2016 Honda Pilot
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,706 owner complaints filed for this model year. This is the highest complaint count among 23 Pilot model years with reports.
Of the 2016 reports, 23 involved a crash and 10 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Structure, frame and membersJun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Campaign 26V365000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpDec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Campaign 23V858000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalNov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Campaign 23V751000 on NHTSA.gov
Structure, body, hoodNov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Campaign 21V932000 on NHTSA.gov
Fuel system, gasoline, storageMar 30, 2017
Honda (American Honda Motor Co.) is recalling certain 2016 Honda Pilot 2WD and AWD vehicles. The affected vehicles have fuel tanks that may leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Honda will notify owners, and dealers will replace the fuel tank, free of charge. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is KE8.
Campaign 17V219000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyJun 9, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura MDX 2WD and MDX 4WD vehicles, 2016 Acura MDX 4WD vehicles, 2015-2016 Honda Odyssey vehicles, and 2016 Honda Pilot 2WD and 4WD vehicles. The affected vehicles have fuel tanks that were manufactured with insufficient welds which may separate and allow fuel to leak out.
A fuel leak in the presence of an ignition source may result in a fire.
Honda will notify owners, and dealers will replace the fuel tanks, free of charge. Owners may contact Honda/Acura customer service at 1-888-234-2138. The recall began on July 29, 2016. Honda's numbers for this recall are KA9 (Honda vehicles) and KB0 (Acura vehicles).
Campaign 16V417000 on NHTSA.gov
Electrical system, instrument cluster/panelOct 16, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot 2WD vehicles manufactured May 4, 2015, to September 8, 2015 and 2016 Pilot 4WD vehicles manufactured May 7, 2015 to September 4, 2015. In the affected vehicles, when one of the safety systems such as tire pressure monitoring, anti-lock braking or electronic stability control malfunctions, there is potential that the instrument panel will not illuminate the corresponding warning light, however the warning lamps will illuminate when the ignition is turned off and then turned back on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic stability control systems", number 135, "Light vehicle brake systems" and number 138, "Tire pressure monitoring systems".
If a safety system cannot immediately warn the driver when needed, the driver may be at increased risk of a crash.
Honda will notify owners, and dealers will update the instrument cluster software, free of charge. The recall began on December 11, 2015. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JV7.
Campaign 15V668000 on NHTSA.gov
Seat belts, rear/otherJul 6, 2015
Honda (American Honda Motor Co.) is recalling certain model year 2016 Honda Pilot vehicles manufactured May 4, 2015, to June 5, 2015. Due to an assembly issue, the third row seatbelt may be trapped between the rear seat and the rear sideliner.
If the third row seatbelt is trapped, the occupants may not be restrained properly, increasing the risk of injury.
Honda will notify owners, and dealers will inspect and repair the rear third row seat belt, free of charge. The recall began on August 6, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JS7.
Campaign 15V424000 on NHTSA.gov
Representative owner complaints
1,706 reports, newest first.
Power train, Electrical system, Engine, Jun 16, 2022
Multiple times the vehicle wouldn’t start. The start stop switch is the culprit after 7 months of dealing with it and taking it to dealership finally. Car will cut off at stop light but won’t turn back on. Takes like 4 tries to get it back on. Also at 126k or 128k engine had a knocking sound and needed replaced and it cost $7000 the air conditioning doesn’t work and this is very upsetting this isn’t why I buy Hondas. The start stop event happens everyday and every time I start the car and don’t deactivate the start/stop system
Other or unspecified, Jun 15, 2022
Honda has a "stop / start" feature that when stopping at a stop sign or traffic light, with brakes applied, stops the engine. Once you take foot off brakes, the engine should restart. On four occasions, the engine did not restart. This is a fuel saving feature, however, in each case I'm stuck in traffic while trying to "restart" my Honda Pilot.
Engine, Jun 14, 2022
When stopping at a stop light the auto idle start stop will not start up immediately as it sometimes has a lag and the audio in the car also completely shuts off. The car stalls out. Have brought car to dealership and since they can’t “recreate” the problem they’re acting like there is no problem. There is definitely a problem. This vehicle has been doing this on and off for sometime now and I have to remember to turn OFF the idle/stop function button every time I start up my car in order to avoid stalling in the middle of traffic. Very unsafe, dangerous and scary.
Electrical system, Engine, Jun 14, 2022
My 2016 Honda pilot stalls when my car turns off from the auto idle engine. If I do not manually turn the feature off EVERYTIME I turn my car on my car will stall out when i lift my foot off the brake. It has progressively taken longer to turn the vehicle back on (anywhere from 30 seconds to 2 minutes) I have been to honda 2x for this issue & their "fix" has never resolved the issue. They will not admit they cannot fix it, even when I showed them a video of exactly what happens when I try to get my vehicle back on.
Electrical system, Jun 14, 2022
The engine idle-stop feature did not restart. It is available for inspection. The safety of my two small children and myself was at risk as we had to get out of the car at a busy intersection. It has not been reproduced by a dealer or a service center. The vehicle and the parts have not been inspected by authorities. It happens without warning. While at a red light, when I take my foot off the brake it shuts off completely.
Engine, Jun 13, 2022
Engine stops completely when I make a stop at the signal. I think this is due to the engine shut down idle function. When the engine shuts down completely, the car doesn't start for 5 to 10 minutes. This happened at least 10 times in 6 months on the middle of the road.
Electrical system, Jun 13, 2022
The Pilot has an auto start/stop function that turns off the engine when the car is stopped/idling. When the driver releases the break pedal, the engine is supposed to turn back on. The engine would very frequently fail to turn back on after idling. This happened many times at traffic lights and while stopped in traffic. It's much worse than stalling out with a manual transmission vehicle, because the engine does not turn back on quickly. The whole system (including battery power to the car) needs to be turned off and turned on again. This is a safety issue because the engine has failed to start while in traffic on the interstate, where cars are quickly accelerating, and the failure for the car to accelerate with traffic could lead to a collision. It also poses the risk of leaving the driver stuck in a dangerous location without the ability to move the car. I took the car to the dealership and they told me my battery was dying, and they charged me to replace the battery. So far, I haven't experienced anymore engine stalling with the new battery. The car has not been inspected by anyone other than the local Honda dealership. There were no warning lamps or messages prior to the failure. The failure first started in 2020, but only happened a few times. Since then, the problem increased in frequency, until I finally took it to the dealership and had the battery replaced.
Electrical system, Engine, Jun 13, 2022
I bought this car used in May 2022. My wife is the primary driver and this incident happened to her three times and myself once. When stopping at a red light, the engine turns off to save fuel with the auto start stop feature. We normally turn this off, but sometimes when we forget, the auto start fails to start the engine leaving us stuck in traffic trying to start the car at a green light. It takes multiple attempts to restart the car. This wouldn't be an issue if we could turn off the auto stop start permanently. We don't like the feature anyway, sometimes it causes the car to lurch forward when removing your foot from the break while the engine is starting.
Other or unspecified, Engine, Jun 13, 2022
Stop/start feature fails to restart the car. I have to turn off the car completely to restart.
Electrical system, Jun 13, 2022
The stop/start feature fails to restart engine and I have to shut off the car completely to restart again.
Engine, Jun 12, 2022
There have been many instances of the vehicle failing to restart after a complete stop at a stop light. In these situations, the vehicle's auto stop-start system engages and turns the engine off. When the brake peddle is disengaged and the engine is supposed to start, the engine fails to restart. There are some errors on the dashboard but nothing was captured on the vehicle computer when I took it into the dealership. When the engine won't restart it takes a minute or two of blocking traffic before the engine will start up. I have to turn off the vehicle and then restart sitting in the lane hoping none will crash into me. I have also taken the vehicle into the dealership numerous time to no avail.
Engine, Jun 11, 2022
On 11/29/21, 1 block from home, the engine started making a very loud knocking noise. I was able to turn around and drive back home but no faster than 20 MPH. After having the car towed to Schlossmann Honda, the diagnosis was: Full engine seizure, cylinder 3 connecting rod broken, piston damaged bank 1 cylinder head, metal contamination in bank 2 cylinder head, scoring on bank 2 camshaft and cam journals. Replaced short block assembly and both cylinder assemblies. This happened at 101,587 miles, which was 1,587 miles after extended warranty expired. Repair was not covered but after pushing with Honda Corp, they agreed to charge me an $8,000 deductible for the repair.
Engine, Jun 11, 2022
On 6/11/22, while driving on I-94 in downtown Chicago in heavy traffic the vehicle engine turned off as part of the auto shut off/on feature. The vehicle would not start button. back up and was stranded in the middle lane. The engine would not start back up, even after putting in park, pressing the brake and holding the start button. After 10 minutes or so I was able to get the vehicle re-started by pressing the brake and holding the start button for 10 seconds. Totally an unsafe situation being in the middle lane in downtown Chicago! This has happened at least 7-10 times previously.
Other or unspecified, Jun 10, 2022
stop-start fuel saving system don't work properly.
Electrical system, Jun 10, 2022
The contact owns a 2016 Honda Pilot. The contact stated that after stopping the vehicle and then attempting to accelerate, the vehicle lost motive power and stalled. There was no warning light illuminated. The vehicle restarted however, there was a delay in the proper functionality of the vehicle. The vehicle was taken to the local dealer to be diagnosed; however, the mechanic found no failure with the vehicle. The contact stated that an unknown part of the instrument panel was replaced however, the failure persisted. The manufacturer was not contacted or notified of the failure. The failure mileage was approximately 20,000.
Engine, Forward collision avoidance, Jun 9, 2022
I have been having trouble with the auto-engine idle/restart feature for over 2years! (I saw this is a current investigation) I reported the problem to my local dealer at time of routine maintenance visit ~2yrs ago and (without driving it except from the garage to the customer driveway) they said “there’s no problem, looks fine”. I now try to remember to disengage that feature as soon as I turn on the car, but when I forget I stall out at red lights. It’s always been a design flaw that you can’t just turn off the feature! I’ve never had to be jumped off but it does block up traffic for a minute to have to restart the car. This same vehicle also had the failed fuel injectors at ~35k miles, starting almost a year before the official recall, and it took over 6 mos to diagnose that problem through multiple various dealerships and service stations. This 2016 model with the first generation of the Honda tech package has been a hot mess! (The lateral collision sensors are also set too wide and the car will abruptly break for cars in turn lanes or driveways adjacent to your lane. I reported this to the dealership within the first year as well)
Engine, Jun 9, 2022
Start-stop failure on Honda Pilot. When this feature is in use, car will shut off completely and has happened at intersections which creates a danger.
Engine, Jun 9, 2022
If I forget to turn the auto idol off my car shuts down when stopped and won't restart. This has been going on for years and when I tell the Honda service to check it out they find nothing wrong and tell me this is normal. I know this can't be normal as it's a safety hazard. I fear for my life when this happens as I am afraid a car will drive into me until I can get my car started again. It's very stressful and I have just dealt with it as I have not been able to afford to get a new car. I recently heard this safety problem has been recognized. I should have sent this in much sooner but when my Honda service tells me this is normal I didn't think there was anything I could do. I can't enter a date below because this is an ongoing issue.
Engine, Fuel/propulsion system, Jun 9, 2022
The problem has happened at-least 5 times won’t restart on its own from a complete stop at a traffic light or intersection with the stop-start feature in use.Brought to Honda dealership and they stated the do not see a problem. This is a safety problem that needs to be addressed. It stopped completely when i was in traffic also almost caused an accident.
Electrical system, Engine, Jun 9, 2022
The vehicle’s Auto Stop/Start feature routinely fails to restart the engine when releasing the brake, turning the steering wheel, or selecting Park. In order to start the vehicle, it must be placed into Park, turned off, and then turned back on by holding the Start button. This has worked on most occasions (approx 90% of occasions thus far); other times a jump start was required. Attempts to resolve from Honda have required several purchases of a new battery and denial of there being a larger issue. There is no indication or warning that the feature has failed until attempting to resume driving (or the vehicle attempts to restart itself based on the vehicle’s self-monitored parameters). The failure to start leaves the vehicle stuck in traffic risking collision and/or personal injury as a result.
Engine, Jun 9, 2022
There have been two instances of the vehicle failing to restart after a complete stop at a stop light. In these situations, the vehicle's auto stop-start system engages and turns the engine off. When the brake peddle is disengaged and the engine is supposed to start, the engine fails to restart. There are some errors on the dashboard but nothing was captured on the vehicle computer when I took it into the dealership. When the engine won't restart it takes a minute or two of blocking traffic before the engine will start up.
Electrical system, Engine, Fuel/propulsion system, Jun 9, 2022
While at a stop light, with the engine "Auto Start/Stop" switch engaged, I released my foot from the brake, and the car died. I was totally confused as to what occurred. After a minute or two I was able to restart the car. I was very concerned about being re-ended as when the light changed to green is when the car died. I had no advance warning of a problem, and it just died unexpectedly as I released my foot from the break. No lights on the dash either. I notified my dealer, who had never heard of this happening, and said when I can, please bring it in. In as much as the incident occurred in May 2022, and hadn't happened since, I did not take my car into the dealer. I can take my car in at any time to be examined.
Fuel/propulsion system, Jun 9, 2022
Unknown. Background: Driving vehicle and engine warning came on. Looked up code and it was due to injector failure. Dealership changed injectors and reprogrammed. Now vehicle gets nowhere the gas mileage and the start/stop has stopped. That doesn't bother me as bad due to it shut off at light one day and would not start back for about a min. Then started and went it's way.
Engine, Jun 9, 2022
The auto engine restart does not always engage when pressing on the accelerator after a stop. When it happens, it takes about 30 seconds and several pushes of the ignition button for the engine to restart. I have been stranded in the middle of a busy intersection waiting to turn left with my kids in my vehicle, vulnerable to a broadside hit as the light has turned. I have not taken it in because the problem is not easily reproducible, and I don’t have time for them to give me the run around. The battery is not original; it was replaced in 2020. I disengage the auto stop/restart system with the button each time I turn on the vehicle.
Engine, Jun 8, 2022
In 3 occasions my Pilot was stopped waiting for the light to change and all of the sudden the engine died and refuse to turn itself ON as usual. The first time it happens in Miami, Fl. The second time in our hometown of Teaneck, NJ and the third time it happens in New York City (Manhattan) The first time the car re-started after 5 minutes trying (more than 5 times). The second time the car died and 5 took about 5 times to restart again. The third time, we had to use our battery jump starter because the battery died. After the car turned on, all the systems were fine, including the battery.