2023 Hyundai Santa FE
Problems, recalls and owner-reported issues
Power train is the leading concern among 210 owner complaints filed for this model year. This is the 15th highest complaint count among 25 Santa FE model years with reports.
Of the 2023 reports, 11 involved a crash and 3 involved a fire. 15 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideMar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Campaign 23V181000 on NHTSA.gov
Representative owner complaints
210 reports, newest first.
Engine, Apr 28, 2025
On two separate occasions, I was a stop light in high traffic. I was unable to drive my vehicle when the light turn green because of no power. A message display prompting me to "shift to P or N to start engine." Unfortunately, that didn't work. I had to sit there for a few mins, signaling other motorists to go around me. Eventually, I had to restart my vehicle. I panicked because I felt unsafe as I was blocking traffic. I took my vehicle to the dealer and was told that there were no code after the diagnostic test but yet the technician told me the door on the driver side is not aligned and I need to take it to a mechanic. I never got any alert that my door is open so that diagnosis didn't make sense. I took my vehicle le to the mechanic to check the alignment of the door who in return told me that there was no issue with my alignment. I am scared to drive my vehicle because I don't want to cause an accident.
Electrical system, Other or unspecified, Apr 27, 2025
The car loses power. The battery and key ignition light keep coming on. A message displays auto engine off. Please shift to n or p and start engine manually. After communicating and showing video proof of the incident, the dealership replaced the alternator and battery. The issues started around 5000 miles. The infotainment system lags and the car lags. Sometimes I am left on the road because the case refuses to cut on or off.
Power train, Apr 23, 2025
When accelerating from a stop, my car will not go over 20 mph. It just revs up like it’s not changing gears . I have to pull over and park it. It runs fine afterwards. This does not happen all the time. Usually it happens once a month. It’s been to the dealership 3 times. They drive it around the block and tell us that they can’t replicate the problem. Therefore, they don’t troubleshoot anything and return the car to me. I’m truly scared to drive it. I wrecked twice at a red light intersection.
Other or unspecified, Back over prevention, Apr 15, 2025
My car won’t shift on the highway and all of a sudden I can’t drive more than 40mph. It also has not wanted to let me press on the gas and make it go as I’m driving bc Its jerking 4 or 5 times before it’ll register and go. Also, not too long ago, I was in a parking lot and went to leave and my car never notified me that there was a huge pillar next to me and I crashed into it, it was in my blind spot and couldn’t see it. My car has had many many other issues in which I can’t list, but I truly bought a lemon.
Other or unspecified, Apr 8, 2025
Driving on [XXX] in Victorville; sunroof shattered. Originally thought it was a tire blowout but there were no indications on the dash, no alerts, etc. Pulled over when safe to inspect vehicle and to make sure my kids were safe. Upon pulling over and exiting the vehicle, I started to make my way around the car to check the tires. All 4 tires were completely fine. Made a second round to double check everything, see if something went under the car, there was no sign of any damage. As I was getting into the car I noticed a huge hole in the sunroof, it was completely shattered. Safety of my family was at risk but fortunately it was a chilly morning and the sunroof was closed. Vehicle is available for request if needed but it currently located at the local Hyundai dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Mar 24, 2025
The purchase price was $35,800. As of today, I have paid a total of $24,590. The vehicle has a manufacturing defect that has significantly impacted its performance. The engine has been problematic, as it appears to be consuming oil, and it often fails to start on the first attempt, requiring me to press the button multiple times. The most concerning issue is that the car can unexpectedly shut off while I am driving. Additionally, there is an abnormal noise coming from the engine. I consider this situation serious, as it poses a significant risk to my safety. These symptoms appear on January 13/2025. I want to emphasize that I have completed all scheduled maintenance on time. I filled out reports regarding this issue, and I have attached two reports that confirm the vehicle is consuming 2 quarts of oil per 1,000 miles, vehicle is consuming oil due manufacturing defect. These reports were given to me by Safford Hyundai.
Air bags, Forward collision avoidance, Mar 20, 2025, crash
I had adaptive cruise control on and debris hit my windshield and I went into the rumble strip and eventually into the guard rail where the car essentially pingponged from there until it eventually stopped when the metal hit the front. It appears the emergency brake did not activate and the lane keep did not activate. My air bags did not deploy.
Power train, Other or unspecified, Engine, Mar 13, 2025
The car has shut down unexpectedly for at least six times while driving at roads and highways. When this happens, engine stalls and nothing works and all alarms and check lights turn on and activated. Driver has to pull the car to the roadside which cannot be imagined when in a highway with all cars driving at 65-70mpH and the car suddenly slows down to stop. The other problem is that when the car is turned off and on again, all alarm and faults go away, and it can be driven again! It clears all safety and alarm checks and lights and behaves like nothing has happened. Car was bought on June2023. The first incident happened on Aug2023 and the next one on Sep2023. The next incidents on Feb2024, Sep2024, Nov2024 and the most recent on March 2025. The car has taken to the Sport Durst Hyundai dealership (Durham, NC) after incidents, however dealership did not perform any repairs in first four times claiming they could not duplicate the incident! (service reports attached for 3) After the third incident, we opened a case with Hyundai company trying to invoke the Lemon law, but our request did not go through despite all evidence we provided. Shamefully, their final suggestion to us was to sell the car! This was around March/Apr 2024. (Final decision letter attached) On fifth time, the driver did not shut down the car and towed it to the dealership while leaving electrical system on. They checked the car and claimed they found the cause and changed a part from car claiming it has been fixed. This was on Nov.2024. At the time we did not notice but, apparently that was a lie to make us quiet. The last time (sixth time) the same incident happened on [XXX]. The car was towed to dealership and is left there. We do have all screenshots from engine failures, although the dealership tried to wipe the history at some point. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Mar 12, 2025
The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted. There was no warning light illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The contact stated that the failure reoccurred, and the vehicle was towed to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 55,917.
Other or unspecified, Fuel/propulsion system, Forward collision avoidance, Feb 24, 2025, crash, fire
The accelerator stuck and the vehicle crashed. The vehicle is totaled. It happened [XXX]. No one has yet inspected the vehicle. I notified Hyundai about 5 days ago. The phone number of the towing company is 516 433 1011. The following link is a YouTube video of the accident: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Feb 13, 2025
Every time it rains, one of the dual tone horns will fail. I have had the horn replaced 2 times. I am beginning to have a problem with the horn again after this last rain. It is a matter of time before it fails completely after a rain and becomes unusable. I feel this is a significant warning feature that MUST be reliable.
Other or unspecified, Jan 21, 2025
Took vehicle to the dealership on Jan 3, 2025 for the 15k mile oil change. They informed me they completed the multi-point inspection, with no issues discovered. Jan 10, 2025 I attempted to us the horn and discovered it didn't work, so I immediately went back to the dealership and scheduled a service, to troubleshoot the horn. Jan 20, 2025 dealership discovered both horns were defective and replaced both. Very strange for both horns to die so early.
Service brakes, Forward collision avoidance, Jan 17, 2025
In January, 2024, my vehicle (2023 Hyundai Santa Fe) started shuddering when brakes were applied at high speed, on quick or hard stops, in stop and go traffic, and especially going downhill. I had only been driving the vehicle for about 5 months. I took the vehicle to an independent mechanic, who explained that my front rotors had burn spots. He recommended that I have them resurfaced. I did not want to pay for the problem to be fixed when I believed it was a factory defect and should be covered by warranty. I asked the Mission Hills Hyundai dealership Service Department to investigate and correct the problem, because I felt that my family's safety was jeopardized by faulty brakes. They showed me the burn spots on the front rotors and recommended resurfacing. They said I could wait for the pads to wear down and do the resurfacing at the same time as the pad replacement. Their estimate for resurfacing was higher than the one from my mechanic. I found a Hyundai Technical Service Bulletin, Number 23-BR-004H, which described the exact defects of my vehicle. I returned to the dealership with the TSB in February, 2024. They replaced the two defective front rotors and front disc pads at no charge. The shuddering was no longer evident, and I thought the problem was resolved. However, 10 months later in December, 2024, I once again experienced the shuddering while braking on the freeway while going downhill and when slowing for stops from high speed. Since I had been told that the new rotors and pads were covered by warranty for 5 years or 60,000 miles, I returned to the dealership on 1/16/25 and asked them to evaluate the brakes again. They said that the front rotors again had burn spots. They once again recommended resurfacing at a cost of $249. I reminded them that there was a warranty on the new parts, they claimed that the only warranty was for the original parts that had been replaced. They agreed to resurface no charge. Please investigate and respond to my complaint.
Structure, Jan 17, 2025
The sunroof glass violently shattered/exploded while driving the vehicle. The manufacturer claims the window meets current standards and is not defective. The curtain or fabric cover was extended covering the glass panel otherwise the driver would have been covered with broken glass.
Electrical system, Jan 7, 2025
The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving at approximately 55 MPH, the horn was inoperative. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the horn needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 7,600.
Power train, Jan 6, 2025
The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving 45 MPH, the message "Shifter System Malfunction - Service Immediately" was displayed. The contact stated that the vehicle failed to shift into the park or reverse. The contact activated the parking brake and turned off the vehicle. The vehicle was towed to the dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 18,192.
Other or unspecified, Dec 27, 2024
Horn Failed. Would not sound, making it impossible to warn people if car might hit them or their vehicles or about any other issue they would need timely reporting about. Car was brought into dealer and 2 horns assemblies were replaced as non-functional
Power train, Vehicle speed control, Engine, Dec 27, 2024
Automobile approached and stopped at stop sign. When accelerator pressed to continue, car remained in place, shuddering (as if transmission were slipping),and making significant noise. Car would not shift out of gear, nor move. Operator shut off car and then restarted car. Car started normally and was in park without shuddering. Expectations at busy intersection was that it was my turn to move and did not do so, creating doubt on what my car might do next. Traffic flow was briefly confused and some drivers honked and were unsure what they should do. This could have caused an accident with an impatient driver re-ending my car, or with others going through the intersection "out of turn" and unclear on my situation. No lights or other warnings were displayed before this incident. It has not re-ocurred. I brought into the dealer who had no other reports of this type of behavior.
Power train, Vehicle speed control, Engine, Dec 27, 2024
While travelling at highway speed, attempted to accelerate to pass slow traffic. Rather than accelerating, the car hunted for a gear, and wouldn't shift properly. The car downshifted but engine would not go beyond 4000 RPM and speed remained the same. This has happened multiple times. By unexpectedly not accelerating, this created a risky situation by not allowing car to pass slower traffic as expected creating a potentially dangerous situation. (Video of one of the instances exists). No warning lamps, messages or symptoms occurred up to that point. Car was brought to dealer but since no codes were contained in the computer, they said there was no trouble found.
Wheels, Service brakes, Dec 15, 2024
I purchased my 2023 Santa Fe brand new off the show room floor in Jan 2024. After about 6k miles when braking on the highway the entire vehicle would shudder and shake including the steering wheel. I took it into the dealership where I was informed this is a KNOWN ISSUE with this year/make/model with the rotors. They claimed they would turn the rotors but if the issue persists they would replace them. About 2k miles later (apx 2 months) the shuddering happened AGAIN. So I made an apt to get them replaced where the new service tech tried to tell me again this is a KNOWN ISSUE but now I would be responsible for a $250 replacement of the rotors. I refused to pay as they are within the 12k or 1 year warranty and they refused to replace them. That service tech also said the day prior he had to deliver that news to 4 OTHER patrons about the replacement of their rotors. I feel extremely unsafe in this vehicle and the issue is still not fixed as I have a claim in process with the manufacture directly. The claim was put in on 12/7/24 where I was told I would be contacted within 2-3 BUSINESS DAYS by a manager due to my claim being escalated. It is now 12/15/24 and still NO CONTACT from Hyundai. The vehicle shuddering is increasingly worse and worse and I feel very unsafe in this suv.
Other or unspecified, Dec 8, 2024
Just purchased the vehicle one week ago. I bought it used from a Hyundai dealer. Just discovered that the horns don't work, either the high tone or the low tone. I discovered it when I went to use the horn to alert a driver who was coming into my lane, pushed the horn on the steering wheel and nothing! I've checked the fuse and it is fine. Internet research shows this to be a prolific problem with Hyundai's. Because the horns don't work, neither does the alarm system. I tested by pushing the panic button on the key fob. The lights flash, like the alarm is trying to fully work, except the horns don't sound. I will be bringing it to the dealer as it is still under warranty.
Power train, Steering, Dec 7, 2024
Shuddering Issue with Current Vehicle: - Problem: Progressive shuddering during take-off, accelerating, slowing down, and braking uphill.
Power train, Engine, Fuel/propulsion system, Dec 4, 2024
First- it has been reported to dealer at least twice when car was in for other service. They said they could not reproduce. When speeding back up from a stop on near stop, especially in a right turn, the engine will not accelerate. After a second or two it finally takes off. During this time, I fear getting hit by another vehicle, either from behind or to the side. It is very scary and puts me and my passengers at great risk! There was no warning indication at all. The date mentioned was the most recent time, but the issue has been happening since the car was brand new. Again, NO help from the dealer.
Forward collision avoidance, Dec 3, 2024
Emergency brakes engage while driving for no apparent reason. This has happened on several occasions over the last 6 months.
Seat belts, Nov 5, 2024
The seat belt in the middle seat of the second row did not work. And it was not fastened. So when braking, my child was thrown toward the center console. I think it's a big safety issue if the seat belt doesn't work.