2016 Honda Pilot
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,706 owner complaints filed for this model year. This is the highest complaint count among 23 Pilot model years with reports.
Of the 2016 reports, 23 involved a crash and 10 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Structure, frame and membersJun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Campaign 26V365000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpDec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Campaign 23V858000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalNov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Campaign 23V751000 on NHTSA.gov
Structure, body, hoodNov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Campaign 21V932000 on NHTSA.gov
Fuel system, gasoline, storageMar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Campaign 17V219000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyJun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
A fuel leak in the presence of an ignition source may result in a fire.
Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Campaign 16V417000 on NHTSA.gov
Electrical system, instrument cluster/panelOct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Campaign 15V668000 on NHTSA.gov
Seat belts, rear/otherJul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Campaign 15V424000 on NHTSA.gov
Representative owner complaints: electrical system
579 reports, newest first. Show all
Electrical system, Engine, Aug 10, 2022
The contact owns a 2016 Honda Pilot. The contact stated that the auto start /stop feature cut off and the vehicle shifted to neutral. The vehicle shut off and failed to restart. All the instrument cluster warning lights were illuminated. The contact disengaged the auto start/stop feature. The contact called the local dealer but the vehicle was not diagnosed or repaired as of yet. The manufacturer was not contacted. The failure mileage was approximately 91,400.
Electrical system, Engine, Aug 3, 2022
2016 Honda Pilot stalls during idol-start stop. Driver is forced to put it into park and restart vehicle. I took the vehicle to Manchester Honda (CT) for service over a year ago, but no issues were found. They updated the software, but it did not help. The issue is getting worse - sometimes it takes multiple attempts to restart the vehicle. This is a serious safety concern as it has happened in the middle of a busy intersection and in the middle of the highway in traffic. It is currently not possible to disable the system and I don't always remember to manually shut it off every time I start the car.
Electrical system, Aug 1, 2022
Keyless Start System Problem light came on and I saw that there had been recalls on this.
Electrical system, Jul 31, 2022
When the car is locked, the alarm will randomly keep going off and the cluster randomly flickers.
Electrical system, Jul 29, 2022
Auto stop/start function shut down all electrical components when vehicle was stopped and the function activated. This occurred on 2 separate occasions.
Electrical system, Engine, Jul 28, 2022
During several stops now, the auto engine idle kicks in, but vehicle does not restart. The vehicle is at a complete stop with the engine off. This has happened on 2 occasions on freeway off/on ramps, which has been extremely dangerous, with the speed that vehicles are traveling. It has also happened over 4 times at intersections and stop signs. 2 separate dealerships have inspected the vehicle, where 1 was able to reproduce the issue and both times, my battery was replaced, well before the life of the battery. Maybe 1 year into having the new battery the issue presents itself again. I have owned the vehicle for just over 3 years now and I have purchased 2 batteries, that is not acceptable.
Power train, Electrical system, Jul 27, 2022
Multiple times the idle-stop feature has caused my car to stall out at an intersection. The idle-stop will engage, but when I take my foot off the break (or move the steering wheel), the car does not start again, instead it will try to start but then turns off completely. At that point I have to re-engage the break, put the car in park, turn off the car and then try to turn it back on as normal. When this happens at a green light it's very stressful and dangerous as cars are behind me. This has happened probably 10 times in my ownership period, it is always worse when it's hot outside since so many parts are running (including the AC). I have brought the car in to fix this a bunch of times, they never find anything wrong at the dealer. The last time they replaced the starter button at no charge saying that this piece was known to be faulty. It has happened once or twice since replacing that part.
Electrical system, Jul 25, 2022
At low idle, car will lock up, unable to drive, cannot put in neutral, will not go. I can't even shut the car off to restart. The dash tells be to push brake and start button, but that still does not work. I continue to push buttons until it finally kicks in. I was in the middle of the road. 1 car almost rear ended me. This also happened while I was traveling and stopped at the end of highway. I needed assistance, but since I couldn't put car in neutral, we could not push. I put hazards on and again, pushed random buttons until kicked back in. This is very dangerous! I will not let my kids take my car for fear that they will get stuck as well. I'm scared to drive it. Honda's response was bad gas or alternator, which it is NOT.
Power train, Electrical system, Other or unspecified, Jul 25, 2022
Ocassionally when stopped at intersections my 2016 Honda Pilot touring edition will go into idle stop mode and not restart. Upon trying to proceed the engine will try to start and stall out. The engine goes dead and I am unable to accelerate out of the intersection. The info dash system indicates the vehicle was in Neutral and that I needed to shift to Park to Proceed. After putting the vehicle in Park the info dash system instructs me to start the engine by pressing the Brake and pushing the Start button. This action is not possible when the vehicle has stalled out as described above and continues to prevent the driver from accelerating out of the intersection. The only solution I found that works is to remove my foot from the brake and power down the vehicle completely. Only when the vehicle is completely powered down is it possible to restart the vehicle by pressing the Brake and Pushing the power button. This event has happened 4 times in the past 3 months on my Pilot. The mileage on my Pilot is ~125,000 miles.
Electrical system, Engine, Jul 24, 2022
While at a stop the engine stopped as it should but did not restart. It then took multiple tries of pressing the brake and hitting the start button to get it to restart. This meant the car was blocking the flow of traffic creating a safety issue. This has occurred on multiple occasions with no issues found at the dealer.
Electrical system, Jul 21, 2022
The auto idle start stop does not restart automatically while in traffic or stopped. Issue has occurred several times, I must turn off vehicle completely to restart vehicle. Huge safety factor when traffic is following again and I am unable to restart vehicle.
Electrical system, Engine, Jul 15, 2022
When the auto idle stop is not disengaged (the default setting when the car starts is that the auto idle stop is engaged), the car will sometimes not restart when the idle stop occurs. It's unpredictable and scary, especially when it occurs at a light or in stop-and-go traffic. The dashboard lights up like a Christmas tree, and there is a clicking noise. I have to place it into Park, shut off the engine fully (it's not running - I think it's in Accessory mode), step on the brake and restart. Because of this, I make a habit of disengaging the auto idle stop when I start the car. Unfortunately, sometimes I forget to disengage and this engine restart failure happens. I have read that an old/weak battery is suspected. This is not true in my case. This issue has happened several times after I changed the battery on 12/15/2020. Interstate MTX48/H6 battery at $300. It's not just me - it has happened to my wife, and my 17 year old son, when driving this car. At first, I thought my wife did something wrong, then it happened to me. In total, I'd guess it's happened > 6-7 times. We try to be careful to push the button and disengage the auto idle stop. But you have to do it EVERY TIME YOU START THE CAR. If you forget or are distracted, then the problem can occur.
Electrical system, Engine, Fuel/propulsion system, Jul 14, 2022
While stopped at a red light, with the auto start enabled, the car would not turn back on and placed the car in “neutral”. The dash info message prompted me to put the car in “park”. I did. It then instructed me to depress the brake and hit the “start” button to turn the car on. It did not after I tried a few times. Finally to get it started I pushed the “start” button with the key fob. It then turned on and allowed me to put it in “drive”.
Electrical system, Engine, Jul 10, 2022
Today was the second time my car has shut down at a traffic light in the last 2 months. The auto engine stop kicks in and the car shuts down. It took multiple combinations of pressing the start button and turning on/off the car before I could get it to restart. I’ve recently replaced the battery so I don’t think it’s a weak battery.
Electrical system, Engine, Fuel/propulsion system, Jul 7, 2022
When idling at a stop light, the auto shut off feature engaged and turned off the engine. When I engaged the gas to start moving again, the engine would not restart. I applied to brake, put the car into park and then tried to manually restart the car using the start button on the dash. The car engine would not start. The auxiliary power to the accessories would not go off when I pushed the stop/start button on the dash, but the engine would not restart either. I attempted to restart the car several times. It did not attempt to turn the engine over, but did literally nothing. I paused and waited for a minute and then attempted to restart the car again with the stop/start button and the car engine finally turned on. The exact same sequence of events has happened and two separate occasions some weeks apart. This incident put my and my passengers’ safety at risk by stranding me at very busy intersections with no way to move the vehicle out of the road. The auto-shutoff feature has engaged while in stop and go traffic on the freeway and if this had happened then, the results could be catastrophic. I now always manually turn off this feature due to fear of this happening again and would disengage it entirely if possible, but was informed by the dealer that was not possible. No one has inspected the vehicle as the problem is not reproducible on demand, but I am willing for any necessary inspections to occur.
Electrical system, Engine, Jun 30, 2022
The contact owns a 2016 Honda Pilot. The contact stated that on multiple occasions, the START/STOP feature failed to operate as needed while at a complete stop. The contact stated that the vehicle would shut off upon releasing the brake pedal with several unknown warning lights illuminated. The contact had the vehicle towed to an independent mechanic on several occasions where several electrical components were replaced. The dealer was notified of the failure and the contact was informed that they had no knowledge of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 75,000.
Electrical system, Engine, Jun 26, 2022
Auto Idle System failure. This has been a problem for several years and continues to be a safety issue. If I don't disable the auto idle feature my car will die when I take my foot off of the brake to accelerate.. The vehicle has to do a complete computer reset before I am able to restart the engine. This has happened many, many times at stop lights when the light turns green and I attempt to accelerate, when waiting to merge onto the frontage road of I-35, when turning onto a main road out of a parking lot when traffic is backed up but someone was attempting to let me into the lane (I was half in and half out of the parking lot). In every situation, there is someone behind me expecting me to go (rightfully so). I could easily be hit if the other drivers weren't paying attention. This is a safety hazard and needs to be recalled and repaired. I've asked my mechanic about it and the Honda dealership. No one knows what to do. I've replaced the battery twice thinking maybe that would help but it didn't.
Electrical system, Engine, Jun 24, 2022
the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the Auto Start/Stop function engaged. Making it necessary to restart manually.
Electrical system, Jun 21, 2022
The contact owns a 2016 Honda Pilot. The contact stated while attempting to drive from a complete stop, the brake pedal was released however, the Auto STOP/START feature failed to operate as designed. There was no warning light illuminated. The contact stated that the failure recurred on several occasions. The vehicle was taken to the dealer and the ignition switch was replaced; however, the failure persisted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 44,000.
Power train, Electrical system, Engine, Jun 16, 2022
Multiple times the vehicle wouldn’t start. The start stop switch is the culprit after 7 months of dealing with it and taking it to dealership finally. Car will cut off at stop light but won’t turn back on. Takes like 4 tries to get it back on. Also at 126k or 128k engine had a knocking sound and needed replaced and it cost $7000 the air conditioning doesn’t work and this is very upsetting this isn’t why I buy Hondas. The start stop event happens everyday and every time I start the car and don’t deactivate the start/stop system
Electrical system, Engine, Jun 14, 2022
My 2016 Honda pilot stalls when my car turns off from the auto idle engine. If I do not manually turn the feature off EVERYTIME I turn my car on my car will stall out when i lift my foot off the brake. It has progressively taken longer to turn the vehicle back on (anywhere from 30 seconds to 2 minutes) I have been to honda 2x for this issue & their "fix" has never resolved the issue. They will not admit they cannot fix it, even when I showed them a video of exactly what happens when I try to get my vehicle back on.
Electrical system, Jun 14, 2022
The engine idle-stop feature did not restart. It is available for inspection. The safety of my two small children and myself was at risk as we had to get out of the car at a busy intersection. It has not been reproduced by a dealer or a service center. The vehicle and the parts have not been inspected by authorities. It happens without warning. While at a red light, when I take my foot off the brake it shuts off completely.
Electrical system, Jun 13, 2022
The Pilot has an auto start/stop function that turns off the engine when the car is stopped/idling. When the driver releases the break pedal, the engine is supposed to turn back on. The engine would very frequently fail to turn back on after idling. This happened many times at traffic lights and while stopped in traffic. It's much worse than stalling out with a manual transmission vehicle, because the engine does not turn back on quickly. The whole system (including battery power to the car) needs to be turned off and turned on again. This is a safety issue because the engine has failed to start while in traffic on the interstate, where cars are quickly accelerating, and the failure for the car to accelerate with traffic could lead to a collision. It also poses the risk of leaving the driver stuck in a dangerous location without the ability to move the car. I took the car to the dealership and they told me my battery was dying, and they charged me to replace the battery. So far, I haven't experienced anymore engine stalling with the new battery. The car has not been inspected by anyone other than the local Honda dealership. There were no warning lamps or messages prior to the failure. The failure first started in 2020, but only happened a few times. Since then, the problem increased in frequency, until I finally took it to the dealership and had the battery replaced.
Electrical system, Engine, Jun 13, 2022
I bought this car used in May 2022. My wife is the primary driver and this incident happened to her three times and myself once. When stopping at a red light, the engine turns off to save fuel with the auto start stop feature. We normally turn this off, but sometimes when we forget, the auto start fails to start the engine leaving us stuck in traffic trying to start the car at a green light. It takes multiple attempts to restart the car. This wouldn't be an issue if we could turn off the auto stop start permanently. We don't like the feature anyway, sometimes it causes the car to lurch forward when removing your foot from the break while the engine is starting.
Electrical system, Jun 13, 2022
The stop/start feature fails to restart engine and I have to shut off the car completely to restart again.