2025 Honda Pilot
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 202 owner complaints filed for this model year. This is the 14th highest complaint count among 23 Pilot model years with reports.
Of the 2025 reports, 11 involved a crash. 11 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, pedals and linkagesJun 12, 2025
Honda (American Honda Motor Co.) is recalling certain 2021-2025 Acura TLX, 2023-2025 Acura MDX, and 2023-2025 Honda Pilot vehicles. The brake pedal pivot pin was not secured properly, which can cause the pedal to shift out of position. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard numbers 108, "Lamps, Reflective Devices, and Associated Equipment" and 135, "Light Vehicle Brake Systems."
A brake pedal that shifts out of position can prevent the driver from applying the brakes as intended, increasing the risk of a crash or injury.
Dealers will inspect and replace the brake pedal assembly as necessary, free of charge. Owner notification letters were mailed July 29, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are FLX and XLY.
Campaign 25V391000 on NHTSA.gov
Seat belts, rear/otherFeb 5, 2025
Honda (American Honda Motor Co.) is recalling certain 2025 Honda Pilot vehicles. The third-row passenger seat belt assembly may not function, due to incorrect routing that traps the seat belt behind the passenger side panel. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
A non-functioning seat belt cannot properly restrain the seat occupant, increasing the risk of injury during a crash.
Dealers will inspect and repair the seat belt routing as necessary, free of charge. Owner notification letters were mailed March 24, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's number for this recall is ZL4.
Campaign 25V056000 on NHTSA.gov
Fuel system, gasoline, fuel injection systemJan 23, 2025
Honda (American Honda Motor Co.) is recalling certain 2022-2025 Acura MDX Type-S, 2023-2025 Honda Pilot, and 2021-2025 Acura TLX Type-S vehicles. A software error in the fuel injection electronic control unit (FI-ECU) may cause an engine stall or a loss of power.
An engine stall or loss of power can increase the risk of a crash or injury.
Dealers will reprogram the FI-ECU software, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are EL1 and AL0.
Campaign 25V031000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capNov 27, 2024
Honda (American Honda Motor Co.) is recalling certain 2023-2024 Passport and 2023-2025 Pilot vehicles. The fuel filler neck tube and fuel filler pipe may separate, allowing fuel to leak.
A fuel leak in the presence of an ignition source increases the risk of a fire.
Dealers will inspect and repair the fuel filler neck tube and pipe as necessary, free of charge. Owner notification letters were mailed January 7, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is OKM.
Campaign 24V900000 on NHTSA.gov
Representative owner complaints: service brakes
32 reports, newest first. Show all
Steering, Service brakes, Jul 6, 2025
I purchased a brand-new 2025 Honda Pilot Elite, and within the first 1,000 miles of driving, I began noticing multiple concerning noises and performance issues: Steering Noise: At low speeds, particularly while turning, the steering system emits a subtle but persistent creaking noise/noises from the steering wheel area. The creaking is especially noticeable when making slow turns in parking lots or driveways. It appears to worsen in warmer temperatures and is consistent regardless of road condition. I brought the issue to the dealership's attention, and they kept the vehicle for approximately three weeks. They replaced the clock spring and airbag, claiming the noise was resolved. However, the creaking noise returned shortly after I resumed driving the vehicle. Brake Popping: There is also a popping/clicking noise coming from the front left brake area, especially when braking or shifting between drive and reverse. The dealership lubricated the brake hardware but did not resolve the issue. Despite Honda service attempts, the noises persist. Numerous other 2023–2025 Honda Pilot owners have reported similar symptoms online, many citing steering rack/pinion defects or unresolved brake component issues. These defects appear widespread and unresolved by standard dealership repairs. Safety Concern: While the issues may currently present as mechanical noises, I am deeply concerned that they may signal underlying defects in critical safety systems—such as steering control and braking performance. Unaddressed, these could potentially lead to steering failure, brake failure, or loss of control, especially during low-speed maneuvers where driver response time may be compromised due to mechanical unpredictability. Request for Investigation: I respectfully request that the NHTSA investigate these issues, as they appear to be affecting a growing number of new Honda Pilot vehicles across the 2023 to 2025 model years, the dealership do not know what to do.
Electrical system, Service brakes, Forward collision avoidance, May 14, 2025, crash
My 2025 Honda Pilot’s Collision Mitigation Braking System and backup sensors have failed three times at low speed, resulting in collisions with objects directly behind or in front of the vehicle. These include a front collision with a tree, running over a small tricycle, and backing into a tree — all under 5 mph with sensors fully enabled. The system failed to detect or respond in any instance. This is a critical safety failure
Steering, Electrical system, Service brakes, Oct 5, 2024
New 2025 Pilot with about 3,000 miles, driving in Montana on a level dusty gravel road at about 5,000 feet altitude. Driving into the morning sun for about 20 minutes at a slow speed of about 30 mph all of a sudden multiple warnings flashed, engine, brakes, etc. Steering was stiff and brakes did not feel active, very stiff. I just coasted to a stop on a desolate gravel road, no other traffic. The engine was still running, did not press on the gas for in large red letters the warning panel said "DO NOT DRIVE". The car was very dusty. If we had been on an Interstate at 70 mph that would have been an accident, with steering and brakes inhibited somehow? I shut OFF the engine, waited 10 minutes, started engine again and WARNINGS still active. Shut OFF engine and waited 20 minutes. Restarted engine and looked like warning were starting to clear, and steering and brakes felt normal again. With no WARNINGS showing I drove very slowly for many miles with no further occurrences. Slowly worked my way back across the country to Florida without any further failures. It appears to all be computer related, perhaps sensors failing and the computer shutting down what must be electrical steering and brake assist. At speeds with Interstate traffic, that condition will be an accident. There are no failure codes shown on the access panel. We have an appointment with our Honda service dealer, maybe they will be able to access a computer history to see the failure mode that caused loss of steering and brakes. The fact that a computer can impact those critical systems on a vehicle, is a serious safety issue. Prior to this incident, driving about 30 minutes on a dusty gravel road in Montana, some sensor must have been actuating the rear brake caliper, I could hear the scraping sound of pad on rotor, didn't sense the car slowing. The car was dusty, maybe sensors inhibited, the scraping lasted about 15 minutes, at least that it could be heard in the car. Could be a safety iss
Service brakes, Forward collision avoidance, Sep 30, 2024
While driving on a winding mountain pass traveling from Bozeman, MT to Butte, MT. I was driving my 2025 Honda Pilot in the inside lane while a semi was traveling in the outside lane ahead of me. As the road curved left, I approached as the semi was ahead in the next lane. I believe my Honda Pilot recognized this as a potential crash and braked hard causing the distance between me and the semi to increase dramatically, even though both vehicles were clearly in their own lanes. Fortunately there was nobody traveling immediately behind me.
Power train, Structure, Service brakes, Aug 29, 2024
The transmission jerks/jumps when accelerating and also as slowing down. The vehicle, including the steering wheel, shakes when braking at speeds above 60mph. Several parts of the body are not put together properly, leaving gaps, overlaps, etc.
Steering, Electrical system, Service brakes, Jul 31, 2024
I was driving my new 2025 Honda Pilot when I went to make a right turn and the steering system locked on me. I couldn't turn right and was almost in a horrible accident. Thank God that the other vehicles were able to stop in time. But I had to get the car out of traffic with the help of good samaritans. I cut the car off and all the systems dispalyed a error and said to see dealer. It was the most scariest and stressful time. I was late to work, my husband had to leave work to come and get me. I had the car towed to the dealership and was given a rental but I want to know why this happened and what will the Honda do to ensure this won't happen to me or someone else driving that car for it to be a 2025 elite edition. I could have been seriously hurt or killed.
Electrical system, Service brakes, Forward collision avoidance, Jul 17, 2024
My CMBS stopped my car in the middle of the road coming home one day. There were no other cars around me (in front of me, behind me, or coming towards me). The word “brake” flashed across my dash and then it beeped at me and just stopped in the middle of the road going 55 mph. My kids and elderly mother in law were in the car with me and we were all shaken up and also very glad there were no cars behind us, or else we could have been injured in a rear-end collision. The dealer has had my car for 21 days now and cannot reproduce it, but they asked if I was in the road that it occurred on, because they have had similar complaints from owners. I do not understand why they don’t drive my car down that same road to be able to reproduce the incident. My below email was sent to the dealer on June 18, because the car keeps locking me out with the key fob inside and the dash resets itself, but won’t turn back on, it is just in the constant spinning reset wheel. My attached photos are of the car refusing to lock because it says a door is open or a window is down, when none of that is happening. (The doors are closed and the windows are up.). The CMBS incident occurred on June 24th, I drove home and had Honda tow my car to the dealership. They have had it ever since.