2016 Honda Pilot
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,706 owner complaints filed for this model year. This is the highest complaint count among 23 Pilot model years with reports.
Of the 2016 reports, 23 involved a crash and 10 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Structure, frame and membersJun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Campaign 26V365000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpDec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Campaign 23V858000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalNov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Campaign 23V751000 on NHTSA.gov
Structure, body, hoodNov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Campaign 21V932000 on NHTSA.gov
Fuel system, gasoline, storageMar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Campaign 17V219000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyJun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
A fuel leak in the presence of an ignition source may result in a fire.
Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Campaign 16V417000 on NHTSA.gov
Electrical system, instrument cluster/panelOct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Campaign 15V668000 on NHTSA.gov
Seat belts, rear/otherJul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Campaign 15V424000 on NHTSA.gov
Representative owner complaints: engine
812 reports, newest first. Show all
Engine and engine cooling, Dec 31, 2024
The contact owns a 2016 Honda Pilot. The contact stated that while operating the vehicle, there was a loud knocking sound coming from the engine compartment with the check engine warning light illuminated. The contact diagnosed a misfire in cylinder #3 and replaced all the spark plugs and coils; however, the failure persisted. The vehicle was later towed to the local dealer who diagnosed that the connecting rod bearing had failed. The contact was advised that the engine short block needed to be replaced. The engine short block was replaced, and the vehicle was repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 23V751000 (ENGINE AND ENGINE COOLING). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 149,000.
Engine, Dec 30, 2024
Honda service determined there is a failure of the number 5 cylinder connecting rod bearing. This could pose a safety issue if it had continued to be driven. We have also seen through news and online forums that this is a known, systemic issue.
Power train, Engine, Dec 26, 2024
Our 2016 Honda Pilot suddenly lost power on [XXX] and simultaneously developed a loud knocking sound coming from the engine on Monday ([XXX]) evening sometime between 7 and 8 PM. My son who was driving the vehicle was lucky to avoid an accident because it was difficult to pull to the right side of the road as there were fast-moving cars merging onto [XXX] from the westbound lanes of [XXX] . He pulled onto the right shoulder of [XXX] at just about [XXX], [XXX] . My other son and I drove to him. I was able to start the car but the knocking sound was still there and the engine struggled to stay on. I drove 0.5 miles safely and slowly (20-25 mph) to Midas at 1410 S. Nevada Ave. Midas diagnosed the vehicle with "a bad engine rod knock and main bearing squeak" that they could not fix. We had the vehicle towed to Corwin Honda in Colorado Springs on [XXX]. Honda technicians diagnosed the problem as connecting rod bearing failure. They recommended an engine replacement. There were recalls for the exact problem of our vehicle but our VIN was not part of the recall. We contacted Corporate Honda but they would not assist with any repairs and denied manufacturer responsibility for the connecting rod bearing failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Dec 23, 2024
the engine had a rod fail while driving and destroyed the engine with no warning. This happened November 2023, about 2 weeks after the recall from Honda for some 249,000 vehicles for this exact issue. they told me it was not included in the recall. My son was driving home from a school activity when this happened. It just stopped working and slowing down. It was a dangerous situation for him. My mechanic inspected it confirming the rod failed. There were no warnings lamps or messages that ever appeared before it happened. I ended up selling the vehicle for scraps but want to hold Honda accountable now that I have seen what happened. I want them to make me whole for the FMV of my vehicle which i lost when this happened. Please help!
Engine and engine cooling, Fuel system, Gasoline, Dec 18, 2024
The contact owns a 2016 Honda Pilot. The contact stated that while driving on the highway at 40 MPH, the vehicle lost automotive power and shut off in the middle of the highway. The contact stated that all the warning lights had been illuminated. The vehicle was not able to be restarted. The vehicle was towed to a local dealer where the vehicle was diagnosed; however, the dealer found no cause for the failure. The vehicle was not repaired. The contact linked the failure to NHTSA Campaign Numbers: 23V751000 (ENGINE AND ENGINE COOLING) and 23V858000 (FUEL SYSTEM, GASOLINE). The manufacturer was notified of the failure. The approximate failure mileage was 124,000.
Electrical system, Engine, Dec 15, 2024
We have had consistent, non-stop, unknown and unresolved engine issues from the day we purchased this vehicle. The dealership has not been able to identify or resolve these issues, which include the Rocker Arm, Cam Shaft and Cam Shaft sensors, numerous electrical, fuse and sensor failures and more. The symptoms appear to be the same as those cited with the connecting rod bearing issues but for some reason our vehicle has not fallen under the recalls.
Engine, Dec 12, 2024
No precursors and vehicle always followed recommended maintenance. Started vehicle and began making knocking and screeching sound which grew increasingly louder, followed by the engine light flashing. Immediately pulled over and had vehicle towed. Gunn Honda ran diagnostics and determined engine failure originating in the lower engine.
Engine, Dec 10, 2024
Engine failure only at 80k miles
Power train, Engine, Dec 9, 2024
The contact owns a 2016 Honda Pilot. The contact stated while driving at an undisclosed speed, there was a loud knocking sound coming from the engine compartment. The vehicle was towed to an independent mechanic and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The contact stated that while test driving the vehicle after the repair, the transmission was slipping. The vehicle was then towed to a transmission specialist. The contact was informed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 86,000.
Engine, Dec 8, 2024
The component that failed was the connector rod bearing in cylinder 4. It is not available for inspection. Our safety was put at risk because the connector rod bearing failed while my family and I were driving at 80mph (legal freeway speed) on the freeway. We lost power and the engine shuddered and the car shook while we navigated to the shoulder. The vehicle was inspected by the independent service center. There were no symptoms that I noticed prior to the failure. It was sudden, and occurred on my Pilot on just 112,546 miles. The problem was confirmed by an independent service center.
Engine, Dec 4, 2024
Driving at highway speeds when I notice a light rattling noise from front of car. Soon, light rattling turns to loud rattling and the check engine light comes on blinking. Slowed down and exited freeway as soon as possible and stopped at nearest gas station (right off freeway). Had vehicle towed to nearest Honda dealership for investigation of the problem. Upon investigation, service tech reported connecting rod damage to the crankshaft - recommend replacement engine.
Engine, Dec 4, 2024
Connecting rod failure, needs complete engine rebuild. 102,0000 miles. I was able to exit the highway and get to the dealership so there wasn’t a safety issue for me. I saw that this issue was a recall but my vehicle was not on the list so I thought I would submit. Dealership said I need a new engine. I bought it in 2020 at a dealership as a certified used Honda. I have service history with the dealership. No explanation was given as to what caused this. Check engine light started flashing and lost some power on the highway.
Steering, Engine, Nov 30, 2024
Been having engine issues for a while. All the way back to around 32,000 miles. The display says something about rods locker arms or something like that. I've also had an issue with throttle position sensor which was repaired however technician didn't tighten up a boat and I lost the oil pressure. The car was repaired at the end of 2017 in the beginning of 2018 but I've had the issue ever since so I typically don't drive the car too far since that incident. Some of the repairs should be in the Carfax however issue shows up from time to time on my display. I've also had to have some steering control module replaced in 2021. And I just got a transmission service to have the torque converter flush and reprogrammed because of constant jerking when accelerating.
Engine, Nov 28, 2024
Connecting rod bearings failed in cylinders 1 and 4 with 133000 miles on the vehicle.
Engine and engine cooling, Nov 27, 2024
The contact owns a 2016 Honda Pilot. The contact stated that while his son was driving at an unclosed speed, the lower part of the engine was making an abnormal knocking sound and the vehicle was shuddering. The contact stated that the failure recurred upon starting the vehicle and while driving 20 MPH. The check engine warning light and several other unknown warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with thrown rod bearing failure. The mechanic determined that the failure was related to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 103,000.
Engine, Nov 25, 2024
The connecting rod bearing seized up. Connecting rod broke and puncture through the engine housing. No recall notice was received from manufacturer about the issue. I was driving on the highway when my car made a sudden stop and smoke came from the hood along with a slight metal sound. There have been no professional inspector yet. My brother in law is a car mechanic and found the problem for us. When the car came to a stop there was no indicating of any signs. I did try to start the car again and that is when all the lights came one.
Engine and engine cooling, Nov 25, 2024
The contact owns a 2016 Honda Pilot. The contact stated while driving 35 MPH, or while the vehicle was cold started, the engine was running rough and making an abnormal clanking sound. The contact stated no warning light was illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the connecting rod bearings were damaged and needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The failure mileage was 165,383.
Engine, Nov 25, 2024
Had a knocking noise coming from the engine of our 2016 Honda Pilot. My fear of "rod knock" was a reality. Piazza Honda of Pottstown, PA confirmed that it was likely a failed rod bearing(s). Honda of America (corporate) is supposedly giving some good will money to help offset the cost. The dealership initially said that it would cost around $9000.00 to repair it (that's without "good will"). They have had our Pilot for over 2 weeks now and the new estimate today is $17,280.00. It's all over the internet that these Honda/Acura J-Series V6 engines are having premature rod bearing issues.
Engine and engine cooling, Nov 25, 2024
The contact owns a 2016 Honda Pilot. The contact stated while driving at an undisclosed speed, there was a rattling sound coming from the engine compartment. The vehicle was taken to the dealer where it was diagnosed and determined that there were metal shavings inside the oil pan and with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed of NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 185,000. The VIN was unavailable.
Electrical system, Engine, Nov 24, 2024
In 2021, while driving on a highway all vehicle warning lights came on. Engine ran at high rpm and low speed. Honda said is was a software update. Charged for update. This seemed to resolve issues. Car is regularly maintained and transmission fluid changed 2/1/2024. In 2024, the vehicle warning lights (in multiple & varying groups) began coming on and off at various intervals. The car stalled while at a red light on at least two occasions. When I was not near home I would stop at AutoZone for computer readings; misfiring of cylinder 2, random multiple misfire detected, system too rich bank 2. Car was at Honda for 2nd software update and lights were off at pickup. Lights started again. The mechanic found the vehicle was sending upwards of 100 codes. Repairs were made (and paid for) at local shop 2 separate times. Car is now at Honda diagnosed with engine failure due to bent rod. Honda will not offer goodwill on vehicle. However, the car has a "soft" recall for fuel injectors which seems to be the likely culprit. KBB in early '24 was $16k. Honda wants $18 k for repair and nearly $1k for diagnostic fee.
Engine, Nov 24, 2024
2016 Honda Pilot AWD EX-L Vin: [XXX] Mileage: 72,475 Connecting Rod Bearings failing on 3.5 liter, V-6 engines, leading to complete engine failure. Affected Model Years: 2016 through 2020 The engine in my vehicle is the Honda J35, V-6 which was the subject of a NHTSA mandated recall of approximately 250,000 Honda and Acura vehicles in 2023. I have observed a pronounced engine knock when the vehicle is at idle, that intensifies when the car is driven. I brought the car to a Honda dealership (DCH Honda of Nanuet) where it was confirmed that the connecting rod bearing problem was the cause. The dealership advised that a bearing replacement would not be feasible, and that an engine replacement would be necessary (see attached). I contacted American Honda and advised them of the same and a case was opened for me. (Case # [XXX]) But I was advised that there was no recall on my vehicle and no current, applicable warranty. I am presently awaiting a call from a Honda Case Manager on my request for financial assistance to defray the quoted cost of $8,057, plus applicable sales tax for the dealership to replace the defective engine. Based on the documented history of this problem and the associated potential for an accident that this is a considerable safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Electrical system, Engine, Nov 22, 2024
This vehicle was recently recalled for the START / STOP in 2023 after complaining about it since 2017. The vehicle was repaired which resulted in starter and all related components associated with the recall. I questioned the repair as if you can't duplicate the failure (turn it on and turn it off) how do you know you have it fixed. They assured me they replaced all the associated components. Guess what the same problem is happening again. Start/Stop system is not working properly again post recall and software update. The US Government should go after Honda on this as it is truly a safety issue when your car dies at a stop and go light and then you have cares approaching you from behind at 55mph.
Engine and engine cooling, Nov 20, 2024
The contact owns a 2016 Honda Pilot. The contact stated that while his wife was driving 65 MPH, the check engine warning light illuminated, and the vehicle lost motive power and stalled. The contact was unable to restart the vehicle. The vehicle was towed to an independent mechanic to be diagnosed and it was determined that the engine needed to be replaced. The contact made inquiries of the independent mechanic and was informed that there was a known issue with the engines of similar vehicles. The vehicle was towed to the dealer however, the contact was not offered any assistance in repairing the vehicle. The contact related the failure to NHTSA Campaign Number: 23V751000 (ENGINE AND ENGINE COOLING); however, VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The contact was informed that the VIN was not included in the recall. The failure mileage was 90,000.
Engine, Nov 19, 2024
the car had developed a light ticking sound intermittently for the last three that seemed to go away randomly then the engine stalled and won't start due to seized engine
Engine, Nov 19, 2024
The contact owns a 2016 Honda Pilot. The contact stated that while his son was driving approximately 50 MPH, the vehicle lost motive power and stalled. The vehicle was towed to the local dealer who detected an engine knocking sound and determined that the engine was faulty and needed to be replaced. The engine was replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 117,000.