2003 Hyundai Elantra
Problems, recalls and owner-reported issues
Suspension is the leading concern among 234 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Elantra model years with reports.
Of the 2003 reports, 42 involved a crash and 1 involved a fire. 33 people were injured.
What owners report most often
Recalls and investigations
Suspension, front, control armApr 16, 2009
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V125000 on NHTSA.gov
Fuel system, gasoline, storageJul 26, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Campaign 04V369000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 9, 2004
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 04V178000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsDec 3, 2003
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
Campaign 03V496000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsJul 22, 2003
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 03V257000 on NHTSA.gov
Representative owner complaints: exterior lighting
13 reports, newest first. Show all
Electrical system, Exterior lighting, Jun 9, 2017
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE ACTIVATING THE TURN SIGNALS IN EITHER DIRECTION, THE SIGNAL LIGHTS WOULD EITHER WORK INTERMITTENTLY OR NOT WORK AT ALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
Electrical system, Exterior lighting, Apr 3, 2010
HEADLIGHTS BURNING OUT. I HAVE REPLACED 10 DRIVER SIDE HEADLIGHTS AND 2 PASSENGER HEADLIGHTS SINCE I BOUGHT THE CAR IN 2003. THE DEALER SAYS THEY DO NOT KNOW WHAT IS GOING ON.
Exterior lighting, Jul 27, 2009
2003 HYUNDAI ELANTRA HAS 69,173 MILES & HAS HAD NUMEROUS PROBLEMS WITH THE HEADLIGHTS BURNING OUT. THE MOST RECENT REPLACEMENTS DIDN'T EVEN LAST 1,000 MILES. 7/27/09 - LEFT HEADLIGHT- 69,173 (MILEAGE) 7/5/09 - BOTH HEADLIGHTS - 68,670 (MILEAGE) 5/6/08 - LEFT HEADLIGHT- 57,921(MILEAGE) 11/5/07 - RIGHT HEADLIGHT- 52,428(MILEAGE) 9/5/07 - LEFT HEADLIGHT- 50,633(MILEAGE) 4/9/07 - RIGHT HEADLIGHT- 45,223(MILEAGE) 6/3/06 - LEFT HEADLIGHT- 36,405(MILEAGE) 10/21/05 - 29,192(MILEAGE) I TALKED TO A MECHANIC- HE SAID THERE IS NOTHING THAT CAN BE DONE TO FIX THE PROBLEM OTHER THAN KEEP REPLACING THE BURNED OUT LIGHTS. I FIND THIS AN UNACCEPTABLE SOLUTION - IT IS A SAFETY HAZARD. MY SON WAS DRIVING HOME ON 7/5/09 & BOTH HEADLIGHTS BURNED OUT. HE HAD TO DRIVE HOME ON HIGH BEAMS. THERE IS NO REASON FOR A CAR TO KEEP BURNING OUT HEADLIGHTS. *TR UPDATED 08/04/09.8JB
Exterior lighting, Air bags, Jul 23, 2009
TL*THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT CONTINUED TO ILLUMINATE ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THE MODULE FAILED AND WOULD COST OVER $600 TO REPAIR. THERE WERE NO RECALLS FOR THE FAILURE AND THE MANUFACTURER HAS NOT BEEN NOTIFIED. IN ADDITION, THE LOW BEAM HEADLIGHTS WOULD BURN OUT EVERY 3-6 MONTHS. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 36,700. UPDATED 9/1/09 *CN UPDATED 09/02/09.*JB
Exterior lighting, Dec 13, 2008
I'VE OWNED THIS 2003 ELANTRA SINCE JULY AND HAVE HAD BOTH HEADLIGHTS REPLACED. THIS IS UNCOMMON. THE CAR HAS ONLY 33,000 MILES. SOMETHING IS WRONG THE LIGHTS SHOULD LAST LONGER THAN THAT. *TR
Exterior lighting, Nov 25, 2008
HEAD LIGHTS - I HAVE A 2003 ELANTRA AND HAVE TO REPLACE HEADLIGHTS EVERY TWO TO SIX MONTHS. I NEED TO KNOW WHAT IS CAUSING THIS PROBLEM. DEALERSHIP ONLY CLAIMS THAT EVERYONE IS COMPLAINING OF THE SAME THING, BUT OFFER NO EXPLANATION. *TR
Exterior lighting, Nov 10, 2008
SINCE HAVING THE CAR, I BOUGHT IT USED A YEAR AGO, WHILE NOT NOTICING ANY MAJOR ISSUES, I STILL CONTINUE TO HAVE PROBLEMS WITH THE HEADLIGHTS GOING OUT. I HAVE HAD THE HEADLIGHTS CHANGED THREE TIMES NOW WITH ALTERNATING SIDES GOING OUT EVERY FEW MONTHS. I CANNOT IMAGINE THIS BEING A NORMAL OCCURRENCE. *TR
Exterior lighting, Oct 31, 2008
HEAD LIGHT BULBS KEEP BURNING OUT. I HAVE TO REPLACE THE HEADLIGHTS IN MY CAR ABOUT EVERY 3-6 MONTHS SINCE I PURCHASED THE CAR NEW IN OCT 2002. AND THE DEALERSHIP SAID THERE WAS NO PROBLEM. I HAVE HAD THE DEALERSHIP REPLACE THEM, GARAGES REPLACE THEM, A NEIGHBOR WHO IS A MECHANIC AND MYSELF SO IT'S NOT THAT IT HAS NOT BEEN DONE CORRECTLY. I HAVE STARTED BUYING THE 2 PACK OF BULBS BECAUSE ALMOST LIKE CLOCKWORK ONCE THE ONE BULB GOES THE OTHER GOES WITHIN A SHORT PERIOD. I HAVE PUT ABOUT 10-15 BULBS IN EACH HEADLIGHT SINCE I BOUGHT THE CAR BUT HAVE NEVER REPLACED THE HIGHBEAM BULBS ONLY THE LOW BEAM. *TR
Exterior lighting, Apr 8, 2007
WE PURCHASED A 2003 IN FEBRUARY 2006 , SINCE THEN THE HEADLIGHTS HAD TO BEEN CHANGED 3 TIMES, AND NOW AGAIN AFTER BEING STOPPED NOT KNOWING THE PASSENGER SIDE WAS OUT, IT WENT OUT RIGHT BEFORE WE GOT STOPPED ON API L 7,2007, BEING CHARGED WITH A TICKET. AND 3 POINTS OFF MY DRIVERS LICENSE WITHOUT A WARNING TICKET TO GET IT FIXED. THERE NEEDS TO BE A RECALL ON THESE CARS IT SHOULDNT HAPPEN THAT MANY TIMES. *AK
Exterior lighting, Equipment, Feb 18, 2007
I HAVE HAD TO REPLACE THE DRIVER'S SIDE HEADLAMP 3 TIMES IN 3 YEARS. APPARENTLY I AM NOT THE ONLY ONE, THE CHATS AND BLOGS ARE FULL OF SIMILAR COMPLAINTS INTERNATIONALLY. ACCORDING TO WHAT I HAVE READ, I AM ONE OF THE LUCKY ONES. OTHERS HAVE EXPERIENCED MUCH MORE FREQUENT REPLACEMENTS. CURIOUSLY ENOUGH, THE DRIVER'S SIDE LAMP IS THE ONE THAT BLOWS. I HAVE SAVED THE LAST LAMP REPLACED. IT IS A SYLVANIA SILVERSTAR. THIS IS THE THIRD BRAND OF BULB / LAMP. MY WIFE IS NIGHT BLIND. SHE TRIES TO AVOID DRIVING AFTER DARK. THE UNDEPENDABLE LIGHTING SYSTEM POSES A SERIOUS SAFETY HAZARD IN HER CASE AND I AM SURE IN SENIORS WHO REQUIRE MORE LIGHT TO SEE CLEARLY. *NM
Exterior lighting, May 11, 2006
DT*: THE CONTACT STATED THE LENSES ON THE HEADLIGHTS CLOUDED OVER IN LESS THAN TWO YEARS, MAKING IT HARD TO SEE THE ROAD AT NIGHT. BOTH LOW AND HIGH BEAMS ARE AFFECTED. THE DEALER HAS BEEN ALERTED AND DETERMINED THE HEADLIGHTS NEED TO BE REPLACED.
Exterior lighting, Jan 6, 2006
I PURCHASED A USED 2003 HYUNDAI ELANTRA 4 DOOR SEDAN IN FEBRUARY 2005. IN JUNE 2005 I HAD TO HAVE BOTH LOW BEAM HEADLIGHTS REPLACED. NOW IT IS JANUARY 2006 AND I WILL HAVE TO REPLACE THEM BOTH AGAIN. *NM
Exterior lighting, Aug 13, 2002
HEADLIGHTS WILL READ DIM BUT LIGHT WILL ACTUALLY BE ON HIGH BEAM, CAUSING PROBLEM TO OTHER DRIVERS. DEALER NOTIFIED. *AK