2003 Hyundai Elantra
Problems, recalls and owner-reported issues
Suspension is the leading concern among 234 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Elantra model years with reports.
Of the 2003 reports, 42 involved a crash and 1 involved a fire. 33 people were injured.
What owners report most often
Recalls and investigations
Suspension, front, control armApr 16, 2009
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V125000 on NHTSA.gov
Fuel system, gasoline, storageJul 26, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Campaign 04V369000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 9, 2004
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 04V178000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsDec 3, 2003
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
Campaign 03V496000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsJul 22, 2003
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 03V257000 on NHTSA.gov
Representative owner complaints: air bags
48 reports, newest first. Show all
Suspension, Air bags, Structure, Oct 21, 2023
Live in Indiana where the weather is super salty in the winters and all of the salt in Indiana has really really affected the whole underside of my car. The whole subframe is falling apart and the rust has gotten to everything under the car. I have spent about 4 thousand dollars into this car doing all the work myself to make this car run In pristine conditions. I am very very worried that my whole back end will just fall apart going down the road due to the rust.
Air bags, Structure, Jun 3, 2018, crash
I HAD A WRECK TODAY ON A HIGHWAY WHERE I WAS TRAVELING AT 40 MPH AND I SLAMMED ON MY BRAKES AND HIT THE CAR IN FRONT OF ME WHEN THE VEHICLE IN FRONT OF ME STOPPED SUDDENLY. MY CHEST RAMMED INTO THE STEERING WHEEL AND THE BAGS DID NOT DEPLOY.THE CAR WAS TOTALLY SMASHED IN THE FRONT AND THE DOOR HAD A HARD TIME OPENING. I WAS RUSHED TO THE ER AND HAD CONTUSIONS TO MY STERNUM AREA OF MY CHEST. *I DID WEAR SEAT BELTS.
Air bags, Nov 16, 2016
AIR BAG SIGN ON, I TOOK DEALER MECHANIC SAID IT IS MANUFACTURING ISSUE.
Electrical system, Air bags, Sep 7, 2016
REPLACED SENSORS BECAUSE THE CHECK ENGINE LIGHT CAME ON, NOW THE CAR WON'T PASS INSPECTION. THE DIAGNOSTIC TESTS WON'T READ ANY MALFUNCTION AND THE AIRBAG LIGHT WON'T GO OFF
Electrical system, Air bags, Fuel/propulsion system, Jun 22, 2016
I HAD TO REPLACE STRUTS IN FRONT
Air bags, Service brakes, Sep 25, 2015, crash
TL* THE CONTACT OWNED A 2003 HYUNDAI ELANTRA. WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE BRAKES FAILED TO RESPOND AND ANOTHER VEHICLE CRASHED INTO THE FRONT PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE VEHICLE SPUN AROUND SEVERAL TIMES. ONLY THE PASSENGER SIDE CURTAIN AIR BAGS DEPLOYED. THE CONTACT WAS TAKEN FROM THE ACCIDENT BY AMBULANCE TO A NEARBY HOSPITAL. THE CONTACT WAS TREATED FOR NECK AND LOWER BACK PAIN. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 151,000.
Air bags, Jun 9, 2015
DRIVING AT 45MPD AIR BAG LIGHT ACTIVATED. WENT TO MY REPAIR SERVICE RAM AUTO(FT. PIERCE,FL. TECH TESTED WITH CAR DIAGNOSTIC DEVICE. COULD NOT FIND ISSUE. TRIED TO DELETE CODE FOR AIR BAG, LIGHT COMES BACK ON. SUGGESTED I SEE IF ANY RECALLS FOR THIS VEHICLE- NO REPORTS OF AIR BAG RECALLS FOR A HYUNDAI 2003 GLS.
Air bags, Seat belts, Structure, Jun 17, 2014, crash
I HAD A LOW SPEED ACCIDENT APPROXIMATELY 10-20MPH IN A PARKING LOT WHERE I HIT A CEMENT SURROUNDING OF A POLE ON THE DRIVER SIDE AND THE AIRBAG DEPLOYED ON THE PASSENGERS SIDE CAUSING SIGNIFICANT DAMAGE TO THE WINDSHIELD, BUSTED THE DASH VENTS, LOCKED MY DRIVERS SEATBELT AND SHATTERED WINDSHIELD GLASS ALL OVER THE CAR. *TR
Engine and engine cooling, Air bags, Seat belts, Fuel/propulsion system, Sep 29, 2013
A FEW MONTHS BACK I BEGAN NOTICING THAT MY CHECK ENGINE LIGHT CAME ON. WOULD TAKE 10- 15 MINS TO FILL UP GAS TANK. SENSOR WAS TRIGGERED EVERY FEW SECONDS, SUGGESTING GAS TANK WAS FULL, BUT IT WAS NOT. TOOK IT TO THE DEALER AND WAS TOLD THERE WAS NOTHING WRONG WITH THE CAR. WITH IN THE LAST MONTH I HAVE BEEN NOTICING THAT REAR AUTOMATIC LOCKING SEAT BELT IS NOT STAYING LOCKED. CHILD CAR SEATS DO NOT STAY SECURED. CAR OCCASIONALLY STALLS WHEN STARTED, AND AIR BAG LIGHT DOES NOT ILLUMINATE TO DETERMINE IF AIR BAG WILL DEPLOY OR NOT. *TR
Air bags, Mar 31, 2011
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHEN THE CONTACT STARTED THE VEHICLE, HE NOTICED THAT THE AIR BAG LIGHT WAS ILLUMINATED. HE STATED NO ONE WAS SITTING IN THE PASSENGER SEAT. THE AIR BAG LIGHT STAYED ON CONSTANTLY SINCE FEBRUARY 2011. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THE AIR BAG CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS CONTACTED AND THE CONTACT WAS ADVISED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 29,500.
Air bags, Dec 15, 2010, crash
THE VEHICLE WAS INVOLVED IN A FRONT END COLLISION, TOTALING SAID VEHICLE, AND THE AIRBAGS DID NOT DEPLOY. NOTHING WAS DONE TO CORRECT THIS FAILURE AS THE VEHICLE WAS A TOTAL LOSS. HOWEVER, HYUNDAI MOTORS NEVER CAME TO INSPECT THE CAR, DESPITE BEING GIVEN AMPLE NOTICE. THE VEHICLE HAS SINCE BEEN SCRAPED. *TR
Air bags, Oct 22, 2010, crash
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT WAS TRAVELING 25 MPH AND SWERVED IN ORDER TO AVOID HITTING A DEER. WHEN THE CONTACT SWERVED, HE CRASHED INTO A ROCK HEAD ON; HOWEVER, THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE BACK TO HER RESIDENCE. THE CONTACTS INSURANCE COMPANY INSPECTED THE VEHICLE AND STATED THAT IT WAS DESTROYED. THE CONTACT HAS HELD ONTO THE VEHICLE IN ORDER TO FIND OUT WHY THE AIR BAGS DID NOT DEPLOY. OVER TIME THE CONTACT NOTICED THAT THE STEERING WHEEL WAS COMING APART AND THAT THE AIR BAG WAS EXPOSED. THE VEHICLE HAD NOT BEEN INSPECTED BY THE DEALER. THE CONTACT WANTS TO KNOW WHY THE AIR BAGS DID NOT DEPLOY. THE FAILURE AND CURRENT MILEAGES WERE 85000. UPDATED 01/12/11*LJ UPDATED 03/28/11
Air bags, Oct 1, 2010, crash
2003 HYUNDAI ELANTRA. CONSUMER STATES VEHICLE WAS IN AN ACCIDENT AND AIRBAGS DID NOT DEPLOY *TGW THE VEHICLE WAS TOTALED. *JB
Air bags, Sep 30, 2010
DRIVING DOWN THE ROAD BOUT 25-30 MILES SWERVED (VERY SHARP) DIDN'T THINK IT SHOULD HAVE BEEN SUCH A SHARP TURN- ANYWAY SWERVED FROM HITTING A DEER- SO I DID ACCELERATE AND ENDED UP WITH A DIRECT FRONT HIT- CAR IS TOTALED- ACTUALLY LOST A PIECE OF WHAT HOLDS THE ENGINE UP THE BOLT IS BROKEN IN HALF-HOOD OF CAR CAN NOT BE OPENED - IMPACT THROUGH MY NECK AND BACK OUT- NO AIRBAGS. *TR
Air bags, Jul 28, 2010
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE AIR BAG LIGHT BEGAN TO INTERMITTENTLY ILLUMINATE ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE AN UNKNOWN CABLE WITHIN THE ONE OF THE FRONT SEATS WAS REPLACED UNDER WARRANTY. APPROXIMATELY 2 YEARS LATER THE FAILURE BEGAN TO RECUR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THIS WAS NOT A KNOWN FAILURE AND HE WOULD HAVE TO PAY TO HAVE THE VEHICLE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 50,000.
Air bags, Aug 12, 2009, crash
NO KNOWN PROBLEMS WITH AIR BAGS. I WAS IN A T-BONE COLLISION WITH A LARGE SUV (SUBURBAN) TOTALING MY CAR. THE HIT WAS ON THE DRIVER'S SIDE AND NONE OF THE AIRBAGS DEPLOYED. THE POLICE OFFICER STATED SUBURBAN WAS TRAVELING 35-40 MPH. *TR
Exterior lighting, Air bags, Jul 23, 2009
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT CONTINUED TO ILLUMINATE ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THE MODULE FAILED AND WOULD COST OVER $600 TO REPAIR. THERE WERE NO RECALLS FOR THE FAILURE AND THE MANUFACTURER HAS NOT BEEN NOTIFIED. IN ADDITION, THE LOW BEAM HEADLIGHTS WOULD BURN OUT EVERY 3-6 MONTHS. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 36,700. UPDATED 9/1/09 *CN UPDATED 09/02/09.*JB
Air bags, May 7, 2009
I HAD TAKEN MY CAR IN FOR SERVICE IN APRIL 09 FOR OIL CHANGE, TIRE BALANCING. I HAD TO RETURN IT BECAUSE CAR WAS VEERING TO THE LEFT. WHEN I PICKED IT UP THE 2ND TIME THE THE AIRBAG LIGHT CAME ON AND NOW STAYS ON WHILE DRIVING. ON 5/1/09 I TOOK THE CAR BACK TO DEALER AND THEY SAID THE CAUSE IS "PPD SENSOR OPEN" WHICH THEY WANT TO CHARGE ME $390 TO FIX. SINCE THE ELANTRA OF 2001-2002 HAD THE SAME ISSUE WITH AN AIRBAG LIGHT THIS MAY BE A DEFECT IN THE 2003S AS WELL. *TR
Air bags, Apr 16, 2009, crash
MY SON WAS DRIVING A 2003 HYUNDAI ELANTRA AND HIT BLACK ICE ON INTERSTATE 81S AT APPROXIMATELY 60MPH. HE LOST CONTROL OF THE CAR AND IT SPUN AND HIT THE CENTER GUARDRAIL. THE VEHICLE WAS A TOTAL LOSS. THE AIRBAGS DID NOT DEPLOY. FORTUNATELY, HE WAS UNHURT, BUT I HAVE SEARCHED THE WEB AND THERE ARE MANY COMPLAINTS ABOUT THIS ISSUE POSTED AT VARIOUS SITES. BUT IT SEEMS THAT HYUNDAI IS NOT TAKING ACTION. *TR
Air bags, Dec 8, 2008, crash
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE DRIVING 15 MPH ON NORMAL ROAD CONDITIONS, ANOTHER VEHICLE CRASHED INTO THE PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT SUSTAINED MODERATE INJURIES. THE VEHICLE WAS COMPLETELY DESTROYED. THE POLICE AND AMBULANCE WERE CALLED TO THE SCENE AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A COLLISION CENTER. THE FAILURE AND CURRENT MILEAGES WERE 72,000. UPDATED 01/14/09. *LJ UPDATED 01/21/09
Air bags, Dec 4, 2008
MY 2003 HYUNDAI ELANTRA HAS 64,000 MILES ON IT & THE AIRBAG MODULE WENT OUT & AM TOLD IT WILL COST OVER 800.00 TO FIX & IT WON'T DEPLOY IF I HAVE AN ACCIDENT. I HAVE HYUNDAI EXTENDED COVERAGE PLAN OF 10 YEARS/100,000 MILES & WAS TOLD IT COVERS 'EVERYTHING BUT THE SINK' THEY TELL ME IT WON'T COVER THIS. THIS SEEMS LIKE A SAFETY ISSUE TO ME. *TR
Air bags, Jul 29, 2008, crash
A DEER LEAPED IN FRONT OF MY CAR CAUSING ME TO CRASH INTO THE DIVIDER ON HIGHWAY - NO AIRBAGS DEPLOYED DURING THIS INCIDENT. *TR
Air bags, Apr 28, 2008
THE AIRBAG LIGHT IS ON, I IT REPLACED. I HAVE NO IDEA IF IT WILL WORK, IF IT WILL GO OFF AND KILL SOMEONE DRIVING THE CAR. PLEASE RECALL THE CARS AND HAVE HYUNDAI REPLACE OR REPAIR THIS SITUATION BEFORE MORE PEOPLE ARE KILLED. THANKS *TR
Air bags, Jul 13, 2007, crash
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. ON AUGUST 15, 2006, WHILE DRIVING 40 MPH, THE FRONT END OF THE CONTACT'S VEHICLE CRASHED (T-BONED) INTO THE FRONT END OF ANOTHER VEHICLE. THE VEHICLE WAS DESTROYED. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED CHEST PAINS FROM THE STEERING WHEEL PRESSING INTO HER CHEST. A POLICE REPORT WAS FILED. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 150,000.
Electrical system, Air bags, Tires, Apr 26, 2007
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT NOTICED THAT THE AIR BAG INDICATOR LIGHT KEPT ILLUMINATING. THE DEALER REPAIRED THE FAILURE AND DIAGNOSED IT AS THE AIR BAG SENSOR. APPROXIMATELY 60,000 MILES LATE, THE FAILURE RECURRED. ALSO, CURRENTL YTHE ELECTRICAL SYSTEM FAILED. THE CONTACT STATED THAT THE RADIO ACTIVATED AUTOMATICALLY, THE VOLUME INCREASED, AND CERTAIN LIGHTS INSIDE THE VEHICLE, SUCH AS THE AIR CONDITIONER CONTROLLER LIGHTS, FAILED TO ILLUMINATE. THE CONTACT HAD THE RADIATOR REPLACED . IN ADDEITION, THE TIRES WERE CONSTANTLY WEARING OUT, AND SHE WAS ABOUT TO PURCHASE FOURTH SET IN LESS THAN TWO YEARS. SHE HAS NOT SPOKEN WITH THE MANUFACTURER ABOUT THE FAILURES. THE CURRENT MILEAGE IS 73,000 .AND FAILURE MILEAGES WAS 45,000. *AK ABL.PCO