2006 Honda Pilot
Problems, recalls and owner-reported issues
Air bags is the leading concern among 268 owner complaints filed for this model year. This is the 12th highest complaint count among 23 Pilot model years with reports.
Of the 2006 reports, 23 involved a crash and 7 involved a fire. 119 people were injured and 99 people died.
What owners report most often
Recalls and investigations
Vehicle speed control, accelerator pedalOct 10, 2019
Dorman Products, Inc. (Dorman) is recalling certain Accelerator Pedal Assemblies part numbers 699-114 and 825-5029-1, sold as replacement parts for 2003-2006 Acura MDX, 2004-2008 Acura TL and TSX, 2003-2007 Honda Accord, 2005-2006 Honda CR-V, 2007-2011 Honda Element, 2005-2008 Honda Pilot and 2006-2014 Honda Ridgeline vehicles. The rotating portion of the accelerator pedal assembly may bind. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 124, "Accelerator Control Systems."
If the accelerator pedal binds, the engine may not quickly return to idle after the pedal is no longer pressed, increasing the risk of a crash.
Dorman will notify owners, and qualified service facilities will replace the affected accelerator pedal assemblies, free of charge. The recall began December 9, 2019. Owners may contact Dorman customer service at 1-800-523-2492, using option 5. Dorman's number for this recall is AS1019XXXX.
Campaign 19E068000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleJun 27, 2019
Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Honda will notify owners, and dealers will replace the passenger frontal airbag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are E5D and X5C.
Campaign 19V501000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleJun 27, 2019
Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are Q5A and Y58.
Campaign 19V499000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleMar 6, 2019
Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.
An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.
Honda will notify owners, and dealers will replace the driver's air bag inflator with an alternate inflator, free of charge. The recall began April 10, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is O41. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is U40.
Campaign 19V182000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleApr 26, 2018
Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.
An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.
Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.
Campaign 18V268000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleJan 10, 2017
Honda (American Honda Motor Co.) is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2011 Honda Element vehicles, 2005-2012 Acura RL vehicles, 2006-2012 Honda Ridgeline vehicles, 2007-2008 Honda Fit vehicles and 2005-2008 Honda Pilot vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, if not included in "Zone A" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2009 Acura RL and Honda Element vehicles, 2007-2008 Honda Fit vehicles, 2005-2008 Honda Pilot vehicles and 2006-2009 Honda Ridgeline vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, if not included in "Zone A" or "Zone B" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2008 Acura RL, Honda Element and Honda Pilot vehicles, 2007-2008 Honda Fit vehicles and 2006-2008 Honda Ridgeline vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Honda will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall bagan March 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KD9 and KE0.
Campaign 17V029000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleMay 23, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Honda is recalling certain model year 2003-2006 Acura MDX, 2005-2008 Acura RL, 2005-2006 Honda CR-V, 2003-2008 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2008 Ridgeline vehicles originally sold, or that have ever been registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Honda is recalling model year 2002-2004 Odyssey and model year 2003-2004 Acura MDX, Honda Element, and Honda Pilot vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began June 27, 2016. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KA0, KA1, KA2, and KA3.
Campaign 16V344000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleMay 28, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.
In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began on July 1, 2015. Owners may contact Honda customer service at 1-888-234-2138. Owners may contact Acura customer service at 1-800-382-2238, select option 4. Note: Vehicles that have had their driver frontal air bag replaced previously as part of a recall remedy prior to September 12, 2014 need to have their air bag replaced under this recall as well. Vehicles that, on or after September 12, 2014, received a remedy for a prior driver frontal air bag inflator recall already received an inflator of a different design, and therefore are not included in this recall and do not require additional servicing. Note: This recall fully supersedes recalls 08V-593, 09V-259, 10V-041, 11V-260, 14V-351 and 15V-153. Honda's numbers for this recall are JQ9, JR0, JR1, JR2, JR3, JR4, JR5, JR6, JR7, and JR8.
Campaign 15V320000 on NHTSA.gov
Equipment, mechanical, carrier/rackFeb 5, 2008
HONDA IS RECALLING 2,032 HITCH STYLE BIKE RACKS SOLD AS AFTERMARKET FOR USE ON MY 2003-2007 AND SOME MY 2008 HONDA PILOT, RIDGELINE, AND ACURA MDX VEHICLES. A PINCH BOLT EXISTS BETWEEN THE BIKE ARM BRACKET AND THE UPRIGHT ASSEMBLY OF THE "HITCH" STYLE BICYCLE RACK.
WHEN MOVING THE BIKE ARM BRACKET TO ITS DOWN POSITION, THIS PINCH BOLT HAS THE POTENTIAL OF CAUSING SEVERE LACERATION OR AMPUTATION TO THE USER'S FINGERTIPS OR HAND.
OWNERS SHOULD CONTACT THULE AT 800-THULE91 (800-848-5391) TO OBTAIN A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS OR OWNERS MAY CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238 FOR FURTHER INFORMATION.
Campaign 08E013000 on NHTSA.gov
Equipment, other, owners/service/other manualJul 26, 2006
ON CERTAIN PASSENGER VEHICLES AND MOTORCYCLES, THE OWNER'S MANUALS CONTAIN INCORRECT CONTACT INFORMATION FOR THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S (NHTSA) VEHICLE SAFETY HOTLINE.
THE LANGUAGE IN THE OWNER'S MANUALS IS NOT IN ACCORDANCE WITH THE CURRENT MANDATORY REQUIREMENTS.
HONDA WILL SEND A POSTCARD TO DEALERS AND OWNERS WITH THE CORRECT NHTSA VEHICLE SAFETY HOTLINE INFORMATION AND WITH INSTRUCTIONS TO INSERT THE CARD INTO THE "REPORTING SAFETY DEFECTS" SECTION OF THE OWNER'S MANUAL. THE RECALL BEGAN ON AUGUST 2, 2006. OWNERS MAY CONTACT HONDA AT 1-800-999-1009, ACURA AT 1-800-382-2238 OR HONDA MOTORCYCLES AT 1-866-784-1870.
Campaign 06V270000 on NHTSA.gov
Representative owner complaints
268 reports, newest first.
Structure, Mar 29, 2012
WET FLOORS IN FOOTWELL AREA. COMMON PROBLEMS ON MANY YEARS OF PILOT/RIDGELINE VEHICLES. HONDA REFUSES TO ADDRESS THIS ISSUE UNDER FACTORY BUMPER-BUMPER WARRANTY AND HONDACARE EXTENDED WARRANTY, YET HONDA IS AWARE AND ISSUED A TSB SURROUNDING FOOTWELL LEAKS. *JS
Service brakes, Hydraulic, Mar 15, 2012
I JUST BOUGHT A USED HONDA PILOT AFTER HAVING A BABY, NEEDING A BIGGER AND SAFER CAR FOR MY KIDS. 5 DAYS AFTER BUYING MY CAR THE VSA LIGHT CAME ON, SO I TOOK IT TO THE DEALERSHIP AND THEY SAID THEY FIXED IT.3 WEEKS LATER IT CAME BACK ON AND AS I WAS DRIVING WITH MY KIDS IN THE CAR ALL OF A SUDDEN FULL BRAKES WERE APPLIED FOR NO REASON. MY FOOT WAS NOT EVEN ON THE BRAKE PEDAL, THANK GOD NO ONE WAS BEHIND ME.I HAD NO IDEA WHY THAT HAD JUST HAPPENED. SO I WENT ONLINE TO RESEARCH WHAT THE VSA SYSTEM, NOT THINKING THE BRAKING HAD ANYTHING TO DO WITH THE VSA SYSTEM, THEN I COME ACROSS A HONDA FORUM AND FIND OUT THIS HAS HAPPENED TO ALOT OF OTHER PILOT OWNERS, AND THAT THE BRAKING IS CONNECTED TO THE VSA SYSTEM. THIS IS A DANGEROUS HAZARD AND SHOULD BE ADDRESSED ASAP BEFORE SOMEONE GETS KILLED. UNFORTUNATELY ALOT OF PEOPLE TAILGATE AND IF THIS WERE TO HAVE HAPPENED ON THE FREEWAY IT COULD HAVE BEEN DEADLY. I WILL ALSO BE WRITING A LETTER TO HONDA TO SEE IF THERE ANY KIND OF RECOURSE FOR US PILOT OWNERS. *TR
Service brakes, Hydraulic, Feb 28, 2012
TL* THE CONTACT OWNS A 2006 HONDA PILOT. THE CONTACT WAS DRIVING 10 MPH WHEN THE BRAKE PEDAL WAS DEPRESSED BUT THE BRAKES SEIZED AND FAILED TO RELEASE PROPERLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS CONFIRMED THAT THE VEHICLE STABILITY CONTROL NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 82,000.
Seats, Feb 21, 2012
WHILE DRIVING THE VEHICLE AT APPROXIMATELY 40MPH, THE PLASTIC SUPPORT CLIPS ON THE DRIVER'S SEAT BACK PANEL DISLODGED AND THE SEAT PANEL FELL OFF COMPLETELY. I TRIED TO REATTACH THE PANEL BUT THAT FAILED. I CONTACTED THE DEALER (CONCERNING THIS AND ANOTHER ISSUE) AND AFTER BEING TOLD THAT IT WAS MY FAULT, THE DEALER OFFERED TO REPLACE THE BACK PANEL AS A "GOOD WILL" GESTURE. THE PANEL WAS REPLACED (NEW). I NOTICED THAT THE FIT WAS NOT CORRECT AND MENTIONED THAT TO THE DEALER, BUT WAS TOLD THAT WAS THE BEST THEY COULD DO AND WITHIN THREE WEEKS THE SAME THING HAPPENED. I, AGAIN, CONTACTED THE DEALER, AND THEY ORDERED A NEW PART, AGAIN, AND REPLACED IT. I AM STILL NOT HAPPY WITH THE "FIT" OF THE PART. I HAVE HAD THE SEAT PANEL REPLACED FOR ABOUT 3-4 WEEKS NOW AND IT HAS NOT FALLEN OFF YET. HOPEFULLY THIS WILL BE THE END OF MY ORDEAL. *TR
Seats, Jan 19, 2012
TL* THE CONTACT OWNS A 2006 HONDA PILOT. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE PLASTIC SUPPORT CLIPS DISLODGED FROM THE FRONT DRIVER'S SEAT BACK PANEL AND RESULTED IN THE PANEL BECOMING PARTIALLY DETACHED. THE FAILURE WOULD OCCUR WHENEVER THE VEHICLE WAS IN MOTION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE SUPPORT CLIPS WERE REPLACED. MOST RECENTLY, THE SIMILAR FAILURE RECURRED AND THE CONTACT PURCHASED A NEW BACK PANEL FOR THE FRONT DRIVER'S SEAT TO REPLACE THE DEFECTIVE ONE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 02/06/12*BF THE CONSUMER STATED THE REPAIR TO THE CLIPS WERE MADE BY THE DEALER TWICE WITHIN TWO YEARS. THE CONSUMER WAS INFORMED IF THEY REPLACED THE CHEAP PLASTIC CLIPS, IT WOULD FALL AGAIN SINCE THE PLASTIC SLOT WHERE THE CLIPS SLIDE INTO BECOME BENT EACH TIME IT FALLS OUT. THE PANEL FALLS OFF SPONTANEOUSLY WITHOUT ANY WARNING. UPDATED 02/10/12
Structure, Latches/locks/linkages, Dec 22, 2011
THE REAR DOOR/HATCH OF OUR 2006 HONDA PILOT HAS AN ISSUE WITH THE LATCHING MECHANISM. THE ACTUAL MECHANISM ON THE REAR HATCH HAS BECOME DISCONNECTED FROM THE FRAME AND IS ABLE TO MOVE FREELY ABOUT. THIS CAUSES THE REAR HATCH TO NOT LATCH, LATCH PARTIALLY, OR LATCH BUT STILL ALLOW THE REAR HATCH TO SLIGHTLY MOVE. THE LATCHING MECHANISM IS ONLY BEING HELD IN PLACE (IN A CONFINED AREA) BY THE PLASTIC PANELING OF THE CAR. SINCE THE LATCH IS NO LONGER ATTACHED TO THE FRAME, THE MOVEMENT OF THE MECHANISM DETERMINES IF THE REAR HATCH IS GOING TO LATCH OR NOT. WHEN IT IS LATCHED, THE ONLY ITEM SECURING THE MECHANISM IS THE PLASTIC PANELING. THE MECHANISM ITSELF IS NOT DEFECTIVE OR BROKEN HOWEVER; THE WAY THE MECHANISM HAS BEEN SECURED SEEMS TO BE THE ISSUE. THE MOST CONCERNING ASPECT IS HOW A DOOR LATCH MECHANISM COULD BECOME DISCONNECTED AND ALLOW FOR AN INCIDENT TO POSSIBLY OCCUR. *TR
Electrical system, Other or unspecified, Oct 25, 2011
LOUD POPPING NOISE COMING FROM REAR SPEAKER WHEN STARTING THE VEHICLE. ON AND OFF FOR YEARS NOW. *TT
Electrical system, Oct 22, 2011
ON MULTIPLE TIMES, WHEN I START THE IGNITION, A LOUD NOISE COMES FROM THE REAR STEREO SYSTEM SPEAKER. IT ONLY HAPPENS WHEN THE IGNITION IS TURNED ON. IT HAPPENS 50% OF THE TIME WHEN THE VEHICLE IS STARTED. IT IS ANNOYING BUT I READ THAT SOMEWHERE THAT THIS COULD BE RELATED TO FAILED ANC (ACTIVE NOISE CANCELLATION UNIT) AND THE COST COULD BE $500. I FEEL THE MANUFACTURER SHOULD REPLACE THIS FREE OF COST. *TR
Electrical system, Seats, Sep 15, 2011
DRIVER'S SIDE SEAT WARMER GETS UNBEARABLY HOT! THE SEAT SEEMS TO ONLY WARM ON THE RIGHT SIDE, BUT IT IS EXTREMELY HOT!! *KB
Structure, Jul 8, 2011
TL* THE CONTACT OWNS A 2006 HONDA PILOT. THE CONTACT STATED THAT AFTER ROLLING DOWN THE REAR DRIVERS SIDE WINDOW, IT WOULD NOT ROLL BACK UP. A POPPING NOISE COULD BE HEARD COMING FROM THE WINDOW WHILE THE CONTACT ATTEMPTED TO ROLL IT BACK UP. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE ACTUATOR FOR THE WINDOW FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 86,912.
Engine and engine cooling, Vehicle speed control, Jun 5, 2011
I WAS BACKING UP OUT OF MY GARAGE IN MY 2006 HONDA PILOT WHEN THE VEHICLE SUDDENLY ACCELERATE. I HAD MY FOOT RESTING LIGHTLY ON THE BRAKE AND I WAS ABLE TO STOP THE VEHICLE SAFELY. I WAS THEN ABLE TO DRIVE OFF. *TR
Child seat, May 14, 2011
I INSTALLED MY RADIAN80SL REARFACING WITH LATCH TWO DAYS AGO -- I AM AWARE OF THE PROBLEMS IT'S BEEN HAVING IN CERTAIN VEHICLES SO I WAS EXTREMELY CAUTIOUS TO CHECK THAT IT WENT IN TIGHTLY, THE SUPERLATCH STRAP WAS NOT LOOSENING, THE ADJUSTER WAS NOT ON THE EDGE OF THE BELT PATH, THE TAB WAS NOT EASY TO PUSH DOWN, ETC. THE STRAP WAS COMPLETELY TIGHT AND I FELT I HAD A VEHICLE THAT WAS FREE OF PROBLEMS, SO I WENT AHEAD AND USED IT THAT WAY. (I TYPICALLY USE A SEATBELT INSTALL IN A DIFFERENT SEATING POSITION, BUT THE LATCH INSTALL IS EASIER.) TWO CHILDREN HAVE RIDDEN IN THE SEAT SINCE THEN -- 34 & 36LBS -- WITHOUT INCIDENT. TODAY I WENT TO REMOVE THE SEAT, AND NOTED THAT THE SUPERLATCH STRAP WAS LOOSE. I WOULD GUESS THERE WAS ABOUT AN INCH BETWEEN THE RADIAN ITSELF AND THE LATCH ADJUSTOR. I DO HAVE A PHOTOGRAPH IF NHTSA WOULD LIKE TO SEE THE EXACT EXTENT OF THE LOOSENING. I HAVE NOT YET CONTACTED SUNSHINE KIDS BUT WILL DO SO SHORTLY. I WILL ALSO BE INSTALLING SOLELY WITH THE SEATBELT FROM HERE ON OUT. (RELATED VEHICLE INFORMATION: MODEL YEAR=2006, MAKE=HONDA, MODEL=PILOT). *TR
Structure, Mar 14, 2011
2006 HONDA PILOT-SEVERE INTERIOR LEAK IN FRONT PASSENGER SIDE FLOORBOARD, EXTENDING TO DRIVER'S SIDE FLOORBOARD. UNKNOWN HOW LONG THIS HAS BEEN OCCURRING. THE CARPET IS SATURATED. THE CARPET PAD UNDERNEATH IS ALSO SATURATED. MILDEW, MOLD AND BODY RUST WILL DEVELOP. HONDA ISSUED SERVICE BULLETIN (07-010) FOR THIS PROBLEM ON FEB. 8, 2007. DEALER DISCLAIMS ANY RESPONSIBILITY FOR SERVICE BULLETIN WORK, DUE TO OUTSIDE OF THEIR 3 YEAR WINDOW. NO ACCIDENTS/ VEHICLE DAMAGE PRIOR TO FINDING SOAKED CARPET. REGULAR MAINTENANCE DONE PER MANUFACTURER'S SCHEDULE. VEHICLE STILL UNDER EXTENDED WARRANTY. LACK OF NOTICE ABOUT SERVICE BULLETIN CAN LEAD TO MOLD ISSUES, BY EXTENSION TO RESPIRATORY ISSUES. HONDA CAN PREVENT THIS POTENTIAL PROBLEM BY NOTIFYING OWNERS, NOT WAITING FOR THEM TO DISCOVER SATURATED, SOAKED, AND IN SOME INSTANCES FROZEN CARPET INSIDE THE CAR. *TR
Vehicle speed control, Mar 7, 2011, crash
TL* THE CONTACT OWNS A 2006 HONDA PILOT. THE CONTACT WAS ATTEMPTING TO ENTER A RESIDENTIAL DRIVEWAY TRAVELING 5 MPH WHEN THE VEHICLE SUDDENLY ACCELERATED CAUSING HER TO CRASH INTO HER HOME. AFTER THE CRASH, THE CONTACT NOTICED THAT THE CRUISE CONTROL WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER AND THE CONTACT WAS AWAITING THE RESULTS OF DIAGNOSTIC TESTING. THE CURRENT AND FAILURE MILEAGE WAS 45,000.
Engine and engine cooling, Power train, Mar 1, 2011
MY 2006 HONDA PILOT EXPERIENCED SUDDEN ACCELERATION THIS MORNING WHILE DRIVING AT ABOUT 25 MPH. THE ENGINE SUDDENLY REVVED UP AND THE AUTO LUNGED FORWARD. I APPLIED THE BRAKE BUT THIS DID NOT SLOW ME DOWN QUICKLY ENOUGH. I THEN MANAGED TO GET THE CAR IN NEUTRAL AND TAPPED THE GAS PEDAL UNTIL THE HIGH REVVING STOPPED. THE INCIDENT OCCURRED AT 11:00AM EASTERN MARCH 01, 2011, THE PILOT HAD 57789 MILES AT TIME OF INCIDENT. *TR
Air bags, Nov 5, 2010, crash
TL*THE CONTACT OWNS A 2006 HONDA PILOT. WHILE DRIVING 45 MPH, ANOTHER VEHICLE RAN A STOP SIGN AND CRASHED INTO THE CONTACT'S VEHICLE. A CHEMICAL ESCAPE FROM THE AIR BAGS THAT BURNED THE CONTACT'S RIGHT HAND. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE CONTACT CALLED THE MANUFACTURER WHO TOOK A COMPLAINT, BUT OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 50,800.
Vehicle speed control, Nov 1, 2010
TL*THE CONTACT OWNS A 2006 HONDA PILOT. THE CONTACT STATED THAT THE VEHICLE SUDDENLY ACCELERATED WHILE HE WAS MOVING INTO A PARKING SPACE AT LESS THAN 5 MPH. THE CONTACT WAS ABLE TO PREVENT THE VEHICLE FROM CRASHING BY SHIFTING INTO PARK. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 49,000.
Vehicle speed control, Oct 27, 2010, crash
TL* THE CONTACT OWNS A 2006 HONDA PILOT. THE CONTACT WAS DRIVING 25 MPH WHEN THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT STATED THAT THE FAILURE WOULD OCCUR SPORADICALLY AND ON NUMEROUS OCCASIONS. THE FAILURE CAUSED THE CONTACT TO BE INVOLVED IN TWO CRASHES. THE CONTACT WAS UNINJURED YET THE AIR BAGS DID NOT DEPLOY IN EITHER CRASH. THE VEHICLE WAS INSPECTED BY AN AUTHORIZED DEALER WHO WAS UNABLE TO LOCATE A FAILURE WITHIN THE VEHICLE. THE CONTACT STATED THERE WERE OTHER COMPLAINTS REGARDING THE SUDDEN ACCELERATION AND THE MANUFACTURER WAS NOT TAKING RESPONSIBILITY FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 60,000.
Suspension, Sep 24, 2010
VIBRATION ON 2006 HONDA PILOT I OWN A 2006 HONDA PILOT AWD. I HAVE MADE MANY COMPLAINTS ABOUT VIBRATION ON MY CAR TO HONDA DEALER AND HONDA HEADQUARTER, HOWEVER THEY CLAIM THEY DO NOT FEEL VIBRATION I FELT. I HAVE BEEN FOLLOWING WHAT OTHER PEOPLE ARE COMPLAINING ON LINE AND I AM NOT ONLY ONE. THERE ARE SO MANY OTHER OWNERS WHO HAS SAME PROBLEM AND WHO BEEN TOLD IT IS NATURE OF THAT CAR. I HAVE CHANGED MY TIRES AND ADD ACURA MDX MODIFICATIONS, IT IMPROVED HOWEVER VIBRATION STILL EXIST. HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F0F0758/0 THIS IS JUST ONE SITE AND THERE ARE MANY MORE. IS THERE ANY THING NHTSA CAN DO? OR DO WE HAVE TO JUST LIVE WITH IT? *TR
Air bags, Jun 22, 2010
TL* THE CONTACT OWNS A 2006 HONDA PILOT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 3 5 MPH, THE PASSENGER SIDE CURTAIN AIR BAG INDEPENDENTLY DEPLOYED. THE PASSENGER SUFFERED UNKNOWN INJURIES FROM THE AIR BAG DEPLOYMENT. THE DEALER ADVISED PERFORMED A DIAGNOSTIC BUT WAS UNABLE TO DETERMINE THE CAUSE OF THE AIR BAG DEPLOYMENT YET STATED THE FAILURE POTENTIALLY COULD HAVE BEEN CAUSED BY THE HOT WIRE FRONT THE FRONT END OF THE VEHICLE TO THE REAR POWER INVERTER. THE DEALER CUT THE AIR BAG FROM THE VEHICLE USING A RAZOR BLADE AND ADVISED THE CONTACT THE VEHICLE WAS SAFE TO DRIVE. THE MANUFACTURER ADVISED THAT THE FAILURE COULD HAVE BEEN CAUSED BY A TRAILER PACKAGE THAT WAS INSTALLED IN THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 66,971.
Vehicle speed control, May 28, 2010, crash
WAS PULLING INTO A PARKING SPOT IN A PARKING GARAGE GOING SLOW AND THE HONDA PILOT ACCELERATED ON ITS OWN, THE RPMS WENT UP AND SLAMMED INTO THE CEMENT WALL IN THE GARAGE IN LESS 5 SECONDS. THE AIRBAG DEPLOYED AND DAMAGE TO THE FRONT OF THE CAR. *TR
Other or unspecified, Mar 29, 2010
MY HUSBAND HAD 3 EPISODES OF SURGING WHILE EXITING HIGHWAYS OVER THE PAST YEAR OR SO IN MY 2006 HONDA PILOT. EACH TIME HE HAD TO PUT THE CAR IN NEUTRAL TO STOP IT. AFTER DRIVING AT SUSTAINED SPEED ON A HIGHWAY, I SLOWED TO PULL OFF AT THE EXIT RAMP, WHICH WAS AN INCLINE, AND THE CAR SUDDENLY SURGED FORWARD, THE ENGINE MADE A SOUND AS IF IT WERE RACING AND THE CAR WOULD NOT STOP EVEN WITH PUTTING MY RIGHT FOOT ON THE PEDAL AND APPLYING ALL THE STRENGTH OF BOTH FEET. I PUT THE CAR IN NEUTRAL AND IT DID STOP, BUT THE ENGINE CONTINUED TO ROAR. THE FLOOR MAT WAS NOT IMPEDING THE ACCELERATOR AND THE ACCELERATOR WAS NOT PUSHED DOWN, IT WAS IN THE PROPER POSITION. THE LOCAL HONDA DEALER EXAMINED THE CAR AND FOUND NOTHING WRONG - NO CODES HAD BEEN TRIGGERED. WE HAD YET ANOTHER EVENT WITH MY HUSBAND DRIVING THIS TIME ABOUT A MONTH LATER, AND MYSELF AND TWO OTHER WITNESSES IN THE CAR. HONDA HAD A REGIONAL PARTS AND SERVICE MANAGER EXAMINE THE CAR AFTER THE SECOND EVENT AND HE FOUND NOTHING WRONG. I TOLD HIM THAT I WAS FRIGHTENED AND VERY DISAPPOINTED THAT THEY WERE NOT DOING SOMETHING MORE TO FIND AND REMEDY THE PROBLEM. A HONDA CUSTOMER SERVICE SUPERVISOR THEN CONTACTED ME TO REVIEW THE EVENTS AND TOLD ME HE WOULD TAKE THE ISSUE "TO THE ENGINEERS" BECAUSE IT WAS VERY UNUSUAL THAT 2 DRIVERS WOULD EXPERIENCE THE SAME PROBLEM IF IT WAS DRIVER ERROR. HE CALLED BACK AND TOLD ME THAT THE ENGINEERS (WHO DID NOT LOOK AT THE CAR) SAID IT WAS A PROBLEM CALLED BRIDGING, WHERE YOU ACCIDENTLY PUT YOUR FOOT ON THE GAS PEDAL WHILE BRAKING. HE DID NOT ADDRESS WHY NEITHER ONE OF US HAD EVER EXPERIENCE "BRIDGING" THE FIRST FEW YEARS THAT WE OWNED THE CAR, WHEN WE BOTH HAD DRIVEN IT EXTENSIVELY AT HIGHWAY SPEEDS. THE CAR HAS 52K MILES ON IT CURRENTLY. THIS IS A VERY DANGEROUS PROBLEM AND SOMEONE NEEDS TO DEAL WITH IT BEFORE PEOPLE ARE KILLED. I KNOW THAT I DID NOT HAVE MY FOOT ON THE BRAKE AND THE GAS PEDAL AT THE SAME TIME AND NEITHER DID MY HUSBAND.
Engine and engine cooling, Power train, Vehicle speed control, Mar 14, 2010
MY 2006 HONDA PILOT EX-L EXPERIENCED SUDDEN UNINTENDED ACCELERATION (SUA) AT 3:53 P.M. ON SUNDAY, FEBRUARY 28, 2010 NEAR OUR HOME ON KEY BISCAYNE, FLORIDA. WE WERE DRIVING AT AROUND 20 MPH AND AS WE GENTLY BRAKED IN APPROACH OF THE STOP SIGN, THE ENGINE OPENED UP NEARLY FULL THROTTLE AT JUST ABOVE 5000 RPMS. MY HUSBAND IMMEDIATELY AND FIRMLY APPLIED THE BRAKE AND PLACED THE GEAR IN PARK. WITH HIS FOOT ON THE BRAKE, NOT THE ACCELERATOR PEDAL, THE ENGINE CONTINUED TO ROAR AT 5000 RPMS UNTIL HE TURNED IT OFF AT THE IGNITION AFTER ABOUT 30 SECONDS. HE RESTARTED THE ENGINE AND THE ENGINE RPM IMMEDIATELY SHOT UP TO 5000 RPMS AGAIN, WITH HIS FOOT ON THE BRAKE AND THE CAR IN PARK. THE TACHOMETER STAYED AT THE 5000 RPM LEVEL CONTINUOUSLY UNTIL HE AGAIN TURNED OFF THE ENGINE AT THE IGNITION AFTER ABOUT 45 SECONDS. WE WAITED A FEW MORE SECONDS AND RE-STARTED THE ENGINE AGAIN. THAT TIME, THE ENGINE STARTED AT A NORMAL RPM AND WE DROVE HALF A BLOCK TO OUR HOUSE. WE RECORDED A VIDEO OF THE SECOND EPISODE OF 5000 RPMS WITH A CAMERA WE HAD WITH US. WE PROVIDED THE VIDEO IMMEDIATELY TO AMERICAN HONDA CUSTOMER SERVICE. AT THE REQUEST OF CUSTOMER SERVICE, I TOOK OUR PILOT TO BRICKELL HONDA IN MIAMI ON MARCH 1. I SHOWED THE VIDEO OF THE SUA TO THE SERVICE MANAGER, GEORGE RUIZ, ON HIS COMPUTER. HE WAS ASTOUNDED BY WHAT HE SAW AND EXPRESSED HIS GENUINE CONCERN THAT THE CAR WAS UNSAFE TO OPERATE, REGARDLESS OF WHETHER HIS SERVICE DEPARTMENT WAS ABLE TO FIND THE SOURCE OF THE PROBLEM. HE SAID UNDER NO CIRCUMSTANCE SHOULD THE ENGINE OPERATE AT 5000 RPMS WITHOUT THE ACCELERATOR BEING DEPRESSED ALMOST ALL THE WAY TO THE FLOOR. THE DISTRICT SERVICE MANAGER, KEVIN MCCLUNG, ALSO INSPECTED THE CAR. AMERICAN HONDA DETERMINED THE PILOT WAS OPERATING WITHIN NORMAL PARAMETERS. WE WERE INSTRUCTED TO PICK UP THE CAR ON MARCH 5 AND DID SO ON MARCH 8. NO REPAIRS WERE PERFORMED. MY HUSBAND SPOKE TO HONDA CUSTOMER SERVICE MANAGER TERRY NIELSEN ON MARCH 3 WHO COULD NOT EXPLAIN THE VIDEO. *TR
Vehicle speed control, Mar 9, 2010
ON DEC 4,2007 I TOOK MY 2006 HONDA PILOT TO A HONDA DEALERSHIP IN WINNIPEG MB CANADA FOR ENGINE REVVING ISSUES. I EXPLAINED HOW WHEN GOING TO BRAKE AT AN INTERSECTION THE VEHICLE JOLTED AHEAD AS THE ENGINE STARTED TO REV HIGH- RPM GREATER THAT 4000 - AND THE SPEEDOMETER NEEDLE WAS BOUNCING FROM TOP TO BOTTOM ERRATICALLY. I WAS BRAKING LOWLY AT FIRST BUT WHEN THIS STARTED I USED TWO FEET ON THE BRAKR TO PREVENT ME FROM HITTING THE CAR IN FRONT OF ME. IT JUST FINALLY STOPPED. IT NEVER HAPPENED AGAIN BUT WITH THE TOYOTA RECALLS I WONDER WHETHER HONDA HAS THE SAME ISSUES WITH THEIR VEHICLES. PLEASE REPORT THIS OCCURRENCE FOR ME. NOTICE: MILEAGE ON VEHICLE AT THE TIME WAS 38000 KILOMETERS AND THE SPEED I WAS GOING WAS 50-60 KM PER HOUR. I COULDN'T ADJUST THAT IN THE FOLLOWING PAGES TO REFLECT THE METRIC SYSTEM WE USE UP HERE. *TR
Electrical system, Mar 4, 2010
TL*THE CONTACT OWNS A 2006 HONDA PILOT. THE CONTACT STARTED THE IGNITION. THERE WAS ALOUD NOISE COMING FROM THE REAR STEREO SYSTEM SPEAKER. THE FAILURE OCCURRED WHENEVER TRAVELING AT A LOW SPEED OR THE ENGINE WAS IDLING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE WAS CONTRIBUTED TO THE ACTIVE NOISE CANCELLATION UNIT (ANC). THE COST OF THE SERVICE REPAIR WAS $500.00. THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE MILEAGE WAS 80,000. UPDATED 02/01/11 *LJ UPDATED 03/21/11