seconds before it died again. That is very similar symptoms described in the recall information: "Safety Risk THIS MAY RESULT IN AN ENGINE STALL WHILE DRIVING WITHOUT WARNING OR WITHOUT THE ABILITY TO RESTART AND CAN INCREASE THE RISK OF A CRASH.” End of complain. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Jun 19, 2026
I just recently got my fuel pump fixed and a new radiator fixed that was the knot problem wrong with my car now all of a sudden I get my car back from the shop with NO OIL I put oil even though I already just had a oil changed and my engine light is now blinking but when I bought the car it was just on [XXX] to Tallahassee and I live in eestpalm beach with no problem now my car smokes so much and auto shop Firestone says it’s my engine . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Electrical system, Engine, Apr 28, 2026
Beginning in approximately May 2025, the vehicle began displaying diagnostic trouble codes identified by independent auto parts retailers and service providers. These codes indicated potential issues within the engine, electrical, and powertrain systems. The vehicle was subsequently brought to a dealership for diagnostic evaluation and remained there from approximately May 15 through May 19, 2025. During this time, the dealership reported that no diagnostic codes were present and did not resolve the reported issue. However, the vehicle had recently exhibited repeatable symptoms, including entering “limp mode” and triggering diagnostic trouble codes, prior to being delivered to the dealership. Similar codes and issues were again identified after the dealership visit. The vehicle has experienced multiple incidents of entering “limp mode,” resulting in sudden loss of power and reduced drivability while in operation. This condition occurred without reliable warning and created unsafe driving situations, including the inability to maintain normal traffic flow. Due to safety concerns, the vehicle has not been driven under normal conditions since approximately May 2025 and has been limited to short, local movements only. The issue poses a safety risk to the driver, passengers, and surrounding traffic due to unexpected loss of power and inconsistent system diagnostics. The problem appears to be ongoing and unresolved. Independent diagnostic records and service visit documentation are available upon request.
Power train, Engine, Fuel/propulsion system, Mar 23, 2026
I filled up my gas tank and a couple minutes later experienced shuddering while parked so I decided to turn the vehicle off and turn it back on but it struggles to turn back on. I then drove back home and as I was driving the acceleration was going up and down and then to 0. As i stopped on a red light the car completely shut down while the light then turned green and the check engine light, battery, and oil light came on. I then turned the vehicle off and in order to start it I had to step on the gas. I made it home but have not driven it since. I noticed there was a 19S22 recall but I spoke with ford and they said my vehicle didn’t get it but it is experiencing the same issues that the recall mentioned. There is a one time replacement for the CPV but it doesn’t cover half of what the 19S22 does and it seems to be the same problem.
Steering, Vehicle speed control, Engine, Dec 29, 2025
the car runs without power when shifted to drive gear. It is sluggish trying to speed up. Took to Ford Dealers on a recall with that is suppose to take care of it..nothing seems to have changed. I am not sure anything was done. trans makes a rough sound starting..
Power train, Latches/locks/linkages, Engine, Nov 21, 2025
The contact owns a 2012 Ford Focus. The contact stated that the rear driver’s side door failed to open as intended. The contact used force to attempt to open the door and failed. No warning lights were illuminated. The contact stated that when the vehicle was purchased, she was informed that the vehicle had an open recall related to NHTSA Campaign Number: 20V331000 (LATCHES/LOCKS/LINKAGES). When the contact retrieved the vehicle, the contact was informed that the recall had been repaired; however, there was no proof that the vehicle was under recall or that the recall repair was performed. The contact stated that several weeks later, mold was found in the driver’s seat and on the driver’s side seat belt. The contact stated that after a snowstorm, the moonroof was misty, and there was a water ring found above the interior roof. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that on a separate occasion, after starting the vehicle, there was an abnormal hissing sound coming from the vehicle underneath the driver’s side of the vehicle. No warning lights were illuminated. The contact was able to drive to the post office. After returning to the vehicle and starting the vehicle, the abnormal hissing sound persisted. The vehicle was not taken to the dealer or an independent mechanic. Upon further investigation, the contact related the failure to Manufacturer Recall Number: 18S32. The manufacturer was notified of the failures and would not confirm if the VIN was or was not under recall. The failure mileage was 129,354.
Electrical system, Engine, Aug 28, 2025
The car started shutting down while I am driving and also hard to start after
Engine and engine cooling, Aug 4, 2025
The contact owns a 2012 Ford Focus. The contact stated that while attempting to start the vehicle, the engine shuddered while idling, with the check engine warning light illuminated. The local independent mechanic was contacted; however, the vehicle was not diagnosed. The contact was advised that the failure might be attributed to coolant intrusion into the engine. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,058.
Power train, Engine, Jul 9, 2025
The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the TCM, purge valve, and clutch assembly had failed and needed to be replaced. The TCM and purge valve were repaired under warranty. The clutch assembly was not repaired or replaced. The manufacturer was made aware of the failure and referred the contact to the NHTSA hotline for further assistance. The approximate failure mileage was 128,000.
Service brakes, Engine, Fuel/propulsion system, Jun 14, 2025
I was starting to pull away from a traffic light but the car would not go to second gear and was shaking violently this has happened more times then I can count and I take care of my [XXX] we travel 50 miles a day in this car on one of the most dangerous roads in the nation [XXX] ) there are places on this road with no emergency lanes in case my car stalls again or just won't go into gear and I have drivers bearing down on me at 70 miles an hour. I know for a fact these issues have come up with countless others that have bought this vehicle and I just don't understand why this isn't a big enough safety concern is it going to take the death of me and my grandson for a recall to be made on this piece of garbage ford calls a transmission? I don't have $ for another vehicle and if this one doesn't keep getting me to work I'll be out of a job and we will be homeless a friend helped me buy this car and I assumed he checked it out first and he only looked at the accident report but not the overall report on these vehicles which shouldn't even be on car lots for sale they are unsafe death traps and when people start dying in them which im sure has already happened those deaths are on ford and on this so called national highway safety because your not doing your job this recall should have happened years ago INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, May 17, 2025
I went to emissions and I received an “Important Vehicle Safety Recall Information” notice that states Transmission Control Module Extendes Warranty Coverage”.
Engine, Apr 11, 2025
Ford manufactured faulty clutches in Ford Focus cars years 2012-2015. The clutches were put in automatic transmissions and after short periods of time the clutch slips requiring full replacements. In 2023 my daughter was driving on a 55 mile per hour highway when the car shut down and would no longer drive. She had to immediately pull over and have the car towed to the dealership. We spent $4,600 reporting the clutch. Just barely after 2 years the clutch is completely out again. A clutch in an automatic car should not go out within 2 years and 13,000 miles. When the clutch slips it puts the driver and other drivers at increased risk of an accident. Ford is aware of these issues and refuse to do any sort of recalls.
Other or unspecified, Engine, Forward collision avoidance, Apr 3, 2025
The TCM on the transmission needs fixed they said i could get a rental car.
Engine and engine cooling, Mar 19, 2025
The contact owns a 2012 Ford Focus. The contact stated that while the vehicle was parked in the driveway, there was a puddle of liquid with an abnormal odor underneath the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer for an unknown recall repair, and a message was displayed. The message “Stop vehicle immediately to prevent engine damage” was displayed. The contact pulled over to the side of the road, waited for the tow truck, and the vehicle was towed to the dealer. The dealer diagnosed the vehicle with a timing cover assembly failure. The vehicle was repaired under recall. The local dealer was contacted; however, the vehicle was not repaired because it was not under recall after the recent failure. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 138,000.
Power train, Engine, Jan 30, 2025
The contact owns a 2012 Ford Focus. The contact stated while driving at approximately 65 MPH, the check engine warning light illuminated, and the vehicle was losing motive power. The contact was able to exit the highway and stop the vehicle. The contact turned off and restarted the vehicle and was able to regain vehicle functionality. The contact stated that the vehicle was taken to a local dealer who diagnosed the vehicle. The contact stated that the vehicle was repaired; however, the contact was not notified of the cause of the failure. The contact stated that the failure reoccurred. The contact stated that the vehicle was taken back to the same dealer several times and the contact was advised that the vehicle was repaired; however, the failure reoccurred. The contact received a postcard from the manufacturer for two manufacturer recalls for the TCM: (14M02) and Canister purge valve (24N07); however, after calling the dealer, the contact was informed that the vehicle was no longer covered under warranty for the manufacturer recalls. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 91,000.
Engine, Fuel/propulsion system, Jan 21, 2025
Vehicle has difficulty starting after refuel. Vehicle stalls randomly to the point that is too much of a danger to drive. All of the symptoms correlate to recall (18S32) yet this particular vehicles vin was not listed in the list of recalled vehicles. The DTC's are as follows,P0420, P0456, P1450. Upon being serviced for the ford customer satisfaction program 24N07 it was noted by a service advisor that the replacement of a fuel tank and fuel pump was necessary which would be a reference to recall (18S32). However due to this vin not falling under recall (18S32) the service for a replacement fuel tank and fuel pump is not covered by warranty. Vehicle has erratic and innacurate fuel gauge indication. Vehicle stalled in the middle of traffic shortly after service was completed. Dealership has no clearance from Ford to address problem because 24N07 makes no mention of components that could be affected by faulty canister purge valve, unlike (18S32) and as such leaves this vehicle to be a hazard on the road.
Electrical system, Engine, Jan 7, 2025
I’ve been to several Fords for the Transmission control module TCM, the engine lagging or stalling all lights on my car going on now my whole right side of my car doesn’t work after telling Ford about these problems. They denied to fix my car even though there was a customer care warranty through Ford
Engine and engine cooling, Dec 6, 2024
The contact owns a 2012 Ford Focus. The contact stated that while opening the front driver's side door, the engine fan inadvertently turned on without starting the vehicle. The engine fan remained running after the vehicle was turned off, causing the battery to become drained. The contact had to purchase a new battery. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 120,000.
Fuel system, Gasoline, Engine, Oct 8, 2024
The contact owns a 2012 Ford Focus. The contact stated that the vehicle was difficult to start after refueling. The contact had to rev the engine to keep the vehicle running. The check engine warning light was illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 19V515000 (Fuel System, Gasoline). The vehicle was taken to an independent mechanic who used a code reader and determined that the failure was due to the purge valve and charcoal canister. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 136,000.
Power train, Engine, Oct 7, 2024
The contact owns a 2012 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle unexpectedly downshifted, with the check engine warning light illuminated. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 127,242.
Power train, Engine, Sep 16, 2024
The contact owns a 2012 Ford Focus. The contact stated that the check engine warning light was illuminated. While driving at various speeds, the contact had to manually shift the gear shifter to neutral and then to drive even though the vehicle had an automatic transmission. The vehicle was taken to the dealer who informed the contact that the transmission had failed and needed to be rebuilt or replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 78,971.
Electrical system, Engine, Fuel/propulsion system, Jul 8, 2024
1) each and every time I pop it fuel into my car, even if I'm just topping it off, when I start it it like starts to bog down like it's clogged or something, then just like that clears up. 2) while car is off, and no keys in ignition at all, my cars dashboard makes this almost clicking sound and I notice the fuel tank and gauge both shot b up to the top then drop back downs, it's strange, 3) sometimes when accelerating from hear the car almost stalks... That's v the only way I'd be by able to describe it
Engine, Fuel/propulsion system, Jul 7, 2024
Car will stall and then completely shut down. And takes awhile to restart. This last time I was on the highway and cars were going so fast. Almost had a panic attack!!