2003 Hyundai Sonata
Problems, recalls and owner-reported issues
Air bags is the leading concern among 199 owner complaints filed for this model year. This is the 18th highest complaint count among 26 Sonata model years with reports.
Of the 2003 reports, 17 involved a crash and 2 involved a fire. 45 people were injured.
What owners report most often
Recalls and investigations
Latches/locks/linkages, doors, latchAug 7, 2009
HYUNDAI IS RECALLING 82 MODEL YEAR 2002-2003 SONATA VEHICLES. REPEATED USE OF THE INTERIOR DOOR HANDLE MAY CAUSE WEAR OF THE CHROME PLATING. IF THE TOP EDGE OF THE HANDLE HAS VERY THIN CHROME PLATING THAT PORTION OF THE PLATING MAY WEAR AWAY MORE EASILY THAN MORE THICKLY PLATED AREAS AS THE DOOR HANDLE IS USED. THE WORN CHROME PLATING ON THE UPPER EDGE OF THE HANDLE MAY RESULT IN A CRACK OR SEPARATION BETWEEN THE CHROME PLATING ON THE INBOARD AND OUTBOARD SURFACES OF THE HANDLE, WHICH MAY FORM A SHARP EDGE.
A SHARP EDGE COULD LACERATE OR OTHERWISE INJURE A VEHICLE OCCUPANT.
DEALERS WILL REPAIR THE CHROME PLATED INTERIOR DOOR HANDLE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 16, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-787-999-3333.
Campaign 09V317000 on NHTSA.gov
Latches/locks/linkages, doors, latchMay 21, 2009
HYUNDAI IS RECALLING 91,350 MY 2002-2003 HYUNDAI SONATA VEHICLES. REPEATED USE OF THE INTERIOR DOOR HANDLE MAY CAUSE WEAR OF THE CHROME PLATE. IF THE TOP EDGE OF THE HANDLE HAS VERY THIN CHROME PLATING, THAT PORTION OF THE PLATING MAY WEAR AWAY MORE EASILY THAN MORE THICKLY PLATED AREAS AS THE DOOR HANDLE IS USED. THE WORN CHROME PLATING ON THE UPPER EDGE OF THE HANDLE MAY RESULT IN A CRACK OR SEPARATION BETWEEN THE CHROME PLATING ON THE INBOARD AND OUTBOARD SURFACES OF THE HANDLE, WHICH MAY FORM A SHARP EDGE.
THIS MAY INFLICT LACERATION INJURIES TO ANYONE USING THE DOOR HANDLE.
DEALERS WILL REPAIR THE CHROME PLATED INTERIOR DOOR HANDLE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V171000 on NHTSA.gov
SuspensionApr 16, 2009
HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUB-FRAME ON THE VEHICLES, AND MAY RESULT IN THINNING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION IS FREQUENTLY VISIBLE AND OFTEN DISCOVERED DURING INSPECTION OR ROUTINE MAINTENANCE, AND OWNERS MAY ALSO HEAR NOISES OR NOTICE TIRE MISALIGNMENT AND STEERING PULL. IF THESE SIGNALS ARE UNDETECTED OR UNHEEDED, THE CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM MAY DETACH FROM THE SUB-FRAME.
IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH.
DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE SUB-FRAME AND WILL TREAT THE SUB-FRAME WITH RUST-PROOFING MATERIAL TO STOP THE CORROSION PROCESS. THIS PROCEDURE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V124000 on NHTSA.gov
Fuel system, gasoline, storageJul 26, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Campaign 04V369000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 9, 2004
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 04V178000 on NHTSA.gov
Tires, temporary/emergency spare tireMar 17, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A TRACTION CONTROL SYSTEM (TCS), IF THE T125/70D-15 COMPACT SPARE TIRE IS INSTALLED ON A FRONT WHEEL POSITION, THE TCS MAY INADVERTENTLY ACTIVATE BEGINNING AT SPEEDS OF 20 MPH.
INADVERTENT ACTIVATION OF THE TCS WILL CAUSE AUTOMATIC APPLICATION OF THE BRAKE AT THE WHEEL WHERE THE COMPACT SPARE TIRE IS INSTALLED. INADVERTENT BRAKE APPLICATION COULD CAUSE OVERHEATING AND DAMAGE TO THE BRAKE, AND MAY PREVENT THE VEHICLE FROM BEING DRIVEN AT SPEEDS ABOVE 20 MPH, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE SPARE TIRE WITH A NEW LARGER DIAMETER T125/80R-15 COMPACT SPARE TIRE AND A NEW TIRE PRESSURE LABEL WILL BE INSTALLED ON THE DRIVER'S DOOR TO PROVIDE INFORMATION APPLICABLE TO THE T125/80R-15 COMPACT SPARE TIRE. VEHICLES PRODUCED FROM NOVEMBER 15, 2002 THROUGH DECEMBER 16 2002, ALREADY CONTAIN T125/80R-15 COMPACT SPARE TIRES, WILL ONLY REQUIRE NEW TIRE PRESSURE LABELS. OWNER NOTIFICATION BEGAN JUNE 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 03V097000 on NHTSA.gov
Representative owner complaints: suspension
15 reports, newest first. Show all
Suspension, Structure, Jun 11, 2026
The contact owns a 2003 Hyundai Sonata. The contact stated that while the vehicle was at Valvoline for a service appointment, the contact was made aware of NHTSA Campaign Number: 09V124000 (Suspension). The vehicle was taken to the dealer, who informed the contact that the subframe assembly and additional unknown parts were not included in the recall repair. In addition, the contact was informed that the recall could not be performed because other repairs were needed prior to the recall repair. The vehicle was not repaired. The contact stated that the vehicle was unsafe to drive. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the repair was not covered under the recall. The failure mileage was approximately 170,000.
Suspension, Sep 4, 2025
The contact owns a 2003 Hyundai Sonata. The contact stated that upon taking the vehicle to an independent mechanic, the mechanic discovered severe corrosion on the suspension. Upon investigation, the contact discovered NHTSA Campaign Number: 09V124000 (Suspension). The vehicle was taken to a dealer, and the contact was informed that due to the severe corrosion, the recall repair could not be performed. The mechanic at the dealer described the vehicle as being unsafe to drive. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 58,000
Suspension, Jun 26, 2024
The contact owns a 2003 Hyundai Sonata. The contact stated that while the vehicle was being serviced by an independent mechanic, the mechanic informed the contact that the front subframe was severely corroded. The mechanic determined that the failure was related to a recall. The vehicle was taken to the dealer, where the contact was informed that the subframe needed to be replaced; however, the repair could not be covered under NHTSA Campaign Number: 09V124000 (Suspension) because the parts had been discontinued. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was unknown. Parts distribution disconnect.
Suspension, Power train, Fuel/propulsion system, Oct 5, 2020
YOU CAN NOT FILL GAS TANK PASS HALF WITH OUT THE SMELL FILLING THE CAR .THE BACK SUSPENSION WHEN YOU GO OVER 40 TALES FROM SIDE TO SIDE .THE CAR WAS ON THE HIGHWAY .
Suspension, May 20, 2020
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED BY AN INDEPENDENT MECHANIC, SHE WAS INFORMED THERE WAS CORROSION TO THE VEHICLE'S SUBFRAME. THE CONTACT WAS ALSO INFORMED THAT THE FRONT PASSENGER'S SIDE SWAY BAR LINKAGE AND BOTH FRONT WHEEL BEARINGS NEEDED TO BE REPLACED. A DEALER WAS NOT NOTIFIED OF FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED NOR REPAIRED AS OF YET. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND A COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 184,077.
Suspension, Jun 24, 2017
6-22-17 MY DAUGHTER WAS RETURN TO WORK IN HER 2003 HYUNDAI SONATA, AS SHE WAS LEAVING AN ADJACENT PARKING LOT TO WHERE SHE PARKED, THE RIGHT FRONT WHEEL POPPED LOUDLY, THE CAR LOST POWER SHE STOPPED THE VEHICLE GOING STRAIGHT AT A RELATIVE LOW SPEED. THE CAR WAS INOPERABLE SO I HAD IT TOWED TO MY HOUSE. 6-24-17 I BEGIN TO INSPECT WHAT HAPPENED, I JACKED THE RT FRT END OFF THE GROUND AND BLOCKED IT UP. I FOUND THE LOWER CONTROL ARM WAS SOMEWHAT LOOSE. IT WAS BROKEN LOOSE FROM THE RT SIDE SUBFRAME. I CAME IN THE HOUSE AND RESEARCHED THE INTERNET AND FOUND THIS WAS A PROBLEM WITH SONATA'S FROM 1999-2004 CAMPAIGN NUMBER 09V12400, I CONTACTED HYUNDAI CUSTOMER SERVICE 6-24-17 AROUND 12:30PM. I GAVE THE CAR INFO TO THE LADY AND SHE SAID ONLY AN A-C RECALL WAS AVAILABLE FOR THE CAR. I ASKED ABOUT THE RECALL AND GAVE THE NUMBER, SHE SAID NOT FOR MY CAR AND THAT WAS ALL THEY COULD OFFER. WHEN THE CONTROL ARM BROKE LOOSE FROM SUBFRAME IT CAUSED THE AXLE TO PULL OUT OF THE DIFFERENTIAL AND THAT WAS WHY IT LOST POWER. I ALSO FOUND THAT THE SUBFRAME IS ALMOST RUSTED THROUGH AND WEAK.
Suspension, Oct 24, 2016
SUBFRAME RUSTING SO MUCH THAT THE DEALER TOLD ME THAT THE CAR IS UNSAFE TO DRIVE AND WON'T LET ME TAKE IT OUT.
Steering, Suspension, Wheels, Apr 14, 2015
03 HYUNDAI SONATA GLS (V6). DRIVING 55MPH HIT POTHOLE AND LOST STEERING. PULLED OVER, REMOVED RF WHEEL TO DISCOVER CONTROL ARM BOLTS RIPPED OUT OF THE SUBFRAME FROM RUST. HEARD ABOUT RECALL AND INVESTIGATED. CAR WAS INSPECTED FOR RECALL IN 2010 PASSED THEN AT DEALER IN MARLTON, NJ. WAITING FOR CALL BACK FROM DIFFERENT DEALER TO FIND OUT THE PROCEDURE TO FILE A CLAIM. DEALERS IN SE PA ARE NOT CUSTOMER ORIENTED SO MAKING COMPLAINT HERE TO DOCUMENT INCIDENT.
Steering, Suspension, Dec 18, 2014
NO ACCIDENT, DEALER SAYS RECALL#09V124000 IS ONLY APPLICABLE TO ORIGINAL OWNER AND THEY WILL NOT FIX IT,,,SOUNDS WRONG ?????? *TR
Suspension, Structure, Jul 30, 2014
VERY HEAVY RUST ON RIGHT SIDE ,THE SUB FRAME GAVE WAY AND RIPPED THE CV AXLE OUT OF ITS HOUSING. *TR
Suspension, Nov 13, 2013
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE REAR OF THE VEHICLE BEGAN SWAYING ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THE MECHANIC STATED THAT BOTH REAR STRUTS WOULD HAVE TO BE REPLACED. WHILE THE REPAIR WAS BEING PERFORMED THE REAR DRIVER'S SIDE UPPER CONTROL ARM FRACTURED. THE MECHANIC STATED THAT THE REAR UPPER CONTROL ARM AND FRAME WERE SEVERALLY CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. UPDATED 1/6/14*CN
Suspension, Oct 6, 2011
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT DURING ROUTINE MAINTENANCE, THE LOCAL REPAIR SHOP CONFIRMED CORROSION NEAR THE SUB FRAME. THE VEHICLE WAS NOT TAKEN TO THE DEALER BUT THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE VIN DID NOT QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 09V124000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 106,000.
Suspension, Feb 27, 2011
THE CAR IS NOT MINE, I AM A MECHANIC,A 2003 SONATA I DO A LOT OF WORK ON JUST HAD A RR LOWER CONTROL ARM FAIL, I KNOW THEY HAVE A SUBFRAME ISSUE,SO KNOWING THIS, HOW MANY MORE OF THESE"TIME BOMBS" ARE OUT THEIR,THEY SELL ALOT OF THESE CARS IN THE STATE I LIVE IN[NEW YORK], HOW MANY MORE MAJOR SUSPENSION COMPONENTS ARE FAILING DUE TO CORROSION! ALOT OF YOUNG PEOPLE BUY THEM BECAUSE OF PRICE,THE ELDERLY ALSO,THAT IS WHY IM WRITING THIS CAR BELONGS TO AN OLDER WIDOW WHO CAN'T AFFORD THE REPAIRS,THE WARRANTY SHOULD COVER THE REPAIR BUT HER LATE HUSBAND BOUGHT THIS CAR BECAUSE OF THE WARRANTY!! *TR
Suspension, Structure, Tires, Oct 6, 2009
I HAVE A 2003 HYUNDAI SONATA. I HAVE HAD NOTHING BUT TROUBLE WITH THIS VEHICLE. I PURCHASED 2 SETS OF NEW TIRES IN THE PAST 4 YEARS AND HAVE HAD ROUGHLY 15 FLAT TIRES. I ALSO MOST RECENTLY ALMOST KILLED MYSELF AND MY 3 KIDS W/ HAVING THE TIRE ROD ALMOST CRACK. I HAD A BILL OF $385 TO HAVE JUST THAT ONE PART TO BE FIXED. I HAVE BEEN ON HOLD FOR OVER AN HOUR NOW FOR THE RECALL NUMBER I RECEIVED IN THE MAIL. I AM A SINGLE PARENT AND NEED TO BE REIMBURSED FOR MY TROUBLES AS THIS WAS DIRECTLY RELATED TO THE RECALL LETTER I JUST RECEIVED. PLEASE CONTACT ME. *TR
Suspension, Jan 9, 2004
WHEN COMING TO A STOP, THE CONSUMER HEARD A RUMBLING NOISE. THE VEHICLE VIBRATED SOON AFTER THAT. DEALERSHIP WAS UNABLE TO RESOLVE THE PROBLEM. *AK THE STEERING WHEEL WOULD SHAKE ALONG WITH THE VEHICLE WHEN SITTING AT IDLE AND MORE WHEN THE A/C WAS ON. THE VEHICLE ALSO PULLED TO THE RIGHT. *SC *JB