2003 Hyundai Elantra
Problems, recalls and owner-reported issues
Suspension is the leading concern among 234 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Elantra model years with reports.
Of the 2003 reports, 42 involved a crash and 1 involved a fire. 33 people were injured.
What owners report most often
Recalls and investigations
Suspension, front, control armApr 16, 2009
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V125000 on NHTSA.gov
Fuel system, gasoline, storageJul 26, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Campaign 04V369000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 9, 2004
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 04V178000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsDec 3, 2003
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
Campaign 03V496000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsJul 22, 2003
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 03V257000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
21 reports, newest first. Show all
Engine and engine cooling, Apr 25, 2015
EMISSION CONTROL SYSTEM FAILURE. I JUST HAD MY VEHICLE REPAIRED FOR A FAILING VAPOR CANISTER PURGE VALVE THAT CAUSES THE CHECK ENGINE LIGHT TO ILLUMINATE. THIS VALVE IS PART OF THE EVAPORATIVE (EVAP) EMISSION CONTROL SYSTEM. ACCORDING TO MY MECHANIC, THE FAULTY VALVE STAYS IN THE OPEN POSITION WHICH ALSO CAUSES THE CHARCOAL FROM THE CANISTER TO RELEASE INTO THE FUEL LINES,CLOGGING IT. THE SYMPTOM OF THIS PROBLEM CAUSES YOU TO START HAVING TROUBLE FILLING YOUR GAS TANK. THE GAS HOSE KEEPS SHUTTING OFF AT THE BEGINNING OF THE FILL ACTING AS IF THERE IS A VAPOR LOCK. IT WON'T LET ME PUT IN MUCH MORE THAN 25-50 CENTS BEFORE THE GAS HOSE CUTS OFF. THIS REPEATS MANY TIMES. IT TAKES ME BETWEEN 15 TO 20 MINUTES TO FILL UP MY GAS TANK. I WENT ONLINE TO SEE IF I COULD FIGURE OUT THE PROBLEM AND TO MY SURPRISE, THERE ARE AN UNBELIEVABLE AMOUNT OF PEOPLE EXPERIENCING THIS EXACT SAME PROBLEM WITH THEIR HYUNDAI'S. MANY PEOPLE ONLINE MADE COMMENTS ABOUT BEING SURPRISED THAT HYUNDAI DOESN'T HAVE A RECALL FOR THIS COMMON PROBLEM. MY REPAIR BILL TO HAVE THIS PROBLEM FIXED WAS $399.31. THANK YOU FOR YOUR CONSIDERATION TO THIS PROBLEM. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine and engine cooling, Air bags, Seat belts, Fuel/propulsion system, Sep 29, 2013
A FEW MONTHS BACK I BEGAN NOTICING THAT MY CHECK ENGINE LIGHT CAME ON. WOULD TAKE 10- 15 MINS TO FILL UP GAS TANK. SENSOR WAS TRIGGERED EVERY FEW SECONDS, SUGGESTING GAS TANK WAS FULL, BUT IT WAS NOT. TOOK IT TO THE DEALER AND WAS TOLD THERE WAS NOTHING WRONG WITH THE CAR. WITH IN THE LAST MONTH I HAVE BEEN NOTICING THAT REAR AUTOMATIC LOCKING SEAT BELT IS NOT STAYING LOCKED. CHILD CAR SEATS DO NOT STAY SECURED. CAR OCCASIONALLY STALLS WHEN STARTED, AND AIR BAG LIGHT DOES NOT ILLUMINATE TO DETERMINE IF AIR BAG WILL DEPLOY OR NOT. *TR
Engine and engine cooling, Dec 9, 2010, fire
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE BEGAN TO EMIT SMOKE AND STALLED. THERE WERE NO PRIOR WARNINGS. THE DEALER FIRST REPLACED THE HEAD GASKET AND ENGINE BUT THE FAILURE OCCURRED AGAIN. THE DEALER THEN REPLACED THE HEAD GASKET AGAIN. THE FAILURE OCCURRED FOR A THIRD TIME. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 60,000.
Engine and engine cooling, Sep 30, 2010
CK ENGINE LIGHT CAME ON 3 TIMES TOOK IT TO DEALER SAID NO PROBLEMS JUST NEEDED TO RESET CODES??? ABOUT 2 YRS. LATER WAS DRIVING IN MY 2003 HYUNDAI ELANTRA IN SEPT. OF 2009- A VERY HOT DAY101-WITHOUT WARNING NO TEMP LIGHTS (NOTHING) I SAW WHITE SMOKE COMING FROM THE HOOD AT FIRST THOUGHT MAYBE HEAT WAVES- THEN CAR STARTED TO LOOSE POWER-PULLED OVER (VERY DANGEROUS) DUE TO LOOSING POWER ON THE HIGHWAY QUICKLY WITH MANY PEOPLE DUE TO FRI.-LABOR DAY WEEKEND 5PM- ANYWAY PULLED OVER TO SEE THAT CAR WAS SMOKING (WHITE SMOKE) ENGINE WAS SO HOT IT MELTED THE RADIATOR-WENT TO DEALER (BILL DUBE HYUNDAI) SAID WARRANTY JUST RAN OUT- BECAUSE CAR ENGINE WAS SEIZED AND DID NOT WORK PLUS THAT FACT THAT I STILL OWED SO MUCH MONEY ON BANK LOAN THEY COULD NOT POSSIBLY TRADE IT IN-SO I HAD TO REPLACE THE ENGINE AND RADIATOR AND STILL PAY BANK LOAN. *TR
Engine and engine cooling, Sep 22, 2010
2003 HYUNDAI ELANTRA, 138,000 MILES. WHEN DRIVING ON HIGHWAY 9/18/10, SUDDENLY BEGAN TO SMELL (BURNING), WHITE SMOKE FROM ENGINE, THEN CHECK ENGINE LIGHT CAME ON AND TEMP GAUGE SHOWED EXTREMELY HOT - NO WARNING BEFORE THE ENGINE OVERHEATED. MECHANIC SAYS PROBLEM WAS CLAMP IN RADIATOR THAT EITHER CORRODED OR SOMEHOW CAME OFF. RESULT IS THAT THE ENTIRE ENGINE IS DAMAGED, AND WE HAVE TO REPLACE IT. MY CONCERNS ARE (1) THIS SEEMED TO HAPPEN WITH NO WARNING. THERE WAS NO LEAK OR SYMPTOMS OF PROBLEMS BEFORE THE ENGINE OVERHEATED AND WAS IRREPARABLY DAMAGED. (2) WE HAD THIS EXACT SAME PROBLEM ABOUT 2 YEARS AGO. SAME SCENARIO - DRIVING ON HIGHWAY, ENGINE OVERHEATED WITHOUT WARNING, CAUSED MUCH ENGINE DAMAGE. AT THAT TIME, WE WERE ABLE TO FIGHT FOR SOME WARRANTY COVERAGE FROM THE DEALERSHIP. NOW, WE ARE WELL PAST THE LIMITS OF THE WARRANTY. I JUST FIND IT EXTREMELY STRANGE THAT THIS WOULD HAPPEN TWICE TO THE SAME VEHICLE. *TR
Engine and engine cooling, Dec 7, 2009
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE PARKED THE RPM'S INCREASED TO 7000 AND WOULD NOT DECREASE UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP, AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 77246.
Engine and engine cooling, Dec 23, 2008
I PURCHASED MY CAR ABOUT 3 MONTHS AGO. NOT LONG AFTER PURCHASE, THE ENGINE LINE LIT UP. I NOTICED WHEN THIS HAPPENED THE RPM'S DROPPED AND THE CAR WOULD SPUTTER. I HAD A MECHANIC LOOK AT IT. HE CHECKED THE CAR BY COMPUTER AND FELT IT NEEDED 2 SENSORS. I LET HIM REPLACE THESE. 2 DAYS AFTER THE REPAIR THE SAME ISSUE BEGAN OCCURRING AGAIN. THIS TIME, WHEN I STOPPED AS FOR A TRAFFIC LIGHT, THE CAR WOULD STALL, ALL WARNING LIGHTS WOULD GO ON, AND IT WOULD TAKE A COUPLE OF TRIES TO START. ALSO, I PURCHASED THIS CAR AT ARNOLD HYUNDAI IN ROSEVILLE, MI. THEY WENT OUT OF BUSINESS NOT LONG AFTER I PURCHASED THE CAR. I TOOK THE CAR TO ANOTHER MECHANIC AND THEY COULD FIND NOTHING WRONG. I TOOK THE CAR TO A HYUNDAI DEALER. THEY THOUGHT A GUIDE WIRE HAD COME LOOSE AND REPAIRED IT. A COUPLE DAYS LATER THE CAR WAS HAVING THE SAME PROBLEMS. I TOOK IT TO THE DEALERSHIP ON DECEMBER 22. THEY DID A THOROUGH INSPECTION AND SAID THERE IS A LEAK IN THE VACUUM SYSTEM? ALSO A PROBLEM WITH THE EXHAUST. I'M WONDERING HAS THERE BEEN A RECALL ON THIS SYSTEM OR DO HAVE SOME SORT OF RECOURSE? *TR
Engine and engine cooling, Dec 5, 2008
DEFECTIVE DESIGN OF ENGINE TEMPERATURE GAUGE. GAUGE READS NORMAL TEMPERATURE WITH NO COOLANT IN THE ENGINE. *TR
Engine and engine cooling, Jan 11, 2008
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE DRIVING AT ANY SPEED, THE VEHICLE HESITATED AND PAUSED. THE VEHICLE WAS TAKEN TO A DEALER APPROXIMATELY FIVE TIMES WITH NO RESOLUTION. THE CURRENT MILEAGE IS 31,000 AND FAILURE MILEAGE WAS 31,000. UPDATED 03-04-08 *BF THE CONSUMER ALSO STATED THE VEHICLE WAS BUCKING FROM THE REAR. UPDATED
Engine and engine cooling, Oct 16, 2007
ON MARCH 4, 2006 I PURCHASED A PRE-OWNED 2003 HYUNDAI ELANTRA WITH 33,855 MILES FROM BUHLER & BITTER DODGE LOCATED ON ROUTE 35 IN HAZLET, NEW JERSEY. AT THE TIME OF PURCHASE I WAS ADVISED THAT ALL USED CARS ARE CERTIFIED PRE-OWNED VEHICLES AND ARE PUT THROUGH A 135 POINT CHECK PRIOR TO BEING PUT ON THE LOT. THE HYUNDAI THAT I PURCHASED PASSED THIS 135 POINT CHECK AND STILL HAD THE REMAINDER OF THE FACTORY WARRANTY WHICH WAS 5 YEARS OR 60,000 MILES. THE BALANCE OF THIS WARRANTY WOULD BE TRANSFERRED TO THE NEW OWNER. THE CAR RAN GREAT AND LIKE ALL OF OUR CARS IN THE PAST IT WAS GARAGE KEPT AND SERVICED IN ACCORDANCE WITH THE SERVICE SCHEDULE ISSUED TO US FROM THE DEALER UPON PURCHASE. ON AUGUST 22, 2007 I DROVE TO STATEN ISLAND FOR A DOCTOR?S VISIT. ON MY WAY HOME- WHILE TRAVELING ON THE GARDEN STATE PARKWAY-THE CAR APPEARED TO BE LOSING POWER AS IT RELATED TO MY ABILITY TO MAINTAIN SPEED OR ACCELERATE. FOR MY SAFETY I BEGAN TO MOVE OVER TO THE SHOULDER AND PROCEEDED TO SHUT OFF THE CAR. UPON RESTART NOTHING OCCURRED SO I TURNED THE IGNITION OFF AGAIN. THERE WAS NO SIGN OF TROUBLE ASIDE FROM THE LACK OF POWER (I.E. NO INDICATOR LIGHTS ILLUMINATED, NO SMOKE OR NOISE WAS COMING FROM THE CAR), IT JUST WOULDN'T START AND THEN SLOWLY EVERYTHING APPEARED TO SHUT OFF INCLUDING THE ELECTRICAL POWER. AT THAT POINT, I SAT AND WAITED FOR HELP TO ARRIVE. A GENTLEMAN FROM JULIAN?S GARAGE NAMED SCOTT ARRIVED WITH A TOW-TRUCK AND AFTER TRYING TO START THE CAR HIMSELF STATED THAT THE EITHER THE TIMING BELT WENT OR THE HEAD GASKET FAILED. BASED ON EVERYTHING SHUTTING DOWN, IT APPEARED THAT IT MOST LIKELY WAS THE HEAD GASKET. HE THEN TOWED ME TO A GAS STATION NEAR MY HOME. ALTHOUGH DISTURBED BY THE SITUATION AND THE FACT THAT IT WAS CLEAR I WOULD BE WITHOUT A CAR FOR A FEW DAYS, I KNEW THAT I HAD THE WARRANTY AND WAS COVERED. *JB
Service brakes, Hydraulic, Engine and engine cooling, Jul 20, 2007
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT HAD TO DEPRESS THE BRAKE PEDAL DOWN TO THE FLOOR IN ORDER TO STOP THE VEHICLE. THE FAILURE OCCURRED WHILE DRIVING 35 MPH. WHILE AT THE DEALER FOR AN OIL CHANGE, THEY TESTED HER POWER BRAKES WHILE THE ENGINE WAS RUNNING. THE BRAKE FAILURE OCCURRED AFTER THE TEST WAS COMPLETED. THE FRONT BRAKES WERE REPLACED. THE CURRENT MILEAGE IS 55,000 AND FAILURE MILEAGE WAS 54,831. THERE WAS AN EVAP LEAK. UPDATED 08/06/07. *JB THE CONSUMER PROVIDED MULTIPLE REPAIR INVOICES PERTAINING TO THE DEFECT. UPDATED 08/09/07 *TR UPDATED 08/28/07 *TR THE DEALER STATED THE TRANSMISSION WAS FINE BUT THE MOTOR LACKS PERFORMANCE. UPDATED 09/06/07 *TR
Engine and engine cooling, Jan 14, 2007
MY WIFE WAS DRIVING ON A FREEWAY APPROX 65 MPH WHEN SHE HEARD A LOUD POP, LOOKING AT THE DASH BOARD ALL GAUGES REPORTED NOTHING WRONG. SUDDENLY A LARGE AMOUNT OF WHITE SMOKE CAME FROM UNDER THE HOOD, BLINDING HER VISIBILITY AND CARS BEHIND HER. SHE WAS ABLE TO VEER OFF TO THE MEDIAN AND CALL FOR ASSISTANCE. THE REPAIR SHOP NOTED THAT A PLASTIC RESERVOIR TANK EXPLODED AND DRAINED ALL COOLANT AND DAMAGED THE RADIATOR AND RECOMMENDED CALLING HYUNDAI SINCE CAR IS IN WARRANTY AND SUGGESTS THAT ENGINE DAMAGE (SEAL DAMAGE MAY RESULT IN COMPLETE DAMAGE OF ENGINE AND NEED REPLACEMENT) THE CAR IS CURRENTLY AT DEALERSHIP. THIS IS A SIMILAR REPORT AS LISTED AND MAY CAUSE SERIOUS INJURY OR DEATH DUE TO SMOKE DISABLING DRIVERS VIEW. *NM
Engine and engine cooling, Nov 15, 2005
CHECK ENGINE LIGHT WAS DISPLAYED ON THE DASH. 2003 HYUNDAI ELANTRA EVAP SYSTEM HAD A SMALL LEAK, FOUND PURGE CONTROL. *TS THE ENGINE LIGHT WOULD CONSTANTLY ILLUMINATE DUE TO THE SYSTEM DETECTING A SMALL EVAP LEAK. THE DIAGNOSIS WOULD BE GAS CAP WAS LOOSE, SECURE THE CAP, CLEARED CODE/OPERATING TO SPECIFICS AND FOUND FUEL CAP HARDLY THREADED/VERY LOOSE, FOUND FAULT CODE FOR LARGE VAPOR LEAK, PURGE VALVE TO HAVE INTERNAL DAMAGE, AND EVAPORATIVE EMISSION SYSTEM LEAK DETECTED (SMALL LEAK). THE CONSUMER WOULD ENSURE THAT THE GAS CAP FITTED TIGHTLY. THE PURGE VALVE HAD BEEN REPLACED TWICE. THE CONSUMER REQUESTED REIMBURSEMENT. *SC
Engine and engine cooling, Aug 14, 2005
EVER SINCE I HAVE BOUGHT THE 2003 HYUNDAI ELANTRA NEW 2 YEARS AGO, I HAD NOTHING BUT PROBLEMS. I HAVE HAD SERIOUS EXHAUST PROBLEMS, AND HAVE BEEN TO THE DEALER SEVERAL TIMES ABOUT THIS. I HAVE BEEN REALLY SICK, BREATHING IN THE FUMES FROM THE CAR. MY CARBON MONOXIDE LEVEL IS HIGH, AND I HAVE BEEN HAVING TROUBLE BREATHING FOR A LONG TIME NOW. THE DEALER REFUSES TO SEE A PROBLEM WITH THE CAR. I HAVE HAD PEOPLE DRIVE IN MY CAR, AND SMELL THIS EXHAUST. THE EXHAUST SMELLS LIKE A SKUNK, AND BACKS UP THROUGH THE FRONT INSIDE VENTS, IT SMELLS BEHIND THE CAR, AND I CANNOT OPEN THE WINDOWS, BECAUSE THE SMELL IS SO STRONG IT COMES THROUGH THE WINDOWS WHEN OPENED TO. THE DEALER KEEPS SAYING THEY DON'T SMELL ANYTHING. THIS IS A VERY SERIOUS MATTER, AND IT AMAZES ME THAT PEOPLE CARE ABOUT MONEY, INSTEAD OF SOMEONE'S HEALTH AND SAFETY. *NM
Engine and engine cooling, Electrical system, Dec 1, 2004
CONSUMER STATED THAT WHILE SHE WAS ON THE FREEWAY DRIVING AT ABOUT 65-70 MPH, SHE WITNESSED AN OBJECT FLYING BY. SHE STATED SHE LOOKED DOWN AND ALL OF HER GAGES WERE FINE, THEN SUDDENLY SHE SAW SMOKE, SHE STATES SHE PULLED TO THE SIDE AND GOT HERSELF AND HER CHILD OUT OF THE VEHICLE. SHE THEN LOOKED UNDER THE VEHICLE AND SAW PIECES WERE HANGING FROM THE ENGINE. SHE STATES BY THIS TIME ALL OF THE SMOKE THAT SHE HAD SEEN WAS GONE. SHE STATED THAT SHE CALLED THE TOW TRUCK AND HAD HER VEHICLE TOWED TO A DEALER. SHE STATES SHE COULD HAVE BEEN KILLED, ALONG WITH HER INFANT. *JB THE CONSUMER STATED THAT THE ENGINE WAS BLOWN AND HAD TO BE REPLACED.*TC
Engine and engine cooling, May 21, 2004
AT 36,000 MILES THE VALVES STARTED TAPPING. CHECKED OIL LEVEL, WHICH WAS AT THE "LOW" LINE, AND THEN ADDED OIL. TAPPING STOPPED, THEN RESUMED ON HIGHWAY. ENGINE CUT OUT WHILE DRIVING. THE CAR WAS TOWED TO THE DEALERSHIP AND UPON INSPECTION IT WAS DETERMINED THAT A CRANK IN THE CAM HAD BROKEN, THROWING METAL CHARDS THROUGHOUT THE ENGINE. ENTIRE ENGINE NEEDES REPLACEMENT. *AK
Engine and engine cooling, Dec 3, 2003
VEHICLE EXPERIENCED SUDDEN ACCELERATION AFTER BRAKES WERE APPLIED.*MR CONSUMER APPLIED ALL HIS WEIGHT ONTO THE PEDAL AND IT DIDN'T STOP UNTIL A COUPLE OF FEET BEHIND THE LINE. HE REALIZED THE ENGINE WAS REVVING UP WITH HIS FOOT ON THE BRAKE AND NOT THE GAS. HIS WIFE SUGGESTED HE SHIFT TO PARK. WHEN HE DID, IT SOUNDED LIKE THE ENGINE WAS GOING TO FLY OUT. HE SHIFTED BACK TO DRIVE, KEEPING FULL PRESSURE ON THE PEDAL. AFTER THE LIGHT CHANGED, HE CAREFULLY RELEASED HIS FOOT AND THE ENGINE RETURNED TO NORMAL IDLING. CONSUMER PLANNED TO GET IT SERVICED BUT WANTED A RECORD OF THE FAILURE ON FILE. *PH
Engine and engine cooling, Nov 7, 2003
I PURCHASED A DEFECTIVE VEHICHLE,THAT BECAME DISSABLED, AND TOWED INTO THE DEALERSHIP FOR WARRANTY REPAIRS TO THE ENGINE WITH ONLY 2800 MILES.I HAVE MADE NUMEROUS CALLS TO THE DEALER, INQUIRING ABOUT THE VEHICLE.THE SERVICE MANAGER COULD NOT LOCATE MY CAR AND COULDNT GIVE ME ANY INFORMATION ON ITS WHERE ABOUT'S OR ANYTHING.*AK
Engine and engine cooling, Vehicle speed control, Jul 7, 2003
WHEN PRESSING ON THE ACCELERATOR PEDAL VEHICLE ACCELERATES SLOWLY. VEHICLE WAS TAKEN TO THE DEALER ON 7/2/2003. DEALER STATED THE PROBLEM WAS WITH THE REFORMULATED GASOLINE THAT WAS USED. *AK
Suspension, Engine and engine cooling, May 30, 2003
I HAVE A 2003 HYUNDAI ELANANTA GT. THERE IS A WHINING NOISE FROM BOTH SIDES OF THE FRONT OF THE VEHICLE WHEN DRIVING ON THE HIGHWAY AT HIGH SPEEDS, SOMETIMES AT 55 MPH OR AT 75 MPH. THE DEALER REPLACED THE LEFT FRONT WHEEL BEARING ON 4/22/03. THE NOISE ON THE LEFT WENT AWAY. THE SAME NOISE SURFACED ON THE ON THE RIGHT SIDE OF THE CAR. ON 5/22/03 THE DEALER REPLACED THE RIGHT FRONT ENGINE MOUNT, THEY SAID IT WAS COMING APART. ONCE I DROVE THE CAR ON THE HIGHWAY AGAIN ON 5/29/03 THE NOISE WAS THERE. I ALSO STILL HEARD THE WHINNING NOISE FROM THE LEFT SIDE OF THE CAR AGAIN, BUT FOR JUST A COUPLE OF SECONDS. THE RIGHT SIDE WILL MAKE NOISE CONTINUOUSLY. NOW I HAVE TO GO BACK TO THE DEALER AGAIN, WASTING MORE OF MY TIME, MONEY, AND EXTRA MILES ON MY CAR. I LIVE 130 MILES FROM THE NEAREST HYUNDAI DEALER. I HAVE OWNED THIS CAR FROM 4/08/03 AND THE CAR HAS 2400 MILES ON IT AND WILL NOW BE ON MY THIRD ATTEMPT TO HAVE THIS CAR REPAIRED.*AK
Engine and engine cooling, Mar 26, 2003
2003 HYUNDAI ELANTRA: VEHICLE COMPLETELY LOST POWER WHILE ENTERING FREEWAY ON-RAMP. HAD TO PULL OFF ROAD TO AVOID REAR-END COLLISION WITH APPROACHING VEHICLES. VEHICLE RETURNED TO DEALER WHERE IT WAS "FIXED." A SECOND EPISODE OCCURRED AFTER VEHICLE WAS EXAMINED AND FIXED BY DEALER. *JB