2025 Honda Pilot
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 202 owner complaints filed for this model year. This is the 14th highest complaint count among 23 Pilot model years with reports.
Of the 2025 reports, 11 involved a crash. 11 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, pedals and linkagesJun 12, 2025
Honda (American Honda Motor Co.) is recalling certain 2021-2025 Acura TLX, 2023-2025 Acura MDX, and 2023-2025 Honda Pilot vehicles. The brake pedal pivot pin was not secured properly, which can cause the pedal to shift out of position. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard numbers 108, "Lamps, Reflective Devices, and Associated Equipment" and 135, "Light Vehicle Brake Systems."
A brake pedal that shifts out of position can prevent the driver from applying the brakes as intended, increasing the risk of a crash or injury.
Dealers will inspect and replace the brake pedal assembly as necessary, free of charge. Owner notification letters were mailed July 29, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are FLX and XLY.
Campaign 25V391000 on NHTSA.gov
Seat belts, rear/otherFeb 5, 2025
Honda (American Honda Motor Co.) is recalling certain 2025 Honda Pilot vehicles. The third-row passenger seat belt assembly may not function, due to incorrect routing that traps the seat belt behind the passenger side panel. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
A non-functioning seat belt cannot properly restrain the seat occupant, increasing the risk of injury during a crash.
Dealers will inspect and repair the seat belt routing as necessary, free of charge. Owner notification letters were mailed March 24, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is ZL4.
Campaign 25V056000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemJan 23, 2025
Honda (American Honda Motor Co.) is recalling certain 2022-2025 Acura MDX Type-S, 2023-2025 Honda Pilot, and 2021-2025 Acura TLX Type-S vehicles. A software error in the fuel injection electronic control unit (FI-ECU) may cause an engine stall or a loss of power.
An engine stall or loss of power can increase the risk of a crash or injury.
Dealers will reprogram the FI-ECU software, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are EL1 and AL0.
Campaign 25V031000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capNov 27, 2024
Honda (American Honda Motor Co.) is recalling certain 2023-2024 Passport and 2023-2025 Pilot vehicles. The fuel filler neck tube and fuel filler pipe may separate, allowing fuel to leak.
A fuel leak in the presence of an ignition source increases the risk of a fire.
Dealers will inspect and repair the fuel filler neck tube and pipe as necessary, free of charge. Owner notification letters were mailed January 7, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is OKM.
Campaign 24V900000 on NHTSA.gov
Representative owner complaints: engine
30 reports, newest first. Show all
Power train, Engine, Apr 5, 2025
When shifting to reverse it shifts back to park And it will not move forward or reverse I nearly had someone rear ended me as I backed up from my driveway. This has happened numerous times that I am afraid to drive it. The mileage right now is only 216 miles since bought in December 2024.
Steering, Electrical system, Engine, Dec 6, 2024
I was driving and I began slowing down as I approached a red light. My vehicle suddenly stopped. I was unable to turn the vehicle back on nor change the gear. When I would press the start button while pressing the brakes, some dash lights would turn on but again I was not able to change the gear. After several attempts of turning the car on, the car started and I was able to change gears to Drive. Approximately one or two blocks later, while in motion, the car abruptly stopped again. This time the dash displayed “Engine Oil Pressure Low” Stop Engine. Do not Drive”. The car was subsequently towed to a nearby Honda Dealership where an inspection was allegedly done and the issue was supposedly fixed. The service notes stated the vehicle was found with low oil levels and that no leak was found. They released the car back to me. Now, one week after I picked the car up from the Honda Service Department, I encountered the same issue again. While stopped in traffic, my vehicle shut down. I was unable to turn it back on nor change the gears. An orange steering wheel with an orange exclamation mark next to it popped up on the upper right hand corner of my dashboard along with a red battery logo below it. I was on the roadway unable to turn the car back on for approximately one hour. After continuous failed attempts to turn the car on and change the gear, at one point it turned back on and I was able to drive the car.
Other or unspecified, Engine, Nov 26, 2024
At 65 mph or higher ( highway speed), I hear the constant troubling noise coming from the front of the vehicle. I had taken the car to the dealership in Fallston, Harford County, Maryland, for inspection twice. The mechanic acknowledged hearing the same noise but could not diagnose any problem with the vehicle. The same mechanic drove another 2025 Honda Pilot and was able to replicate the same noise while driving at highway speeds. Subsequently, I wrote the letter to American Honda Motor Co., Inc outlining the problem and seeking resolution. I was informed there was no open campaigns and to contact NHTSA to file my complain.
Other or unspecified, Engine, Fuel/propulsion system, Nov 13, 2024
- Had initially reported this problem to dealer at ~1590 miles on the vehicle. After ~2,200 miles gasoline smell is still there and severe. - The smell is obnoxious to driver if driving with Windows rolled up and is a safety concern. - Issue is more pronounced, severe when driving at the beginning of the day after overnight parking. - Took it to same dealer twice, they did diagnosis and informed it’s because of the plastic stuck to the exhaust which is the cause. They want to wait out till it’s fully burnt and the smell should go away. - Have raised a case with the manufacturer too and they’re looking.
Other or unspecified, Engine, Fuel/propulsion system, Oct 25, 2024
- Extremely strong gasoline smell inside the vehicle while driving. Didn’t matter AC on or off, smell was terrible but more evident with AC/Fan on. Had to lower all the 4 windows to let out the air. - With a toddler in car it was terrifying with the nauseating smell and/or the risk of fire if at all. - Problem not reproduced by dealer and was mentioned it’s a sticky plastic in exhaust, will go away. - First appeared only on 23rd Oct 2024 with around 1,590 miles on it and not until then. No other related symptoms. - Fuel was almost 3/4th full and had been more than 8 days since last filled. Never filled to the brim ever or overflowed.