2003 Hyundai Elantra
Problems, recalls and owner-reported issues
Suspension is the leading concern among 234 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Elantra model years with reports.
Of the 2003 reports, 42 involved a crash and 1 involved a fire. 33 people were injured.
What owners report most often
Recalls and investigations
Suspension, front, control armApr 16, 2009
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V125000 on NHTSA.gov
Fuel system, gasoline, storageJul 26, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Campaign 04V369000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 9, 2004
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 04V178000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsDec 3, 2003
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
Campaign 03V496000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsJul 22, 2003
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 03V257000 on NHTSA.gov
Representative owner complaints: structure
32 reports, newest first. Show all
Structure, Dec 18, 2003
VEHICLE IS LOW TO THE GROUND. WHEN PULLING INTO THE DRIVEWAY THE BUMPER HIT THE GROUND AT LEAST TEN TIMES IN THE LAST SIX MONTHS. WHENEVER THE BUMPER HIT THE GROUND THE BOLTS HOLDING IT FELL OUT. *AK
Structure, Oct 31, 2003
RECENTLY I HAD TAKEN AN INTERSTATE TRIP. THERE IS A LOUD NOISE COMING FROM SOMEWHERE AT THE FRONT OF THE VEHICLE AT HIGHER SPEEDS OF 60-75 MPH, WHICH SOUNDS LIKE THIS NOISE IS IN THE WHEELS? THE FRONT GRILL? HAPPENS ON BOTH FRONT SIDES OF THE VEHICLE. *LA
Service brakes, Hydraulic, Visibility, Structure, Oct 8, 2003
DEFECTIVE WINDSHIELD-2003 HYUNDAI ELANTRA GLS. *MR THERE WAS A TERRIBLE GLARE FROM THE SUN HITTING THE WINDSHIELD WHICH MADE IT EXTREMELY HARD TO JUDGE THE DISTANCE OF OBJECTS. THE DEALER WAS NOTIFIED AND STATED THAT THE GLARE WAS A CHARACTERISTIC OF THE CAR. THE VEHICLE EXPERIENCED BRAKE NOISE. THE DEALER DID SOME WORK ON THE CAR BUT IS WAS STILL NOISY. THE DEFROSTER TOOK 15-20 MINUTES TO CLEAR THE WINDOWS AND HEATED MIRRORS. WHEN IT RAINED THE WATER WAS ON THE INSIDE THE VEHICLE ON THE UNDERSIDE OF THE CAR DOOR. *SCC *JB *NLM
Power train, Structure, Wheels, Jun 5, 2003
WE GET A WIND NOISE WHEN DRIVING INTO THE WIND AND OTHER MISC TIMES. NOISE SOUNDS LIKE AN ALARM CLOCK WITHOUT THE PAUSES IN TONE. IT SOUNDS TO BE EMINATING FROM FRONT OF VEHICLE, WINDSHEILD, OR THE DOORS. THE DEALER THINKS ITS THE DOOR SEALS. WAITING TO SEE. BEEN TO THE SHOP 5 TIMES FOR THIS PROBLEM NOW! 1ST TIME THEY DIDN'T KNOW WHAT IT WAS, NEVER HEARD OF THIS PROBLEM, COULDN'T DUPLICATE, SECOND TIME THEY KNEW EXACTLY WHAT IT WAS, ORDERED DOOR SEALS. 3RD TIME THEY GOT THE WRONG DOOR SEALS, FORTH TIME, THEY GOT ONE WRONG DOOR SEAL AGAIN! FIFT TIME THE HAVE HAD IT FOR ONE WEEK THREE DAYS TO THIS DATE! ALSO REVS UP TO HIGH DURING START UP. DEALER STATED THAT THE TRANSMISSION WAS AT FAULT???? THAT IT HAD TO CATCH IN GEAR????? THIS IS A MANUAL! WHAT IS HE TALKING ABOUT!!!!?? ALSO HAS BENT RIMS! WE HAVE BABY-ED THAT CAR! ONLY 2400 MILES AND BENT RIMS! THIS CAR IS A LEMON!! WHAT DO YOU THINK? BEAR@TBHOD.TK . *AK
Structure, Apr 24, 2003
WHEN TRAVELING ON HIGHWAY AT SPEEDS OF 65 MPH OR GREATER THERE IS A VERY LOUD HUMMING TYPE NOISE AT THE CORNERS OF THE WINDSHIELD. I NOTICED IT IS GREATLY ENHANCED WHEN THERE IS A STRONG HEADWIND. *NLM
Structure, Apr 1, 2003
EXTREMELY LOUD WIND NOISE WHEN DRIVING INTO OR WITH A CROSSWIND. NOISE SEEMS TO EMANATE FROM FRONT OF VEHICLE. DEALER HAS BEEN UNABLE TO REPAIR. *JB
Structure, Mar 5, 2003
WHILE DRIVING FROM 45 MPH OR GREATER WITH A CROSS WIND ACROSS THE CAR (LEFT TO RIGHT) THE CAR WILL HOWL OR WHISTLE. THE SOUND IS SO LOUD THAT IT DROWNS OUT THE RADIO AND THE ROAD NOISE. OPENING THE WINDOW SEEMS TO STOP THE SOUND BUT YOU CAN'T DRIVE FOR 8 HOURS WITH THE WINDOWS DOWN IN THE RAIN OR HEAT. I HAVE TRIED THE DEALERS SUGGESTION OF USING TAPE ON THE VENTS TO QUIET THE NOISE BUT TO NO SOLUTION.*JB