2009 GMC Sierra 1500
Problems, recalls and owner-reported issues
Air bags is the leading concern among 280 owner complaints filed for this model year. This is the 12th highest complaint count among 26 Sierra 1500 model years with reports.
Of the 2009 reports, 7 involved a crash and 4 involved a fire. 5 people were injured.
What owners report most often
Recalls and investigations
Air bags, frontal, passenger side, inflator moduleFeb 5, 2021
General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.
Campaign 21V053000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleFeb 5, 2021
General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.
Campaign 21V052000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleFeb 5, 2021
General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.
Campaign 21V050000 on NHTSA.gov
EquipmentApr 26, 2018
General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.
Campaign 18V267000 on NHTSA.gov
Representative owner complaints
280 reports, newest first.
Steering, Feb 11, 2026
This letter serves as a formal notice of concern and demand for accountability regarding the 2009 GMC Sierra LD, VIN [XXX] , owned by [XXX] . There are numerous documented complaints and safety investigations concerning premature tie rod failure in 2009 GMC Sierra models. While the 2009 model year may not have been subject to a sweeping, industry-wide recall specific to tie rods in the 1500 series, it is undeniably and consistently associated with premature steering component failure — including both inner and outer tie rods. The refusal to proactively address this defect, assign a broader recall, or take ownership of the recurring issue reflects a troubling disregard for consumer safety. Documented and Reported Issues Include: • Premature Wear: Tie rods becoming loose or failing between 50,000–100,000 miles, resulting in steering wander and excessive play in the steering wheel. • Clunking/Knocking Noises: Audible front-end knocking at low speeds, a well-known symptom of failing tie rod joints. • Severe Safety Risk: Instances where tie rods have separated or become dangerously compromised, directly affecting steering control. • Uneven Tire Wear: Excessive inner or outer tire edge wear caused by steering instability. • Recall 14V-246000: A related recall acknowledging improper tightening of tie rods where they thread into the steering gear rack — a defect that could cause separation and loss of steering control. The common symptoms — steering vibration, looseness, clunking when turning, and vehicle pulling due to misalignment — are not minor inconveniences. They represent serious safety hazards that endanger drivers, passengers, and the public. It is unacceptable for GMAC and General Motors to minimize or compartmentalize this issue when patterns clearly demonstrate a systemic steering component weakness in this model year. The presence of Recall 14V-246000 further demonstrates that the manufacturer was aware of tie rod-related risks ! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Air bags, Nov 4, 2025
Early October my passenger side airbag deployed and I was sitting in the drivers seat and had just put the key into the key hole but did not turn the key to start the vehicle. 3 weeks later I was going into the passenger side of the vehicle and the key was in my pocket and the drivers side airbag deployed. Both times the vehicle was not started and the airbags deployed I called GMC and they had the vehicle towed to a dealer to investigate why the airbags deployed. They said it was a sensor that was corroded and that’s why the airbags deployed. I asked GMC, why didn’t the sensor left the driver know that it was going bad, just like it notifies the driver if you have low tire pressure or needs an oil change. I had no notifications that the airbags were going to deploy. I’m so grateful that no one was driving the vehicle when they deployed. GMC said the vehicle is not safe to drive so they had it towed from my house to the dealership and then back to my house however they said they are not taking responsibility for the deployment and said it’s my responsibility to get the airbags fixed. I told GMC that I was filing a complaint with you all. Thank you for looking into this matter.
Engine, Aug 18, 2025
The contact owns a 2009 GMC Sierra 1500. The contact stated that while driving at highway speeds, the vehicle hesitated while depressing the accelerator pedal. The traction control and check engine warning lights were illuminated. The contact used a code reader and discovered a misfire in cylinder #4, and performed a compression test, which verified that cylinder #4 was failing to maintain compression. The vehicle was taken to a dealer where it was discovered that there was a failure with the lifter in cylinder #4. The vehicle was not repaired and remained with the dealer for additional diagnostic tests. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 56,000.
Engine, Jun 18, 2025
To Whom It May Concern, I am submitting this report regarding repeated engine and valve lifter failures in my 2009 GMC Sierra 1500 with a 5.3L V8 engine, VIN: [XXX] . 1. Component/System Malfunctioned: Both the original engine and a replacement engine—professionally installed by a Chevrolet dealership—experienced valve lifter failure related to the Active Fuel Management (AFM) system. The most recent failure was sudden and unexpected. The engine may be available for inspection upon request. 2. Safety Risk: Engine failure puts driver and passenger safety at serious risk, particularly if the vehicle loses power unexpectedly while in motion. In both instances, the failure created unsafe driving conditions. 3. Reproduction/Confirmation: The issue was confirmed by a Chevrolet dealership during the initial engine failure and again more recently on the current engine, which is now exhibiting the same failure. 4. Inspection Status: The vehicle has been inspected by the same dealership that performed the original engine replacement. To my knowledge, it has not been inspected by GM corporate, police, or insurance representatives. 5. Warning Signs: There were no warning lamps, messages, or clear symptoms prior to the failure. The problem occurred without advance notice and did not provide an opportunity to address it before damage occurred. This is the second engine failure my truck has suffered from the same issue, even after dealership installation of a new motor. I urge the NHTSA to investigate whether this represents a broader defect in GM 5.3L AFM-equipped engines. It is unacceptable that repeated critical failures can occur in these engines with no warning and no resolution, even after following proper replacement procedures. Thank you for your attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Mar 11, 2025
Allison transmission - random hard shifts, random multiple DTC's, random limp mode. Clear codes and works fine until it doesn't. Might have to clear codes 3-4 times a day or it might make it a week before it goes into limp mode again.
Air bags, Dec 23, 2024
General Published an article about the Takata Airbag recall stating that the dashboard would be inspected prior to doing the recall work and if already cracked or damaged the dashboard would not be replaced. My dash board is like new with no damage or cracks. The dealer told me (contrary to this article) that if their service men damaged my dashboard while doing the recall replacement I would be responsible for any replacement even if my dashboard is in perfect condition prior to the work. I find this unacceptable and will not have my airbag replaced under these conditions. The dealer/GM should be responsible for any damage they cause during the repair.
Electrical system, Jan 7, 2024
TCM and electrical transmission grounded out TCM IN MY RESEARCH a lot of people are having issues with these. Dealers are of no help “backordered” so having to rebuild them. This is an expensive failure!
Electrical system, Jul 31, 2023
While driving on Saturday, July 29th, I went to make a right turn @ intersection of Nottingham Way onto Ledo Rd. The vehicle started jerking and suddenly shutoff. I had no power steering, No power brakes. I had to manually steer and stop the truck into the median, while avoiding oncoming traffic. I got the vehicle to stop. I tried to restart and the engine turned over, but would not start. I contacted the local Chevrolet dealership, and was told they don't work on anything older than 2013 vehicles. I had the truck towed to the house. After further investigation, there was a service bulletin 14515B, that replaced 14515A. The Safety recall stated CHASSIS ELECTRONIC CONTROL MODULE INTERNAL CONTAMINATION. So GM is aware of this issue, that could have caused an accident. The local dealership is denying that my truck is involved in this recall. They knew of the problem and never contacted me about this issue. This is a severe SAFETY issue. GM should be responsible for repairing a defective Control module as they knew of contamination as of January 2015. This almost cause multiple head on collisions.
Other or unspecified, May 2, 2023
Door panel gets loose over time catching on inside of door frame making it difficult to open a door. This is a safety hazard in the case of an emergency so I removed my door panel completely.
Air bags, Apr 25, 2023, crash
The contact's father owns a 2009 GMC Sierra. The contact stated that while his father was making a left turn at 20 MPH, another vehicle from the opposite direction ran the red light and struck the contact's father's driver's side front end. The TPMS warning light was illuminated. None of the air bags deployed upon impact. The contact's father suffered rib, pelvis, and spine fractures and was transported to the hospital by ambulance. A police report was filed. The vehicle was towed to a tow yard but was not yet inspected or deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Air bags, Feb 16, 2023
The contact owns a 2009 GMC Sierra. The contact stated that while driving at an undisclosed speed, the air bag warning light was illuminated. The contact related the failure to Technical Service Bulletin Number - 09184C (Material Over Sensing and Diagnostic Module Retaining Moisture) . The vehicle was taken to a dealer, where it was diagnosed as a corroded air bag control module. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.
Electrical system, Exterior lighting, Vehicle speed control, Jan 13, 2023
Dashboard instrument panel all lights and gauges goes out while driving down the road when vehicle is turned off a clicking noise is made in the dash. This issue causes when driving down the road, not knowing the speed because the speedometer is out or how much gas the vehicle has, or any other readings, and at night all lights go out, not able to see while driving down the road.
Power train, Dec 8, 2022
Yes, the airbag has not been replaced but I have another SERIOUS SAFETY PROBLEM with this vehicle: The stabilitrak system does NOT work, it is NOT POSSIBLE to shift into gear, if the vehicle is put into use there is a definite possibility that the truck will go into LIMP MODE with a very limited speed (20 mph?) while trying to keep up with the traffic flow at 75+mph while the. transmission searches for which gear and wheel to apply power. This is a frightening experience to say the least. And I am without my work truck (and work) for more than 4 months because GMC has no ETA for parts to repair this problem. I guess this is NOT. safety issue in reality since I cannot/ will not drive this piece of dangerous GENERAL MOTORS engineering nightmare. When I search for solutions to this problem I find that there are many many GM vehicles (cars,suvs,vans, trucks) experiencing the same SERIOUSLY DANGEROUS situations. It is time to investigate this company before it shutters its doors and moves offshore to leave their junk in the United States without responsibility for repairs or accidents. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Electrical system, Oct 5, 2022
My dashboard instrument cluster has been going in and out since iv owned the vehicle in February of 2022 and iv replaced fuses did the reset test and everything on it and nothing I can’t see my speed rpm’s gas gauge nothing all the lights are on but nothing else moves or comes on I can’t even tell the speed I’m going or if I even have enough gas in the truck to even make it to a store I have add electrical problems since day one with the truck and replaced so many fuses for everything and nothing work’s really even my alarm system don’t work
Suspension, Aug 29, 2022
I own the 2009 GMC this truck was bought new by me and it only has 41,000 miles on a 13 year old truck it is very well maintained. Both upper shock mounts rusted off and the rear spring shackles have holes in them I had a service center look at it and he said there maybe not enough metal to weld to. The whole frame and cross members are badly rusted and although it is not a safety issue both cab corners are rusting out, and the left rear wheel opening I really feel there is no reason any vehicle should rust so bad and be undriveable.
Air bags, Aug 11, 2022
2009 GMC SIERRA. CONSUMER WRITES SEEKING REIMBURSEMENT FOR REPAIRS RELATED TO TAKATA AIRBAG SAFETY RECALL. THE CONSUMER STATED THE AIRBAG LIGHT ILLUMINATED. THE DEALER STATED THE AIRBAG RECALL HAD ALREADY BEEN PERFOMED ON THE VEHICLE. THE CONSUMER PAID TO HAVE THE AIRBAG SENSOR REPAIRED.
Structure, Jul 25, 2022
Dashboard cracked
Structure, Jan 29, 2022
The dash is cracked and busted to the point it rattles no matter what road you are on. The dash was maintained. Just cheap plastic in an expensive truck. The defrost grille is totally broke out. GM should take care of this problem if they want repeat business.
Air bags, Nov 4, 2021, crash
The contact owns a 2009 GMC Sierra 1500. The contact stated while driving at 45 MPH, he crashed into the driver's side of another vehicle. The air bags failed to deploy. The contact did not know whether a warning light illuminated. A police report was filed. The contact did not sustain any injuries and drove the vehicle to his residence. The dealer was notified of the failure and informed the contact that they could not assist with the air bags failure unless he had a recall notification. The contact also stated while driving at 40 MPH, his vehicle crashed into the rear of another vehicle and the air bags failed to deploy. There were no warning lights illuminated. The contact did not sustain any injuries and drove to his residence. A police report was not filed. The contact stated that another vehicle crashed into the rear of his vehicle. The air bags did not deploy. There were no warning lights illuminated. The contact did not sustain any injuries. A police report was filed. The contact was able to drive to his residence. The contact stated while driving at 75 MPH on a wet road, the brake pedal was depressed and the front and rear tires inadvertently locked. The vehicle slid off the road and crashed into a tree. The air bags failed to deploy. There were no warning lights illuminated. The contact stated that he did not sustain any injuries and drove to his residence. A police report was not filed. The contact received a recall notification for NHTSA Campaign Number: 21V052000 (AIR BAGS) for the front passenger air bag only. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failures. The approximate failure mileage was 40,000.
Structure, Oct 27, 2021
My truck was bought new by my cousin and not even a year having it the frame started rusting badly. Now we own it & it is scary to drive the frame is so bad rusted. We have put so much money into it it’s ridiculous & cant afford to anymore. It’s a danger for my family to drive it. I’m scared to drive my 8 year old in it. It’s causing more than the frame to rust. We’ve replaced gas lines, brake lines & so much more. I wished GMC would fix this problem & repair all vehicles this has happened to.
Air bags, Oct 18, 2021
Received a air bag recall notice . I scheduled a appointment with Hall Buick GMC in Tyler Texas 10-18-21 at 11:00 am . We showed up to service Dept. The young guy checking us in told us that 92% of the time they will crack the dash when getting it removed to do the the air bag recall work and the dealer is not responsible for any damage. I told him to get his manger so he did. We talked to service manger John Mackey he told use the same thing that the dealer is not responsible for any damage done to the dash like cracks or breakage while doing air bag recall work. I told him as you can see this truck has been garage kept since new and not in the sun. He said I can see that . I told him per the paper work I received if not fixed it may cause serious injury or death to passengers .Who's going to pay for that. He said GM and Takata. Is there any one that can do the air bag recall work without damaging the dash.
Air bags, Oct 14, 2021
The contact called on behalf of a GM dealer where he is employed. He stated that a customer had dropped off his 2009 GMC Sierra to be serviced for NHTSA Campaign Number: 21V052000 (Air Bags). As the vehicle sat on the dealer lot with the engine off, the contact witnessed both the passenger and driver side air bags deploy without incident. The manufacturer was notified of the failure and a case was filed. The vehicle had yet to be repaired. The failure mileage was 68,895.
Electrical system, Vehicle speed control, Other or unspecified, Aug 30, 2021
Transmission Control Module Since the summer of 2020 the vehicle has at least half a dozen times, without warning, experienced the following symptoms (most recently July 27, 2021 when I captured it on video). 1. power door locks begin cycling open and closed 2. intermittent chime operation 3. transmission locks into a single gear and won't shift or will shift harshly 4. gauges fluctuate 5. traction control and stabilitrak turn off 6. service traction control and service stabilitrak messages appear 7. transmission position indicator disappears
Other or unspecified, Aug 29, 2021
Dash cracked. A known problem for these vehicles
Other or unspecified, Aug 25, 2021
Dashboard has cracked right in the middle. Happened overnight.