2003 Hyundai Elantra
Problems, recalls and owner-reported issues
Suspension is the leading concern among 234 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Elantra model years with reports.
Of the 2003 reports, 42 involved a crash and 1 involved a fire. 33 people were injured.
What owners report most often
Recalls and investigations
Suspension, front, control armApr 16, 2009
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V125000 on NHTSA.gov
Fuel system, gasoline, storageJul 26, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Campaign 04V369000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 9, 2004
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 04V178000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsDec 3, 2003
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
Campaign 03V496000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsJul 22, 2003
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 03V257000 on NHTSA.gov
Representative owner complaints
234 reports, newest first.
Suspension, Dec 18, 2015
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT DRIVER SIDE TIRE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 09V125000 (SUSPENSION) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.
Air bags, Service brakes, Sep 25, 2015, crash
TL* THE CONTACT OWNED A 2003 HYUNDAI ELANTRA. WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE BRAKES FAILED TO RESPOND AND ANOTHER VEHICLE CRASHED INTO THE FRONT PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE VEHICLE SPUN AROUND SEVERAL TIMES. ONLY THE PASSENGER SIDE CURTAIN AIR BAGS DEPLOYED. THE CONTACT WAS TAKEN FROM THE ACCIDENT BY AMBULANCE TO A NEARBY HOSPITAL. THE CONTACT WAS TREATED FOR NECK AND LOWER BACK PAIN. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 151,000.
Electrical system, Sep 22, 2015
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE DRIVING 60 MPH, THE VEHICLE STALLED AND ALL OF THE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE IT WAS RESTARTED AND RESUMED NORMAL OPERATION. THE CONTACT MENTIONED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 146,000.
Suspension, Aug 11, 2015
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE DRIVING, THE REAR OF THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE REAR CROSS MEMBER WAS CORRODED. THE MECHANIC STATED THAT THE VEHICLE WAS UNSAFE TO OPERATE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Air bags, Jun 9, 2015
DRIVING AT 45MPD AIR BAG LIGHT ACTIVATED. WENT TO MY REPAIR SERVICE RAM AUTO(FT. PIERCE,FL. TECH TESTED WITH CAR DIAGNOSTIC DEVICE. COULD NOT FIND ISSUE. TRIED TO DELETE CODE FOR AIR BAG, LIGHT COMES BACK ON. SUGGESTED I SEE IF ANY RECALLS FOR THIS VEHICLE- NO REPORTS OF AIR BAG RECALLS FOR A HYUNDAI 2003 GLS.
Engine and engine cooling, Apr 25, 2015
EMISSION CONTROL SYSTEM FAILURE. I JUST HAD MY VEHICLE REPAIRED FOR A FAILING VAPOR CANISTER PURGE VALVE THAT CAUSES THE CHECK ENGINE LIGHT TO ILLUMINATE. THIS VALVE IS PART OF THE EVAPORATIVE (EVAP) EMISSION CONTROL SYSTEM. ACCORDING TO MY MECHANIC, THE FAULTY VALVE STAYS IN THE OPEN POSITION WHICH ALSO CAUSES THE CHARCOAL FROM THE CANISTER TO RELEASE INTO THE FUEL LINES,CLOGGING IT. THE SYMPTOM OF THIS PROBLEM CAUSES YOU TO START HAVING TROUBLE FILLING YOUR GAS TANK. THE GAS HOSE KEEPS SHUTTING OFF AT THE BEGINNING OF THE FILL ACTING AS IF THERE IS A VAPOR LOCK. IT WON'T LET ME PUT IN MUCH MORE THAN 25-50 CENTS BEFORE THE GAS HOSE CUTS OFF. THIS REPEATS MANY TIMES. IT TAKES ME BETWEEN 15 TO 20 MINUTES TO FILL UP MY GAS TANK. I WENT ONLINE TO SEE IF I COULD FIGURE OUT THE PROBLEM AND TO MY SURPRISE, THERE ARE AN UNBELIEVABLE AMOUNT OF PEOPLE EXPERIENCING THIS EXACT SAME PROBLEM WITH THEIR HYUNDAI'S. MANY PEOPLE ONLINE MADE COMMENTS ABOUT BEING SURPRISED THAT HYUNDAI DOESN'T HAVE A RECALL FOR THIS COMMON PROBLEM. MY REPAIR BILL TO HAVE THIS PROBLEM FIXED WAS $399.31. THANK YOU FOR YOUR CONSIDERATION TO THIS PROBLEM. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel/propulsion system, Mar 15, 2015
ONGOING PROBLEMS WITH FUEL FILLING. IT TAKES ALMOST 1/2 HOUR TO FILL A TANK. IT CONTINUES TO SHUT OFF. THIS IS NOT GETTING BETTER, BUT ACTUALLY WORSE. PLEASE ADVISE ON ANY RECALLS OR SAFETY ISSUES WITH THE GASOLINE/TANK. THANK YOU. *TR
Suspension, Jan 21, 2015
AS MY WIFE WAS EXITING OUR DRIVEWAY THE RIGHT FRONT LOWER CONTROL ARM BROKE. THE VEHICLE WAS NOT OPERABLE. IT WAS TAKEN TO MALLOY HYUNDAI IN WOODBRIDGE, VA. I WAS NOT ADVISED OF ANY RECALLS. THE VEHICLE WAS REPAIRED FOR $1353.52 OUT OF POCKET. I RECENTLY LEARNED ABOUT THE RECALL ON THE SUSPENSION. EXCLUDING NORTHERN VIRGINIA DRIVERS PLACES US AT RISK. IT WAS FORTUNATE MY WIFE WAS NOT ON INTERSTATE 95 AND WAS NOT INJURED. *TR
Suspension, Power train, Structure, Sep 30, 2014
MY DAUGHTER WAS DRIVING HOME FROM SCHOOL AND THE STRUT/AXLE BROKE AND CAUSED HER TO SKID OFF THE RODE, LUCKILY SHE WAS NOT INJURED AND WAS ABLE TO COME TO A STOP IN AN EMPTY LOT. THE TIRE WAS RUINED AND THE FENDER WAS ALSO DAMAGED. WE WERE ABLE TO GET THIS FIXED AT THE REPAIR SHOP, FOR JUST UNDER $500, HOWEVER NOW THE VEHICLE WILL NOT PASS INSPECTION DUE TO THE SUBFRAME BEING DETERIORATED. UPON RESEARCHING THE COST TO REPLACE THIS, I FOUND THAT THE VEHICLE HAS HAD SEVERAL RECALLS, AND WOW BOTH OF THESE WERE ON THE LIST. MY CONCERN IS THAT THE VEHICLE IS 2003 AND WE ARE NOT THE ORIGINAL OWNERS. I AM CONCERNED NOW THAT THE OTHER RECALLS MAY ALSO AFFECT THEIR VEHICLE. THE SAFETY OF MY DAUGHTER AND GRANDSON IS TOP PRIORITY. WHAT CAN YOU HELP ME WITH. CAN WE STILL USE THE RECALL TO HAVE THE VEHICLE REPAIRED? *TR
Steering, Suspension, Jul 21, 2014
TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, SHE NOTICED THE SUSPENSION MALFUNCTIONED WHICH CAUSED HER TO LOSE CONTROL OF THE VEHICLE WITHOUT WARNING. ALSO, THE CONTACT MENTIONED THAT THE STEERING WHEEL BECAME HARD TO MANEUVER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THE PASSENGER SIDE FRONT LOWER CONTROL ARM FRACTURED BETWEEN THE BALL JOINTS DUE TO EXCESSIVE CORROSION. THE CONTACT NOTIFIED THE MANUFACTURER AND THEY INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V125000 (SUSPENSION). THE APPROXIMATE FAILURE MILEAGE WAS 220,000...UPDATED 08-28-14 *BF THE VEHICLE WAS REPAIRED. UPDATED 09/11/14
Other or unspecified, Jul 18, 2014
JUST WANT TO KNOW IF ALL RECALL WERE DONE TO THIS CAR. *TR
Fuel system, Gasoline, Jul 16, 2014
UNABLE TO FILL GAS TANK BECAUSE THE GAS PUMP WOULD CLICK OFF JUST AFTER PUMPING A FEW DOLLARS OF GAS INTO CAR ALTHOUGH THE GAUGE INDICATED THE VEHICLE WAS NEAR EMPTY. THIS CONTINUES TO BE A PROBLEM OVER AND OVER AGAIN AND JUST STARTED OUT OF THE BLUE. ONE DAY IT WAS WORKING FINE, THEN, APPROX 1 MONTH AFTER I HAD THE CAR, I NOTICED I WAS HAVING PROBLEMS WITH GAS PUMP CLICKING OFF. *TR
Suspension, Jun 27, 2014
THE RIGHT SIDE LOWER CONTROL ARM SUDDENLY COMPLETE BROKE IN HALF CLOSE TO THE BALL JOINT CAUSING THE TIRE TO DANGLE AND LOSS OF STEERING AND MOVEMENT. THIS HAPPENED AT A VERY LOW SPEED PULLING OUT OF OUR DRIVEWAY. THERE WAS VISIBLE RUST AND CORROSION ON THE INSIDE OF THE BOXED STAMPED STEEL CONTROL ARM NEAR THE BALL JOINT. THIS FAILURE WAS EXACTLY LIKE NHTSA ACTION NUMBER : PE09011 DESCRIBED. THIS VEHICLE WAS REGISTERED IN VA SO THE CAR WAS NOT SUBJECT TO THAT SPECIFIC RECALL ALTHOUGH OTHER STATES AROUND US WERE. WE RECEIVED NO NOTICE OF THIS RECALL IN THE MAIL OR THE POTENTIAL PROBLEM EVEN THOUGH WE USE AND TRAVEL OFTEN TO THE STATES THAT DID HAVE THE RECALL AND THEY DO PUT A LOT OF SALT ON NORTHERN VA ROADS. *TR
Air bags, Seat belts, Structure, Jun 17, 2014, crash
I HAD A LOW SPEED ACCIDENT APPROXIMATELY 10-20MPH IN A PARKING LOT WHERE I HIT A CEMENT SURROUNDING OF A POLE ON THE DRIVER SIDE AND THE AIRBAG DEPLOYED ON THE PASSENGERS SIDE CAUSING SIGNIFICANT DAMAGE TO THE WINDSHIELD, BUSTED THE DASH VENTS, LOCKED MY DRIVERS SEATBELT AND SHATTERED WINDSHIELD GLASS ALL OVER THE CAR. *TR
Steering, Suspension, Power train, Jun 16, 2014
FRONT PASSENGER SIDE CONTROL ARM FRACTURED, ALLOWING WHEEL TO TURN 90 DEGREES TO THE RIGHT RESULTING IN AN UNCONTROLLED SLIDE DOWN THE HIGHWAY. THIS ALSO BLEW OUT THE TIRE AND SEPARATED THE AXLE FROM THE TRANSMISSION, SPILLING TRANSMISSION FLUID. VEHICLE WAS UNCONTROLLABLE, AND ONCE STOPPED IMMOVABLE, AND SO STRANDED IN THE MIDDLE OF THE HIGHWAY. *TR
Structure, May 9, 2014
I WENT TO HAVE MY CAR LOOKED AT BECAUSE OF THE RATTLING NOISE AND THE POPPING WHEN I BRAKE AND THEY TOLD ME THAT I NEED TO REPLACE MY SUBFRAME. I FOUND OUT TODAY THAT MY CAR WAS RECALLED FOR THE SAME PROBLEM IN 2011 THE SAME YEAR I HAD BOUGHT IT. *TR
Suspension, Structure, May 9, 2014
IN 2009, A RECALL WAS ISSUED FOR RUST/CORROSION OF THE FRONT LOWER CONTROL ARMS OF THESE VEHICLES (RECALL 091 PER HYUNDAI). WE FOUND OUT ABOUT THIS AND TOOK IT TO OUR LOCAL DEALER IN 2011. HOLES WERE DRILLED AND THE CAR "PASSED" WITHOUT NEED TO REPLACE ANYTHING. A "PROTECTIVE COATING" WAS APPLIED. ON SATURDAY, MAY 3, MY HUSBAND WAS DRIVING AND PULLING OUT OF A PARKING SPACE. HE HEARD A GRINDING NOISE AS HE BACKED OUT, THEN HEARD SOMETHING BREAK AND THE CAR WOULDN'T MOVE. WE COULDN'T EVEN PUSH THE CAR BACK INTO THE PARKING SPACE, AS THE TIRE/ARM APPEARED TO BE DETACHED. WE FOUND OUT THE RIGHT CONTROL ARM HAD RUSTED THROUGH COMPLETELY, ALSO CAUSING DAMAGE OF THE AXLE. THE CAR WAS TAKEN FIRST TO OUR MECHANIC AND THEN THE DEALERSHIP AND IT WAS DETERMINED THE SAME RECALLED PART HAD RUSTED THROUGH, CAUSING THE BREAK. THE CAR WAS FIXED BY HYUNDAI, INCLUDING REPLACEMENT OF BOTH CONTROL ARMS. I'M JUST VERY CONCERNED THAT THIS COULD HAVE OCCURRED WHILE DRIVING AND CAUSED A CRASH AND SERIOUS INJURY. WE HAD NO IDEA OF THE RISK, ALTHOUGH WE DID HAVE A BAD WINTER WITH A LOT OF ROAD SALT USED SO I'M NOT SURPRISED. I AM SURPRISED, THOUGH, THAT IT WAS NEVER ADVISED TO RETURN AND HAVE THIS RE-CHECKED. I CALLED HYUNDAI'S CARE MANAGEMENT DEPT AND THE PERSON I SPOKE WITH ([XXX]) DENIED THIS ISSUE WAS RELATED TO THE RECALL AND SAID IT MUST HAVE BEEN REPAIRED ONLY AS A COURTESY. I STRONGLY DISAGREE BY WHAT I HEARD FROM THE MECHANIC. I WANTED TO MAKE YOU AWARE AS I'M SURE THE SAFETY OF MANY IS AT RISK IF THIS A RESULT OF A RECALLED PART AND THEY ARE UN-KNOWINGLY AT RISK AFTER THIS BAD WINTER. THANK YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel/propulsion system, Apr 16, 2014
WE BOUGHT OUR 2003 HYUNDAI ELANTRA USED BUT IN VERY GOOD CONDITION. NOW AFTER ABOUT A YEAR WHEN WE TRY TO FILL THE GAS TANK THE PUMP SHUTS OFF REPEATEDLY. IS THERE ANY RECALL COVERING THIS? *TT
Suspension, Apr 2, 2014
ON APRIL 1ST 2014 THE FRONT RIGHT LOWER CONTROL ARM BROKE OFF WHEN I APPLIED THE BRAKES IN ORDER TO AVOID HITTING A CANADIAN GOOSE THAT WAS SAUNTERING MAJESTICALLY ACROSS THE ROAD (THE GOOSE WAS UNHURT). THE RIGHT FRONT WHEEL WAS ROTATED ABOUT 60 DEGREES TO THE HORIZONTAL AND WAS MOVED BACKWARDS ENOUGH TO DAMAGE THE RIGHT FENDER. SOME TWO YEARS AGO, HYUNDAI RECALLED THIS MODEL TO INSPECT FOR POSSIBLE CORROSION IN THE FRONT SUSPENSION COMPONENTS. AT THAT TIME THE LOCAL HYUNDAI DEALER STATED THAT THERE WAS NO CORROSION DETECTED IN THIS VEHICLE. WHILE IT IS EASY TO BLAME THIS BREAK ON POTHOLES, I WOULD LIKE TO STATE THAT I AM METICULOUS ABOUT AVOIDING THEM AND I WONDER IF THE SUSPENSION COMPONENTS WERE NOT WEAKENED BY POOR QUALITY CORROSION PROTECTION AND GAVE WAY WHEN I BRAKED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Suspension, Structure, Feb 27, 2014
THANKFULLY NO INCIDENT, MY MECHANIC POINTED OUT TO ME DURING NORMAL MAINTENANCE ON THE CAR, THE LOWER CONTROL ARM HAD SEVERE CORROSION DAMAGE THAT ITS ALMOST SPLIT HE ADVISED NOT TO TAKE IT ON THE HIGHWAY UNTIL IT WAS FIXED. HE PRINTED OUT THE RECALL NOTICE OF THE PROBLEMS WITH THE FRONT LOWER CONTROL ARM. HYUNDAI IS GIVING ME PUSH BACK ON TAKING CARE OF IT BECAUSE IM NOT IN THE SALT BELT. I AM NOT IN A SALT FREE STATE THEY SALT HEAR AT THE THREAT OF FLURRIES. THAT KIND OF DAMAGE IS NOT NORMAL WEAR AND TEAR ON A CAR THAT'S UNDER 60K MILES. I DON'T WANT THE WORLD I JUST WANT THEM TO FIX THE DEFECTIVE PRODUCT, MORE IMPORTANT THAN THAT HAD MY MECHANIC NOT POINTED IT OUT I COULD HAVE PUT MYSELF OR OTHERS IN DANGER IF THIS SNAPPED AND I LOST CONTROL OF THE PASSENGER SIDE WHEEL. I CANT BE THE ONLY ONE OUTSIDE OF THE SALT BELT THAT IS HAVING THIS ISSUE AND MAY BE IN DANGER IF IT SEPARATES. THANK YOU FOR TAKING THE TIME TO LISTEN. *TR
Steering, Feb 7, 2014
POWER STEERING LINE WORE HOLE IN LINE WHERE LINE CROSSES OVER FRAME. POWER STEERING LINE SHOULD HAVE BEEN PROTECTED FROM FRAME AND ELEMENTS OF ROAD SALT AND WATER TO KEEP FROM WEARING OUT. VERY MUCH OF A SAFETY MATTER, SHOULD BE RECALLED & FIXED PROPERLY TO PREVENT AN ACCIDENT. *TR
Suspension, Sep 30, 2013
I WAS BEHIND TWO VEHICLES AT A TRAFFIC LIGHT, THE LIGHT TURNED GREEN AND WE ALL JUST STARTED TO PROCEED FORWARD WHEN THE FRONT VEHICLE SLAMMED HIS BRAKES ON. THE VEHICLE DIRECTLY IN FRONT OF ME SLAMMED HIS BRAKES ON AND I SLAMMED MINE ALSO. I FELT THE FRONT END GIVE A LITTLE SO I MADE A RIGHT TURN AND SLOWED DOWN TO AROUND 5 MPH. I PROCEEDED TO MY HOME ABOUT 500 FEET AWAY AND TURNED INTO THE DRIVEWAY. I GOT OUT OF THE VEHICLE AND FOUND THE RIGHT LOWER CONTROL ARM BROKEN JUST PAST THE BALL JOINT. I FORGOT TO SAY THERE WASN'T ANY CONTACT BETWEEN ANY OF THE VEHICLES, NO ONE WAS INJURED. *TR
Engine and engine cooling, Air bags, Seat belts, Fuel/propulsion system, Sep 29, 2013
A FEW MONTHS BACK I BEGAN NOTICING THAT MY CHECK ENGINE LIGHT CAME ON. WOULD TAKE 10- 15 MINS TO FILL UP GAS TANK. SENSOR WAS TRIGGERED EVERY FEW SECONDS, SUGGESTING GAS TANK WAS FULL, BUT IT WAS NOT. TOOK IT TO THE DEALER AND WAS TOLD THERE WAS NOTHING WRONG WITH THE CAR. WITH IN THE LAST MONTH I HAVE BEEN NOTICING THAT REAR AUTOMATIC LOCKING SEAT BELT IS NOT STAYING LOCKED. CHILD CAR SEATS DO NOT STAY SECURED. CAR OCCASIONALLY STALLS WHEN STARTED, AND AIR BAG LIGHT DOES NOT ILLUMINATE TO DETERMINE IF AIR BAG WILL DEPLOY OR NOT. *TR
Fuel system, Gasoline, Sep 12, 2013
UNABLE TO FILL GAS TANK BECAUSE THE GAS PUMP WOULD CLICK OFF JUST AFTER PUMPING A FEW DOLLARS OF GAS INTO CAR ALTHOUGH THE GAUGE INDICATED THE VEHICLE WAS NEAR EMPTY. THIS CONTINUED TO BE A PROBLEM OVER AND OVER AGAIN AND JUST STARTED OUT OF THE BLUE. ONE DAY IT WAS WORKING FINE, THEN I NOTICED I WAS HAVING PROBLEMS WITH GAS PUMP CLICKING OFF. TOOK VEHICLE TO MECHANIC AND DESCRIBED THE PROBLEM, THEY PULLED UP THE RECALL NOTICE. CONTACTED HYUNDAI AND WAS TOLD THAT MY CAR "JUST MISSED" THE RECALL. RECALL EFFECTED THROUGH NOVEMBER 9, 2003 AND MY CAR WAS MADE DECEMBER 17, 2003. THEREFORE I WOULD NOT QUALIFY FOR THE FUEL TANK ASSEMBLY VALVE RECALL ID # 04V369000 - FUEL SYSTEM, GASOLINE:STORAGE A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR. AFTER BEING TOLD I DID NOT QUALIFY FOR THE RECALL I TAKE MY CAR TO THE DEALERSHIP THAT STATES, FOUND CANISTER ASSEMBLY COME APART INTERNALLY RESTRICTING VALVE. THE COST WAS GOING TO BE $450.00 PLUS TAX AND LABOR. TRIED TO FIND A BETTER DEAL AND ALL MECHANICS ARE TELLING ME HYUNDAI IS REFUSING TO FIX THE FUEL TANKS ON SOME CARS, BUT ALL THE MECHANICS ARE DOING IS REPLACING THE FUEL TANK ASSEMBLY VALVE AND VEHICLES ARE RUNNING FINE WITH NO FURTHER COMPLAINTS. HYUNDAI IS RIPPING OFF CUSTOMERS BY FAILING TO INCLUDE ALL CARS AFFECTED BY THIS RECALL. AFTER TALKING TO SEVERAL MECHANICS THEY SAY IS ONCOMING FOR A CANISTER ASSEMBLY TO COME APART (NOTING IT COULD HAPPEN, BUT RARELY). THE HYUNDAI PEOPLE ARE SAYING MY CAR IS NOT "SENSING" WHEN IT IS FULL. WHICH SOUNDS LIKE THE EXACT THING THE RECALL IMPLIES. I'M IN THE PROCESS OF GATHERING THE MONEY TO HAVE THIS DONE (NOT AT THE DEALERSHIP) AND SEE IF IT FIXES MY PROBLEM AS WELL. *TR
Steering, Jul 24, 2013
WHEN DAUGHTER WAS DRIVING HER 2003 HYUNDAI, SHE HAD DIFFICULTY STEERING (VERY DIFFICULT TO TURN WHEEL)...WE TOOK IT TO A LOCAL REPAIR SHOP WHO REPLACED THE POWER STEERING PRESSURE HOSE THAT HAD DETERIORATED. WE ARE WONDERING IF OTHERS HAVE HAD THIS ISSUE AS WELL. IT WAS VERY DANGEROUS FOR HER. COULD THIS BE RELATED TO OTHER ISSUES UNDER THE CAR RELATED TO CORROSION??? *TR