2023 Hyundai Santa FE
Problems, recalls and owner-reported issues
Power train is the leading concern among 210 owner complaints filed for this model year. This is the 15th highest complaint count among 25 Santa FE model years with reports.
Of the 2023 reports, 11 involved a crash and 3 involved a fire. 15 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Representative owner complaints
210 reports, newest first.
Other or unspecified, Jan 3, 2026
I stopped to fill the gas on my road trip and the gas panel would not open. As a single women driving alone this is not ideal. It took 45 min of continuous unlocking/locking with pushing to get it to pop open. There needs to be an alternative/emergency handle to pull so this does not happen again. I was standing in 32 degree weather the entire time! NOT SAFE
Other or unspecified, Dec 26, 2025
Both horns have failed for the second time since the vehicle was purchased new in November 2023 and is currently showing 25,000 miles. The first set was replaced under warranty at a Hyundai dealership approximately 1 year ago. Not having a functioning vehicle horn is a safety hazard that would fail annual vehicle safety inspection testing in my state.
Other or unspecified, Dec 23, 2025
My back up camera is not working properly. The picture at times is scrambled and starts floating around on the screen. This was not the first time this has happened. I reported it to the dealership service department when I first noticed, about a year ago or longer. They updated the software and told me that would correct the problem. Clearly it did not correct the problem, if it is continuing to have issues.
Electrical system, Dec 17, 2025
Both horns on my 2023 Hyundai Santa FE have failed 3 times. The first set was covered under warranty (3/24), the second set cost $499.64 (3/25). Now both horns are nonfunctional after just being replaced this Spring. After reviewing many complaints on the Hyundai community form, it is very obvious there is a major issue with their horns ( and not just the Santa Fe model). Twice this week I was in need of my horn to alert other drivers but instead had to make quick maneuvers to avoid an incident. My vehicle currently cannot pass a state inspection.
Other or unspecified, Dec 11, 2025
The horn has broken 4 times. I was told that it is a design defect in the car and there is no permanent fix. Water gets in to the horn when it rains and because of the location of the horn it would have to be moved to fix it. Hyundai is aware of this safety issue and has not issued a recall because there is no permanent fix. They are supposed to be buying back my car but are dragging their feet. I'm sure this is an issue in more than just my car and it's very unsafe for the horn to just stop working.
Power train, Dec 10, 2025
The vehicle cannot pick up speed, and it is displaying the DTC- P1C2D03. This is similar to the issues that led to "Safety Recall 236 to repair a condition involving the 8-Speed Dual-Clutch Transmission (DCT) system" in earlier model years (till 2022) for certain Hyundai and Kia vehicles. NHTSA should issue a recall for 2023 model years also as Hyundai has not addressed this issue to the fullest extent in 2023 model years.
Electrical system, Engine, Forward collision avoidance, Dec 8, 2025
On a clear road a sencor comes on detect comes on says detection collision. The breaks come on when you are traveling on interstate or two lane roads. When you are traveling 75 mph and breaks come on all of a sudden on the highway. We are lucky we never got hit in the back of the car going that fast. We will stop 75 to 35 mph in 10 seconds.
Electrical system, Nov 21, 2025
At stop sign and car with auto start stop on and at the time of releasing the brake, car was not able to start engine. Car had to be shifted to parking position to start engine.
Electrical system, Other or unspecified, Nov 19, 2025
Horn has failed 4 times
Other or unspecified, Nov 18, 2025
Horn has needed to be replaced twice. Stops working for no apparent reason.
Electrical system, Service brakes, Forward collision avoidance, Nov 14, 2025
Component/System: Automatic Emergency Braking / Forward Collision-Avoidance (AEB/FCA) system and/or Electronic Parking Brake (EPB). The vehicle is available for inspection upon request. What happened: While driving my 2023 Hyundai Santa Fe (VIN: XXX) at highway speeds, the vehicle suddenly and aggressively applied the emergency braking system on two separate occasions within the same day (approximately 45–60 minutes apart). In both instances, the red emergency braking warning lights illuminated on the dashboard, and a warning sound activated. There were no vehicles, obstacles, or hazards in front of me either time. The braking was forceful and abrupt, causing rapid deceleration at highway speed. Both events occurred under normal, clear driving conditions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Safety risk: My safety and the safety of other drivers were put at significant risk. Sudden unintended braking at highway speeds can easily lead to a rear-end collision since the deceleration was not caused by driver input and gave no warning. Reproduction / dealer confirmation: The dealer has not been able to reproduce the issue, and no diagnostic trouble codes have been found so far. The vehicle is currently at the dealership for inspection. Inspection: The vehicle has been inspected by the Hyundai dealership, but the cause has not been identified. No manufacturer field engineer, police, or insurance inspection has taken place yet. Warning lamps / prior symptoms: During the failures, the red emergency braking indicator and audible warning activated immediately when the brakes engaged. There were no warning lights or symptoms prior to either event. Assessment: Cause UNKNOWN. The problem appears to be an intermittent malfunction of the Automatic Emergency Braking system, forward collision sensors, or related braking components. No diagnostic codes were stored. This is a serious safety issue that occurred twice within one hour and could easily result in a collision.
Other or unspecified, Nov 10, 2025
The sunroof on my 2023 Santa Fe exploded.
Service brakes, Oct 31, 2025
The vehicle front brake disks are not compatible for this vehicle. The action of braking causes heating of the disks. The disks warp due to the heat. The result is when braking at highway speeds, the entire front end vibrates excessively. This is unsafe in wet or snowy conditions as this greatly decreases the braking efficiency. The first time this was observed the vehicle had 22,000 miles and the dealership machined the rotors. The second time it happened at vehicle mileage of 32,000. Once again the rotors were 'machined' by the dealership. The action of braking at highway speeds and the resulting front end vibrations is a troublesome event. If this occurs a third time, I will try to find and install non-Hyundai disks.
Vehicle speed control, Forward collision avoidance, Oct 31, 2025
The vehicle's software was updated on Oct 21, 2025. The software has serious flaw. When driving on slight incline on the passing lane the vehicle will apply the brakes without warning. This has happened 3 times. At times, when vehicles were following me they also had to apply the brakes unexpectedly. Had they not applied their brakes, they would have rear ended me at highway speeds. I also recall that there were no vehicles either in front or to the right ahead of me when it occurred. Also there was a guardrail on the left side of the highway at the time. This did not occur with the previous installed software. Every time this happened, the vehicle was in cruise control and driver assist was ON to keep vehicle in the lane.
Engine, Oct 29, 2025
Was driving at 10 MPH on highway car began to cut out run rough and produce an extremely pungent smell of gasoline.. then stalled.. vehicle serviced and low pressure fuel injector had a leak causing fuel to spill onto the vehicles starter causing it to fail as well.. both were replaced under warranty by dealer. Highly concerned about fuel leaking from injector system onto a hot engine and electrical components and the aerosolized fuel. Police advised not to start vehicle due to fuel leaking and smell.
Seat belts, Oct 16, 2025, crash
I was in a car accident on September 30, 2025. I was hit from behind by a dump truck and was pushed into the car in front of me. My seat belt in my Santa Fe did not tighten, and my head hit the steering wheel. There is something wrong with the seat belts. I was going to take it to the dealer to check after repairs, but my car is a total loss. Just wanted you to know the seat belts failed, and it could happen to others who own this type of vehicle. The air bag did not deploy, but my understanding is that the car has to be going a certain speed.
Other or unspecified, Oct 11, 2025
Vehicles' charging side deck will heat up any phone we put in to charge inside that slot. We brought this to the dealers attention a couple times but they stated I needed to pay a service fee to have it looked at. It began happening a few weeks after we purchased the vehicle. We have not used the port ever since.
Electrical system, Other or unspecified, Oct 5, 2025
Horn No longer works in vehicle - A major safety issue
Other or unspecified, Oct 1, 2025
I have had 6 car appointments and on my 3rd horn replacement in this car. It goes completely out and it is a safety hazard to not have any horn. It loses both the high and low pitch horn
Engine, Sep 29, 2025
My 2023 Santa Fe Limited has 3,000 mils on it. At least four times it had low speed hesitation (lags then revs up for a few seconds). It’s a problem with the DCT (Dual Clutch Tranny) Hesitation pulling onto a highway poses a significant risk of a faster car colliding into my car. I called my car dealer and the service manager said they know they are having problems with this. He said they tried everything to remedy the problem but, there is no solution. They said the only way not to have the problem is to get a different car!!! Hyundai should have a recall on this hesitation matter before someone gets injured or killed. It’s a safety issue. The last time it happened will be the date of my incident report.
Seat belts, Sep 26, 2025
Driver and passenger seatbelts not always latching or becoming unlached while driving
Electrical system, Engine, Sep 12, 2025
On [XXX] in Rehoboth, DE, my 2023 Hyundai Santa Fe experienced a sudden and complete power failure while reversing out of a parking spot. All electrical systems shut down—including propulsion, dashboard lights, and emergency brake—causing the vehicle to roll backward into oncoming traffic. No warning lights appeared beforehand. After about an hour, power returned on its own. A passing police officer witnessed the situation and a report was filed with the Rehoboth Beach Police Department. On September 6th, Hyundai service performed a diagnostic scan of the engine and transmission systems. No fault codes were found, and the issue could not be replicated. After sitting overnight, the vehicle restarted normally and passed a road test. The dealership documented the incident but returned the vehicle without repair, stating: “Cannot duplicate concern at this time.” I was advised to tow the vehicle in if the issue recurs and, if rolling occurs again, to use a wheel chock. I purchased this vehicle new in 2023. It has only 40,000 miles and is covered under a 10-year bumper-to-bumper warranty. A failure of this magnitude—especially during a basic maneuver like reversing—poses a serious safety risk. Despite the dealership’s inability to replicate the issue, I do not feel safe operating the vehicle until the root cause is identified and resolved. I am currently in the process of escalating to Hyundai corporate for further investigation, including a buyback review, replacement evaluation, or extended diagnostic protocol. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Sep 5, 2025
horn has stopped working. Seems to be a systemic issue when looking online in Forums etc... I have scheduled the problem to be fixed and it is not a fuse issue. It will be a month before the dealership is able to get me in to assess the problem. This is a safety related issue and this needs to be addressed with the manufacturer.
Service brakes, Forward collision avoidance, Sep 2, 2025
I was travelling at 50mph a car pulled in front of me and stopped unexpetedly. I braked hard. My car began to slow, but the brake pedal went to the floor and did not slow, AFter a few seconds, the brake pedal came up from the floor and braking was resumed. I held the pedal to the floor the whole time trying to stop. It was as though the braking system failed and recovered. There was no pulsing felt on the brake pedal typical of ABS working. After my car resumed braking thte collision avoidance system took over and the car stopped just inches from the stopped car in front of me. I had just taken the car in for dealer service at 24,200 and everything was supposedly checked out as required by maintenance. I have contacted Hyundai but have not gotten a response yet.
Electrical system, Aug 28, 2025
horn has stopped working twice. Had it replaced under warranty in January of 2024. Same incident happened where horn of vehicle does not work. Seems to be a systemic issue. This is a safety related issue and this needs to be addressed with the manufacturer.