2016 Honda Pilot
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,706 owner complaints filed for this model year. This is the highest complaint count among 23 Pilot model years with reports.
Of the 2016 reports, 23 involved a crash and 10 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Structure, frame and membersJun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Campaign 26V365000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpDec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Campaign 23V858000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalNov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Campaign 23V751000 on NHTSA.gov
Structure, body, hoodNov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Campaign 21V932000 on NHTSA.gov
Fuel system, gasoline, storageMar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Campaign 17V219000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyJun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
A fuel leak in the presence of an ignition source may result in a fire.
Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Campaign 16V417000 on NHTSA.gov
Electrical system, instrument cluster/panelOct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Campaign 15V668000 on NHTSA.gov
Seat belts, rear/otherJul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Campaign 15V424000 on NHTSA.gov
Representative owner complaints
1,706 reports, newest first.
Other or unspecified, Engine, Aug 1, 2022
When coming to a complete stop, the vehicles' start/stop feature was engaged and the car's engine turned off. Instead of turning back on when the brake was released, the car did not turn back on. Hitting the ignition button also did not start the vehicle back up immediately. This happened to me two times in the past month. Both times, I was stopped at a red light and the car left me stranded in traffic. After a few attempts of hitting the ignition button, the car would start back up. The vehicles start/stop feature malfunctioned and it would be available for inspection upon request. This put my family's safety at risk because the car left us stranded in the middle of a busy intersection. The vehicle has not been inspected yet. There were no warning lamps prior to the problem.
Electrical system, Aug 1, 2022
Keyless Start System Problem light came on and I saw that there had been recalls on this.
Electrical system, Jul 31, 2022
When the car is locked, the alarm will randomly keep going off and the cluster randomly flickers.
Engine, Jul 29, 2022
The contact owns a 2016 Honda Pilot. The contact stated while at a stop light and attempting to accelerate, the vehicle lost motive power and stalled. The contact attempted several times to restart the vehicle however, the vehicle failed to start up immediately. After several more attempts, the vehicle restarted and operated normally. The vehicle was taken to the dealer for diagnostic testing however, the mechanic was unable to determine the cause of the failure. The manufacturer was not contacted. The failure mileage was 23,000.
Electrical system, Jul 29, 2022
Auto stop/start function shut down all electrical components when vehicle was stopped and the function activated. This occurred on 2 separate occasions.
Electrical system, Engine, Jul 28, 2022
During several stops now, the auto engine idle kicks in, but vehicle does not restart. The vehicle is at a complete stop with the engine off. This has happened on 2 occasions on freeway off/on ramps, which has been extremely dangerous, with the speed that vehicles are traveling. It has also happened over 4 times at intersections and stop signs. 2 separate dealerships have inspected the vehicle, where 1 was able to reproduce the issue and both times, my battery was replaced, well before the life of the battery. Maybe 1 year into having the new battery the issue presents itself again. I have owned the vehicle for just over 3 years now and I have purchased 2 batteries, that is not acceptable.
Power train, Electrical system, Jul 27, 2022
Multiple times the idle-stop feature has caused my car to stall out at an intersection. The idle-stop will engage, but when I take my foot off the break (or move the steering wheel), the car does not start again, instead it will try to start but then turns off completely. At that point I have to re-engage the break, put the car in park, turn off the car and then try to turn it back on as normal. When this happens at a green light it's very stressful and dangerous as cars are behind me. This has happened probably 10 times in my ownership period, it is always worse when it's hot outside since so many parts are running (including the AC). I have brought the car in to fix this a bunch of times, they never find anything wrong at the dealer. The last time they replaced the starter button at no charge saying that this piece was known to be faulty. It has happened once or twice since replacing that part.
Other or unspecified, Jul 25, 2022
I have a Honda Pilot 2016 with a keyless start system issue. I see a recall document Service Bulletin 20-117 dated December 9, 2020; however, when I type my VIN number for my vehicle, I do not see a recall. I have been having the Keyless start system issue for the past 3 days.
Electrical system, Jul 25, 2022
At low idle, car will lock up, unable to drive, cannot put in neutral, will not go. I can't even shut the car off to restart. The dash tells be to push brake and start button, but that still does not work. I continue to push buttons until it finally kicks in. I was in the middle of the road. 1 car almost rear ended me. This also happened while I was traveling and stopped at the end of highway. I needed assistance, but since I couldn't put car in neutral, we could not push. I put hazards on and again, pushed random buttons until kicked back in. This is very dangerous! I will not let my kids take my car for fear that they will get stuck as well. I'm scared to drive it. Honda's response was bad gas or alternator, which it is NOT.
Power train, Electrical system, Other or unspecified, Jul 25, 2022
Ocassionally when stopped at intersections my 2016 Honda Pilot touring edition will go into idle stop mode and not restart. Upon trying to proceed the engine will try to start and stall out. The engine goes dead and I am unable to accelerate out of the intersection. The info dash system indicates the vehicle was in Neutral and that I needed to shift to Park to Proceed. After putting the vehicle in Park the info dash system instructs me to start the engine by pressing the Brake and pushing the Start button. This action is not possible when the vehicle has stalled out as described above and continues to prevent the driver from accelerating out of the intersection. The only solution I found that works is to remove my foot from the brake and power down the vehicle completely. Only when the vehicle is completely powered down is it possible to restart the vehicle by pressing the Brake and Pushing the power button. This event has happened 4 times in the past 3 months on my Pilot. The mileage on my Pilot is ~125,000 miles.
Engine, Jul 24, 2022
Purchased the car back in 2/2016. Had the battery replaced this year after noticing the auto stop-start function showed some signs of hesitation. In the past month, I've had the vehicle stall twice. The first time, I was at a parking lot, waiting for the other car to move out. While the car was stopped - the auto stop/start feature activated. Upon letting go of the brake, the car failed to restart. I had to place it in Park. Hit the ignition button. It restarted after 2-3 tries. The second time happened today while at a stop light. The car was off when the auto stop/start activated. When light turned green, brake was released and car failed to start. Had to go through the same routine as above. The car finally start.
Electrical system, Engine, Jul 24, 2022
While at a stop the engine stopped as it should but did not restart. It then took multiple tries of pressing the brake and hitting the start button to get it to restart. This meant the car was blocking the flow of traffic creating a safety issue. This has occurred on multiple occasions with no issues found at the dealer.
Other or unspecified, Engine, Jul 24, 2022
I’m having problem with the start/stop feature if my honda pilot 2016. For a couple of incidents already, when the car idle on a stop, it will not start back. It happened today 7/23/22 in Fletcher ave in Fort Lee, NJ. I had to jump start the car and it caused traffic for a while.
Engine, Jul 23, 2022
The Auto Engine Idle Stop malfunctions. This has happened multiple times. When this feature is NOT de-activated, the engine will turn off (at say a traffic light) and will not restart properly. While this has happened multiple times, today I took note of the specifics. When I realized the engine was turning off, I attempted to disable the auto engine idle stop. The car switched itself to neutral, the battery light came on and I had to push the button to start it again. During this time the A/C also turned off. On previous occasions, instructions have appeared on the digital screen (i.e. press brake, press start twice, etc,), but I do not recall the specifics as this causes anxiety and panic when it happens. I've had to turn on my hazard lights in the past while I attempt to restart the vehicle, while traffic is building behind my disabled vehicle. This issue does not always happen, but when it does, it's terrifying. It's dangerous as someone would expect you to be driving, but cannot because your vehicle has randomly shut off (say in traffic). I told the dealer about it a while ago, but they could not recreate the issue.
Other or unspecified, Jul 22, 2022
Auto Engine Idle Stop has failed to restart the vehicle in multiple situations, including at traffic lights and in stop and go traffic. Inspection is available upon request. When a trafic light turns green and I have tried to proceed the vehicle stalls and will not restart quickly, the cars behind me are surprised and not happy when I have to go through a procedure to get the car to restart. I have almost been hit by cars behind me several times as they expected me to go when the light turns green. Sometimes my vehicle will not restart for a minute or more. This could be a major issue if you were in traffic and ended up stuck in a place where you should not stop or stall. One time I had to call AAA to get my vehicle to start. They had to disconnect my battery and reattach so the system would reset itself. Only then would the vehicle start. The dealer said they have heard from other owners of Honda Pilots that they want this auto engine idle stop permanently turned off. But they told me they can’t turn it off. This should auto engine idle stop should be something you opt into not have to opt out every time you start your vehicle. There weren’t any lights or warnings that this system would fail ahead of time.
Other or unspecified, Jul 22, 2022
The idle stop on the car is defective, if not turned off which had to be turned off everytime we start the car, The car will randomly idle stop at intersections and won't come back on, will have to forcefully turn off the car and turn it back on. Couple this happened on dangerous intersection and traffic lights. Honda has not resolution, they just say turn off idle stop everytime.
Structure, Jul 21, 2022
A roof moulding flew off my vehicle on the expressway. Apparently there is a Honda Service Bulletin that came out to the dealership that indicates these mouldings need to be secured better. However, they listed only some of the VINs and mine wasn't one of them, but the moulding ended up flying off anyway. It sounds like is a problem for other VINs that Honda didn't indicate.
Electrical system, Jul 21, 2022
The auto idle start stop does not restart automatically while in traffic or stopped. Issue has occurred several times, I must turn off vehicle completely to restart vehicle. Huge safety factor when traffic is following again and I am unable to restart vehicle.
Engine, Jul 20, 2022
At lights when the vehicle stops for a short period, the engine goes off and is supposed to restart. Many times the engine is kicking off, this is not normal, it has almost caused us to get rear-ended a couple of times because the car goes off completely. You have to put the car in park and turn it off and on again to restart. As you can imagine this also frustrates drivers behind us. Please look into this, it is a HUGE safety issue. I don't see it as a recall as of yet, but read people have been reporting the same issue.
Engine, Jul 20, 2022
While waiting for green light,the gear transfer from D to P automatically and stuck there, the only thing I can do is turn off the engine and restart it, that happened four times in recent three months , the car became unreliable, I don’t know when it will happen again.
Power train, Engine, Fuel/propulsion system, Jul 18, 2022
The engine begins to idle rough, after a few days of driving a lot of cluster lights come on starting with check engine light, VSA as well as others. Disconnecting battery works to clear the the codes, engine will appear to idle ok but after a week of driving it will start idling rough again, then the cluster lights will light up as before. I believe this is due to Service Bulletin 20-100 or Service Bulletin A20-100 which states that issues with the fuel injectors were found relating to quality control. The TSB listed above states that if your vehicle is affected by these symptoms your warranty will be extended to 10 years of manufacture date or 150,000 miles. Our Pilot currently has under 80,000 miles on the odometer.
Steering, Engine, Jul 18, 2022
While driving on the highway on cruise mode, the car was driving fine. Then suddenly, cruise mode turns off, and the following four lights appeared on the dash: emissions system problem, vehicle stability assist problem, hill stability assist problem, and steering problem. When the car attempted to accelerate, it would not go above 50 mph on a 70mph highway. When it did go above 50mph, the car would bounce as if it was on a bumpy road even though the road was smooth. Additionally, when the problem would appear again, the car would suddenly slow down, increasing risk for an accident with the other cars driving so fast. We have bought many cars in the past but this was the first time we have ever experienced a problem like this with a Honda vehicle. I came on here to send this message to make other drivers aware that this is a common problem that 2016 Honda pilots have been experiencing, according to some mechanics.
Electrical system, Engine, Jul 15, 2022
When the auto idle stop is not disengaged (the default setting when the car starts is that the auto idle stop is engaged), the car will sometimes not restart when the idle stop occurs. It's unpredictable and scary, especially when it occurs at a light or in stop-and-go traffic. The dashboard lights up like a Christmas tree, and there is a clicking noise. I have to place it into Park, shut off the engine fully (it's not running - I think it's in Accessory mode), step on the brake and restart. Because of this, I make a habit of disengaging the auto idle stop when I start the car. Unfortunately, sometimes I forget to disengage and this engine restart failure happens. I have read that an old/weak battery is suspected. This is not true in my case. This issue has happened several times after I changed the battery on 12/15/2020. Interstate MTX48/H6 battery at $300. It's not just me - it has happened to my wife, and my 17 year old son, when driving this car. At first, I thought my wife did something wrong, then it happened to me. In total, I'd guess it's happened > 6-7 times. We try to be careful to push the button and disengage the auto idle stop. But you have to do it EVERY TIME YOU START THE CAR. If you forget or are distracted, then the problem can occur.
Engine, Jul 15, 2022
Cuando el motor se pone en reposo para economizar gasolina y emitir menos emisiones y le toca arrancar no enciende el motor.
Electrical system, Engine, Fuel/propulsion system, Jul 14, 2022
While stopped at a red light, with the auto start enabled, the car would not turn back on and placed the car in “neutral”. The dash info message prompted me to put the car in “park”. I did. It then instructed me to depress the brake and hit the “start” button to turn the car on. It did not after I tried a few times. Finally to get it started I pushed the “start” button with the key fob. It then turned on and allowed me to put it in “drive”.