2017 Grand Design Reflection
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 25 owner complaints filed for this model year. This is the 2nd highest complaint count among 10 Reflection model years with reports.
Of the 2017 reports, 1 involved a fire.
What owners report most often
Recalls and investigations
Equipment, appliance, refrigeratorJan 28, 2022
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
An electrical arc increases the risk of a fire.
Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
Campaign 22V038000 on NHTSA.gov
Electrical system, wiringJun 19, 2020
Grand Design RV, LLC (Grand Design) is recalling certain 2016-2018 Reflection trailers. A wiring connector in the vehicle underbody may not be properly secured, allowing water intrusion into the wiring connector, possibly resulting in an electrical short circuit.
If water enters the wiring connector, it can cause a short circuit, increasing the risk of a fire.
Grand Design will notify owners, and dealers will inspect and secure the wiring connectors up to prevent water intrusion, free of charge. This recall began June 29, 2020. Owners may contact Grand Design's customer service at 1-574-825-9679. Grand Design's number for this recall is 910020.
Campaign 20V362000 on NHTSA.gov
Equipment, mechanical, integrated jack/leveler/stabilizerDec 8, 2017
Grand Design RV, LLC (Grand Design) is recalling certain 2017-2018 Reflection and Imagine travel trailers equipped with a Smart-Jack model power tongue jack. The laminated plastic touch pad on the jack may crack or separate allowing water to enter, potentially causing the jack to operate unintentionally.
If the tongue jack retracts or extends unexpectedly, there could be an increased risk of a crash or injury.
Grand Design will notify owners, and dealers will replace the power tongue jack, free of charge. The recall began on December 29, 2017. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 900012.
Campaign 17V789000 on NHTSA.gov
Equipment, other, labelsOct 7, 2016
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2017 Reflection recreational trailers, model 357BHS and 367BHS, manufactured November 12, 2014, to September 22, 2016. The affected vehicles have an incorrect Gross Axle Weight Rating (GAWR) on the Federal Certification Label, stating a GAWR of 7,000 lbs when the actual GAWR is 6,400 lbs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
If the operator loads the vehicle to the GAWR on the label, it can cause a loss of vehicle control, increasing the risk of a crash.
Grand Design will notify owners, and dealers will install a corrected Federal Certification Label, free of charge. Owners will also have the option to replace the Certification Label themselves, free of charge. The recall began on October 28, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910007.
Campaign 16V717000 on NHTSA.gov
Equipment, recreational vehicle/trailer, lpg systems, lines and fittingsMay 25, 2016
Grand Design RV, LLC (Grand Design) is recalling certain model year 2016-2017 Imagine and Reflection recreational trailers manufactured January 15, 2016 to May 4, 2016. The MB Sturgis LP regulator on these vehicles may allow propane gas to leak into the regulator sight glass causing it to degrade and potentially crack.
If the indicator sight glass cracks, propane gas may leak out, increasing the risk of a fire.
Grand Design will notify owners, and dealers will replace the LP regulator kit, free of charge. The recall began on June 6, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910006.
Campaign 16V355000 on NHTSA.gov
Representative owner complaints: service brakes
18 reports, newest first. Show all
Service brakes, Feb 19, 2021
INTERMITTENT BRAKES (LOST BRAKES) ON FIFTH WHEEL DUE TO THE USE OF UNDERSIZE WIRE AND OVERUSE OF SCOTCHLOK GUILLOTINE CONNECTORS. EACH BRAKE HAS A MAXIMUM CURRENT DRAW OF 4AMPS. 4X4 = 16 AMP POSSIBLE DRAW ON 14 AWG WIRE AT APPROXIMATELY 60+ FOOT LOOP ROUND TRIP FROM PIN BOX TO BRAKES BACK TO PIN BOX. THIS IS AN EXTREMELY DANGEROUS SITUATION. THE BRAKE WIRING IS SUBSTANDARD IN EVERY CONCEIVABLE WAY. SHOULD BE AT LEAST CONNECTED 10AWG USING CRIMPED BUTT SPLICES AND CIRCLE CONNECTORS. IT WOULD ALSO HELP TO HAVE A GROUND BOND AT THE AXLE TO REDUCE THE LOOP BY 50%. SOMEDAY SOMEONE WILL DIE (PROBABLY HAVE ALREADY) BECAUSE OF CHEAP UNDERSIZED WIRE WITH CHEAP GUILLOTINE CONNECTORS EVERYWHERE. FOR LIGHTS OK FOR BRAKES? NEVER!*DT*JB
Service brakes, Jun 29, 2019
TWO SEPARATE ISSUES: 1. LIPPERT WHEEL BEARINGS LEAKED GREASE ALL OVER THE DRUM BRAKES WITH LESS THAN 4000 MILES. LIPPERT REFUSED TO PAY FOR REPAIRS BECAUSE IT HAS BEEN MORE THAN ONE YEAR. 2. WITH BRAND NEW BRAKES PROPERLY ADJUSTED, BRAKES ARE STILL VERY WEAK. APPLYING 12 VOLTS FROM BRAKE CONTROLLER RESULTS IN MINIMAL BRAKING. SUSPECT UNDERSIZED FINAL WIRING TO BRAKES (20 GAUGE). BRAKES HAVE BEEN UNDERPERFORMING SINCE DAY 1. *DT*JB*DT*JB
Service brakes, Aug 9, 2018
DURING MOSTLY HIGHWAY TRAVEL WITH OUR CAMPER THE AXLE GREASE SEALS FAILED WHICH ALLOWED GREASE TO CONTAMINATE THE BRAKE SHOES AND BRAKE DRUMS AFFECTING BRAKING PERFORMANCE. REVIEWING OTHER POSTS ON-LINE A LOT OF OTHER OWNERS OF THESE CAMPERS ARE EXPERIENCING THE SAME PROBLEM, WHICH IS A SIGNIFICANT SAFETY ISSUE.
Service brakes, Aug 18, 2017
THE BRAKES, SEALS AND BEARINGS ON MY 5TH WHEEL TRAVEL TRAILER WILL HAVE TO BE REPLACED FOR THE THIRD TIME DUE TO THE SEALS LEAKING GREASE ONTO THE BRAKES. ALL FOUR BACKING PLATES, THE FRONT TWO HUBS AND ALL FOUR GREASE SEALS AND BEARINGS WERE REPLACED ON OUR FIRST TRIP AFTER TAKING POSSESSION OF THE FIFTH WHEEL IN MAY 2017. THIS WAS DONE AT A CAMPING WORLD DEALERSHIP IN NORTH CAROLINA AND RESULTED IN BEING WITHOUT THE USE OF OUR TRAILER FROM MAY 18 ' 23. ON OUR SECOND TRIP, STARTING ON JULY 9, 2017, THE BRAKES AGAIN BEGAN PERFORMING POORLY. RAY DUFFY, OF GRAND DESIGN, ARRANGED TO HAVE THEM INSPECTED IN WEST YELLOWSTONE, MONTANA ON JULY 14, 2017 AT JAKE'S AUTOMOTIVE. HE PRE-SHIPPED REPLACEMENT PARTS IN ANTICIPATION OF BAD SEALS. THE TECHNICIAN AT JAKE'S AUTOMOTIVE FOUND GREASE CONTAMINATION ON THE RIGHT FRONT, RIGHT REAR AND LEFT REAR BRAKES. HE ALSO FOUND THAT THOSE SEALS AND BEARINGS HAD SEPARATED FROM THE HUBS AND REMAINED ON THE SPINDLE WHEN THE HUBS WERE REMOVED. THE RECEIPT STATES, 'HAD TO REPLACE 3 OF FOUR BACKING PLATES AND HARDWARE DUE TO WHEEL SEALS BLOWING OUT.' THE FOURTH WHEEL, THE LEFT FRONT, WAS NOT REMOVED OR INSPECTED BY THE REPAIR FACILITY SINCE THEY DID NOT HAVE REPLACEMENT PARTS AVAILABLE AND THEY WERE CONCERNED THAT REMOVAL OF THE WHEEL COULD DAMAGE THE GREASE SEAL. I REMOVED ALL FOUR HUBS TODAY. THE INTERIORS OF THE TWO LEFT HUBS WERE COMPLETELY COATED WITH GREASE. THE LEFT FRONT WAS WORSE THAN THE LEFT REAR. THE TWO RIGHT HUBS DID NOT HAVE AS MUCH GREASE ON THEM AND WERE EVIDENTLY DOING THE MAJORITY OF THE BRAKING. THE INSIDE OF BOTH HUBS WERE PRETTY SEVERELY SCORED BY THE MAGNETS AND NEED TO BE REPLACED. ALL FOUR GREASE SEALS AND THE INNER BEARINGS STAYED ON THE SPINDLES WHEN THE HUBS WERE REMOVED. SINCE THE SEALS ARE SUPPOSED TO BE PRESSED IN, I FOUND THEIR REMAINING ON THE SPINDLES PROBLEMATIC.
Service brakes, Aug 16, 2017
BRAKES WERE NOT WORKING VERY WELL, WITH THE TRAILER BRAKE CONTROLLER GAIN IN MY TRUCK SET AT 10.0 (FULL ON). PROBLEM WAS CAUSED BY LEAKING AXLE SEALS ON THE PASSENGER SIDE OF THE VEHICLE WHICH RESULTED IN THE BRAKE SHOES AND DRUMS BEING COATED WITH AXLE GREASE. ALL FOUR BRAKE ASSEMBLIES AND AXLE SEALS WERE REPLACED BY THE DEALER UNDER WARRANTY.
Service brakes, Jul 22, 2017
3 OF 4 WHEELS HAD GREASE LEAKING FROM THE INNER HUB SEAL ONTO THE BRAKE SHOES AND DRUMS, WITH LOSS OF BRAKING POWER. ALL BRAKES HAD TO BE REPLACED.
Service brakes, Jul 1, 2017
THE AXLES/BRAKE ASSEMBLIES HAD DEFECTIVE INTERIOR SEALS. THE SEALS FAILED AND CONTAMINATED THREE OUT OF FOUR BRAKES WITH GREASE. THIS NEARLY CAUSED ME TO HAVE A SERIOUS ACCIDENT DUE TO UNABLE TO STOP THE TRAILER TO AVOID VEHICLE THAT PULLED OUT IN FRONT OF ME. I HAD TO RUN OFF ROAD TO AVOID ACCIDENT. THIS IS A KNOW ISSUE WITH LIPPERT COMPONENTS THAT THEY CONTINUE TO TRY TO DENY. I ATTACHED TWO PHOTOS OF WHAT I FOUND IN THREE OUT OF FOUR BRAKE HUBS UPON INSPECTION.
Suspension, Service brakes, Jun 9, 2017
WHEEL BEARING GREASE TOO THIN AND LEAKS PAST SEALS CONTAMINATING BRAKE MAGNETS AND BRAKES. MANY CUSTOMERS IMPACTED BASED ON FACEBOOK GROUP POSTS.
Service brakes, May 27, 2017
AXLE SEAL LEAKED CAUSING GREASE TO LEAK ONTO BRAKE FRICTION SURFACE, GREATLY REDUCING BRAKING ABILITY. PROBLEM WAS FOUND DURING OWNERS SELF INSPECTION. THIS PROBLEM WAS BROUGHT TO MY ATTENTION FROM THE GRAND DESIGN OWNERS FORUM. "HTTP://WWW.GRANDDESIGNOWNERS.COM/FORUM/SHOWTHREAD.PHP/8531-POLL-HOW-MANY-OF-YOU-HAVE-HAD-YOUR-GREASE-SEALS-FAIL "
Wheels, Equipment, Service brakes, Mar 3, 2017
WITH LESS THAN 3000 MILES, THE WHEEL GREASE SEALS HAVE LEAKED CONTAMINATING THE TRAILER BRAKES. RESULTED IN REDUCED BRAKING ABILITY. POTENTIAL SAFETY PROBLEM REDUCING TRAILER BRAKES EFFECTIVE STOPPING POWER.
Other or unspecified, Service brakes, Mar 2, 2017
WE WERE ON A TRIP FROM CALIFORNIA TO TEXAS AND THE GREASE SEALS ON ALL 4 WHEELS FAILED AND CONTAMINATED THE BRAKES. I HAVE OWNED THE VEHICLE FOR 1 MONTH AND IT HAD LESS THAN 1,200 MILES ON IT.
Equipment, Service brakes, Feb 23, 2017
WHEEL GREASE SEALS ARE LEAKING ON THE NEW TRAILER (2 OF 4 SEALS). THIS IS A NEW TRAILER AND I HAVE ONLY PUT ON ABOUT 50 MILES. THERE HAS BEEN NUMEROUS COMPLAINTS ON THIS ISSUE WITH GRAND DESIGN TRAILERS.
Service brakes, Feb 18, 2017
LEAKING GREASE SEALS ON BOTH PASSENGER SIDE AXLES CONTAMINATING BRAKE SHOES. I HAD DEALER PULL THE BRAKE DRUMS PRIOR TO DELIVERY OF OUR NEW TRAILER AND WE FOUND GREASE CONTAMINATION. THE TRAILER ONLY HAD BEEN TRANSPORTED FROM INDIANA TO FLORIDA DEALER.
Service brakes, Jan 20, 2017
THIS NEW VEHICLE, A 9000 LB UVW, WAS DELIVERED WITH BRAKES CONTAMINATED WITH GREASE RENDERING THEM INEFFECTIVE AND CREATING AN UNSAFE CONDITION. NO ACCIDENT OCCURED. THE BRAKES ARE GOING TO BE REPLACED. WHEEL BEARING GREASE BREACHED THE HUB SEALS, CONTAMINATING THE BRAKE DRUMS AND BRAKE SHOES.
Service brakes, Jan 3, 2017
JUST PURCHASED AN NEW TRAVEL TRAILER. MANY, MANY REPORTS OF LCI AXLE SEALS LEAKING AND DISPERSING GREASE ON BRAKE ASSEMBLIES. SURE ENOUGH, DEALER HAD TO REPLACE TWO OF FOUR BRAKE ASSEMBLIES, AS WELL AS ALL FOUR SEALS AS THEY ALL HAD LEAKED (TRAILER WAS NEW, JUST DROVE TO DEALER FROM FACTORY). THIS ISSUE NEEDS TO BE CORRECTED BEFORE SOMEONE IS HURT.
Service brakes, Dec 17, 2016
A JUST PURCHASED NEW REFLECTION 337RLS THAT HAS A 11/30/16 DATE IN THE VEHICLE INFORMATION SHEET AND 11/24/16 DATE ON THE SERIAL NUMBER DATA SHEET. THE ONLY MILES ON THE UNIT WERE THE DELIVERY MILES FROM THE PLANT TO THE DEALER IN COLORADO AND THE ~400 MILES ADDED TO THOSE. ON THE TRIP HOME (THE 400 MILES), THE ELECTRIC BREAKS BECAME SIGNIFICANTLY LESS EFFECTIVE TO THE POINT WHERE THE BRAKE CONTROLLER GAIN HAD TO BE SET TO ITS MAXIMUM LEVEL RESULTING IN LIMITED 5TH BREAKING. THE DISCOVERY WAS SIGNIFICANTLY NERVE-RACKING AS DISCOVERY HAPPENED WHEN EXITING THE INTERSTATE AT 65MPH AND A DOWN HILL RAMP! AT THAT TIME, THE GAIN ON THE BRAKE CONTROLLER WAS SET TO THE PREVIOUS SUFFICIENTLY WORKING LEVEL OF 5 (50% OF MAX). AFTER FURTHER INVESTIGATION, THE GREASE SEALS WHERE DISCOVERED TO BE BAD ON BOTH AXELS. THIS IS A VERY DANGEROUS ISSUE AS DISCOVERY OF A LACK OF BRAKES ON THE TOWED VEHICLE CAN OCCUR AT ANYTIME WITHOUT WARNING.
Service brakes, Oct 31, 2016
AT 1,850 MILES, THE BRAKES ON THIS UNIT WERE COMPLETELY SATURATED IN WHEEL BEARING GREASE CAUSING THEM TO BECOME INEFFECTIVE AT EVEN THE HIGHEST BRAKE CONTROLLER SETTING. ALL FOUR BRAKES WERE AFFECTED. A TRAILER OF THIS SIZE IS REQUIRED TO HAVE FUNCTIONING BRAKES. THE BRAKES ARE DESIGNED THAT THEY WILL STOP THE VEHICLE IF THE TRAILER BREAKS AWAY FROM THE TOW VEHICLE BY ACTIVATING A BATTERY CONTROLLED BREAK AWAY SWITCH. HOWEVER, SINCE THE BRAKES ARE CONTAMINATED WITH GREASE, THE VEHICLE WILL NOT BE ABLE TO STOP IN A SAFE DISTANCE. THIS IS MY SECOND GRAND DESIGN VEHICLE EQUIPPED WITH LIPPERT MANUFACTURED BRAKES THAT ARE CONTAMINATED WITH GREASE.
Suspension, Service brakes, Oct 30, 2016
GREASE LEAKING FROM AXLE SEALS WITH EXTENSIVE CONTAMINATION OF BRAKES ON 2 OUT OF 4 WHEELS. A 3RD WHEEL IS JUST STARTING TO SHOW SIGNS OF GREASE LEAKING PAST SEAL WITH ONLY THE START OF CONTAMINATION OF BRAKE PAD. LIPPERT AXLE AND BRAKE ASSEMBLIES. APPROXIMATELY 3,420 MILES SINCE MANUFACTURE OF TRAILER IN JUNE 2016. SAFETY CONCERN IS LOSS OF BRAKING ABILITY ON A TRAILER WITH A GVWR OF 11,995 LBS. CONTAMINATION NOTED ON OCTOBER 30, 2016 WHEN OWNER PERFORMED INSPECTION OF AXLE AND BRAKE ASSEMBLIES AFTER LEARNING OF NUMEROUS OTHER OWNERS WITH SIMILAR ISSUES ON THE ONLINE GRAND DESIGN OWNERS FORUM.