2016 Ford Focus
Problems, recalls and owner-reported issues
Power train is the leading concern among 1,192 owner complaints filed for this model year. This is the 6th highest complaint count among 19 Focus model years with reports.
Of the 2016 reports, 27 involved a crash and 3 involved a fire. 24 people were injured.
What owners report most often
Recalls and investigations
Power train, manual transmissionJun 9, 2026
Ford Motor Company (Ford) is recalling certain 2015-2018 Focus and 2013-2016 Fusion vehicles previously repaired incorrectly under recall numbers 18V169 and 18V845. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.
A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.
Dealers will update the software, free of charge. Additionally, dealers will inspect Focus vehicles and replace the clutch assembly as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 5, 2026. Additional letters will be sent once the remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S43. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.
Campaign 26V376000 on NHTSA.gov
Fuel system, gasoline, storage, evaporative emissions, canisterJun 9, 2026
Ford Motor Company (Ford) is recalling certain 2012-2018 Focus vehicles previously repaired incorrectly under recall number 18V735. The Canister Purge Valve (CPV) may malfunction, causing the engine to stall unexpectedly while driving.
An engine that stalls while driving increases the risk of a crash.
Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed July 29, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S40. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.
Campaign 26V369000 on NHTSA.gov
Equipment, electrical, engine block heaterJan 15, 2026
Ford Motor Company (Ford) is recalling certain 2016-2018 Focus, 2019 Explorer, and 2024 Explorer vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed February 13, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026. This recall expands previous recall number 25V685.
Campaign 26V012000 on NHTSA.gov
Equipment, electrical, engine block heaterJan 15, 2026
Ford Motor Company (Ford) is recalling certain 2013-2018 Focus, 2013-2019 Escape, and 2015-2016 MKC vehicles equipped with a 2.0L engine. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed March 6, 2026. Additional letters will be sent once the final remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S01. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026.
Campaign 26V011000 on NHTSA.gov
Engine and engine cooling, engine, oil/lubrication, pumpDec 22, 2023
Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus and 2018-2022 Ford EcoSport vehicles. The oil pump drive belt or drive belt tensioner may fail, resulting in a loss of engine oil pressure.
A loss of oil pressure can result in an engine stall and a loss of power braking assist, increasing the risk of a crash.
Dealers will replace the oil pump tensioner assembly and oil pump drive belt, free of charge. If engine failure occurs due to a damaged oil pump belt and/or oil pump belt tensioner, Ford has authorized dealers to replace the engine assembly as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). Owner notification letters were mailed August 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S64.
Campaign 23V905000 on NHTSA.gov
Power train, manual transmissionNov 28, 2018
Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus vehicles equipped with a 1.0L Fox GTDI engine and a 6-speed manual transmission. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.
A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.
Ford will notify owners, and dealers will update vehicles with software that detects and prevents prolonged clutch slip, and will replace the clutch, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 18S07. Note: This recall is an expansion of Recall 18V-169.
Campaign 18V845000 on NHTSA.gov
Fuel system, gasoline, storageOct 22, 2018
Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.
The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began August 19, 2019. Owners may contact Ford Customer service at 1-866-436-7332. Ford's number for this recall is 18S32. Note: Until the vehicle is serviced for this concern, owners are advised to keep the fuel tank at least halfway full.
Campaign 18V735000 on NHTSA.gov
Power train, manual transmissionMar 12, 2018
Ford Motor Company (Ford) is recalling certain 2013-2014 Ford Fusion vehicles equipped with a 1.6L GTDI engine and 6-speed manual transmission and 2015-2016 Ford Focus vehicles equipped with a 1.0L GTDI engine and 6-speed manual transmission. Also included are four 2017 Ford Focus vehicles that had clutch replacements with potentially affected parts. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.
A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.
Ford will notify owners, and dealers will update the Focus vehicles with software that detects and prevents prolonged clutch slip, and will replace the clutch, as necessary, free of charge. Owners of Fusion vehicles will have their clutch assembly replaced free of charge. The recall began August 3, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S07.
Campaign 18V169000 on NHTSA.gov
Structure, bodyJan 24, 2017
Ford Motor Company (Ford) is recalling certain 2016 Focus and C-Max vehicles. The floor pan may have improperly welded left-hand apron joints.
Improperly welded apron joints may reduce the front-end structural integrity of the vehicle, increasing the risk of injury in the event of a crash.
Ford will notify owners, and dealers will inspect the apron joints, repairing the vehicle, as necessary, free of charge. The recall began March 8, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S03.
Campaign 17V052000 on NHTSA.gov
Latches/locks/linkages, hatchback/liftgate, lockSep 28, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2017 Ford Focus hatchback vehicles manufactured February 14, 2012, to August 26, 2016 and equipped with a manual transmission. The hatchback of the affected vehicles may be unlatched with a single press of the interior latch release button. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
With only a single press needed, the driver may accidently unlatch the hatchback, increasing the risk of injury to any unsecured passengers in the back.
Ford will notify owners, and dealers will reprogram the Body Control Module with updated software, free of charge. The recall began February 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C13.
Campaign 16V698000 on NHTSA.gov
Representative owner complaints
1,192 reports, newest first.
Power train, Sep 12, 2022
The contact owns a 2016 Ford Focus. The contact stated while driving approximately 35 MPH and accelerating up a highway onramp, the vehicle started losing motive power. The contact stated that the transmission fault warning light was illuminated. The contact had observed that as he depressed the accelerator pedal, the vehicle failed to respond; however, the engine was revving with the RPM going up to 5,000 RPM. The contact stopped the vehicle and turned off the engine. The contact restarted the vehicle however, the vehicle failed to exceed 30 MPH. The contact stated that the vehicle had gone into Limp Mode. The contact had not taken the vehicle to a dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to Manufacturer Customer Satisfaction Program: 14M02 (Transmission Control Module). The manufacturer had been informed of the failure. The failure mileage was approximately 123,000.
Power train, Sep 10, 2022
I have had 6 clutches replaced in the past 2 years on my car. Now they are telling me this is the last one they are going to do. It'snot my fault these clutches keep failing. Ford has told me they are not coving the problem anymore.
Fuel/propulsion system, Sep 8, 2022
My car stalls out when I refuel. I've taken my car to a mechanic who has documented that my check engine was on due to low fuel pressure. They also say that there is a fuel tank deformation being caused because of this issue
Power train, Sep 8, 2022
The contact owns a 2016 Ford Fusion. The contact stated that on several occasions while driving at an undisclosed speed, she felt an odd feeling while the accelerator pedal was applied. The contact referenced the Manufacturer's recall number: 14M02 (Transmission Control Module). The vehicle was not diagnosed. The vehicle was not repaired. The dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 40,000.
Power train, Sep 7, 2022
The contact owns a 2016 Ford Focus. The contact stated while driving approximately 10 MPH, the transmission was chattering. The contact felt that the clutch was slipping and the vehicle was hesitating while driving. The contact stated that the vehicle hesitation and transmission chatter stopped while exceeding 30 MPH. The contact stated there was no warning light illuminated. The contact had driven the vehicle to a local dealer, where it was diagnosed and determined that the clutch assembly and two actuators needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 79,900.
Engine and engine cooling, Fuel system, Gasoline, Engine, Sep 2, 2022
The contact owns a 2016 Ford Focus. The contact stated that while starting the vehicle, the check engine warning light illuminated. The vehicle was taken to an independent mechanic who informed the contact that the canister purge value on the fuel tank was stuck or was sticking. The contact called the local dealer and was informed that the vehicle was not covered under a recall and informed her about scheduling an appointment. The vehicle was not diagnosed or repaired. The contact called another local dealer, Crossroads Ford of Apex (1501 N Salem St, Apex, NC 27502) but the vehicle was not diagnosed or repaired. The manufacturer was contacted and provided a case number but no additional assistance was provided. The contact stated that the failure was similar to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The failure mileage was unknown.
Engine, Sep 2, 2022
Engine seized up. Going 70MPH on the highway and suddenly I'm losing speed. I get pulled over to the side of the road and shut the car off. So I start the car and notice my oil light is on. I shut it back off and check the oil. Levels are good. Turn the car back on and got back up to 35 MPH and it just wouldn't go anymore. Engine wouldn't turn back over. Mechanic confirmed engine was seized up and wasn't because of lack of oil. He told me others have had complaints on this issue as well. Only 60k miles on the car and had to get the engine replaced.
Power train, Vehicle speed control, Sep 1, 2022
The contact owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle would not immediately accelerate while depressing the accelerator pedal. The vehicle would then lurch forward unintendedly. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The manufacturer was not notified of the failure. No additional information was available. The failure mileage was 40,353.
Fuel system, Gasoline, Aug 30, 2022
The contact owns a 2016 Ford Focus. The contact referenced NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The contact stated that on multiple occasions while driving at various speeds, the vehicle stalled. The check engine warning light illuminated. Additionally, the contact stated that she noticed that the fuel gauge would indicate the incorrect amount of fuel. The contact stated that if the fuel was below a quarter tank, the vehicle would stall. The check engine warning light would be illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the fuel tank and fuel delivery module needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and the contact was informed of an unknown recall, but no further assistance was provided. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 65,000.
Power train, Aug 30, 2022
My car will not drive or reverse it’s the master control module in the transmission stuck clutch b engaged is the code I brought it to ford they say there is a silent recall/ extended warranty on this part but somehow my car is not part of this recall or extended warranty but there are 12 cars waiting same part I have been without a car for 1 month due to part being on back order.
Power train, Aug 27, 2022
Transmission issues
Power train, Aug 22, 2022
I was stopped at a stop sign in my 2016 Ford Focus Hatchback. I looked both ways and proceeded to hit my gas pedal. The car moved as it should and normally. Halfway through the lane my car stopped accelerating and i put my gas pedal to the floor and my car just continued coasting slowly. I panicked looking at the car coming towards me then let go and stepped on it again finally it kicking into gear and then making it across. This happened later in the day again while driving on a straight road. (Luckily this didn’t put me in danger but did catch me by surprise again) I tried calling multiple dealerships about this and they just said it’d cost $125 for them to take a look. But i know it’s deeper than that and here’s why. My friend has a 2015 Ford Focus and his has been experiencing similar issues. As well as a family members co-worker who has a 2017 Ford Focus they’re all hatchbacks keep in mind. (including mine) I also wanted to go looking for a new car the day after my car nearly got me into accident. So i went out and i met a sales associate from a dealership who told me his friend has a 2016 Ford Focus Hatchback that was dealing with the exact same problem as me. As well as 4 others that week who’s been coming in looking for a new car with their personal trade in vehicle being. You guessed it, a Ford Focus with transmission issues.
Equipment, Aug 22, 2022
The contact owns a 2016 Ford Focus. The contact stated while driving approximately 30 MPH, the radio started making loud popping sounds and playing white noise at an extreme volume that was distracting. The contact stated that even with the vehicle turned off, the radio buzzed and pop loudly. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer however, the vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 70,000.
Power train, Aug 22, 2022
The contact owns a 2016 Ford Focus. The contact stated while driving from a complete stop, the vehicle surged and was shuddering. There were no warning lights illuminated. The contact stated that the failure had been reoccurring. The vehicle was taken to an independent mechanic where it was diagnosed that the transmission clutch needed to be replaced. The dealer was notified of the failure. The contact reference Ford Customer Satisfaction Program Number: 20B23. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA for assistance. The failure mileage was approximately 65,000.
Power train, Engine, Aug 22, 2022
The contact's daughter owns a 2016 Ford Focus. The contact's granddaughter attempted the start the vehicle when and heard an abnormal noise. The vehicle failed to start. No warning lights was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the spark plug was blown. The vehicle was not repaired. The vehicle was then towed to another auto body mechanic where it was also diagnosed that the spark plug was blown. The contact was informed that the spark plugs and ignition coils needed to be replaced. Additionally, a rethread kit was needed to repair damages to cylinder #4. The vehicle was repaired. The dealer was notified of the failure however, the contact was informed there was no recall associated with the failure. The contact was provided an estimate for the repair. The manufacturer was notified of the failure. The failure mileage was approximately 42,105.
Other or unspecified, Aug 20, 2022
My TCM stopped working and now my vehicle won't go into reverse 2nd 4th gear. My dad noticed it when he tried to back it into the garage to do some maintenance on it. I have been told it will be months to fix because of a backorder. I know this is a common issue for Focus but my vehicles Vin doesn't have a recall listed.
Power train, Aug 17, 2022
Very bad Transmission shutter 1-2 gear
Power train, Aug 17, 2022
The contact owns a 2016 Ford Focus. The contact stated while his wife was driving at 35 MPH, the vehicle emitted abnormal clutching sounds. The check engine warning light was illuminated. The contact's wife veered to the side of the road and turned off the vehicle. However, as his wife turned on the vehicle, the failure persisted while driving. The contact stated the failure reoccurred increasingly. The vehicle was taken to an independent mechanic where it was diagnosed that the clutch actuator needed to be replaced. The part was replaced. Additionally, the independent mechanic diagnosed that the transmission components were misaligned. The transmission was aligned and the check engine warning light turned off. The vehicle was taken to the dealer where it was diagnosed that the dual-clutch assembly and the transmission seal assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist as the VIN was not included in NHTSA Campaign Number: 18V845000 (Power Train). The manufacturer referred the contact to NHTSA. The failure mileage was approximately 96,569.
Power train, Aug 17, 2022
The contact owns a 2016 Ford Focus. The contact initially stated that the vehicle would fail to start up as needed. The contact also mentioned that the vehicle would fail to shift gears upon the depression of the accelerator pedal as several unknown warning lights appeared on the instrument panel. The contact had taken the vehicle to a dealer and was informed that the PCM (Powertrain Control Module)needed to be replaced. The contact agreed to the repair; however, the parts for the repair were on backorder. The contact eventually found the part online which he paid for out of pocket and the dealer was able to install the part and repair the vehicle. The contact expressed concern that the failure with his transmission may occur again. The manufacturer had been notified of the failure and referred him to the NHTSA Hotline for assistance. The failure mileage was approximately 125,000
Power train, Aug 16, 2022
The contact owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle would fail to accelerate upon the depression of the accelerator pedal. The contact would then manually shift the transmission to operate the vehicle; however, the "transmission overheating stop safely," warning message would then appear on the instrument panel. The contact took the vehicle to an independent mechanic where she informed that the transmission control module was replaced; however, the failure persisted after the repair. The vehicle was taken back to the mechanic and was then informed that the failure could be linked to the vehicle's clutch plate. The dealer was also notified of the failure and was informed that the vehicle was not included in NHTSA Campaign Number: 18V845000(Power Train). The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was unknown.
Power train, Aug 15, 2022
I have been having issues with my EVAP system and it is effecting my Drivability. It will stall but there is no recall for my car.
Power train, Aug 15, 2022
Transmission or clutch slipping between gears and pedal response time is delayed
Power train, Aug 14, 2022
Vehicle slips at gears 1 and 2 and doesn’t have power when accelerating.
Power train, Aug 13, 2022
Transmission. Car on dealership lot. Car stopped running in busy hospital underground parking ramp. Unable to restart. Ford dealership confirmed bad transmission control module TCM. No warning or warning lamps prior.
Power train, Aug 11, 2022
The contact owns a 2016 Ford Focus. The contact stated he notice that the check engine warning light was illuminated, while driving at 15 MPH. The contact felt the gear shifted roughly. The contact stated at a different occasion the vehicle would not start, the contact had to crank the engine several times for the vehicle to start. The vehicle was taken to the dealer where they stated that the Transmission Control Module needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and the contact informed them that his vehicle was experiencing the same failure as Customer Satisfaction Program 14M02 – Transmission Control Module Extended Warranty Coverage – 2011-2015 Ford Fiesta & 2012-2016 Focus and they stated the VIN was not included. The failure mileage was 83,000.