2017 Ford Focus

What owners report most often

1. Power train454
2. Engine232
3. Fuel/propulsion system117
4. Engine and engine cooling81
5. Other or unspecified81
6. Fuel system61
7. Gasoline61
8. Electrical system39

Recalls and investigations

1. Power train, manual transmissionJun 9, 2026

   Ford Motor Company (Ford) is recalling certain 2015-2018 Focus and 2013-2016 Fusion vehicles previously repaired incorrectly under recall numbers 18V169 and 18V845. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.

   A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.

   Dealers will update the software, free of charge. Additionally, dealers will inspect Focus vehicles and replace the clutch assembly as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 5, 2026. Additional letters will be sent once the remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S43. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.

   Campaign 26V376000 on NHTSA.gov

2. Fuel system, gasoline, storage, evaporative emissions, canisterJun 9, 2026

   Ford Motor Company (Ford) is recalling certain 2012-2018 Focus vehicles previously repaired incorrectly under recall number 18V735. The Canister Purge Valve (CPV) may malfunction, causing the engine to stall unexpectedly while driving.

   An engine that stalls while driving increases the risk of a crash.

   Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed July 29, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S40. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.

   Campaign 26V369000 on NHTSA.gov

3. Equipment, electrical, engine block heaterJan 15, 2026

   Ford Motor Company (Ford) is recalling certain 2016-2018 Focus, 2019 Explorer, and 2024 Explorer vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

   An electrical short circuit can increase the risk of a fire.

   Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed February 13, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026. This recall expands previous recall number 25V685.

   Campaign 26V012000 on NHTSA.gov

4. Equipment, electrical, engine block heaterJan 15, 2026

   Ford Motor Company (Ford) is recalling certain 2013-2018 Focus, 2013-2019 Escape, and 2015-2016 MKC vehicles equipped with a 2.0L engine. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

   An electrical short circuit can increase the risk of a fire.

   Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed March 6, 2026. Additional letters will be sent once the final remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S01. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026.

   Campaign 26V011000 on NHTSA.gov

5. Engine and engine cooling, engine, oil/lubrication, pumpDec 22, 2023

   Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus and 2018-2022 Ford EcoSport vehicles. The oil pump drive belt or drive belt tensioner may fail, resulting in a loss of engine oil pressure.

   A loss of oil pressure can result in an engine stall and a loss of power braking assist, increasing the risk of a crash.

   Dealers will replace the oil pump tensioner assembly and oil pump drive belt, free of charge. If engine failure occurs due to a damaged oil pump belt and/or oil pump belt tensioner, Ford has authorized dealers to replace the engine assembly as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). Owner notification letters were mailed August 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S64.

   Campaign 23V905000 on NHTSA.gov

6. Fuel system, gasoline, storageJul 5, 2019

   Ford Motor Company (Ford) is recalling certain 2012 and 2017 Focus vehicles equipped with 2.0L GDI gasoline engines and 2013-2014 Focus ST vehicles equipped with 2.0L GTDI engines, previously recalled under 18V-735. The affected vehicles did not have the Powertrain Control Module (PCM) updated as intended. Therefore, the Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in the fuel vapor management system.

   The excessive vacuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.

   Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S22.

   Campaign 19V515000 on NHTSA.gov

7. Power train, manual transmissionNov 28, 2018

   Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus vehicles equipped with a 1.0L Fox GTDI engine and a 6-speed manual transmission. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.

   A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.

   Ford will notify owners, and dealers will update vehicles with software that detects and prevents prolonged clutch slip, and will replace the clutch, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 18S07. Note: This recall is an expansion of Recall 18V-169.

   Campaign 18V845000 on NHTSA.gov

8. Fuel system, gasoline, storageOct 22, 2018

   Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.

   The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.

   Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began August 19, 2019. Owners may contact Ford Customer service at 1-866-436-7332. Ford's number for this recall is 18S32. Note: Until the vehicle is serviced for this concern, owners are advised to keep the fuel tank at least halfway full.

   Campaign 18V735000 on NHTSA.gov

9. Seat belts, rear/otherAug 28, 2017

   Ford Motor Company (Ford) is recalling certain 2017 Focus vehicles. The rear left side seat back frame may have an insufficient weld between the outboard pivot bracket and the pivot nut joint, resulting in the seat back having reduced strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems," and 210, "Seat Belt Assembly Anchorages."

   The reduced seat back strength may increase the risk of injury in the event of a crash.

   Ford will notify owners, and dealers will inspect and replace the rear second left side rear seat back as necessary, free of charge. The recall began October 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C13.

   Campaign 17V528000 on NHTSA.gov

10. Latches/locks/linkages, hatchback/liftgate, lockSep 28, 2016

    Ford Motor Company (Ford) is recalling certain model year 2013-2017 Ford Focus hatchback vehicles manufactured February 14, 2012, to August 26, 2016 and equipped with a manual transmission. The hatchback of the affected vehicles may be unlatched with a single press of the interior latch release button. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."

    With only a single press needed, the driver may accidently unlatch the hatchback, increasing the risk of injury to any unsecured passengers in the back.

    Ford will notify owners, and dealers will reprogram the Body Control Module with updated software, free of charge. The recall began February 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C13.

    Campaign 16V698000 on NHTSA.gov

Representative owner complaints: engine

304 reports, newest first. Show all

1. Engine, Aug 26, 2026

   What component or system failed or malfunctioned, and is it available for inspection upon request? Transmission failure after 2 recall/warranty repairs, most recently in July 2026. How was your safety or the safety of others put at risk? Vehicle accelerating and then stopping out right on and off the freeway "bucking" on the freeway, fast then slow, with no foot on the accelerator. Has the problem been reproduced or confirmed by a dealer or independent service center? This was immediately noticed when we picked up the vehicle from the dealer after the 2nd Ford recall repair. No, they deny this, and state this is a coincidence when it was not doing this when we dropped the vehicle off to them. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, but I will be getting police, lawyers and insurance involved since Ford motor company will not help us. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Check engine light and service engine now light on when we picked up the vehicle from the Ford dealership on July 13th, 2026. The day we picked it up, immediately this happened pulling out of the dealership/service department, and on the freeway, 4 times causing close to 4 accidents.

2. Engine and engine cooling, Aug 20, 2026

   The contact owns a 2017 Ford Focus. The contact stated that the vehicle was taken to a dealer for a recall repair associated with an engine oil failure and tensioner replacement. The contact stated that after the recall repair, while her daughter was driving at an undisclosed speed, the vehicle was jerking and then unintendedly accelerated. The "Service Engine" light was illuminated. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.

3. Engine, Aug 14, 2026

   I was driving and during the drive I realized that if the accelerator pedal was pressed more than the lightest touch the car would stop accelerating. I decided that I had to turn back to go home, and during my return trip the engine oil pressure lamp started flashing at me. Soon after, I entered a roundabout and pressed the clutch. At this moment the engine stopped working (tach to 0 rpm) and I had to coast and pull over. The starter worked but the engine did not turn over--it was seized. Prior to that day, it seemed like the car was having trouble with its turbocharger--boost was delayed at first and later intermittent. Since I was on a mostly empty road this did not pose a safety threat to others, though I did slow down traffic as I pulled over on a two-lane road. If this same issue had happened later into my drive on a busier road or highway, mine and others' safety would have been put at risk due to my car suddenly not working with little warning. The engine is seized and needs to be replaced. It would be available for inspection as I have not yet replaced it. The current cost to repair has been quoted to me at between $9000 and $10000.

4. Power train, Engine, Fuel/propulsion system, Aug 13, 2026

   I am filing this complaint regarding a severe safety hazard and prolonged failure to resolve an official recall repair by the manufacturer and dealership. In April 2026, the vehicle was brought to the dealership for an official recall repair. The repair was delayed for 2 months. In June 2026, after the dealership confirmed completion, I retrieved the vehicle. While driving on the highway, the check engine light suddenly illuminated and the vehicle completely lost power. Pressing the accelerator pedal produced no response, leaving the car unable to accelerate in active high-speed traffic. This created an extreme safety risk that nearly caused a severe highway collision. The vehicle was towed back to the dealership. The dealership returned the vehicle a second time, claiming it was repaired, but the exact same check engine light illuminated immediately with the same loss of power, requiring another tow. As of August 2026, the dealership has retained the vehicle for over 4 months in total due to backordered parts, without providing a clear completion date or loaner/rental transportation support. The dealership and corporate customer care are currently ignoring attempts to communicate. The recurring loss of engine power on the highway and unresolved recall defect pose a direct and imminent risk to public road safety. The components involved are currently at the dealership for inspection.

5. Electrical system, Engine, Aug 11, 2026

   The contact owns a 2017 Ford Focus. The contact stated that while driving at various speeds on several occasions, the vehicle stalled. The vehicle was restarted after approximately 45 minutes after each failure. The vehicle was towed to the neighbor's house approximately seven times and was taken once to an independent mechanic; however, the failure could not be duplicated. The contact stated that on one occasion while attempting to restart the vehicle, the accelerator pedal was depressed and the engine revved; however, the vehicle lost power and stalled. The manufacturer was not notified of the failure. The failure mileage was approximately 123,226.

6. Engine, Aug 4, 2026

   Timing belt came apart and my engine blew in the middle of driving. I contacted ford and they said i had to deal with it. So I have had it repaired. I have invoices. Warning light came on seconds before it died. I only have 40,000 miles on my car.

7. Engine, Jul 25, 2026

   I presented my vehicle to Oliver Ford-Lincoln in Plymouth, IN for inspection under recall 23S64 / NHTSA 23V-905. The dealership confirmed that the oil pump drive belt degraded, clogging the oil pickup pump screen and causing engine oil starvation and complete engine failure. The dealership subsequently denied recall coverage claiming "bad maintenance history". Under NHTSA Campaign 23V-905, Ford explicitly acknowledges that the wet belt and tensioner are defective by design and cause oil starvation. Denying a safety recall remedy for the exact failure mechanism detailed in the federal recall notice based on discretionary maintenance rules violates federal safety recall requirements. Furthermore, I attempted to escalate this denial to Ford Corporate. Ford Corporate refused to generate an official case number, promised a callback, and abandoned the request. I am requesting NHTSA intervention to compel Ford Motor Company to honor the remedy mandated under Safety Recall 23V-905.

8. Engine and engine cooling, Jul 15, 2026

   The contact owns a 2017 Ford Focus. The contact stated that while driving at an undisclosed speed, the low engine oil pressure warning light illuminated, and the contact stopped driving the vehicle. The vehicle was taken to the dealer, where the engine oil pump, the engine, and the coolant gasket housing were replaced under NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the vehicle started overheating. The vehicle was taken back to the dealer several times, and the contact was eventually informed that diagnostic trouble codes indicating an overheating failure were retrieved when the vehicle was initially taken to the dealer. The contact stated that the dealer stated that the overheating failure was not related to the recall repair. No further assistance was provided. The manufacturer was notified of the failure and a case was filed; the contact was advised to take the vehicle to another dealer for a second assessment, and the manufacturer would follow up with the initial dealer based on the assessment. The failure mileage was approximately 178,000.

9. Engine and engine cooling, Jul 10, 2026

   See attached document for complaint.

10. Power train, Engine, Fuel/propulsion system, Jul 6, 2026

    While driving approximately 53 mph on a main road, my 2017 Ford Focus suddenly displayed the message “Engine Fault Service Now.” The vehicle immediately entered limp mode, downshifted into 2nd gear, and would not accelerate above approximately 31 mph. During the event, the engine shook noticeably and made abnormal noises. No check engine light appeared during this initial incident. This problem occurred multiple times over several days, most often when the fuel tank was below approximately half full. Each time, I was able to temporarily restore normal operation by shutting the vehicle off, waiting about one minute, and restarting it. After restarting, the vehicle would drive completely normally until the problem occurred again. A few days later, while sitting in my vehicle during a work break, I started the engine and it immediately entered limp mode without being driven. A check engine light then illuminated, and the engine stalled shortly afterward. The diagnostic trouble codes retrieved were: * P1674 (Stored, Pending, Permanent, and Enhanced) * U0100 (Enhanced ABS Code) A mechanic familiar with Ford vehicles suggested the symptoms could be related to the EVAP canister purge valve issue that has been investigated on similar Ford Focus models. He recommended keeping the fuel tank above half full as a test. Since keeping the fuel tank full, the limp mode condition has not reoccurred. I took the vehicle to a Ford dealership to have the purge valve issue evaluated. The dealership declined to perform any purge valve-related repairs because they believed the problem was transmission-related and stated the engine issue would need to be repaired first. I am submitting this report because the vehicle unexpectedly loses power while driving, creating a significant safety hazard when traveling at normal traffic speeds.

11. Electrical system, Engine, Apr 16, 2026

    The block heater on this car is leaking. The recall 26V011 does not apply to this VIN, even though it falls under the year, make, model category. How can I get my vehicle to have the recall done when it shows that it is not affected, even though it is clearly leaking.

12. Engine, Apr 6, 2026

    engine failure - coolant entering engine cylinder #2, Internal engine failure. Car was stalled loss of power on highway and almost killed. Towed to nearest mechanic shop. Need to disassemble and confirm failure point. Ford law suits for coolant internal engine damage and failure. This is a known defect with Ford Ecoboost engines. Including coolant/antifreeze entering the engine. Also, the coolant intrusion into cylinders. Requesting good will assistance as unable to use car for over 2 months. Ford headquarters is acting like they know nothing about this.

13. Vehicle speed control, Other or unspecified, Engine, Apr 3, 2026

    ●Unknown- transmition seem to slip or acted like stalling or about to die. Would jerk forward and shutter till finally would not start after being turned off. So had it towed because would not start again. ●myself and others in my 2017 Ford Focus titanium edition were traveling over a bridge at the time of the incident and very well have stalled out or quit running in the middle of traffic on a bridge causing a collision or worse loss of life ●No- no service center has addressed the issue not due to me not trying but merely, nothing's been done from where I've taken it to ●No- at the moment that is not required as of yet. ●Yes- the forward jerking and shuttering started a couple of years every now and then, until it turned into such a severe situation. ●No - no signs signals lights or anything on the dash showed any kind of sign of anything wrong with the vehicle.

14. Engine, Mar 17, 2026

    Ford refuses to respond to emails nor return calls...... Cracked cylinder head caused from a known issue Ford failed to recall. The 2.0L Ecoboost uses an aluminum cylinder head with relatively thin casting areas between the combustion chamber and coolant passages. Coolant passages run very close to the exhaust valve seats. The turbocharged exhaust temperatures are EXTREMELY high. Thin aluminum sections are repeatedly exposed to rapid heating and cooling cycles. Over time this creates micro-fractures int he heat casting, which eventually grow into a crack between the combustion chamber and coolant jacket. This defect tends to occur between 60k - 100k miles. Safety: Car was smoking so bad that it could have caught fire. The car has been inspected by a Ford dealership and declared this to be the problem. The fix is a new engine that costs 12k. There were no warning lamps or symptoms prior to the failure. Car is still deemed inoperable as Ford refuses to help with the fix.

15. Engine, Mar 13, 2026

    The engine oil light came on during late September or early October of 2024 while on the highway. There was a severe loss of power. I was able to get the car back to my residence and changed the oil filter and oil. The error persisted, I then changed the oil pressure switch to see if that was the issue, but it did not resolve. In approximately December of 2024, a friend who is a mechanic and has thousands of hours of experience offered to look at the issue. He pulled the engine and found that the oil pump belt and timing belt were severely degraded and had clogged the oil screen. He replaced the two belts and cleaned the screen hoping it would resolve the issue. In approximately late may or early June 2025 I got the car back and by the beginning of August the engine had seized due to damage received when the oil pressure had failed due to a clogged screen back in 2024. Thankfully I was not on the highway when the engine seized.

16. Power train, Electrical system, Engine, Mar 11, 2026

    Recall maintenance with regard to NHTSA ID Number: 19V515000 for a Purge Valve was completed 1/9/2025. Starting in October 12, 2025, driving on the freeway, a large "bang" was felt/heard. I pulled over, the dust cover under the car had ripped partially off and took a portion of my grill trim with it. The car still ran perfectly fine, so I continued the mile and a half to my house. I did not see anything that I may have hit on the highway and did not see anything eject behind my car when this incident happened. I noticed the oil light begin to flicker as I was ½ mile from home for maybe a second, then it was off and then flickered again, it did not stay lit. I filed a claim with my insurance-Progressive-they wanted to total my car without inspecting it. I negotiated and they had me take it to The Ford dealer who inspected it visually to see if the cause was internal combustion as my insurance claimed, or external damage. See photos. They recommended a full engine replacement after only a visual inspection and charged me 276.70. I had the oil-pan replaced as shown on my bank statement 1053.77, with Interstate Automotive who verified no engine damage was found. Next the LCD instrument panel showed distorted, or not at all, or perfectly fine at times, which made it hard to read, and no instrument warnings are given for any issue, just the check engine light. As of today, 3/10/26, car will no longer reverse or progress into 2nd gear, is sluggish and feels as though it has no power at all. This happened randomly on 3/9/26 after the car would not start and it was believed to be a battery issue. The battery was replaced 3/9/26 148.08. When the diagnostic codes for the check engine light were tested, they showed a faulty CO2 module issue. New parts will be installed on 3/11/26. All of the above described issues seem as though they could be related to a major safety issue with this vehicle, but Ford insists any courtesy fixes are not available to my VIN.

17. Engine, Feb 25, 2026

    My vehicles engine died in traffic and left me stranded in the middle of a busy road. Upon a mechanics review the issue is a siezed engine because of the oil pump pickup tube clogged with pieces of the oil pump or timing chain pulleys that had broken off.

18. Engine, Fuel/propulsion system, Jan 26, 2026

    UNKOWN my rpms rev up randomly I can’t shut my car off when I get gas and makes a raving up sound I can’t reverse

19. Service brakes, Engine, Fuel/propulsion system, Jan 23, 2026

    I am reporting a dealership conduct issue that directly affected vehicle safety and caused financial loss. Valley Ford of Columbus, Ohio told me by phone that a specific safety-related part for my vehicle was in stock and available. Based on that representation, I traveled to the dealership and took time away from work. When I arrived, I was told the part was not available and had not been there. Shortly after this, I went out of town. During that time, Valley Ford stated they were unable to reach me. After returning, I again contacted Valley Ford and was once more told that the same safety-related part was available. I again traveled to the dealership, taking additional time off work, and once again was told upon arrival that the part was not available. This resulted in the same situation happening twice. Because of this repeated misinformation, I lost wages and hard-earned paid time off (PTO), was delayed in repairing my vehicle, and had to continue driving while waiting for a safety-related component I was told was available. I use my vehicle for work every day for approximately eight hours per day. Being forced to continue operating my vehicle without this safety-related repair places myself and other motorists at risk. After these incidents, I contacted Germain Ford of Columbus, Ohio in an effort to resolve the issue. I was informed that the same safety-related part could take up to eight weeks to become available. This extended delay has further prolonged my inability to complete necessary safety-related repairs and has continued to place me in a potentially unsafe driving situation. I believe this repeated misinformation and prolonged unavailability of a safety-related vehicle component is dangerous and unacceptable. I am submitting this complaint so NHTSA is aware of the actions of Valley Ford of Columbus, Ohio and the ongoing delay reported by Germain Ford of Columbus, Ohio.

20. Engine and engine cooling, Jan 5, 2026

    The contact owns a 2017 Ford Focus. While the contact's husband was driving at an undisclosed speed, the accelerator pedal was depressed, however the vehicle failed to accelerate. The contact ws unsure if any warning lights were illuminated. The vehicle was towed to an independent mechanic where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The contact stated that the replacement engine was purchased from the dealer. The contact later received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, parts were not yet available. The contact stated that the dealer was contacted several times, and the contact was informed that parts were not available, and the call was disconnected. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

21. Engine and engine cooling, Jan 2, 2026

    The contact owns a 2017 Ford Focus. The contact stated that the engine was previously replaced due to a cracked engine block. The contact was provided a loaner vehicle during the several weeks the vehicle was being serviced. The contact received the recall notice of NHTSA Campaign Number: 23V905000(Engine and Engine Cooling). The local dealer was contacted, and confirmed the parts status. The vehicle was not diagnosed or repaired. The manufacturer was notified and confirmed the part availability. The failure mileage was unknown.

22. Engine and engine cooling, Power train, Dec 11, 2025

    The contact owns a 2017 Ford Focus. The contact stated that after the vehicle was stopped at a traffic light, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the transmission downshifted between first and third gear. An abnormal sound could be heard coming from the transmission. After driving a short distance, the vehicle functioned as intended. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that the failure persisted. The contact stated that while driving at 40 MPH on a separate occasion, the transmission downshifted between third and fourth gear, and the vehicle went into limp mode. In addition, an abnormal sound could be heard coming from the transmission, and the vehicle jerked. The contact stated that upon starting the vehicle most recently, the vehicle made an abnormal sound. The check engine warning light illuminated. The vehicle was taken to AutoZone for a diagnostic test, and the contact was informed that the failure may be related to the transmission clutch. Additionally, the contact stated that the fan had turned on independently, and had failed to turn on while driving on other occasions, causing the vehicle to overheat. The vehicle was taken to a collision center, where the contact was informed that the transmission was failing. The cooling system was replaced; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that an unknown sensor had failed, and the sensor was replaced. The contact stated that the transmission failure was worsening. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 50,000.

23. Engine, Dec 7, 2025

    After recall Campaign 23S64 and the engine being replaced with G1FG-6006-DA and traceability Code [XXX] . Incident Description On Saturday [XXX], while driving on the freeway, my vehicle began sputtering and lost power. The RPMs increased but the speed did not. The check engine light illuminated briefly and then went out. This created an Immediate serious safety hazard to me my passenger and other drivers on the road as I was unable to maintain speed in traffic and had to leave the freeway Immediately. Diagnostic Findings •Initial AutoZone OBD-II scan revealed P0302 (Cylinder 2 Misfire). •Dealer’s own diagnostic later reported P0301 (Cylinder 1 Misfire), with carbon tracking on all spark plugs and ignition coil boots. •Dealer noted the locking tab on Cylinder 3 ignition coil connector was broken, requiring a new pigtail. •Dealer also identified a broken front motor mount, but is attempting to charge me for replacement despite the fact that the mount must be removed and reinstalled during an engine swap. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

24. Engine and engine cooling, Nov 25, 2025

    The contact owns a 2017 Ford Focus. The contact stated while driving at various speeds, the vehicle lost motive power. The contact stated that there were no warning lights illuminated. The contact stated that the temperature gauge was moving into the HOT zone and the speedometer displayed that the vehicle was decelerating. The contact stated that the failure had been recurring. The contact had taken the vehicle to the dealer several times, and on several trips to the dealer, the vehicle had to be towed. The dealer diagnosed the vehicle and advised the contact that the vehicle had been repaired; however, the failure persisted. The contact stated that the vehicle was recently taken to the same dealer to be repaired under NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the failure recurred after the recall repair. Additionally, the contact stated that the engine compartment of the vehicle was significantly hot after driving a short distance. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 115,000.

25. Engine, Oct 3, 2025

    I purchased this vehicle 4 days ago. On the second day I noticed a shutter when accelerating, going uphill and often continuous. I have been told that it is the clutch. I am aware that the same issue on the 2017 focus has been recalled. I do not understand why it is just certain vehicles. Especially, since it is the same year and issue as the recalled ones. I am a police officer that has had some health issues with my heart. My parents gave me the money to buy this car. They do not have the money to repair it and neither do I. I called two Ford dealerships as well as the Ford manufacturer. Nobody was willing to help. I discovered that this is the place to file a complaint all on my own. Please try and help me.